NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
20 reportsClear category filterMileage unknown · Dec 9, 2025
Electrical SystemFire
On November 28, 2025, I experienced a vehicle fire in my Mercedes 2020 Sprinter 2500 4WD van. The van engine was on and idling while heating up with the van heater blower on level 6 (out of 7). After about 45 minutes, I saw a haze first and then smelled smoke. Unsure of the source, I turned the vehicle off and exited with my do…
Read full complaint
On November 28, 2025, I experienced a vehicle fire in my Mercedes 2020 Sprinter 2500 4WD van. The van engine was on and idling while heating up with the van heater blower on level 6 (out of 7). After about 45 minutes, I saw a haze first and then smelled smoke. Unsure of the source, I turned the vehicle off and exited with my dog. I opened the hood to look for smoke in the engine bay. No smoke under the hood. I contact Mercedes Roadside and open the driver side door where I see flames under the seat. I grabbed the fire extinguisher I installed and put the fire out within 20-25 seconds of seeing it. I believe the root cause of the fire was running the van blower at a high setting for a sustained 45 minutes. My dog and I were inside and definitely in danger. It scares me to think of a scenario where the van was idling with only my dog inside and something like this occurring. The incident is currently under investigation with MB USA and my insurance company, Progressive. No warning signs or dashboard messages. In general, the electrical wiring for my vehicle has been spotty and was completely rewired by the dealer service center in 2021. Currently, there is an issue blacking out the dashboard screen so there is no screen function including gps, entertainment, or vehicle info.
NHTSA ODI #11703896
51,000 miles · Aug 25, 2025
Back Over PreventionElectrical System
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the f…
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that while in reverse, the rearview camera failed to display a rearview image. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to provide a cause for the failure. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V411000 (Electrical System, Back Over Prevention); but the VIN was not included in the recall. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 51,000.
NHTSA ODI #11682962
Mileage unknown · Dec 24, 2024
Electrical SystemPower Train
Since date of purchase, May 2022, the electrical components have not worked properly. The solar panels have never worked, the second alternator used to only charge while driving intermittently now it doesn't work at all, and plugging into shore power sometimes melts the cord. The chassis battery frequently drains requiring const…
Read full complaint
Since date of purchase, May 2022, the electrical components have not worked properly. The solar panels have never worked, the second alternator used to only charge while driving intermittently now it doesn't work at all, and plugging into shore power sometimes melts the cord. The chassis battery frequently drains requiring constant starting or a jump. It has been replaced four times. The cabin lights continue to flicker when turned on. I sought help from the dealer just weeks after purchasing the van. Due to parts and labor shortages, it wouldn't be for 5 months that they could work on the vehicle. Which they did on and off for five months before sending me from Oregon to Alabama to have the manufacturer work on it. They sent me 2300 miles to fix a brand new vehicle that they sold me. After having been to over 15 Mercedes dealers, towed to many, and to the Tiffin manufacturer (and when it turned out not to be fixed. I took it right back but then when it still wasn't fixed. I sought help from Mercedes.), the van is still not fixed and I am often without power.
NHTSA ODI #11632275
Mileage unknown · Mar 29, 2024
Electrical System
It is very difficult to start the engine, and when it starts the RPM never goes above 750. I had the van towed to a Specialist and diagnosed. Their diagnosis is that the Engine wiring harness is damaged and causing electrical malfunction which causes a number of saftey systems to prevent the vehicle from operating properly. Merc…
Read full complaint
It is very difficult to start the engine, and when it starts the RPM never goes above 750. I had the van towed to a Specialist and diagnosed. Their diagnosis is that the Engine wiring harness is damaged and causing electrical malfunction which causes a number of saftey systems to prevent the vehicle from operating properly. Mercedes Benz customer service representative indicated that the diagnosis has to be done by one of their dealers and they would decide then if they want to assist. Unfortunately, the local dealer has twice failed to address an issue thatcshould have been addressed under warranty and so I have list confidence in their ability or willingness to assist. I have received an estimate of nearly $6,400.00 to replace the faulty wiring harness on a vehicle with less than 11,000 miles.
NHTSA ODI #11580093
Mileage unknown · Jan 2, 2024
Air BagsElectrical SystemSeats
The wiring harness under my front passenger swivel seat became pinched and severed the wires. The air bag warning light came on. I took the vehicle to the dealer and got it fixed at my own expense. I noticed the recall #21V410000 which is for the same thing, however my van was not included. Can my van be included so I can be rei…
Read full complaint
The wiring harness under my front passenger swivel seat became pinched and severed the wires. The air bag warning light came on. I took the vehicle to the dealer and got it fixed at my own expense. I noticed the recall #21V410000 which is for the same thing, however my van was not included. Can my van be included so I can be reimbursed by the mfg? Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11563139
Mileage unknown · Nov 8, 2023
Electrical System
Mercedes has a design and installation flaw for the EIS Connector. Its location under the wheel by the metal wall allows for condensation to directly be absorbed into the connector causing corrosion. Once corrosion happens, the van becomes inoperable as the driver cannot shift gears and the van must be towed to the nearest Merce…
Read full complaint
Mercedes has a design and installation flaw for the EIS Connector. Its location under the wheel by the metal wall allows for condensation to directly be absorbed into the connector causing corrosion. Once corrosion happens, the van becomes inoperable as the driver cannot shift gears and the van must be towed to the nearest Mercedes dealership. This happens often to vans built after 2019 due to a change in design. Corrosion will happen over time after a change in temperature with condensation build up on the windshield. Mercedes has a solution for this, a boot cover over the EIS, however, it is not widely shared over a safety recall causing Sprinter owners to have an inoperable vehicle when such corrosion happens. This issue can be prevented with a safety recall by installing the cover allowing for a safe and reliable vehicle for civilians on the road.
NHTSA ODI #11554202
11,000 miles · Aug 9, 2023
Electrical SystemEngine
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 35 MPH, the instrument cluster lost functionality and the screen went blank. The contact stated no warning was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been …
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated while driving approximately 35 MPH, the instrument cluster lost functionality and the screen went blank. The contact stated no warning was illuminated. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed or repaired. Additionally, the contact stated that the vehicle had experienced cold start failures. The contact stated that occasionally several attempts were needed to start the vehicle. The contact stated that the failures were intermittent. The manufacturer had been informed of the failure. The contact researched online and related the instrument cluster failure to NHTSA Campaign Number: 23V204000 (Electrical System). The failure mileage was approximately 11,000.
NHTSA ODI #11537530
Mileage unknown · May 6, 2023
Electrical System
The rear camera has gone out on numerous occasions. When I place the vehicle in reverse, my infotainment displays a black area with a camera with a line through it, indicating the rear camera is not working. I’m not sure if it’s the same issue as issue “21V411” that affected other 19-21 Mercedes Sprinter vans but it seems like…
Read full complaint
The rear camera has gone out on numerous occasions. When I place the vehicle in reverse, my infotainment displays a black area with a camera with a line through it, indicating the rear camera is not working. I’m not sure if it’s the same issue as issue “21V411” that affected other 19-21 Mercedes Sprinter vans but it seems like it from what was described.
NHTSA ODI #11520784
Mileage unknown · Nov 2, 2022
Electrical SystemPower Train
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any h…
Read full complaint
The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect. Please help? Thank you
NHTSA ODI #11492020
10,000 miles · Sep 27, 2022
Electrical SystemForward Collision Avoidance
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that after inclement weather, the cruise control, Forward Collision Avoidance, and Automatic Emergency braking feature failed to operate as needed. The contact restarted the vehicle however, the vehicle would intermittently return to normal operation. The co…
Read full complaint
The contact owns a 2020 Mercedes-Benz Sprinter 2500. The contact stated that after inclement weather, the cruise control, Forward Collision Avoidance, and Automatic Emergency braking feature failed to operate as needed. The contact restarted the vehicle however, the vehicle would intermittently return to normal operation. The contact had taken the vehicle to various different dealers where the camera, unknown sensors, and other unknown parts were replaced; however, the failure persisted. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 10,000.
NHTSA ODI #11486690
Official recalls
22Dec 13, 2024
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter vehicles. The instrument cluster illumination may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Controls and Displays."
Consequence & remedy
Consequence: A display that is too bright can make it difficult for the driver to see critical safety information, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed January 31, 2025. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BELKOM.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The connection between the propeller shaft bearing and crossmember may loosen, reducing vehicle control.
Consequence & remedy
Consequence: Reduced vehicle control increases the risk of a crash. Additionally, the propeller shaft may damage the fuel tank during a crash, causing a leak and increasing the risk of a fire.
Remedy: Dealers will inspect and replace the crossmember as necessary, free of charge. Owner notification letters were mailed April 19, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3QUERTR.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The longitudinal frame members may be missing reinforcement fasteners, reducing vehicle stability and decreasing the structural integrity of the third-row seats.
Consequence & remedy
Consequence: Reduced stability increases the risk of a crash. Additionally, the third-row seat mountings can fail, increasing the risk of injury during a crash.
Remedy: Dealers will inspect and repair the frame members as necessary, free of charge. Owner notification letters were mailed March 4, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3ROHRAH.
Dec 21, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2023 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The partition wall may be missing bolts, allowing the wall to detach during a crash.
Consequence & remedy
Consequence: A detached partition wall can increase the risk of injury.
Remedy: Dealers will inspect and secure the partition wall as necessary, free of charge. Owner notification letters are expected to be mailed February 16, 2024. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TREWAN.
Mar 24, 2023
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and 2019-2021 Freightliner Sprinter vehicles. The instrument cluster may fail to display any information when the vehicle is started.
Consequence & remedy
Consequence: A blank instrument panel will not show critical information, such as vehicle speed, fuel gauge, warning messages, and warning lights, increasing the risk of a crash.
Remedy: Dealers will update the instrument cluster software on the affected vehicles, free of charge. Owner notification letters were mailed May 5, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMBAUS.
Oct 21, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2022 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with a manual parking brake and 7-speed automatic transmission. The guide bushing on the parking pawl may fatigue, which can cause the parking pawl not to engage and result in vehicle rollaway.
Consequence & remedy
Consequence: Vehicle rollaway increases the risk of a crash.
Remedy: Dealers will update the software of the electronic stability, transmission control, direct select module, and electronic ignition switch control units, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's numbers for this recall are 22V2790611, 22V2790612, and 22V2790613.
May 20, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence & remedy
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Additional source detail variants (2)
Communication: Auto Crash Notification
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter, Mercedes-Benz Metris, and Mercedes-Benz Sprinter vehicles. An error in the communication module's SIM card software can cause a mobile network connection failure, disabling the emergency call (eCall) system.
Consequence: A disabled eCall system would prevent a vehicle occupant from contacting the emergency services call center in an emergency, potentially delaying emergency responders and increasing the risk of injury.
Remedy: The communication module software will be updated through an Over-the-Air (OTA) update, or by a dealer, free of charge. Owner notification letters were mailed October 13, 2022. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2SIMKOM/VS3SIMKOM.
Apr 27, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Freightliner Sprinter and Mercedes-Benz Sprinter vehicles. The rearview camera may not display the rearview image due to a software error. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: An inoperable rearview camera display reduces the driver's rear view, increasing the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed July 20, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3KOMRUE.
Dec 15, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. A software error in the park lock system may allow the vehicle to move after the gear selector has been placed in the Park 'P' position without the parking brake applied.
Consequence & remedy
Consequence: Unintentional vehicle movement can increase the risk of a crash.
Remedy: Dealers will update the electronic stability program control unit software, free of charge. Owner notification letters were mailed February 11, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3PA27 ERI/ERO.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence & remedy
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Additional source detail variants (2)
Air Bags:passenger Side Frontal:cushion
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Electrical System
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2021 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with swivel seats. The wiring harnesses for the front seats may have been routed incorrectly and could become jammed and damaged in the swivel seat frames.
Consequence: Damage to the wiring harness can prevent the side air bag within the seat to deploy inadvertently or not deploy as designed, increasing the risk of injury.
Remedy: Dealers will attach the mounting clip to the correct position, free of charge. Owner notification letters were mailed on August 11, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DREHSEL.
Jun 2, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Additional source detail variants (2)
Electrical System:software
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
Back Over Prevention:display Function
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2021 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The MBUX multimedia system software may cause the display to remain black, or reboot after startup. This could result in the rearview camera image not displaying properly. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: A backup camera that displays a blank image reduces the driver's rear view, increasing the risk of a crash or injury.
Remedy: The multimedia system software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. DVUSA issued owners an interim notification on July 23, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3UXPOBOX.
May 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The screws for the front door hinges may not have been tightened properly.
Consequence & remedy
Consequence: Loose door hinge screws could change the gap between the door and vehicle body, increasing the risk of injury in the event of a crash.
Remedy: Dealers will check the screws and tighten them as necessary, free of charge. Owner notification letters were mailed June 18, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3TURSCHA.
Apr 6, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach and cause hydraulic fluid to leak.
Consequence & remedy
Consequence: A hydraulic fluid leak may cause a sudden loss of power steering assist, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install a screw-type clamp, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is NV3LETULPX.
Apr 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The multifunctional display in the instrument cluster may not be adjustable and appear too bright in certain lighting conditions. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 101, "Control and Displays."
Consequence & remedy
Consequence: A display that is too bright can hinder the driver's vision, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will update the instrument cluster software, free of charge. Owner notification letters were mailed on May 28, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3DISPKI.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles. The retaining washer and bolt that connect the brake pedal to the bearing block, may come loose and detach. This could cause the brake lights to stay illuminated, even when the brake pedal is not pressed.
Consequence & remedy
Consequence: Malfunctioning brake lights can fail to alert other motorists of the driver's intention, increasing the risk of a crash.
Remedy: DVUSA will notify owners and dealers will secure a bearing bracket to brake pedal by retrofitting an additional retaining ring (with PNR A 907 994 01 00) at the bearing bracket of brake pedal, free of charge. DVUSA issued owners an interim notification on May 3, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREBOL.
Mar 10, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter vehicles equipped with an optional electric sliding door. The auxiliary lock on the sliding door may be the incorrect type for an electric sliding door. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 226, "Ejection Mitigation."
Consequence & remedy
Consequence: In the event of a crash, the sliding door could dislocate more than intended, and increase the risk of injury to vehicle occupants.
Remedy: DVUSA will notify owners, and dealers will convert the sliding door from electric to manual function, free of charge. Owner notification letters were mailed January 20, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHIEBT.
Feb 17, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles equipped with the multimedia system "Connect 5" and a rearview camera. The rearview image may not display within 2 seconds from the start of the backing event. In addition, the rearview image may be obscured or covered by the visual display of the Emergency Call (eCall) pop-up window if the eCall system is activated while the reverse gear is engaged. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: A delayed or obstructed rearview camera display can reduce the driver's view of what is behind the vehicle, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will perform a software update on the vehicles, free of charge. The recall began March 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3RUECON.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Dec 21, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2019-2020 Mercedes-Benz Sprinter and Freightliner Sprinter vehicles equipped with electric parking brakes. The rear brake calipers may leak brake fluid into the housing of the electric parking brake connected to the rear axle service brake system, allowing air to enter the hydraulic brake system.
Consequence & remedy
Consequence: Air in the brake system can result in extended brake pedal travel, increasing the risk of a crash.
Remedy: DVUSA will replace the rear brake calipers, free of charge. Owners notification letters were mailed on January 4, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3BREPB.
Oct 28, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2020 Mercedes Benz Sprinter and Freightliner Sprinter vehicles. The hydraulic power steering return line hoses may detach at their connection points under certain operating conditions, causing hydraulic fluid to leak.
Consequence & remedy
Consequence: The sudden loss of power steering assist and hydraulic steering fluid leaking onto the roadway may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the return line connections of the power steering system, correcting it as needed, free of charge. The recall began December 23, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this campaign is NV3LETULPE.
Oct 14, 2020
Daimler Vans USA, LLC (DVUSA) is recalling certain 2020 Mercedes-Benz Sprinter vehicles. The outer area of the brake hoses on the front and rear axles may have been damaged during production.
Consequence & remedy
Consequence: Over time, the hose could begin to leak brake fluid, affecting the braking performance of the vehicle, including the potential loss of directional stability when braking, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will check the condition of the brake hoses on the front and rear axles and replace them as needed, free of charge. The recall began November 24, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3MONTLAU.
Sep 29, 2020
Daimler Vans USA, LLC (DVUSA) is recalling 2019-2020 Mercedes Benz and Freightliner Sprinters. The fuel line clamps may loosen and result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will check the fuel hose clamp connections and tighten or replace the components as needed, free of charge. DVUSA issued owners an interim notification on November 9, 2020. The recall began January 19, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS3SCHELLE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration