NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
2 reportsClear category filterMileage unknown · Aug 7, 2025
Electrical SystemEngineForward Collision Avoidance
I have had 2 major and costly repairs/issues with the engine and its oil system. These are detailed below. I have also received multiple collision or seatbelt dash alerts when no one is near my vehicle whatsoever. Unexpected repairs back-to-back due to defective parts/design: Oil pump control valve and harness replaced. Cos…
Read full complaint
I have had 2 major and costly repairs/issues with the engine and its oil system. These are detailed below. I have also received multiple collision or seatbelt dash alerts when no one is near my vehicle whatsoever. Unexpected repairs back-to-back due to defective parts/design: Oil pump control valve and harness replaced. Cost: $1,499. Replaced crankcase ventilation hose assembly. Cost: $3,293.37
NHTSA ODI #11679070
Mileage unknown · Aug 28, 2022
Electrical SystemUnknown Or Other
I have been trying for 5 months to get this fixed from the dealer and or manufacturer.They still state they dont have the parts or something . Its been to long and this is a serious safety hazrd to not be able to use the back up camera correctly . We are not even using the vehicle at this time .
NHTSA ODI #11481633
Official recalls
14Jul 7, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2018 Mercedes-Benz Metris vans. The value for the maximum combined load weight capacity of the tires is incorrect. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 110, "Tire and Loading Information."
Consequence & remedy
Consequence: An overloaded vehicle may cause tire failure, increasing the risk of a crash.
Remedy: Dealers will install corrected labels on the B-pillar and fuel filler door. Dealers will also inspect and replace incorrect tires, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed beginning April 19, 2024. Owners may contact DVUSA at 1-877-762-8267. DVUSA's number for this recall is VS2LASTRE.
Mar 8, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017-2022 Mercedes-Benz Metris vehicles. The connection of the upper and lower fuel hoses to the engine may be insecure, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Dealers will inspect and repair the fuel hose connections, and replace the clamps and fuel hose, as necessary, free of charge. Owner notification letters were mailed May 5, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2KRAUCH.
Feb 22, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2018 Mercedes-Benz Metris vehicles. A defective memory chip in the rearview camera may cause the display image to freeze.
Consequence & remedy
Consequence: A frozen rearview image does not show the live view of what is currently behind the vehicle, increasing the risk of a crash.
Remedy: Dealers will replace the rearview camera, free of charge. Owner notification letters were mailed February 10, 2023. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2RU54KAM.
Feb 8, 2022
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2021 Mercedes-Benz Metris vehicles. The brake fluid reservoir may be incorrectly mounted, which can allow it to detach.
Consequence & remedy
Consequence: A detached brake fluid reservoir can leak brake fluid, increasing the risk of a crash.
Remedy: Dealers will inspect and repair the brake fluid reservoir mounting, as necessary, free of charge. Owner notification letters were mailed on May 2, 2022. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2BE42BRE.
Feb 5, 2021
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2020 Mercedes-Benz Metris and 2019-2020 Mercedes-Benz Sprinter vehicles. The software design of the communication module may fail to communicate the correct vehicle location for the emergency call system (eCall) in the event of a crash.
Consequence & remedy
Consequence: Failure of the eCall system may result in emergency responders being dispatched to the wrong location, increasing the risk of injury following a crash.
Remedy: DVUSA will notify owners, and dealers will update the software communication module for the automatic emergency call system, free of charge. The recall began on May 5, 2021. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VSXHERMPOS.
Oct 8, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2019 Mercedes-Benz Metris vehicles. The integrated backup battery compartment located underneath the front passenger's seat may not have its own cover, potentially exposing the battery when the seat is moved forward.
Consequence & remedy
Consequence: If conductive material, such as metal, unintentionally drops into the opening and contacts the terminals on the battery, an electrical short can occur, increasing the risk of a fire.
Remedy: DVUSA will notify owners, and Mercedes-Benz dealers will install covers over the battery compartment area, free of charge. DVUSA issued owners an interim notification on December 2, 2019. The recall began March 9, 2020. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SITZAB.
Apr 10, 2019
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence & remedy
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Additional source detail variants (2)
Steering:electric Power Assist System
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Steering
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Metris vehicles sold, or ever registered in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, Washington DC, West Virginia and Wisconsin. The aluminum bolts that attach the power steering gear assist motor to the gear housing may corrode and fracture causing a reduction or complete loss of power steering assist.
Consequence: Loss of power steering assist would require a higher steering effort, especially at lower speeds, which may increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the aluminum bolts with steels bolts, free of charge. DTNA issued owners an interim notification on June 3, 2019. The recall began November 15, 2019. Owners may contact DVUSA customer service at 1-877-762-8267. DVUSA's number for this recall is VS2SCHRALU.
Nov 29, 2018
Daimler Vans USA, LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. The fuel hose in the engine compartment may leak at the lower connecting point of the transition hose, between the underbody fuel line and the Schrader valve and/or where the fuel line connects to the fuel pump.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: DVUSA will notify owners, and dealers will replace the affected hose and clamp, free of charge. The recall is expected to begin January 25, 2019. Owners may contact DVUSA customer service at 1-877-762-8267.
Jul 29, 2018
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017-2018 Mercedes-Benz Metris vehicles. The drive shaft securing bolts may loosen at the automatic transmission flange.
Consequence & remedy
Consequence: If the bolts loosen and fall out, the driveshaft may separate causing a loss of drive, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the transmission flange, securing bolts, and clean the shaft seal, free of charge. The recall began September 28, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Additional source detail variants (2)
Power Train:driveline:driveshaft
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017-2018 Mercedes-Benz Metris vehicles. The drive shaft securing bolts may loosen at the automatic transmission flange.
Consequence: If the bolts loosen and fall out, the driveshaft may separate causing a loss of drive, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the transmission flange, securing bolts, and clean the shaft seal, free of charge. The recall began September 28, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Power Train:automatic Transmission
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017-2018 Mercedes-Benz Metris vehicles. The drive shaft securing bolts may loosen at the automatic transmission flange.
Consequence: If the bolts loosen and fall out, the driveshaft may separate causing a loss of drive, thereby increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the transmission flange, securing bolts, and clean the shaft seal, free of charge. The recall began September 28, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
May 22, 2018
Daimler Vans USA, LLC (DVUSA) is recalling certain 2015-2017 Mercedes-Benz Metris vehicles. The transmission support may not have been properly tightened to the vehicle body, potentially resulting in damage to the driveshaft.
Consequence & remedy
Consequence: Damage to the driveshaft could cause a loss of power to the wheels, increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the transmission support mounting bolts, replacing and tightening them as necessary, free of charge. The recall began July 11, 2018. Owners may contact DVUSA customer service at 1-877-762-8267.
Oct 16, 2017
Daimler Vans USA, LLC (DVUSA) is recalling certain 2017 Mercedes-Benz Metris Vans. The front axle wheel bearings may not have been correctly seated possibly resulting in a front wheel detaching.
Consequence & remedy
Consequence: The loss of a front wheel would increase the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will inspect the front axle wheel bearing retaining rings, correcting their position as necessary, free of charge. The recall began on December 15, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Sep 22, 2017
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2015-2017 Mercedes-Benz Metris vans. These vehicles have electrical power steering control units with improperly welded contact pins.
Consequence & remedy
Consequence: The improperly welded pins may lose contact, deactivating the power steering assist and increasing the risk of a crash.
Remedy: DVUSA will notify owners, and dealers will replace the electric power steering rack, free of charge. An interim notice is expected to be mailed on November 17, 2017. A second notice will be mailed to owners when parts become available. Owners may contact Daimler's customer service at 1-877-762-8267.
Mar 7, 2017
Daimler Vans USA LLC (DVUSA) is recalling certain 2016-2017 Mercedes-Benz Metris vehicles. These vans were to be equipped with the Blind Spot Monitoring (BSM) feature, however, the installed instrument cluster and steering wheel does not support the function, and thus, the BSM system does not work on the vehicle.
Consequence & remedy
Consequence: If a vehicle is in the driver's blind spot, but the BSM system does not warn the driver, there would be an increased risk of a crash.
Remedy: DVUSA will notify owners, and dealers will install the correct instrument cluster and steering wheel to enable the BSM function, free of charge. Interim notices informing owners of the safety risk were mailed on May 8, 2017. Owners will receive a second notice when the remedy becomes available. The recall began on May 26, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Dec 27, 2016
Daimler Vans USA, LLC (DVUSA) is recalling certain model year 2017 Mercedes-Benz Metris Vans manufactured September 9, 2016, to September 28, 2016. The affected vehicles have a passenger air bag that may have been manufactured with an incorrect Tether Activation Unit (TAU). As a result, in the event of a crash necessitating deployment of the passenger frontal air bag, the air bag may not vent properly.
Consequence & remedy
Consequence: An improperly vented air bag may not protect the front passenger as expected, increasing the risk of injury.
Remedy: DVUSA will notify owners, and authorized Mercedes-Benz Sprinter dealers will replace the front passenger air bag, free of charge. The recall began February 8, 2017. Owners may contact DVUSA customer service at 1-877-762-8267.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE18002 · Low Pressure Fuel Supply Hose Leak
Opened Mar 13, 2018 · Closed Jun 18, 2019
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
On November 27, 2018, Daimler Vans USA, LLC submitted a Defect Information Report (DIR) to NHTSA describing two engine compartment fuel hose connection defects in certain model year (MY) 2016 and 2017 Mercedes-Benz Metris vehicles (Recall 18V-837).The recall scope includes approximately 12,383 Metris vehicles manufactured from March 2, 2015 (SOP) to March 15, 2017.The defects may result in leakage from an upper hose connection that feeds the high-pressure fuel pump or from a lower hose connection of the fuel transition hose between the underbody fuel line and the Shrader valve.The upper connection defect was caused by thermal aging of the hose material (Veritas hose), resulting in a loss of elasticity over time.The thermal aging of the hose leads to a progressive reduction of sealing performance, which is most evident at low ambient temperatures.The problem was corrected by changing to a hose with better material properties (ContiTech hose).The lower connection defect was caused by a manufacturing process problem, where the hose clamp may have been installed using an incorrect tool.The recall remedy involves replacing the upper and lower hoses and clamps, as necessary, and ensuring proper installation. The Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-002 to investigate nine (9) complaints (VOQs) reporting incidents of gasoline odor or leakage in nine (9) model year (MY) 2016 Mercedes-Benz Metris vans (subject vehicles).Eight (8) of the VOQs indicated that the problem occurred in cold ambient temperatures, either during engine warm-up after a cold start or after the vehicle had been parked and shutoff. Two (2) of the consumers have indicated to ODI that the problems were diagnosed by dealer service technicians as the upper hose connection defect.As part of PE18-002, ODI analyzed information related to the incidents reported to the Office by consumers and analyzed the information provided by Daimler Vans in response to ODI's information request letter.The fuel hose leak field experience shown in the Failure Report section of this resume all involve vehicles covered by the Daimler Vans recall.This Preliminary Evaluation is closed with recall 18V-837.VOQs associated with the investigation: 10936026, 10936184, 10991876, 11054491, 11057992, 11063437, 11063829, 11104437, 11138922, 11139024, 11140844, 1150262, 11152201.
Illustration