IllustrationTHERE IS A VERY STRONG SMELL OF GASOLINE FUMES EMANATING FROM THE AUTOMOBILE, ESPECIALLY OUTSIDE THE AUTO IT SEEMS FROM AROUND THE DRIVER'S SIDE AND REAR OF THE CAR. IT IS THERE ESPECIALLY AFTER FILLING THE GAS TANK BUT CONTINUES EVEN AFTERWARDS. THE ODOR IS VERY STRONG AND THERE IS OBVIOUSLY A PROBLEM. *TR
2004 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2004 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
80–25K
1525–50K
3150–75K
3275–100K
64100–150K
18150K+
168 reports with mileage · 35 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 79 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel System, Gasoline. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports1 fire reports4 injury reports
What owners actually said
203 reportsI LEFT MY HOME IN CINCINNATI, OH AT 8:25, WITH A 1/2 TANK OF GAS, DROVE ~ 3 MILES TO HWY126 AND MERGED TO 75S. I MOVED FROM THE RIGHT TO THE MIDDLE TO THE LEFT LANE. AFTER BEING AT 50 MPH ~ 2 MINUTES ON THE LEFT LANE, THE CAR SUDDENLY STOPPED. THE DASHBOARD WAS ALL LIT UP WITH WARNING SIGNS, CHECK ENGINE, BRAKES AND OIL. I PUT M…
Read full complaint
I LEFT MY HOME IN CINCINNATI, OH AT 8:25, WITH A 1/2 TANK OF GAS, DROVE ~ 3 MILES TO HWY126 AND MERGED TO 75S. I MOVED FROM THE RIGHT TO THE MIDDLE TO THE LEFT LANE. AFTER BEING AT 50 MPH ~ 2 MINUTES ON THE LEFT LANE, THE CAR SUDDENLY STOPPED. THE DASHBOARD WAS ALL LIT UP WITH WARNING SIGNS, CHECK ENGINE, BRAKES AND OIL. I PUT MY HAZARD LIGHT ON, PUT THE CAR IN PARK, TURNED THE KEY OFF, AND THEN BACK ON. THE SAME WARNING SIGNS CAME ON AND THE CAR DID NOT START. I CALLED MERCEDES ASSISTANCE WHO ADVISED TO CALL 911 AND THAT A TOW TRUCK WILL ARRIVE IN 1 HOUR. I CALLED 911 AND SURPRISINGLY GOT A VOICE MESSAGE THAT ALL OPERATORS ARE BUSY! A MINUTE LATER AN OPERATOR CAME ON THE LINE, SHE ASKED WHERE I WAS AND I TOLD HER THAT I WAS ON THE LEFT (HIGH SPEED LANE). SHE ASKED ME IF I WAS IN A BLACK MERCEDES. SHE INDICATED THAT A DISPATCHER IS ON THE WAY. AT 8:51 I CALLED AAA TO GET A TOWTRUCK EARLIER. THEY SAID THEY WILL COME IN 45 MIN. A CAR ASSISTANCE VAN CAME AND EVENTUALLY THE POLICE CAR. THEY STOPPED BEHIND MY CAR, AND TRIED TO TURN THE CAR ON AND WERE UNABLE TO, THEY ASKED ME TO PUT IT IN NEUTRAL BUT THE GEAR WOULD NOT MOVE. THE POLICEMAN STOPPED THE TRAFFIC ON THE HIGHWAY, ASKED ME TO STEP OUT OF THE CAR WHILE HE MANAGED TO PUT THE GEAR ON NEUTRAL AND ASKED ME TO SIT BACK IN THE CAR AND STEER. THEY MANUALLY PUSHED THE CAR TO THE RIGHT SHOULDER BUT I WAS NOT ABLE TO STEER AS THE POWER STEERING WAS NOT WORKING. AT 9:18 THE AAA TRUCK CAME AND TOWED THE CAR TO THE MERCEDES DEALERSHIP. THEY DIAGNOSED THE PROBLEM AS A SUDDEN FAILURE OF THE CRANKSHAFT POSITION SENSOR AND REPLACED IT FOR A CHARGE OF $463.46. I FOUND ON THE WEB THAT SEVERAL MERCEDES MODELS HAVE HAD THIS PROBLEM OCCUR BUT THERE HAS NEVER BEEN A RECALL. THE SUDDEN COMPLETE FAILURE OF A CAR IN THE MIDST OF RUSH HOUR TRAFFIC CREATING A MAJOR HAZARD TO ME AND OTHER DRIVERS NEEDS THE ATTENTION OF THE NHTSA. *TR
TL* THE CONTACT OWNS A 2004 MERCEDES E-320. THE CONTACT STATED THAT HE WAS EXPERIENCED A STRONG ODOR OF GASOLINE AFTER REFUELING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 07/…
Read full complaint
TL* THE CONTACT OWNS A 2004 MERCEDES E-320. THE CONTACT STATED THAT HE WAS EXPERIENCED A STRONG ODOR OF GASOLINE AFTER REFUELING THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER OR INDEPENDENT MECHANIC. THE MANUFACTURE WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000 AND THE CURRENT MILEAGE WAS 92,000. UPDATED 07/15/14 MA
TL* THE CONTACT OWNS A 2004 MERCEDES BENZ E320. THE CONTACT STATED THAT FUEL WAS POOLING ON THE FLOOR BOARD OF THE REAR SEAT. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE SENDING UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. T…
Read full complaint
TL* THE CONTACT OWNS A 2004 MERCEDES BENZ E320. THE CONTACT STATED THAT FUEL WAS POOLING ON THE FLOOR BOARD OF THE REAR SEAT. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE SENDING UNIT WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 55,000 AND THE CURRENT MILEAGE WAS 56,000.
UPON ENTERING MY CLOSED GARAGE IN THE EARLY MORNING, I NOTICED A VERY STRONG GASOLINE SMELL. I TOOK THE CAR TO MY MERCEDES REPAIR SHOP (NOT A DEALER) WHO INFORMED ME THAT THERE WAS A LEAK IN THE FUEL SENDING UNIT AND THAT THIS WAS A DEVELOPING PROBLEM WITH E CLASS CARS. HE SAID THERE WERE CLASS ACTION SUITS AGAINST MERCEDES FO…
Read full complaint
UPON ENTERING MY CLOSED GARAGE IN THE EARLY MORNING, I NOTICED A VERY STRONG GASOLINE SMELL. I TOOK THE CAR TO MY MERCEDES REPAIR SHOP (NOT A DEALER) WHO INFORMED ME THAT THERE WAS A LEAK IN THE FUEL SENDING UNIT AND THAT THIS WAS A DEVELOPING PROBLEM WITH E CLASS CARS. HE SAID THERE WERE CLASS ACTION SUITS AGAINST MERCEDES FOR THIS PROBLEM. HE SAID MERCEDES WOULD NOT ADMIT IT WAS A SAFETY PROBLEM. WELL, IT SEEMS LIKE A SAFELY PROBLEM TO ME! I CERTAINLY HOPE MY GOVERNMENT'S NTSB IS LOOKING INTO THIS. ARE WE WAITING FOR PEOPLE TO BE SEVERELY BURNED OR KILLED DUE TO THIS PROBLEM? *TR
STRONG SMELL OF GASOLINE PRESENT AFTER FILL UPS AND WHEN CAR IS STATIONARY. WITH FUMES PRESENT IN THE CABIN, THE RISK OF FIRE IS SEVERE. MERCEDES IS AWARE OF THIS PROBLEM, AS IS THE NHTSA, SO PLEASE DO SOMETHING ABOUT IT!..UPDATED 07/23/14 *BF
I HAVE A FUEL UNDERCARRIAGE LEAK FROM THE REAR PASSENGER LEFT SIDE WITH A STRONG GAS SMELL WITHIN THE CABIN OF MY CAR- THIS PROBLEM HAS BEEN REFERENCED MANY TIMES IN THE MB FORUMS AND SEEMS TO BE A NATIONAL PROBLEM. I WOULD APPRECIATE A THROUGH INVESTIGATION REGARDING THIS ISSUE BEFORE A FATALITY ENSUES BECAUSE OF A FAULTY PLAST…
Read full complaint
I HAVE A FUEL UNDERCARRIAGE LEAK FROM THE REAR PASSENGER LEFT SIDE WITH A STRONG GAS SMELL WITHIN THE CABIN OF MY CAR- THIS PROBLEM HAS BEEN REFERENCED MANY TIMES IN THE MB FORUMS AND SEEMS TO BE A NATIONAL PROBLEM. I WOULD APPRECIATE A THROUGH INVESTIGATION REGARDING THIS ISSUE BEFORE A FATALITY ENSUES BECAUSE OF A FAULTY PLASTIC PIECE DESIGNED BY MB. THIS PROBLEM OCCURS WHEN THE TANK IS FILLED WITH GAS, BUT OVER FILLED. I IMPLORE TO DO THE RIGHT THING AN IMPLEMENTING A RECALL FOR CORRECTIVE ACTIONS.[XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
DRIVING ON THE FREEWAY, 61 MPH, START RAINING HARD, POURING, CAR SLIPPED, TURNED AND HIT THE WALL ON THE SIDE OF THE FREEWAY HEADS ON STRAIGHT. GOT HIT BY ANOTHER CAR ON THE SIDE, AFTER COUPLE OF TURNS, IT STOPPED ON THE MIDDLE OF THE FREEWAY. COUPLE OF SIDE AIR BAGS DEPLOYED, THE MOST IMPORTANT ONES, THE FRONT AIR BAGS, DRIVE…
Read full complaint
DRIVING ON THE FREEWAY, 61 MPH, START RAINING HARD, POURING, CAR SLIPPED, TURNED AND HIT THE WALL ON THE SIDE OF THE FREEWAY HEADS ON STRAIGHT. GOT HIT BY ANOTHER CAR ON THE SIDE, AFTER COUPLE OF TURNS, IT STOPPED ON THE MIDDLE OF THE FREEWAY. COUPLE OF SIDE AIR BAGS DEPLOYED, THE MOST IMPORTANT ONES, THE FRONT AIR BAGS, DRIVER AND PASSENGER SIDE DID NOT DEPLOYED. *TR
FUEL LEAKING FROM TOP OF FUEL TANK. TANK WAS CRACKED AND HAD TO BE REPLACED. *TR
WHILE DRIVING I STARTED SMELLING GAS, ESPECIALLY WHEN I WOULD HAVE JUST FILLED THE TANK. THIS SMELL WENT ON FOR YEARS, IT GOT ODOR GOT STRONGER AND STRONGER SO FINALLY I WENT AND GOT IT DIAGNOSED AND MY MECHANIC SAID THAT I NEED REPLACE MY FUEL PUMP AND SHOWED ME THE GASOLINE UNDER THE REAR SEAT (REAR DRIVER'S SIDE) THE AMOUNT O…
Read full complaint
WHILE DRIVING I STARTED SMELLING GAS, ESPECIALLY WHEN I WOULD HAVE JUST FILLED THE TANK. THIS SMELL WENT ON FOR YEARS, IT GOT ODOR GOT STRONGER AND STRONGER SO FINALLY I WENT AND GOT IT DIAGNOSED AND MY MECHANIC SAID THAT I NEED REPLACE MY FUEL PUMP AND SHOWED ME THE GASOLINE UNDER THE REAR SEAT (REAR DRIVER'S SIDE) THE AMOUNT OF GAS WAS SO GREAT THAT I CALLED AND ASKED MY REP AT MERCEDES IF THERE WAS INDEED A RECALL ON THE PART AND I ALSO TOLD HIM THAT MY MECHANIC SAID THAT THERE SHOULD HAVE BEEN A RECALL ON IT , AND STILL HE SAID NO. SO I REPLACED THE PART ON MY OWN. NOW I AM SMELLING THE FUMES AGAIN, I TAKE IT THAT IT IS COMING FROM THE OTHER SIDE. I HAVE TO RIDE WITH MY WINDOWS DOWN AND/OR SUNROOF OPEN TO KEEP FROM GETTING THE HEAD-ACHES AGAIN. THIS HAVE BEEN ONGOING FOR YEARS NOW . I PURCHASED THE CAR IN JAN. 2008. *TR
Official recalls
224V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un