2024 MERCEDES-BENZ Sprinter 2500

2024 Mercedes-Benz Sprinter 2500 experienced unusually rapid brake, tire, and battery wear at low mileage. Front brakes required replacement at approximately 29,000 miles. Rear brakes were already worn low by approximately 37,000 miles. Rear tires required replacement by approximately 37,000 miles. Vehicle battery also failed and required replacement before approximately 37,000 miles. Vehicle had earlier emissions/sensor related repairs as well. This creates safety concerns because premature brake wear can reduce stopping ability and increase stopping distance. Premature tire wear can reduce traction, especially in rain, and increase risk of tire failure or blowout. Unexpected battery failure can disable the vehicle without warning in traffic or roadside conditions. Vehicle is used in normal commercial delivery service and is generally not heavily loaded. I have owned and operated multiple prior Sprinter vans over many years, and previous model years achieved substantially longer brake, tire, and battery life under similar or heavier use. A newer comparable fleet vehicle with similar mileage has not required these repairs. The issue appears abnormal compared with prior ownership experience and may indicate brake system drag, an alignment issue, defective components, battery charging issue, or another unresolved defect. Vehicle has been serviced by dealer and components were replaced, but premature wear remains the concern. In addition, rear brake wear occurring this early suggests possible imbalance or excessive brake application that should be investigated. Rapid tire wear combined with brake wear may indicate alignment or braking system issues affecting vehicle control and safety. I am submitting this complaint so the condition can be reviewed for potential defect trends affecting other similar vehicles. Defective parts may be available from prior repairs depending on service center retention.

The van has a cross wind assist mode. When it activates it aggressively activates only one front wheel brake so dramatically that the van dives down and swerves out of the lane into the adjacent lane. The front wheel happened to be on wet pavement and it was chattering from braking so hard and not getting traction. I passed a slower motorcycle on the road and the crosswind assist almost caused me to run him off the road. The problem has not been reported to the dealer because i have read on several forums that dealers wont do anything about it. many people are complaining about this and it happens without warning. the problem started as soon as I bought the van, it now has 10,000 miles on it. This is a feature that is included with the van. When the dashboard lights do come on when the cross wind assist activates. No other warnings nor is thier any warning before the wind assist activates. Thanks for reading my concern

The contact owns a 2024 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 65-70 MPH, the vehicle stalled without warning. The contact attempted to depress the accelerator pedal however, the vehicle revved but failed to respond. The contact was able to pull to the side of the emergency lane. The contact had called the dealer at that point who advised the contact to turn off the vehicle and lock the vehicle, then reopen and restart the vehicle to reset the computer system. The contact completed the instructions, and the failure did not reoccur. The contact stated that approximately 2 to 3 months later while driving approximately 60-65 MPH, the ABS suddenly activated causing the vehicle to stop unintendedly. The instrument panel displayed that the vehicle had detected an object nearby, causing the brake assist to activate and then go completely black. The contact depressed the accelerator pedal causing the vehicle to accelerate abruptly. The dealer had not been contacted. The vehicle had not been diagnosed or repaired. The manufacturer was made aware of the failure and a case was filed. The failure mileage was 5,000.