2006 Lincoln Zephyr

2006 LINCOLN ZEPHYR. CONSUMER WRITES IN REGARDS TO PROBLEM WITH BRAKES *TGW THE CONSUMER STATED UPON ARRIVING AT AN INTERSECTION, HE APPLIED THE BRAKE, AND THE PEDAL NEARLY WENT TO THE FLOOR, THE ABS SEEMED TO ACTIVATE AS HE MOVED INTO THE INTERSECTION. THE CONSUMER NOTICED THE ABS WAS IN CONTROL, AS HE TRIED TO BRAKE. THE MECHANIC CHECKED THE BRAKE SYSTEM, INCLUDING THE BRAKE FLUID LEVEL, WHICH WAS NORMAL. THE MECHANIC TOOK THE VEHICLE FOR A TEST DRIVE AND NOTICED THE BRAKE PEDAL NEARLY WENT TO THE FLOOR, AFTER WHICH THE ABS ACTIVATED. THE MECHANIC SAW A HEAVY ACCUMULATION OF ICE/SNOW TOWARD THE INSIDE SECTION BEHIND THE RIGHT FRONT WHEEL. THE MECHANIC SUGGESTED LETTING THE SNOW/ICE THAW. ONCE IT THAWED, THE BRAKING SYSTEM RETURNED TO NORMAL. *JB UPDATED 02/24/12

THE ALUMINUM WHEELS ON MY 2006 LINCOLN ZEPHYR ARE PEELING AT THE TIRE CONTACT POINT CAUSING A DETERIORATION OF THE SEAL CAPABILITY OF THE WHEEL. THE TIRES EVENTUALLY WON'T SEAL PROPERLY AND LOSE AIR PRESSURE UNTIL THE TIRE IS EITHER REINFLATED, OR GOES FLAT. THE DEALER WAS NOTIFIED, SEVERAL TIMES BUT WOULD ONLY CLEAN THE WHEELS, AND RESEAL AND REINFLATE THE TIRES. THIS TREATMENT LASTED APPROXIMATELY 3 MONTHS UNTIL THE TIRES BEGAN TO LOSE AIR AGAIN. WE RECEIVED NO SATISFACTION FROM THE LINCOLN DEALER REGARDING ANY PERMANENT CORRECTIVE ACTION FOR THIS PROBLEM. WE WERE TOLD WE'D HAVE TO REPLACE THE ALUMINUM WHEELS, BUT WERE GIVEN NO GUARANTEE THE NEW WHEELS WOULD PERFORM ANY BETTER. *TR

AFTER HAVING MULTIPLE FLAT TIRES - WHICH I INCORRECTLY ATTRIBUTED TO BAD LUCK - I DISCOVERED THE PROBLEM WAS NOT MY TIRES AT ALL, BUT WAS INSTEAD, THE CHROME PEELING ON THE INNER RIM OF THE WHEELS, WHICH NOT ONLY CREATED AN AIR LEAK FROM THE SEAL NOT HOLDING, BUT ALSO DAMAGED THE VERY-EXPENSIVE-TO-REPLACE TIRES. I LEARNED THIS WHEN I TRIED TO PUT 4 NEW TIRES ON THE CAR, THINKING MAYBE ALL THE FLATS WERE DUE TO THE BRAND OF TIRES, AND COSTCO SHOWED ME THE PEELING CHROME PROBLEM AND TOLD ME NOT TO WASTE MY MONEY ON NEW TIRES UNTIL THE WHEELS WERE REPLACED. WAS INFORMED THIS MANUFACTURING DEFECT WITH THE CHROME PLATING IS NOT A PROBLEM FORD WILL FIX AT THEIR EXPENSE AND THE COST FOR PUTTING NEW NON-CHROME WHEELS ON THE CAR WOULD ALL BE MINE. APPARENTLY SUDDEN FLATS DUE TO DEFECTIVE CHROME IS NOT REGARDED AS A SAFETY ISSUE BY FORD. *TR

2006 LINCOLN ZEPHYR. 22K MILES. ALL 4 RIMS CORRODE CAUSING TIRES TO LOOSE AIR. TIRE SHOP BROKE DOWN TIRES AND CLEANED RIMS. APPLIED SEALANT AROUND LIP AND REMOUNTED TIRES. TIRE SHOP OWNER INDICATED HE HAS CLEANED AND RESEALED A NUMBER OF 2006 LINCOLN ZEPHYR ALUMINUM WHEELS. AT 35K MILES ALL 4 TIRES WERE REPLACED AT LINCOLN DEALER. TWO WEEKS AFTER NEW TIRES INSTALLED FRONT DRIVER SIDE TIRE CAME OFF RIM DUE TO LOW AIR PRESSURE. I COMPLAINED TO DEALER THAT THE TIRES ARE LEAKING AIR. DEALER ACKNOWLEDGED PROBLEM WITH RIMS AND REPLACED TIRE FREE OF CHARGE. DEALER ALSO INDICATED ALL FOUR RIMS WERE CLEANED AND RESEALED. *TR

TL*THE CONTACT OWNS A 2006 LINCOLN ZEPHYR. THE CONTACT STATED THAT ALL FOUR WHEELS ON HIS VEHICLE WERE DEFECTIVE. THE WHEELS CAUSE THE TIRES TO FLATTEN AND WILL NOT HOLD AIR. THE CONTACT MUST PLACE AIR IN THE TIRES EACH WEEK. THE DEALER STATED THAT THE VEHICLE NEEDED NEW WHEELS, BUT AT THE CONTACT'S EXPENSE BECAUSE THEY WERE NOT COVERED UNDER WARRANTY. THE FAILURE MILEAGE WAS 43,905. UPDATED 4/16/09 *CN UPDATED 04/20/09.*JB