NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
18 reportsClear category filterMileage unknown · Sep 11, 2025
Power Train
I’ve had two issues with my sprinter van that were transmission shift module that left me stranded with no way to shift the car into neutral. I was blocking a fuel pump and couldn’t get the car into gear. The first time I was stuck in a parking lot with the same issue. I can’t believe no one else had this issue. The screen mess…
Read full complaint
I’ve had two issues with my sprinter van that were transmission shift module that left me stranded with no way to shift the car into neutral. I was blocking a fuel pump and couldn’t get the car into gear. The first time I was stuck in a parking lot with the same issue. I can’t believe no one else had this issue. The screen message said “Service required do not shift gears” I purchased the van new in 2020. It only has 17000 miles on it. The dealerships Mercedes Benz in Sioux Falls and Mercedes Benz in Rochester Minnesota repaired the van.
NHTSA ODI #11686750
Mileage unknown · Jul 17, 2025
EngineFuel/propulsion SystemPower Train
repeated EGR clogging and malfunction: bucking or stumbling behavior, inability to accelerate properly, disabled shifting affecting ability to slow or stop without excessive use of brakes, Limp Home Mode suddenly without warning including inability to maintain a safe speed on highway and speed minimums that the vehicle cannot ke…
Read full complaint
repeated EGR clogging and malfunction: bucking or stumbling behavior, inability to accelerate properly, disabled shifting affecting ability to slow or stop without excessive use of brakes, Limp Home Mode suddenly without warning including inability to maintain a safe speed on highway and speed minimums that the vehicle cannot keep up (20 mph max while climbing moderately), unable to downshift when going downhill - relying solely on braking to keep speed below safe limit or speed limits. EGR failed again after cleaning, in as little as 3 months. No repair seems possible, only repeated cleanings. Since this happened so much, we have been in several unsafe situations due to the sudden and unheralded degradation of performance and safe use of the vehicle. Once repaired, the condition can come back immediately due to the computer still guessing that it is still in failure (limp home mode returned suddenly without warning as we merged onto an interstate with no exit for 7 miles uphill… and only made 20mph). Check Engine light could come on, and did, but never during the actual degradation of performance - and went often after a few run cycles. Mercedes dealers have confirmed and performed all services on the EGR and related issues (malfunction once caused the aircleaner element to be sucked in and that caused a MAF to be destroyed by contaminants): 1) first signs of issue before 43,000 miles (when check engine light and/or LHM happened -repaired 18sep2023, 51,871 miles, MB service code: LI14.20-N-073867); 2) 26 DEC 2023 - EGR failure diagnosed and replaced by MB dealer. Cleaning had not fixed the issue or failure was final as found by driving by technician and not by codes! 3) 09/jul/2024 - MAF replaced, EGR codes noted - but functioning, fix by MB/Canada 4) 07/24/2024 - 70,547 miles - EGR Clean by MB Missoula MT - failed upon highway same day 5) 07/25/2025 - 70,600 miles - MB Missoula MT cleared computer 6) 88,340 MB cleaned EGR - runs ok again
NHTSA ODI #11674336
Mileage unknown · Apr 16, 2025
Power Train
While driving the vehicle, 4x4 and low range would engage on its own. It would cause the transfer case to grind, clunk, and lock up. This happened while the vehicle was in motion and could have easily sent the vehicle out of control. Some warning lights appeared on the dash. I took it into the dealership, they diagnosed it as …
Read full complaint
While driving the vehicle, 4x4 and low range would engage on its own. It would cause the transfer case to grind, clunk, and lock up. This happened while the vehicle was in motion and could have easily sent the vehicle out of control. Some warning lights appeared on the dash. I took it into the dealership, they diagnosed it as a glitch in the transfer case actuator software. They updated the software and declined my warranty claim since the powertrain warranty did not cover software updates. I had to pay out of pocket for this fix. The issue is common to this model.
NHTSA ODI #11654889
Mileage unknown · Dec 24, 2024
Electrical SystemPower Train
Since date of purchase, May 2022, the electrical components have not worked properly. The solar panels have never worked, the second alternator used to only charge while driving intermittently now it doesn't work at all, and plugging into shore power sometimes melts the cord. The chassis battery frequently drains requiring const…
Read full complaint
Since date of purchase, May 2022, the electrical components have not worked properly. The solar panels have never worked, the second alternator used to only charge while driving intermittently now it doesn't work at all, and plugging into shore power sometimes melts the cord. The chassis battery frequently drains requiring constant starting or a jump. It has been replaced four times. The cabin lights continue to flicker when turned on. I sought help from the dealer just weeks after purchasing the van. Due to parts and labor shortages, it wouldn't be for 5 months that they could work on the vehicle. Which they did on and off for five months before sending me from Oregon to Alabama to have the manufacturer work on it. They sent me 2300 miles to fix a brand new vehicle that they sold me. After having been to over 15 Mercedes dealers, towed to many, and to the Tiffin manufacturer (and when it turned out not to be fixed. I took it right back but then when it still wasn't fixed. I sought help from Mercedes.), the van is still not fixed and I am often without power.
NHTSA ODI #11632275
Mileage unknown · Nov 21, 2024
Power Train
The vehicle experiences complete loss of power (dead peddle) in 2 situation. both of which happen completely randomly. 1. From the start at zero miles per hour. In this situation you will start to move and then there is no power no matter how hard you press the peddle. This is very dangerous when turning into traffic. Th…
Read full complaint
The vehicle experiences complete loss of power (dead peddle) in 2 situation. both of which happen completely randomly. 1. From the start at zero miles per hour. In this situation you will start to move and then there is no power no matter how hard you press the peddle. This is very dangerous when turning into traffic. The vehicle has completely stopped running the risk of T bone collision. 2. There is also "dead peddle" while driving on the highway. The problem happens quite often. There have been situations where I have slowed from 60mph down to 20mph forcing me to pull off the road before the vehicle has regained power again.
NHTSA ODI #11626585
Mileage unknown · Oct 11, 2023
Power TrainUnknown Or Other
After starting engine and putting transmission into drive, vehicle does not respond to throttle and will not move forward. If I put the transmission into neutral or park, the engine will respond to throttle input. Vehicle may respond to throttle when in reverse. This is an intermittent problem that seems to occur at higher altit…
Read full complaint
After starting engine and putting transmission into drive, vehicle does not respond to throttle and will not move forward. If I put the transmission into neutral or park, the engine will respond to throttle input. Vehicle may respond to throttle when in reverse. This is an intermittent problem that seems to occur at higher altitudes than our home base of near sea level. The issue has occurred at 4,000 to 12,000 feet elevations. Sometimes the check engine light has come on during these events, but the check engine light clears by the time returning home. When taking the vehicle to Mercedes Van Service to have it checked, no diagnostics data can be found and they cannot reproduce the issue. This issue has occurred numerous times has has been to the Mercedes Van Service Center 4 or 5 times already for the issue. The last event occurred on 10/10/2023. The vehicle eventually behaves normally after several start attempts but makes it very difficult and potentially hazardous when attempting to leave remote campsites. When issue occurs, you don’t know when it will decide to behave normally or if you’ll need to call for emergency assistance via our Garmin satellite handheld unit because of being in a no cellphone service area.
NHTSA ODI #11549365
Mileage unknown · Jun 1, 2023
Power Train
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 22V796000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made awa…
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 22V796000 (Power Train) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.
NHTSA ODI #11524851
Mileage unknown · May 2, 2023
EnginePower TrainVehicle Speed Control
None responsive throttle, driving on highway and engine loses power and loses all throttle response causing rapid slowing to traffic behind the vehicle. No warning lamps and CEL’s. Problem occurs at random times with no CEL or warning.
NHTSA ODI #11519989
32,000 miles · Mar 3, 2023
Power Train
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while driving at an undisclosed speed, the vehicle was jerking. The vehicle was taken to the dealer; however, no cause of the failure was found. The contact related the failure to NHTSA Campaign Number 22V796000 (Power Train). The manufacturer was made …
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while driving at an undisclosed speed, the vehicle was jerking. The vehicle was taken to the dealer; however, no cause of the failure was found. The contact related the failure to NHTSA Campaign Number 22V796000 (Power Train). The manufacturer was made aware of the failure. The failure mileage was approximately 32,000.
NHTSA ODI #11510013
Mileage unknown · Nov 2, 2022
Electrical SystemPower Train
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any h…
Read full complaint
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect. Please help? Thank you
NHTSA ODI #11492020
Official recalls
22Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The connection between the propeller shaft bearing and crossmember may loosen, reducing vehicle control.
Consequence & remedy
Consequence: Reduced vehicle control increases the risk of a crash. Additionally, the propeller shaft may damage the fuel tank during a crash, causing a leak and increasing the risk of a fire.
Remedy: Dealers will inspect and replace the crossmember as necessary, free of charge. Owner notification letters were mailed April 19, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3QUERTR.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
Dec 15, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.
Consequence & remedy
Consequence: Unintentional vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
May 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The screws for the front door hinges may not have been tightened properly.
Consequence & remedy
Consequence: Loose door hinge screws could change the gap between the door and vehicle body, increasing the risk of injury in the event of a crash.
Remedy: Dealers will check the screws and tighten them as necessary, free of charge. Owner notification letters were mailed June 18, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TURSCHA.
Apr 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
Consequence & remedy
Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
Apr 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.
Consequence & remedy
Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.
Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.
Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.
Feb 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Dec 21, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.
Consequence & remedy
Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.
Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.
Oct 28, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Oct 14, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The outer area of the brake hoses on the front and rear axles may have been damaged during production.
Consequence & remedy
Consequence: Over time, the hose could begin to leak brake fluid, affecting the braking performance of the vehicle, including the potential loss of directional stability when braking, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the condition of the brake hoses on the front and rear axles and replace them as needed, free of charge. The recall began November 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3MONTLAU.
Sep 29, 2020
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration