TL* THE CONTACT OWNS A 1996 MAZDA 626. WHILE DRIVING, THE CHECK ENGINE SENSOR LIGHT SUDDENLY ILLUMINATED AND THE INSTRUMENT PANEL LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE WIRE HARNESS WAS REPLACED. A…
Read full complaint
TL* THE CONTACT OWNS A 1996 MAZDA 626. WHILE DRIVING, THE CHECK ENGINE SENSOR LIGHT SUDDENLY ILLUMINATED AND THE INSTRUMENT PANEL LIGHTS WOULD NOT ILLUMINATE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE IGNITION SWITCH WIRE HARNESS WAS FAULTY AND NEEDED TO BE REPLACED. THE WIRE HARNESS WAS REPLACED. APPROXIMATELY SIX MONTHS LATER, THE VEHICLE EXPERIENCED THE SAME FAILURE. WHILE OPERATING THE VEHICLE, THE ENGINE HEAD GASKET MALFUNCTIONED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 165,000.
NHTSA ODI #10875499
Mileage unknown · Mar 16, 2016
Electrical System
TL* THE CONTACT OWNS A 1996 MAZDA 626. THE CONTACT STATED THAT THERE WAS A PROGRESSING ELECTRICAL FAILURE AND UNKNOWN WARNING LIGHTS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. THE VENT CONTROLS FAILED TO WORK FOR THE AIR CONDITIONER AND HEATER. THE VEHICLE WAS TAKEN TO FOUR DIFFERENT INDEPENDENT REPAIR SHOPS AND THEY WERE NOT…
Read full complaint
TL* THE CONTACT OWNS A 1996 MAZDA 626. THE CONTACT STATED THAT THERE WAS A PROGRESSING ELECTRICAL FAILURE AND UNKNOWN WARNING LIGHTS REMAINED ILLUMINATED ON THE INSTRUMENT PANEL. THE VENT CONTROLS FAILED TO WORK FOR THE AIR CONDITIONER AND HEATER. THE VEHICLE WAS TAKEN TO FOUR DIFFERENT INDEPENDENT REPAIR SHOPS AND THEY WERE NOT ABLE TO REPLICATE AND DIAGNOSE THE FAILURE. THE CONTACT LATER RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 15V674000 (ELECTRICAL SYSTEM). THE DEALER WAS UNABLE TO PROVIDE A REASONABLE TIME FRAME TO RECEIVE THE PARTS FROM THE MANUFACTURER. THE CONTACT CALLED THE DEALER FOR MONTHS AND WAS UNABLE TO DETERMINE WHEN THE VEHICLE WOULD BE REPAIRED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS NOT AVAILABLE. PARTS DISTRIBUTION DISCONNECT. UPDATED 05/10/16*LJ
NHTSA ODI #10850053
Mileage unknown · Dec 30, 2003
Electrical System
THE CONSUMER STATED THAT WHILE SHE WAS DRIVING THE VEHICLE JERKED A LOT. SHE ALSO STATED THAT HER OVERDRIVE LIGHT FLASHED ON AND OFF. THE CONSUMER TOOK THE VEHICLE TO THE DEALER/MECHANIC AND WAS TOLD THAT THE VEHICLE HAD AN ELECTRICAL WIRING PROBLEM. THE CONSUMER IS AFRAID SHE MAY HAVE AN ACCIDENT. *NM
NHTSA ODI #10052163
Mileage unknown · Jul 10, 2003
Electrical System
INTERMITTENTLY (IN LOW GEAR, MANUAL SHIFT), AS I PULL THE CAR TO THE LEFT (ONLY), TO PARK OR TURN A CORNER, THE CAR DIES. THE INCIDENT DATE BELOW DENOTES THE LATEST INCIDENT.NOT CERTAIN OF EXACT DATA OF PURCHASE FROM 128 MAZDA, BUT WEB SITE DEMANDED A SPECIFIC DAY SO, TO SATISFY IT, I ENTERED IN AUGUST 7. *AK
NHTSA ODI #10025793
Mileage unknown · Apr 9, 2002
Electrical System
WHILE DRIVING BATTERY CABLE FELL OFF, CAUSING ENTIRE VEHICLE TO SHUT DOWN.*AK
NHTSA ODI #8007174
Mileage unknown · Nov 4, 2001
Electrical SystemFire
SMOKE EMITTED FROM BEHIND THE FAN CONTROL PANEL. FLAMES EMITTED MOMENTS AFTERWARD. AUTO STOPPED AND DRIVER ESCAPED VEHICLE, PROCEEDED TO CALL FIRE DEPARTMENT (ON HIGHWAY AT TIME). FIRE DAMANGED THE ENTIRE DASHBOARD (MELTED MOST OF IT, PASSENGER SIDE AIRBAG PARTIALLY DEPLOYED), WINDSHIELD CRACKED AND IN SOME PLACES MELTED. ENTIRE…
Read full complaint
SMOKE EMITTED FROM BEHIND THE FAN CONTROL PANEL. FLAMES EMITTED MOMENTS AFTERWARD. AUTO STOPPED AND DRIVER ESCAPED VEHICLE, PROCEEDED TO CALL FIRE DEPARTMENT (ON HIGHWAY AT TIME). FIRE DAMANGED THE ENTIRE DASHBOARD (MELTED MOST OF IT, PASSENGER SIDE AIRBAG PARTIALLY DEPLOYED), WINDSHIELD CRACKED AND IN SOME PLACES MELTED. ENTIRE INTERIOR SMOKE AND WATER DAMAGE. PARTS STILL UNDER WARRANTY. NO ELECTRICAL OR ENGINE WARNING LIGHTS ILLUMINATED AT ANY POINT PRIOR TO DRIVER EXITING THE VEHICLE UPON EMISSION OF FLAMES (AT THIS POINT, ABOUT 1 MILE FROM DEALER).*AK
NHTSA ODI #754084
Mileage unknown · Nov 8, 1999
Electrical SystemExterior Lighting
THE INSTRUMENT PANEL LIGHTS AND THE TAIL LIGHTS ARE INOPERATIVE, WHICH MAY RESULT VISUAL DIFFICULTY. OWNER'S MANUAL STATED TO REPLACE THE FUSE. THE OCCUPANT REPLACE THE FUSE, BUT PROBLEM STILL OCCURRING. DEALER SAID THAT THE HEADLIGHT SWITCH NEEDS TO BE REPLACED MANUFACTURER WAS WILLING TO PAY HALF OF THE BILL. PLEASE PR…
Read full complaint
THE INSTRUMENT PANEL LIGHTS AND THE TAIL LIGHTS ARE INOPERATIVE, WHICH MAY RESULT VISUAL DIFFICULTY. OWNER'S MANUAL STATED TO REPLACE THE FUSE. THE OCCUPANT REPLACE THE FUSE, BUT PROBLEM STILL OCCURRING. DEALER SAID THAT THE HEADLIGHT SWITCH NEEDS TO BE REPLACED MANUFACTURER WAS WILLING TO PAY HALF OF THE BILL. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #852654
Mileage unknown · May 17, 1999
Electrical SystemPower Train
CAR WAS PURCHASED WITH 15,000 MILES. I HAVE HAD THESE PROBLEMS WITH THE CAR AND I WOULD LIKE FOR THESE THINGS TO BE INVESTIGATED. I KNOW OF 4 OTHER PEOPLE WHO HAVE HAD SOME OF THESE SAME PROBLEMS WITH THEIR 1996 626.
NHTSA ODI #706602
Mileage unknown · Jan 6, 1999
Electrical SystemEngine And Engine CoolingPower Train
Mazda North American Operations (Mazda) is recalling certain model year 1989-1998 MPV, 1990-1995 323, 1990-1998 Protege, 1992-1993 MX-3, 1993-1995 929, 1993-1997 MX-6, and 1993-1998 626 vehicles. In the affected vehicles, grease applied to the contact points inside the ignition switch may become conductive and overheat.
Consequence & remedy
Consequence: If the ignition switch overheats there would be an increased risk of a fire.
Remedy: Mazda will notify owners, and dealers will replace the ignition switch, free of charge. The recall began on December 17, 2015. Owners may contact Mazda Customer Experience Center at 1-800-222-5500, option#6. Mazda's number for this recall is 8715J.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE SAS SENSOR UNIT. THESE VEHICLES CAN EXPERIENCE AIR BAG DEPLOYMENTS IN MINOR UNDERCARRIAGE IMPACTS.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPROGRAM THE SAS UNIT TO REDUCE THE PROBABILITY OF UNNECESSARY DEPLOYMENTS IN LOW SPEED UNDERCARRIAGE IMPACTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4
RQ99022 · Headlight Failure
Opened Dec 20, 1999 · Closed Aug 30, 2000
Status: closed (inferred from source dates) · Exterior Lighting
OBTAINED RECALL 99V-358
SQ98024 · Speedometer Inoperative
Opened Oct 29, 1998 · Closed Sep 10, 1999
Status: closed (inferred from source dates) · Power Train
SEE RESUME FOR DETAILS.
EA97012 · Oversensitive Air Bag Deployment
Opened May 23, 1997 · Closed Oct 9, 1998
Status: closed (inferred from source dates) · Air Bags
IN MAY OF 1997, ODI UPGRADED TO AN ENGINEERING ANALYSIS WITH 51 COMPLAINTS.ODI IS NOW AWARE OF 88 COMPLAINTS OF ALLEGED INAPPROPRIATE AIRBAG DEPLOYMENTS.TYPICAL COMPLAINTS ALLEGE THAT THE AIRBAGS DEPLOYED AFTER THE VEHICLE HIT A POT HOLE AT BETWEEN 20 AND 45 MPH, OR THAT THE AIRBAGS DEPLOYED WHILE DRIVING AT BETWEEN 20 OR 60 MPH FOR NO APPARENT REASON.APPROXIMATELY 25 DRIVERS ALLEGED THAT THEY DID NOT HIT ANYTHING IN THE ROADWAY.MAZDA WILL CONDUCT A SAFETY RECALL OFALL 1995 AND 1996 MODELS OF THE MAZDA 626 AND MX-6, AS WELL AS A SMALL NUMBER OF 1997 MAZDA 626 MODELS, EQUIPPED WITH THE SAME SAS UNIT.THE SAS UNIT CONTROLS THE AIRBAG SYSTEMIT CONTAINS A BUILT-IN CRASH SENSOR TO DETECT VEHICLE DECELERATION DURING A COLLISION.AFFECTED MODELS WERE ASSEMBLED FROM JUNE 1, 1994 THROUGH SEPTEMBER 10, 1996 AND HAVE A VIN WITHIN THE FOLLOWING RANGES: MAZDA 626:1YVGE22**S5300001 THROUGH 1YVGE22**V5599030 MAZDA MX-6: 1YVGE31**S5300001 THROUGH 1YVGE31**T5589965ALL OWNERS WILL BE NOTIFIED OF THE POSSIBILITY THAT THEIR VEHICLE MAY EXPERIENCE AN UNNECESSARY AIRBAG DEPOYMENT IN CERTAIN SITUATIONS.THEY WILL BE INSTRUCTED TO BRING THEIR VEHICLE TO A MAZDA DEALER TO REPROGRAM THE SAS UNIT TO REDUCE THE FREQUENCY OF UNNECESSARY DEPLOYMENTS.
PE97006 · Inappropriate Air Bag Deployment
Opened Jan 30, 1997 · Closed May 23, 1997
Status: closed (inferred from source dates) · Air Bags
IN JANUARY OF 1997, ODI OPENED A PE BASED ON 9 ODI COMPLAINTS.ODI IS NOW AWARE OF 51 COMPLAINTS OF ALLEGED INAPPROPRIATE AIR BAG DEPLOYMENTS.TYPICAL COMPLAINTS INCLUDE AIR BAG DEPLOYMENTS AFTER THE VEHICLE HIT A POT HOLE WHILE DRIVING BETWEEN 20 AND 45 MPH AND AIR BAG DEPLOYMENTS WHILE DRIVING AT SPEEDS BETWEEN 20 AND 60 MPH FOR NO APPARENT REASON.APPROXIMATELY 21 DRIVERS ALLEGED THAT THEY DID NOT HIT ANYTHING PRIOR TO THE AIR BAG DEPLOYMENT.IN FOUR OF THESE INCIDENTS THE DRIVER CLAIMS TO HAVE LOST CONTROL AND HIT A CURB AFTER THE AIR BAGS DEPLOYED.IN ADDITION THERE ARE FOUR INCIDENTS WHERE THE DRIVER ALLEGES THAT THE AIR BAGS DEPLOYED AFTER A TIRE BLOWOUT WHILE DRIVING.LESS COMMON INCIDENTS INCLUDE ALLEGATIONS OF THE AIR BAGS DEPLOYING AFTER PARKING THE VEHICLE AND REMOVING THE KEY, CROSSING RAILROAD TRACKS, WHILE BEING TOWED, WHILE BRAKING, AFTER HITTING A CURB, AND AFTER HITTING A MANHOLE COVER.ODI IS UPGRADING THIS INVESTIGATION TO OBTAIN ADDITIONAL INFORMATION ABOUT THE REPORTS GATHERED TO DATE, THE SENSORS USED IN THE VEHICLES, AND TO ASSESS THE IMPACT THAT THE ALLEGED DEFECT HAS ON HIGHWAY SAFETY.
1996 Mazda 626 Problems, Complaints & Recalls | Skip That Year
Illustration