WHILE DRIVING IN MODERATE TRAFFIC ENGINE STOPPED. DRIVER (NOT ME) WAS VERY SCARED AND SAID AN ACCIDENT ALMOST OCCURRED AS SHE MANEUVERED TO BREAKDOWN LANE WITHOUT POWER AND NO POWER STEERING. SECOND OCCURRENCE OF SUDDEN ENGINE STOPPAGE WHILE DRIVING WITH LOSS OF ENGINE POWER AND POWER STEERING IN THIS VEHICLE. FUEL PUMP HAD B…
Read full complaint
WHILE DRIVING IN MODERATE TRAFFIC ENGINE STOPPED. DRIVER (NOT ME) WAS VERY SCARED AND SAID AN ACCIDENT ALMOST OCCURRED AS SHE MANEUVERED TO BREAKDOWN LANE WITHOUT POWER AND NO POWER STEERING. SECOND OCCURRENCE OF SUDDEN ENGINE STOPPAGE WHILE DRIVING WITH LOSS OF ENGINE POWER AND POWER STEERING IN THIS VEHICLE. FUEL PUMP HAD BEEN PREVIOUSLY REPLACED. *TR
MERCEDES-BENZ IS RECALLING CERTAIN MODEL YEAR 1999-2002 M-CLASS AND MODEL YEAR 2000-2003 M-CLASS AMG VEHICLES. THE CRUISE CONTROL SYSTEM IN THE AFFECTED VEHICLES ALLOWS THE DRIVER TO DISENGAGE THE SYSTEM IN A NUMBER OF WAYS, INCLUDING TAPPING THE BRAKE PEDAL, USING THE CRUISE CONTROL STALK, OR BRAKING THE VEHICLE ENOUGH TO REACH A CERTAIN RATE OF DECELERATION. MERCEDES-BENZ HAS DETERMINED THAT UNDER CERTAIN CIRCUMSTANCES USE OF THE BRAKE PEDAL MAY NOT AUTOMATICALLY DISENGAGE CRUISE CONTROL AS EXPECTED BY THE DRIVER, ALTHOUGH THE OTHER MEANS OF DEACTIVATING CRUISE CONTROL REMAIN FULLY OPERATIVE. SPECIFICALLY, WHERE THE DRIVER PUMPS THE BRAKES RATHER THAN APPLYING CONSISTENT PEDAL FORCE, THE LEVEL OF FORCE REQUIRED MAY BE UNUSUALLY HIGH.
Consequence & remedy
Consequence: DIFFICULTY OR DELAY IN DISENGAGING CRUISE CONTROL CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN DURING OCTOBER 2011. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
MERCEDES-BENZ IS RECALLING 125,228 MY 1998-2004 M-CLASS VEHICLES. THE HOSE CLAMP USED TO SECURE THE POWER STEERING FLUID COOLING HOSE TO THE POWER STEERING FLUID COOLER MAY NOT PROVIDE SUFFICIENT CLAMPING FORCE FOR THIS CONNECTION.
Consequence & remedy
Consequence: THE LOSS OF POWER STEERING FLUID MAY RESULT IN DIMINISHED POWER STEERING OVER TIME AND ULTIMATELY CAN DAMAGE THE POWER STEERING PUMP. THIS COULD RESULT IN A LOSS OF CONTROL AND A CRASH WITHOUT WARNING.
Remedy: AN EARLIER RECALL REPAIR PERFORMED ON THESE VEHICLES MAY NOT BE SUFFICIENT TO PREVENT A FUTURE LEAKAGE OR FAILURE OF THE POWER STEERING HOSE CONNECTION (PLEASE SEE 03V121). SINCE IT IS NOT POSSIBLE THROUGH INSPECTION TO IDENTIFY SPECIFIC VEHICLES THAT MAY NOT HAVE BEEN PROPERLY REPAIRED, ALL VEHICLES REPAIRED PRIOR TO NOVEMBER 15, 2003, WILL BE REPAIRED AGAIN. THE RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2008. OWNERS MAY CONTACT MERCEDES-BENZ AT 1-800-367-6372.
ON CERTAIN PASSENGER VEHICLES, THE HOSE CLAMP USED TO SECURE THE POWER STEERING FLUID COOLING HOSE TO THE POWER STEERING FLUID COOLER MAY NOT PROVIDE SUFFICIENT CLAMPING FORCE FOR THIS CONNECTION.
Consequence & remedy
Consequence: THE LOSS OF POWER STEERING FLUID MAY RESULT IN DIMINISHED POWER STEERING OVER TIME AND ULTIMATELY CAN DAMAGE THE POWER STEERING PUMP.
Remedy: DEALERS WILL INSTALL A NEW HOSE CLAMP ON THE POWER STEERING HOSE TO THE POWER STEERING COOLER. DURING CLAMP REPLACEMENT, THE POWER STEERING COOLING HOSE WILL BE INSPECTED AND REPLACED AS NECESSARY. OWNER NOTIFICATION BEGAN JUNE 16, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERCEDES-BENZ AT 1-800-367-6372.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
RQ08002 · Power Steering Hose Leak
Opened Mar 11, 2008 · Closed Sep 17, 2008
Status: closed (inferred from source dates) · Steering:hydraulic Power Assist System; Steering:hydraulic Power Assist:hose, Piping, And Connections; Steering:hydraulic Power Assist:power Steering Fluid
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Additional source detail variants (3)
Steering:hydraulic Power Assist:hose, Piping, And Connections
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Steering:hydraulic Power Assist:power Steering Fluid
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
Steering:hydraulic Power Assist System
MERCEDES-BENZ USA (MBUSA) WILL NOTIFY CERTAIN MODEL YEAR (MY) 1998 THROUGH 2003 M-CLASS OWNERS OF THE NEED TO BRING THEIR VEHICLES INTO DEALERS TO ADDRESS THE ISSUE PREVIOUSLY CAMPAIGNED UNDER MBUSA RECALL 2003-040005 (NHTSA RECALL 03V-121).THE MBUSA CAMPAIGN, WHICH ODI IS DESIGNATING RECALL 08V-465, WILL REPLACE THE POWER STEERING COOLER HOSE AND CLAMP IN ALL VEHICLES THAT RECEIVED THE ORIGINAL RECALL REMEDY FOR 03V-121 AND WHICH HAVEN'T RECEIVED A SUBSEQUENT REPAIR TO INSTALL A REVISED HOSE AND CLAMP.APPROXIMATELY ONE-THIRD OF THE VEHICLES THAT RECEIVED THE ORIGINAL REPAIR PROCEDURE AND PARTS RETURNED FOR SUBSEQUENT SERVICE FOR LEAKAGE FROM THE HOSE FITTING AND, IN APPROXIMATELY 10 PERCENT OF THESE VEHICLES, COMPLETE SEPARATION OF THE HOSE FROM THE COOLER.A REVISED SERVICE PROCEDURE FOR 03V-121, WHICH INVOLVED REPLACING THE OLD HOSE AND CLAMP WITH MODIFIED PARTS, HAD SIGNIFICANTLY LOWER RATES OF RETURN REPAIRS.MBUSA WILL APPLY THE REVISED SERVICE PROCEDURE FROM 03V-121 TO THE VEHICLES COVERED UNDER 08V-465.ACCORDINGLY THIS RECALL QUERY IS CLOSED.
2003 Mercedes Benz M Class Problems, Complaints & Recalls | Skip That Year
Illustration