IllustrationDRIVER SIDE FRONT SEAT WOBBLES-ENTIRE ASSEMBLY NEEDS TO BE REPLACED-DANGEROUS IF WELD HAD BROKEN WHILE ON FREEWAY-WHY ISN'T THIS A SAFETY RECALL-NUMEROUS OTHER COMPLAINTS FOR VARIOUS MODEL YEARS EVEN WHEN NEW-ARE SEATS REMOVED BY L0-JACK TECHS WHEN INSTALLING LO-JACK DEVICES?
2004 Mazda MAZDA3
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Mazda MAZDA3 do not stand out strongly from the model-year median of 108.
About this comparison →How this year compares
Owner complaints by model year
Compare all MAZDA3 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
1225–50K
1950–75K
1975–100K
20100–150K
6150K+
111 reports with mileage · 34 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 25 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 24 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
18 crash reports2 fire reports11 injury reports
What owners actually said
145 reportsPOWER STEERING GOES OUT INTERMITTENTLY. OFTEN STARTS WHEN TURNING THE WHEEL TO THE LEFT. THE POWER STEERING FAILURE LIGHT , OR SOMETIMES ALL WARNING LIGHTS, COME ON. THE STEERING WHEEL BECOMES EXTREMELY DIFFICULT TO TURN IN EITHER DIRECTION AND THE CAR IS DIFFICULT AND HAZARDOUS TO NAVIGATE TO A STOP. ELECTRONICS FLASH ON AN…
Read full complaint
POWER STEERING GOES OUT INTERMITTENTLY. OFTEN STARTS WHEN TURNING THE WHEEL TO THE LEFT. THE POWER STEERING FAILURE LIGHT , OR SOMETIMES ALL WARNING LIGHTS, COME ON. THE STEERING WHEEL BECOMES EXTREMELY DIFFICULT TO TURN IN EITHER DIRECTION AND THE CAR IS DIFFICULT AND HAZARDOUS TO NAVIGATE TO A STOP. ELECTRONICS FLASH ON AND OFF (HEADLIGHTS, RADIO, ETC.). CAR SOMETIMES DIES. IF THE STEERING WHEEL IS NOT PERFECTLY STRAIGHT WHEN THE CAR DIES, IT IS LOCKED AND THE CAR CANNOT BE RESTARTED UNTIL SOMEONE CAN WRENCH THE STEERING WHEEL STRAIGHT AGAIN. THIS HAS HAPPENED OFF AND ON FOR A YEAR. SINCE IT IS INTERMITTENT, MECHANICS ARE UNABLE TO FIND THE PROBLEM.
TL* THE CONTACT OWNS A 2004 MAZDA 3. WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL LIGHT ILLUMINATED. THE STEERING WHEEL LOCKED AND WAS HARD TO TURN. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON A FEW TIMES AND SHIFTED THE STEERING WHEEL TO THE LEFT AND RIGHT, BUT THE WHEEL WOULD NOT UNLOCK. THE DEALER AND MANUFACTURER WERE…
Read full complaint
TL* THE CONTACT OWNS A 2004 MAZDA 3. WHEN THE VEHICLE WAS STARTED, THE STEERING WHEEL LIGHT ILLUMINATED. THE STEERING WHEEL LOCKED AND WAS HARD TO TURN. THE CONTACT TURNED THE VEHICLE OFF AND BACK ON A FEW TIMES AND SHIFTED THE STEERING WHEEL TO THE LEFT AND RIGHT, BUT THE WHEEL WOULD NOT UNLOCK. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 93,173.
ENGINE LIGHT CAME ON WITH EVAP LEAK CODE. SMALL LEAK AT FIRST THEN INCLUDED LARGE LEAK CODE LATER. ALSO BEGAN TO NOTICE STRONG GAS SMELL OUTSIDE VEHICLE AFTER FUELING. TURNED OUT THE FUEL PUMP RING THAT HOLDS DOWN AND SEALS FUEL PUMP TO FUEL TANK HAD CRACKED. OVER TIME THE SPLIT BECAME LARGER. WHEN TANK WAS FILLED, RAW FUEL W…
Read full complaint
ENGINE LIGHT CAME ON WITH EVAP LEAK CODE. SMALL LEAK AT FIRST THEN INCLUDED LARGE LEAK CODE LATER. ALSO BEGAN TO NOTICE STRONG GAS SMELL OUTSIDE VEHICLE AFTER FUELING. TURNED OUT THE FUEL PUMP RING THAT HOLDS DOWN AND SEALS FUEL PUMP TO FUEL TANK HAD CRACKED. OVER TIME THE SPLIT BECAME LARGER. WHEN TANK WAS FILLED, RAW FUEL WOULD LEAK OUT AROUND PUMP ON TOP OF TANK. WHICH ALSO HAPPENS TO BE RIGHT UNDER THE REAR SEAT WHERE ME KIDS SIT. REPLACEMENT WAS EXPENSIVE BECAUSE THE RING COULD NOT BE REMOVED FROM UNDER THE SEAT. IT REQUIRED DROPPING THE TANK TO REPAIR. MECHANIC FELT IT WAS A STRESS CRACK. THE FUEL PUMP HAD NEVER BEEN WORKED ON BEFORE. THE ORIGINAL RING WAS INSTALLED AT THE FACTORY.
WAS IN ACCIDENT HIT DITCH AND TREE HEAD ON AND AIRBAGS DID NOT DEPLOY, CAUSING INJURY TO FACE FROM HITTING STEERING WHEEL. WAS ON CITY STREET AND IN MOTION.
THERE WAS A STRONG FUEL SMELL THAT WAS OCCURRING ON BOTH THE INSIDE AND OUTSIDE OF MY CAR EVERY TIME I FILLED MY CAR UP. I TOOK TO MY THE MECHANIC AND IT WAS FOUND MY FUEL TANK WAS LEAKING IN 2 SPOTS. ONE WAS PART OF THE GAS TANK THAT VENTS THE FUMES - THAT SEAL WAS LEAKING AND THE OTHER WAS PART OF THE LOCKING RING THAT IS ON T…
Read full complaint
THERE WAS A STRONG FUEL SMELL THAT WAS OCCURRING ON BOTH THE INSIDE AND OUTSIDE OF MY CAR EVERY TIME I FILLED MY CAR UP. I TOOK TO MY THE MECHANIC AND IT WAS FOUND MY FUEL TANK WAS LEAKING IN 2 SPOTS. ONE WAS PART OF THE GAS TANK THAT VENTS THE FUMES - THAT SEAL WAS LEAKING AND THE OTHER WAS PART OF THE LOCKING RING THAT IS ON THE GAS TANK ITSELF WAS CRACKED.
TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE CORROSION AND THE DOOR FRAME WAS STARTING TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT PORTIONS OF THE VEHICLE COULD BE REPAIRED; HOWEVER, THE CORROSION WAS IN AREAS THAT WERE BEYO…
Read full complaint
TL* THE CONTACT OWNS A 2004 MAZDA 3. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED SEVERE CORROSION AND THE DOOR FRAME WAS STARTING TO DETACH FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY DIAGNOSED THAT PORTIONS OF THE VEHICLE COULD BE REPAIRED; HOWEVER, THE CORROSION WAS IN AREAS THAT WERE BEYOND REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 130,000.
BOUGHT 4 NEW TIRES ON 3/23/12. THREE OF THESE TIRES DEVELOPED BUBBLES AND HAD TO BE REPLACED.
CLUTCH SLIPPING, HIGH RPMS, NOT RED LINING. TRANSMISSION EXPLODED CAUSING ENGINE FIRE AND BURNING MOTOR AND ELECTRICAL COMPONENTS.
WHEN STARTING THE CAR THE AIR BAG LIGHT COMES ON AND STAYS ON FOR WEEKS THEN IT WILL TURN OFF. THIS HAS BEEN HAPPENING FOR OVER A YEAR.
Official recalls
221V494000 · Air Bags:frontal
Jul 1, 2021
Mazda North American Operations (Mazda) is recalling certain 2004-2007 Mazda3 vehicles. During air bag deployment, the plastic emblem on the steering wheel air bag module cover may shatter, and project plastic fragments into the vehicle.
Consequence & remedy
Consequence: Plastic fragments can hit occupants during air bag deployment, increasing the risk of injury.
Remedy: Dealers will replace the air bag module cover, free of charge. Owner letters were mailed between August 28, 2021 and October 28, 2021. Owners may contact Mazda customer service at 1-800-222-5500 Option 4. Mazda's number for this recall is 4921G.
04V468000 · Air Bags:frontal:sensor/control MODULE-INACTIVE
Sep 24, 2004
ON CERTAIN PASSENGER VEHICLES, A CRACK IN THE AIR BAG CRASH ZONE SENSOR HOUSING CAN ALLOW WATER TO ENTER THE SENSOR, CAUSING A SHORT CIRCUIT AND ILLUMINATING THE AIR BAG WARNING LIGHT.
Consequence & remedy
Consequence: IF THIS PROBLEM EXISTS, THE AIR WILL NOT DEPLOY AS DESIGNED IN CERTAIN TYPES OF FRONTAL CRASHES, INCREASING THE RISK OF DEATH OR SERIOUS INJURY TO THE DRIVER AND FRONT SEAT PASSENGER.
Remedy: DEALERS WILL INSPECT THE CRASH ZONE SENSOR AND REPLACE IT, IF NECESSARY. THE RECALL BEGAN ON OCTOBER 28, 2004. OWNERS SHOULD CONTACT MAZDA AT 1-800-222-5500.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.