2003 Mazda Protege

PASSENGER SIDE INNER FENDER WHERE THE STRUT IS MOUNTED IS GETTING RUSTED BADLY MAKING THE CAR UNSAFE TO DRIVE. CAR RUNS FINE BUT I CAN PUSH WITH THE FINGER FROM THE WHEEL SIDE AND SEE THE BODY MOVE. IF CAR GOES OVER A POT HOLE IT MIGHT MAKE THE STRUT FALL OFF AND CAUSE A MAJOR ACCIDENT. THIS IS STRUCTURE ISSUE. I CANT REPLACE ANYTHING. MAZDA SHOULD BUY IT BACK JUST LIKE NISSAN DID ON THEIR PATHFINDER. *TR

TL* THE CONTACT OWNS A 2003 MAZDA PROTEGE. THE CONTACT ATTEMPTED TO START THE VEHICLE BUT THE ENGINE FAILED TO START ACCOMPANIED BY AN ABNORMAL KNOCKING FROM THE ENGINE. THE CONTACT ALSO MENTIONED THAT THE FAILURE OCCURRED MORE OFTEN WHEN THE ENGINE WAS COLD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 13,200.

I RECENTLY PURCHASED A '03 MAZDA PROTEGE5. WHILE DRIVING DOWN THE ROAD YESTERDAY AT 65 MPH, I HEARD A LOUD BANG AND HEARD SOMETHING HIT THE BOTTOM OF THE CAR. THE CAR EXHAUST SUDDENLY BECAME MUCH LOUDER. I IMMEDIATELY PULLED OFF THE ROAD. I LOOKED UNDER THE CAR, AND THE EXHAUST HAD COME APART. THE PIECE OF THE EXHAUST AFTER THE CAT WAS HANGING ABOUT 1 INCH FROM THE GROUND. THIS PIECE IS AFTER THE CATALYTIC CONVERTER, NEAR ONE OF THE HANGING POINTS OF THE EXHAUST SYSTEM. TWO BOLTS, WHICH HOLD THIS PIECE TOGETHER, AND THE EXHAUST GASKET WERE MISSING. LUCKILY, THERE WAS NO DAMAGE WHATSOEVER. THIS PROBLEM COULD HAVE ENDED TRAGICALLY. *TR

TL* THE CONTACT OWNS A 2003 MAZDA PROTEGE. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS WHERE IT WAS STATED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 114,000.

ON AT LEAST 3-5 OCCASIONS THIS 2.0L ENGINE HAS SUFFERED THE EXACT SAME FATE AS NHTSA ID# 10422484. CHECK ENGINE LIGHT ON, MISFIRING, ASSOCIATED NOISE SOUNDING LIKE A BOLT / SCREW BOUNCING AROUND IN THE ENGINE FOR MAYBE 15 SECONDS, THEN WOULD RETURN TO NORMAL. EACH TIME THERE HAS BEEN A DIFFERENT CYLINDER MISFIRE, UPON SPARK PLUG REMOVAL IT WAS FOUND THE GAP WAS CLOSED CAUSING NO SPARK. EACH TIME, A NEW PLUG WAS INSTALLED AND CORRECTED THE IMMEDIATE PROBLEM. AFTER SEEING THESE COMPLAINTS AND A RECALL REGARDING THIS ISSUE I REALIZED I'VE HAD THE SAME ISSUE. DON'T KNOW IF MY VIN # IS IN THE EFFECTED RANGE OR NOT. CAR NOW HAS 123105 MILES. WOULD HOPE THAT MAZDA WOULD COVER ANY VEHICLE WITH THIS PROBLEM. *TR

TL* THE CONTACT OWNS A 2003 MAZDA PROTG. THE CONTACT STATED THAT WHILE ATTEMPTING A LEFT TURN AT 10 MPH, THE VEHICLE BEGAN SLIDING ABNORMALLY. THE CONTACT APPLIED THE BRAKES IN ORDER TO SHIFT GEARS BUT THE VEHICLE WOULD NOT STOP. THE CONTACT THEN ATTEMPTED TO ENGAGE THE EMERGENCY BRAKE BUT TO NO AVAIL AND CRASHED INTO A CURB. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO THE DEALER FOR DIAGNOSIS. THE DEALER ADVISED THAT THE BRAKE SENSOR WOULD NEED REPLACING. THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS REPAIRED. THE VIN WAS NOT AVAILABLE.THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 98,000.