IllustrationTHE SBC UNIT FOR THE BRAKE SYSTEM IS BOUND TO FAIL THERE WAS A 10 YEAR RECALL ON THIS BUT NOT ALL VEHICLE WHERE DONE NOW MERCEDES ATTITUDE IS OH WELL BAD LUCK PAY US AND WE WILL FIX OUR FAULTY PART
2003 Mercedes Benz E320
Owner reports · Recalls · Investigations
More warning signs than most E320 years
Owner complaints for the 2003 Mercedes Benz E320 are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all E320 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
1125–50K
2450–75K
3375–100K
58100–150K
24150K+
162 reports with mileage · 52 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel/propulsion System. Review the 71 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 21 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports1 fire reports8 injury reports
Service Brakes complaints
57 reportsSBC PUMP WENT OUT IN THE MIDDLE OF THE NIGHT, ON A LONELY, DARK TWO LANE ROAD WITHOUT ANY NOTICE THAT THERE WAS A BRAKE ISSUE, APPROXIMATELY 200+ MILES FROM MY HOME. MESSAGE INDICATOR IN CAR STARTED BEEPING AND AN EMERGENCY MESSAGE DISPLAYED STATING BRAKE MALFUNCTION, STOP VEHICLE. CAR HARDLY ANY BRAKE POWER AND COULD NOT BE DRI…
Read full complaint
SBC PUMP WENT OUT IN THE MIDDLE OF THE NIGHT, ON A LONELY, DARK TWO LANE ROAD WITHOUT ANY NOTICE THAT THERE WAS A BRAKE ISSUE, APPROXIMATELY 200+ MILES FROM MY HOME. MESSAGE INDICATOR IN CAR STARTED BEEPING AND AN EMERGENCY MESSAGE DISPLAYED STATING BRAKE MALFUNCTION, STOP VEHICLE. CAR HARDLY ANY BRAKE POWER AND COULD NOT BE DRIVEN OVER 35 MPH. PULLED OVER AND NOW CAR WOULD NOT COME OUT OF PARK. HAD TO WAIT 3 HOURS FOR A TOW TRUCK! LUCKILY I DID NOT HAVE MY FAMILY WITH ME OF WHICH INCLUDES SMALL CHILDREN!
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE BRAKES FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC PUMP FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE O…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES-BENZ E320. WHILE DRIVING AT VARIOUS SPEEDS AND ATTEMPTING TO DEPRESS THE BRAKE PEDAL, THE BRAKES FAILED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC PUMP FAILED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 144,000.
THE SBC BRAKE UNIT FAILED WHILE I WAS ON VACATION. THE REST OF THE BRAKE SYSTEM WORKS FINE. MERCEDES RECALLED THIS BRAKE SYSTEM AND KNEW IT WAS UNSAFE, HOWEVER NOW THEY WILL NOT REPLACE THE PART UNLESS I PAY AND THE COST IS $2,500.00 PER THE DEALER. WITHOUT IT THE CAR IS GARBAGE. IT IS AN ELECTRONIC BRAKING SYSTEM.
BRAKES JUST WHEN OUT ON IT AND THEY HAVE A RECALL BUT IS GOOD FOR JUST 10 THEY NEED TO BE RESPONS FOR THIS PROBLEM MAKING CARS WITH NO BRAKES IS A DEITH WISH I HOPE YOU GUYS DO SOMETHING ABOUT IT IS NOT SAFE AT ALL
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ E320. WHILE PARKED, THE VEHICLE'S "SERVICE BRAKES-VISIT WORKSHOP" LIGHT ILLUMINATED. THE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE O…
Read full complaint
TL* THE CONTACT OWNS A 2003 MERCEDES BENZ E320. WHILE PARKED, THE VEHICLE'S "SERVICE BRAKES-VISIT WORKSHOP" LIGHT ILLUMINATED. THE WARNING LIGHT ILLUMINATED INTERMITTENTLY. THE CONTACT ALSO STATED THAT THERE WAS AN ABNORMAL NOISE COMING FROM THE ENGINE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 77,000.
I WAS TRAVELING ON A SECONDARY ROAD AT A SPEED OF 30MPH WHEN THE MFD TURNED RED, STARTED BEEPING AND STATED BRAKE FAILURE, STOP DRIVING. WHEN I ATTEMPTED TO STOP, THE BRAKE PEDAL WENT TO THE FLOOR AND THE TRANSMISSION AUTOMATICALLY DOWN SHIFTED. AFTER PULLING THE CAR TO THE SIDE OF THE ROAD, I PUT THE TRANSMISSION IN PARK WHERE…
Read full complaint
I WAS TRAVELING ON A SECONDARY ROAD AT A SPEED OF 30MPH WHEN THE MFD TURNED RED, STARTED BEEPING AND STATED BRAKE FAILURE, STOP DRIVING. WHEN I ATTEMPTED TO STOP, THE BRAKE PEDAL WENT TO THE FLOOR AND THE TRANSMISSION AUTOMATICALLY DOWN SHIFTED. AFTER PULLING THE CAR TO THE SIDE OF THE ROAD, I PUT THE TRANSMISSION IN PARK WHERE IT LOCKED IN PLACE. AFTER FIFTEEN MINUTES THE SBC RESET ITSELF AND THE TRANSMISSION UNLOCKED. THE VEHICLE WAS REMOVED TO THE MERCEDES DEALER WHERE I PURCHASED IT. THE MERCEDES TECH STATED THAT THE SBC NEEDS TO BE REPLACED. I WAS TOLD THERE WAS A 10 YEAR WARRANTY ON THE SBC UNIT, BUT IT EXPIRED IN JUNE 2013. I AM THE ORIGINAL OWNER AND MERCEDES BENZ USA STATED THAT THEY DID NOT NOTIFY THE OWNERS OF THE WARRANTY EXTENSION OR OF THE PROBLEMS WITH THE SBC. THE COST TO REPLACE THE SBC IS $2,000.
WHEN I'M STOPING THE CAR, THE BREAKS DID NOT WORK AS IT SHOULD, AND THE STOP DISTANCE INCREASED BY 50% !! ON AUGUST 10TH I WAS IN THE ON THE WAY BETWEEN CHARLOTTE AND NASHVILLE, IN THE MOUNTAINS CURVES WAY DOWN, I USED THE BREAKS, THE CAR ALMOST GOT OUT OF CONTROL.... I FELT LIKE THE FRONT AND REAR BREAKS DON'T DO ANY SYNCHRONI…
Read full complaint
WHEN I'M STOPING THE CAR, THE BREAKS DID NOT WORK AS IT SHOULD, AND THE STOP DISTANCE INCREASED BY 50% !! ON AUGUST 10TH I WAS IN THE ON THE WAY BETWEEN CHARLOTTE AND NASHVILLE, IN THE MOUNTAINS CURVES WAY DOWN, I USED THE BREAKS, THE CAR ALMOST GOT OUT OF CONTROL.... I FELT LIKE THE FRONT AND REAR BREAKS DON'T DO ANY SYNCHRONIZATION TO STOP THE CAR, ITS MAKING THE CAR LOSING CONTROL ON THE CURVES..... I RED ON THIS ISSUE ON INTERNET I FOUND THAT MERCEDES HAS USED A NEW BREAKING SYSTEM FOR THIS CAR AND STOP INSTALLING THIS SYSTEM IT IN 2006! THE REASON WHY THEY STOP USING THIS BECAUSE IT 100% ELECTRONIC BREAKS SYSTEM, IT CALLED SBC (SENSOTRONIC BRAKE CONTROL ) WHEN THIS THRESHOLD IS REACHED THE BRAKE SYSTEM DEFAULTS TO NON POWER ASSISTED HYDRAULIC MODE TO THE FRONT WHEELS ONLY. THIS OCCURS WITHOUT ANY PRIOR WARNING AND RESULTS IN INCREASED STOPPING DISTANCE. I HAVE SENT A COPY OF THE MERCEDES SERVICE BULLETIN S142.46-P-0012A WHICH ADDRESSES THIS ISSUE. MERCEDES STOPPED INSTALLING THIS SYSTEM IN 2006. AT THE VERY LEAST, MERCEDES SHOULD ISSUE A MANDATORY RECALL TO INTERROGATE THESE VEHICLES WITH STAR DAS TO DETERMINE HOW CLOSE TO THE SERVICE THRESHOLD THE SBC UNIT IS AND REPLACE THEM AT THE DEALER'S EXPENSE. THIS IS A MAJOR SAFETY ISSUE THAT NEEDS TO BE ADDRESSED.
VEHICLE PRESENTED WITH RED LIGHT INDICATING TO TAKE VEHICLE TO WORKSHOP IN RED. BRAKING WAS EXTREMELY DIFFICULT, SRS SYSTEM STALLED THE VEHICLE, EMERGENCY MODE WAS ACTIVITED,WE WERE UNABLE, AT FIRST TO TURN ON THE IGNITION SWITCH. THE VEHICLE OPERATED AS IF IT WAS PARALYZED. WE FINALLY GOT THE VEHICLE TO RUN AND RESET THE CODE B…
Read full complaint
VEHICLE PRESENTED WITH RED LIGHT INDICATING TO TAKE VEHICLE TO WORKSHOP IN RED. BRAKING WAS EXTREMELY DIFFICULT, SRS SYSTEM STALLED THE VEHICLE, EMERGENCY MODE WAS ACTIVITED,WE WERE UNABLE, AT FIRST TO TURN ON THE IGNITION SWITCH. THE VEHICLE OPERATED AS IF IT WAS PARALYZED. WE FINALLY GOT THE VEHICLE TO RUN AND RESET THE CODE BY TURNING THE STEERING WHEEL. THE VEHICLE IS VERY DANGEROUS TO DRIVE IF YOU ARE NOT PREPARED FOR LONGER STOPPING DISTANCES, THANKFULLY MY HUSBAND WAS ABLE TO GET THE VEHICLE TO THE DEALERSHIP. I FOUND MYSELF NOT STRONG ENOUGH TO PRESS ON THE BRAKE PEDAL FOR ADEQUATE BRAKING DISTANCE. THIS CAR LEFT ME WITH NO BRAKES AT ALL DRIVING WITH CHILDREN IN THE CAR. THIS I'D NOT SAFE!
VEHICLE PRESENTED WITH RED LIGHT INDICATING TO TAKE VEHICLE TO WORKSHOP IN RED. BRAKING WAS EXTREMELY DIFFICULT, SRS SYSTEM STALLED THE VEHICLE, EMERGENCY MODE WAS ACTIVITED,WE WERE UNABLE, AT FIRST TO TURN ON THE IGNITION SWITCH. THE VEHICLE OPERATED AS IF IT WAS PARALYZED. WE FINALLY GOT THE VEHICLE TO RUN AND TURNED VEHICLE…
Read full complaint
VEHICLE PRESENTED WITH RED LIGHT INDICATING TO TAKE VEHICLE TO WORKSHOP IN RED. BRAKING WAS EXTREMELY DIFFICULT, SRS SYSTEM STALLED THE VEHICLE, EMERGENCY MODE WAS ACTIVITED,WE WERE UNABLE, AT FIRST TO TURN ON THE IGNITION SWITCH. THE VEHICLE OPERATED AS IF IT WAS PARALYZED. WE FINALLY GOT THE VEHICLE TO RUN AND TURNED VEHICLE INTO MB DEALERSHIP. WE WERE INFORMED THAT THE SBC UNIT WAS IN NEED OF REPLACEMENT, WE WERE BESET WITH 1,800.00 REPAIR. THE VEHICLE IS VERY DANGEROUS TO DRIVE IF YOU ARE NOT PREPARED FOR LONGER STOPPING DISTANCES, THANKFULLY MY HUSBAND WAS ABLE TO GET THE VEHICLE TO THE DEALERSHIP. I FOUND MYSELF NOT STRONG ENOUGH TO PRESS ON THE BRAKE PEDAL FOR ADEQUATE BRAKING DISTANCE. FUEL: UPON FUELING VEHICLE, THE FUEL HANDLE WILL STOP AND IMMENSE AMOUNTS OF FUEL WILL SPURT OUT FROM FUEL TANK. THERE IS ALSO A SMELL OF GAS/FUEL IN THE CABIN AFTER FILL UP. THIS CREATES A HUGE SPILL AND NOTIFICATION TO ATTENDANT. TAKES UP A GREAT AMOUNT OF TIME TO FILL UP TANK. SURPRISINGLY WE HAVEN'T BEEN CHARGED FOR FUEL SPILLS. SRS: LIGHT ON FOR SAFETY RESPONSE SYSTEM, SHORTLY AFTER VISIT AT MB DEALERSHIP. HAVE NOT TAKEN VEHICLE TO MB DEALERSHIP FOR FEAR OF ANOTHER EXPENSIVE REPAIR.
Official recalls
224V874000 · Visibility:sun/moon Roof Assembly
Nov 19, 2024
Mercedes-Benz USA, LLC (MBUSA) is recalling certain 2001-2011 C-Class, CLK, E-Class, and CLS vehicles. Please see the recall report for a complete list of models and model years. The glass sunroof panel may not be properly secured and can detach.
Consequence & remedy
Consequence: A detached sunroof panel can become a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the sunroof panel as necessary, free of charge. Owner notification letters were mailed January 10, 2025. Owners may contact MBUSA customer service at 1-800-367-6372. This recall is an expansion of previous NHTSA recall number 22V-954. MBUSA's number for this recall is 2024120001/2/3.
19V918000 · Visibility:sun/moon Roof Assembly
Dec 20, 2019
Mercedes-Benz USA, LLC. (MBUSA) is recalling certain 2001-2011 vehicles. The bonding between the glass panel and the sliding roof frame may deteriorate, possibly resulting in the glass panel detaching from the vehicle. For a full list of the affected models visit: https://static.nhtsa.gov/odi/rcl/2019/RMISC-19V918-4126.pdf
Consequence & remedy
Consequence: A detached glass panel can separate from the vehicle and become a road hazard, increasing the risk of a crash.
Remedy: MBUSA will notify owners, and dealers will inspect the glass panel bonding and replace the sliding roof, as necessary, free of charge. The recall began July 10, 2020. Owners may contact MBUSA customer service at 1-800-367-6372. MBUSA's number for this recall is 2020040011.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA13003 · Fuel Leakage From The Fuel Tank
Opened Mar 15, 2013 · Closed Dec 19, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:delivery; Fuel System, Gasoline:delivery:fuel Pump; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Additional source detail variants (6)
Fuel System, Gasoline:delivery:fuel Pump
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:delivery
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un
Fuel System, Gasoline:storage:tank Assembly
The Office of Defects Investigation (ODI) opened this investigation on January 23, 2012 as PE12-001 based on 20 consumer reports in model year (MY) 2003-2006 E55 AMG vehicles.Based on new reports in other E-Class vehicles, ODI upgraded the investigation to Engineering Analysis (EA) 13-003 on March 15, 2013, and expanded the scope to all E-Class vehicles through MY 2008.The complainants alleged a strong odor of gasoline fuel both inside and outside of their vehicle, particularly after refilling the fuel tank.Many of the complainants noted that the odor subsided or went away after driving some distance thereby lowering the fuel level in the tank.Other owners reported they would only fill the tank to about three quarters full to avoid the odor altogether.Some complainants alleged fuel leaked from the fuel filter/sender, located on the top of the fuel tank on the driver's side, and collected on top of the tank.There were also allegations that the fuel leaks were associated with an Emissions Recall Campaign (No. 2008020001) conducted by Mercedes-Benz USA, LLC (Mercedes) in 2008 on MY 2003-2006 E-Class and CLS-Class AMG models.The issue in the recall involved small cracks in the pressurized outlet fitting of the fuel filter/sender.AMG vehicles are high performance models that operate at higher fuel pressure and use a different fuel filter/sender and fuel pump than non-AMG models.Information on Recall No. 2008020001 is available from the U.S. Environmental Protection Agency (EPA) website at www.EPA.gov.ODI's investigation found various leak sources that are unrelated to the outlet fitting cited in the EPA recall campaign.Through interviews with complainants, field inspections of complaint vehicles, and the collection and laboratory analysis of failed parts, three identifiable leak sources were found.The component parts and areas of the leaks involve the On-Board Diagnostic fuel tank pressure sensor (located on top of the fuel filter/sender), the outlet of the centrally mounted fuel tank fuel filling limiter valve, and the top of the fuel pump. These areas of leakage are located at the top of the fuel tank in unpressurized parts of the fuel system. When the tank is full, fuel can slowly weep/seep from micro-cracks in these components and may collect in cavities on top of the filter/sender, pump, or tank.Contrary to complainant's allegations that fuel entered the inside of their vehicle under the rear seat bench, neither ODI nor Mercedes found a plausible way for this to occur.The fuel tank is located outside of the passenger compartment, attached to the underside of the vehicle.The service access ports for the fuel filter/sender (driver's side) and fuel pump (passenger's side) are located under the rear seat bench, covered by a steel plate, sealed and bolted to the vehicle floor.When technicians service the fuel filter/sender, which has a regularly scheduled 60,000 mile service interval, and/or the fuel pump, the work is performed from inside the vehicle by working through the access ports.By letter dated September 4, 2014, Mercedes has notified the agency that it will extend the original warranty coverage to 15 years and unlimited mileage on Covered Fuel Tank Components in E-Class vehicles in MY 2003-2009 and CLS-Class vehicles in MY 2006-2011.The covered fuel tank components for the warranty extension include the fuel tank, fuel filter/sender, fuel pump, and all related gaskets/seals and retention rings.ODI is closing this investigation based on the manufacturer's extend warranty of the affected fuel system components and in consideration that the nature of the leaks does not appear to present an un