2006 Lincoln Zephyr

THE FRONT DASHBOARD IS CONTINUALLY PEELING UP. IT HAS BECOME WARPED AND I'M AFRAID IT MAY COMPLETELY PEEL UP WHILE I'M DRIVING. I WHOLEHEARTEDLY FEEL THAT THESE AUTOMOBILES SHOULD BE RECALLED AND THE PROBLEM DEALT WITH APPROPRIATELY. LINCOLNS ARE SUPPOSE TO BE UPSCALED AMERICAN LUXURY CARS SO HOW DO THEY PRODUCED SUCH A CAR WITH MEDIOCRE WORKMANSHIP? I'VE PRICED NEW FRONT DASHBOARDS AND THEY CAN RANGE IN THE $1200-$1500 RANGE, USED $300-$400 WITHOUT INSTALLATION. I LOVE MY LINCOLN BUT THIS IS UNACCEPTABLE. SOMEONE NEEDS TO ADDRESS THIS PROBLEM BEFORE SOMEONE DIES! *TR

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT THE DASHBOARD WAS WARPED CAUSING A SEPARATION FROM THE CONSOLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ALSO STATED THAT THE REAR DRIVER'S SIDE DOOR HANDLE DETACHED FROM THE VEHICLE WHILE ATTEMPTING TO OPEN THE DOOR. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000. THE VIN WAS NOT AVAILABLE.

DRIVING AT APPROX 30MPH MY TIRE BLEW OUT AFTER JUST REPLACING ALL 4 TIRES 3K MILES BEFORE. TOOK THE TIRE BACK TO THE MERCHANT AND THEY REPLACED IT BECAUSE I HAD A HAZARD PROTECTION PLAN WITH TIRES. REPLACED ALL 4 TIRES IN SEPT OF 2014 DUE TO NORMAL WEAR AND I HAVE HAD TO REPLACE 3 TIRES DUE TO TIRE COMING OFF OF THE RIM WHILE DRIVING AND LOSING AIR PRESSURE, SLOW LEAK THAT RESULTED IN FLAT AND A BLOWOUT WHILE DRIVING AT 40MPH AND LANDED ME INTO A DITCH. THE TIRE MERCHANT INFORMED ME THAT THE WHEELS ARE DEFECTIVE DUE TO THE CHROME ON RIM PEELING AND DAMAGING TIRE AS WELL AS PREVENTING A SEAL BETWEEN TIRE AND RIM TO KEEP TIRE INFLATED. REPLACING THE WHEELS WITH MANUFACTURER WHEELS WILL RESULT IN SAME PROBLEM BEING THAT IT IS A DEFECT IN THE PRODUCT. I FEEL FORD NEEDS TO TAKE RESPONSIBILITY FOR THIS DEFECT AND REIMBURSE CUSTOMERS FOR NEW WHEELS. *TR

WAS TRAVELING SOUTHBOUND ON I-39 WHEN TIRE BLEW OUT. HAVE HAD TO REPLACE TIRES SEVERAL TIMES AND TOLD BY DEALERSHIP AND 2 AUTO SERVICE CENTERS THAT THE RIMS ARE SO CORRODED THEY DO NOT HOLD AIR PROPERLY AND NEED TO BE REPLACED. ALL WHEELS HAVE CHROME FLAKING OFF. CAR CURRENTLY HAS LESS THAN 75K MILES. IN THE 2.5 YEARS I HAVE OWNED IT, PROBABLY HAVE HAD TO HAVE THE TIRES REPAIRED/REPLACED 10-15 TIMES. *TR

I HAVE A 2006 LINCOLN ZEPHYR AND I HAVE NOTICED THE CHROME ON MY RIMS IS PEELING OFF AND THE RIMS ARE BECOMING VERY CORRODED. THE TIRE KEEP DEFLATING DUE TO THIS PROBLEM EVEN AFTER YOU AIR THE TIRES UP THEY SLOWLY LEAK AIR. I HAVE SEEN MANY COMPLAINTS ABOUT THIS HAPPENING TO THESE RIMS AND IT COULD CAUSE A BLOW OUT DUE TO UNDER INFLATION AS THE TIRE SPECIFICALLY SAYS ON THE SIDE OF THE TIRE. THIS NEEDS TO BE ADDRESSED. *TR

WHILE DRIVING I FELT THE CAR PULLING TO THE LEFT, AFTER EXAMINATION I NOTICED THAT THE PASSENGER LEFT SIDE TIRE WAS FLAT. I MANAGED TO GET TO A GAS STATION, BUT WAS UNABLE TO INFLATE THE TIRE. THESE TIRES WERE PURCHASED IN NEW IN MAY 2014. I HAVE DRIVEN FEW MILES BETWEEN MAY AND NOVEMBER, THE MILEAGE CAN BE VERIFIED WITH DEALERSHIP. THIS IS THE FOURTH TIME THAT I HAVE PURCHASED TIRES FOR THIS VEHICLE. THE FIRST TIME WAS VERY SOON AFTER PURCHASE WHILE TRAVELING OUT OF STATE. I PURCHASED A NEW TIRE THEN THAT WAS VERY HARD TO FIND BECAUSE OF THE YEAR AND MAKE OF CAR. THE TIRES CONTINUED TO LOSE PRESSURE NEVER REALLY REMAINING INFLATED. I PURCHASED A AIR PUMP THAT I USED TO INFLATE THE TIRES, BECAUSE THE TIRES WOULD LITERALLY DEFLATE TO THE RIM. I AGAIN PURCHASED A FULL SET, BUT THE PROBLEM REMAINED. 2014 AGAIN PURCHASED A FULL SET, THEN 2014 PURCHASED ANOTHER TIRE. AS YOU CAN SEE THIS VEHICLE WITH ONE OWNER HAS VERY FEW MILES, BUT SEVERAL TIRE PURCHASES. LINCOLN/FORD NEEDS TO CLOSELY MONITOR THIS COMPLAINT. IT IS GETTING TO COSTLY TO CONTINUE BUYING TIRES FOR SOME REASON OTHER THAN THE DEFECTIVE RIM WHEEL. MY FAMILY SAFETY IS AT STAKE. *TR

THE PROBLEM IS RE-OCCURRING. WHEN THE WEATHER GOES BELOW FREEZING ICE BUILDS UP AROUND THE ELECTRONIC THROTTLE BODY. THE CAR WILL START AND AS THE ENGINE STARTS TO HEAT UP THE ICE STARTS TO BREAK UP. AS SOON AS I HAVE TAKEN THE CAR PAST 25MPH AND I LET OFF THE GAS THE ENGINE STARTS TO STALL OUT SENDING AN ERROR SIGNAL TO THE COMPUTER AND THE WRENCH LIGHT COMES ON. I MUST SAY THAT THE PROBLEM IS VERY RANDOM AND DOES NOT ALWAYS OCCUR. I HAVE LEARNED FROM EXPERIENCE THAT I MUST PULL OVER AND TURN OFF THE CAR. TURNING OFF THE CAR CAUSES THE COMPUTER TO RESET AND THE WRENCH LIGHT TURNS OFF AND THE CAR GOES BACK TO NORMAL. I AM UPSET BECAUSE AFTER I TOOK THE CAR TO MY LOCAL DEALER THEY TOLD ME THAT NOTHING WAS WRONG AND THAT IN ORDER FOR THEM TO FIX THE PROBLEM I WOULD HAVE TO DRIVE THE CAR IN WITH THE WRENCH LIGHT STILL ON. IN REALITY, THIS MEANS THAT I WOULD HAVE TO DRIVE WITH A FUEL STARVED STALLING ENGINE TO THE DEALERSHIP AND I WOULD HAVE TO KEEP THE CAR RUNNING UNTIL SOMEBODY CAME TO HELP. AS SOON AS I TURN OFF THE CAR THE PROBLEM NO LONGER EXISTS. I HAVE READ MANY OTHER ONLINE POSTS AND BLOGS FROM OTHER LINCOLN AND FORD OWNERS DESCRIBING THE SAME ISSUE. I HOPE THAT FORD CAN ACKNOWLEDGE THIS PROBLEM. I AM VERY FRUSTRATED. *TR

THE WHEELS HAVE STOPPED HOLDING AIR FOR ANY AMOUNT OF TIME. REGARDLESS OF TEMPERATURE, SPEED, MILEAGE. MECHANICS HAVE REPORTED THAT BECAUSE OF THE FLAKING CHROME WHEELS, THEY WILL NOT HOLD AIR CORRECTLY FOR ANY AMOUNT OF TIME. HAVE PAID OVER $20 ON SEVERAL OCCASIONS TO HAVE BEAD SEAL, WHICH MAY OR MAY NOT HELP UNTIL THE TIRES HAVE TO BE REPLACED BECAUSE OF UNUSUAL WEAR BECAUSE OF UNDER INFLATION. TIRES HAVE BEEN REPLACED AT AN UNUSUALLY HIGH RATE UNTIL IT IS NOT WORTH BUYING NEW TIRES AS THEY ARE TRASHED IN SHORT ORDER. NOW MY MOTHER DRIVES AROUND ON USED TIRES AND SHE HAS TO STOP IN INSTANT OIL CHANGE TO HAVE HER TIRE PRESSURE CHECKED ALMOST EVERY MORNING. THERE ARE SEVERAL COMPLAINTS ABOUT THIS PROBLEM AND THESE WHEELS SPECIFICALLY. WHY IS THERE NO RECALL REGARDING THIS? THIS IS AN OUTRAGE THAT SO MANY PEOPLE HAVE HAD THIS PROBLEM. THIS IS A MORE THAN $1500 FIX TO HAVE PEACE OF MIND. PLEASE DO SOMETHING SO THAT I CAN QUIT WORRYING ABOUT MY MOTHERS CAR, TIRES, HER LIFE! *TR

TIRES CONTINUALLY LOOSING AIR PRESSURE. MECHANICS SHOWED FLAKING AND CRACKING CHROME PLATING ON WHEELS THAT CREATE AIR LEAKAGE PATH AT BEAD/RIM CONTACT AREA. DAMAGE TO TIRES DUE TO REPEATED LOSS OF AIR PRESSURE. MECHANICS AT BELLE TIRE SAY THIS IS A VERY COMMON PROBLEM WITH THE 2006 LINCOLN ZEPHYR WHEELS. WHY NO RECALL? REPLACEMENT WHEELS ARE APPROX $1,600! *TR