IllustrationI HAVE HAD MY AIR SUSPENSION SYSTEM REPLACED AT LEAST 6 TIMES FOR THE SAME ISSUE. THE REAR DROPS DOWN AND DAMAGES MY TIRES. AFTER REPLACING THE SYSTEM SEVERAL TIMES. I HAD A CONVERSION KIT REPLACED.
2000 Lincoln Navigator
Owner reports · Recalls · Investigations
More warning signs than most Navigator years
Owner complaints for the 2000 Lincoln Navigator are substantially higher than the model-year median of 30.
About this comparison →How this year compares
Owner complaints by model year
Compare all Navigator years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
10–25K
1425–50K
550–75K
975–100K
7100–150K
5150K+
41 reports with mileage · 68 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Tires. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 13 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports17 fire reports4 injury reports
What owners actually said
109 reportsRUN AWAY LINCOLN NAVIGATOR. IN LIGHT OF TOYOTA'S PROBLEMS, THE SAME PROBLEM OCCURRED IN 2007. OUT OF CONTROL ACCELERATION, UNABLE TO STOP, UNABLE TO SHIFT TO NEUTRAL. SUV KEPT INCREASING SPEED DESPITE NOT DEPRESSING THE GAS PEDAL. *TR
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. DURING BRAKE APPLICATION AT 10 MPH, THE BRAKE PEDAL FELL TO THE FLOOR-BOARD. CONSEQUENTLY SHE CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY, IN WHICH THE MECHANIC ATTEMPTED TO MAKE REPAIRS. HOWEVER, WHILE IN THE SHOP THE VEHICLE CAUGHT ON FIRE WHIL…
Read full complaint
TL* THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. DURING BRAKE APPLICATION AT 10 MPH, THE BRAKE PEDAL FELL TO THE FLOOR-BOARD. CONSEQUENTLY SHE CRASHED INTO ANOTHER VEHICLE. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR FACILITY, IN WHICH THE MECHANIC ATTEMPTED TO MAKE REPAIRS. HOWEVER, WHILE IN THE SHOP THE VEHICLE CAUGHT ON FIRE WHILE IDLING. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE FIRE REPORT STATES THAT FIRE WAS CAUSED BY BRAKE BOOSTER FAILURE. ALL THE PLASTIC COMPONENTS OF THE BRAKING SYSTEM AND BRAKE LINES WERE DESTROYED. NO REPAIRS WERE MADE TO THE VEHICLE. THE CURRENT AND FAILURE MILEAGES WERE UNDER 190,000. THE VIN WAS NOT AVAILABLE.
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. WHILE DRIVING THE PASSENGER SMELLED A BURNING ODOR. UPON FURTHER INSPECTION HE NOTICED THAT THE WIRING HARNESS, MAIN TERMINAL, COMPRESSOR AND THE ALTERNATOR HAD MELTED. PRIOR TO THE FAILURE, HE HEARD A PECULIAR NOISE. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR HAS HE NOTIFIED THE M…
Read full complaint
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. WHILE DRIVING THE PASSENGER SMELLED A BURNING ODOR. UPON FURTHER INSPECTION HE NOTICED THAT THE WIRING HARNESS, MAIN TERMINAL, COMPRESSOR AND THE ALTERNATOR HAD MELTED. PRIOR TO THE FAILURE, HE HEARD A PECULIAR NOISE. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR HAS HE NOTIFIED THE MANUFACTURER. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 169,000.
I AM THE OWNER OF A 2000 NAVIGATOR. I BOUGHT IT FROM A PRIVATE OWNER ABOUT A YEAR AND A HALF AGO. WHEN GO TO CHANGE GEARS, THE VEHICLE SOMETIMES WON'T GO INTO GEAR OR IF I PUT IT IN PARK, IT SOMETIMES WON'T GO. THEN I TRIED TO USE MY EMERGENCY BRAKE WHEN PARKING, WHICH IS WHAT I HAD TO RESORT TO DUE TO THE VEHICLE NOT STAYING IN…
Read full complaint
I AM THE OWNER OF A 2000 NAVIGATOR. I BOUGHT IT FROM A PRIVATE OWNER ABOUT A YEAR AND A HALF AGO. WHEN GO TO CHANGE GEARS, THE VEHICLE SOMETIMES WON'T GO INTO GEAR OR IF I PUT IT IN PARK, IT SOMETIMES WON'T GO. THEN I TRIED TO USE MY EMERGENCY BRAKE WHEN PARKING, WHICH IS WHAT I HAD TO RESORT TO DUE TO THE VEHICLE NOT STAYING IN GEAR, IT ALSO WOULD NOT WORK. I WENT TO GET MY VEHICLE SAFETY INSPECTION AND OF COURSE IT DID NOT PASS. SO THAT PROMPTED MY ONLINE RESEARCH AS TO HOW TO FIX THE PROBLEM. THEN I CAME ACROSS THE RECALL IN FORMATION FOR THIS VEHICLE AND SIMILAR MODELS AND I SEE THAT SOME RECALLS WERE MADE, BUT NOT FOR MY VEHICLE'S YEAR. I WAS WONDERING IF MY VEHICLE'S YEAR MODEL SHOULD BE INCLUDED IN SOME OF THE OTHER RECALLS BECAUSE I HAVE THE EXACT SAME PROBLEM BUT MY VEHICLE IS A 2000 AND THE RECALL WAS FOR A 1998 AND SO ON. THANK YOU. *TR
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. AFTER DRIVING 20 MPH, THE CONTACT PARKED THE VEHICLE AND SMELLED BURNING RUBBER. SHE NOTICED SMOKE UNDERNEATH THE HOOD. SHE OPENED THE HOOD AND FLAMES APPEARED. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO ELECTRICAL FAILURE. THE VEHICLE WAS TOWED TO A PRIVATE BODY SHOP FOR …
Read full complaint
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. AFTER DRIVING 20 MPH, THE CONTACT PARKED THE VEHICLE AND SMELLED BURNING RUBBER. SHE NOTICED SMOKE UNDERNEATH THE HOOD. SHE OPENED THE HOOD AND FLAMES APPEARED. THE CONTACT BELIEVES THAT THE FAILURE WAS DUE TO ELECTRICAL FAILURE. THE VEHICLE WAS TOWED TO A PRIVATE BODY SHOP FOR INSPECTION. THE FAILURE AND CURRENT MILEAGES WERE 110,000.
LINCOLN NAVIGATOR 2000 BURST INTO FLAMES LAST NIGHT IN OUR DRIVEWAY AND BURNT OUR OTHER CAR A LAND ROVER AND 8 SUITCASES WORTH OF PERSONAL EFFECTS OF CLOTHES AND JEWELRY. BICYCLIST AWOKE THE FAMILY WHO WERE SLEEPING AT 5AM TO WARN THEM TO EVACUATE THE HOUSE. FIRE FIGHTERS TOOK 3 HOURS TO PUT OUT THE FIRE. *TR
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. FOUR HOURS AFTER BEING DRIVEN, THE VEHICLE BEGAN TO SMOKE AND CAUGHT FIRE. THE FIRE WAS SO BAD THAT THE HOOD BLEW OFF. THE TIRES AND EVERYTHING IN THE VEHICLE WERE MELTED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A FIREFIGHTER STATED THAT THERE WAS A FORD RECALL REGARDING TH…
Read full complaint
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. FOUR HOURS AFTER BEING DRIVEN, THE VEHICLE BEGAN TO SMOKE AND CAUGHT FIRE. THE FIRE WAS SO BAD THAT THE HOOD BLEW OFF. THE TIRES AND EVERYTHING IN THE VEHICLE WERE MELTED. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A FIREFIGHTER STATED THAT THERE WAS A FORD RECALL REGARDING THIS FAILURE. HE FURTHER STATED THAT THE FIRE APPEARED TO HAVE ORIGINATED IN THE ENGINE COMPARTMENT. THE VEHICLE WAS TOWED TO A LOCAL TOW YARD. THE CONTACT HAS PHOTOS AND A VIDEOTAPE OF THE FIRE. THE RECALL NUMBER WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 97,000.
2000 LINCOLN NAVIGATOR, RADIO FLASHES ON AND OFF WITH VEHICLE OFF, AND WINDSHIELD WIPERS ARE NOT WORKING, AFTER VEHICLE HAS BEEN SITTING OFF FOR A COUPLE HOURS, THERE IS A LOUD NOISE COMING FROM UNDER THE HOOD ON THE PASSENGER SIDE UNDER THE WINDSHIELD, OPEN THE VEHICLE DOOR AND A/C IS BLOWING FULL BLAST AND RADIO IS FLASHING O…
Read full complaint
2000 LINCOLN NAVIGATOR, RADIO FLASHES ON AND OFF WITH VEHICLE OFF, AND WINDSHIELD WIPERS ARE NOT WORKING, AFTER VEHICLE HAS BEEN SITTING OFF FOR A COUPLE HOURS, THERE IS A LOUD NOISE COMING FROM UNDER THE HOOD ON THE PASSENGER SIDE UNDER THE WINDSHIELD, OPEN THE VEHICLE DOOR AND A/C IS BLOWING FULL BLAST AND RADIO IS FLASHING ON AND OFF AGAIN SMELLS LIKE SOMETHING IS BURNING AND CAUSED A MINOR FIRE. LOOKED UP RECALL INFORMATION AND FORD STATES THAT OUR VEHICLE IS NOT LISTED UNDER THE RECALL# 01S24, ALTHOUGH IT SHOWS OUR MODEL YEAR ALONG WITH A MAJORITY OF FORD, LINCOLN, AND MERCURY VEHICLES. THIS IS THE SAME PROBLEM THAT HAPPENED WITH THE 2000 FORD EXPEDITION NHTSA ACTION# EA05015. *TR
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE REAR AIR BAG SUSPENSION KIT IS DEFLATED. THE MOTOR APPEARS TO BE SHORTED OUT. HE STATED THAT THE AIR BAGS APPEAR TO WIND BACK UP, BUT THEN MOVE UP AND DOWN WHILE DRIVING AT VARIOUS SPEEDS, AS IF THE MOTOR WAS ATTEMPTING TO POSITION IT CORRECTLY. THE CO…
Read full complaint
TL*THE CONTACT OWNS A 2000 LINCOLN NAVIGATOR. THE CONTACT STATED THAT THE REAR AIR BAG SUSPENSION KIT IS DEFLATED. THE MOTOR APPEARS TO BE SHORTED OUT. HE STATED THAT THE AIR BAGS APPEAR TO WIND BACK UP, BUT THEN MOVE UP AND DOWN WHILE DRIVING AT VARIOUS SPEEDS, AS IF THE MOTOR WAS ATTEMPTING TO POSITION IT CORRECTLY. THE CONTACT WENT TO THE DEALER, BUT THEY WOULD NOT REPAIR IT FOR FREE. THE DEALER IS CHARGING $2,500 TO INFLATE THE AIR BAGS. THERE WAS NO IMPACT OR FAILURE WITH THE VEHICLE ITSELF. THE CURRENT AND FAILURE MILEAGES WERE 110,000.
Official recalls
405V388000 · Vehicle Speed Control
Sep 7, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES EQUIPPED WITH SPEED CONTROL, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A FIRE AT THE SWITCH COULD OCCUR.
Remedy: BY LETTER DATED SEPTEMBER 12, 2005, OWNERS WERE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. OWNERS WHO HAVE HAD THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED THAT PARTS WILL BE AVAILABLE AND ADVISED TO MAKE AN APPOINTMENT TO RECONNECT THE SPEED CONTROL BEGINNING IN FEBRUARY 2006. OWNERS WHO DID NOT HAVE THEIR SPEED CONTROL DEACTIVATED ARE BEING NOTIFIED TO HAVE THEIR SYSTEM REMEDIED BEGINNING IN FEBRUARY 2006. OWNERS ARE URGED TO AVAIL THEMSELVES OF THE FREE DISCONNECT SERVICE AS SOON AS POSSIBLE BECAUSE OF THE SIGNIFICANT RISK OF FIRE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V017 AND 06V286)
05V017000 · Vehicle Speed Control:cruise Control
Jan 27, 2005
ON CERTAIN SPORT UTILITY VEHICLES AND PICKUP TRUCKS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS CONDITION COULD LEAD TO A FIRE. FIRES HAVE OCCURRED WHILE THE VEHICLES WERE PARKED WITH THE IGNITION 'OFF.'
Remedy: AS AN INTERIM REPAIR, OWNERS WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED. AS SOON AS REPLACEMENT PARTS ARE AVAILABLE (EARLY APRIL 2005), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A NEW SWITCH FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673. (NOTE: ALSO SEE RECALLS 05V388 AND 06V286)
01V258000 · Visibility:windshield Wiper/washer:motor
Aug 8, 2001
VEHICLE DESCRIPTION: PASSENGER CARS, SPORT UTILITY VEHICLES, AND LIGHT AND MEDIUM DUTY PICKUP TRUCKS. A SWITCH LOCATED IN THE PLASTIC COVER OF THE WIPER MOTOR GEAR CASE COULD MALFUNCTION AND OVERHEAT, POTENTIALLY RESULTING IN LOSS OF INTERMITTENT WIPER FUNCTION, LOSS OF WIPER PARK FUNCTION, COMPLETE LOSS OF WIPER FUNCTION, OR IGNITION OF THE PLASTIC COVER MATERIAL. SWITCH MALFUNCTION IS MOST LIKELY TO OCCUR WHEN THE INTERMITTENT SETTING OF THE WIPERS IS BEING USED, OR WHEN SNOW OR ICE OBSTRUCTS THE BLADES FROM RETURNING TO THE "PARKED" POSITION AT THE BOTTOM OF THE WINDSHIELD. THESE VEHICLES WERE BUILT AT THE FOLLOWING ASSEMBLY PLANTS: ATLANTA PLANT FROM 2/11/00 THROUGH 7/31/00; CHICAGO PLANT FROM 2/14/00 THROUGH 8/4/00; KANSAS CITY PLANT FROM 2/26/00 TO 9/4/00; KENTUCKY TRUCK PLANT FROM 2/18/00 TO 8/31/00; MICHIGAN TRUCK PLANT FROM 2/23/00 THROUGH 8/3/00; NORFOLK PLANT FROM 2/21/00 THROUGH 7/27/00; WAYNE STAMPING AND ASSEMBLY PLANT FROM 2/25/00 THROUGH 8/15/00; AND WIXOM PLANT FROM 2/15/00 THROUGH 8/8/00.
Consequence & remedy
Consequence: LOSS OF VISIBILITY WHILE DRIVING INCREASES THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE DATE CODE ON THE WIPER MOTOR. MOTORS BUILT WITH THE SUSPECT TIME FRAME WILL HAVE THE WIPER MOTOR GEAR CASE COVER REPLACED. OWNER NOTIFICATION BEGAN AUGUST 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-866-436-7332.
00V073000 · Trailer Hitches
Mar 7, 2000
VEHICLE DESCRIPTION: MULTI-PURPOSE VEHICLES. THE TRAILER HITCH ASSEMBLY TO THE FRAME ATTACHING BOLTS COULD LOSE THE CLAMP LOAD.
Consequence & remedy
Consequence: THE TRAILER HITCH COULD THEN SEPARATE FROM THE VEHICLE.
Remedy: DEALERS WILL REPLACE THE TRAILER HITCH MOUNTING BOLTS AND NUT PLATES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP05005 · Spark Plug Ejection From Cylinder Head
Opened Sep 22, 2005 · Closed Jan 4, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Additional source detail variants (3)
Engine And Engine Cooling:engine
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling:engine:gasoline
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
Engine And Engine Cooling
ON SEPTEMBER 6, 2005, ODI RECEIVED A PETITION REQUESTING THAT THE AGENCY INVESTIGATE ALLEGATIONS OF ENGINE SPARK PLUG EJECTION IN CERTAIN MODEL YEAR 1997 THROUGH 2004 FORD VEHICLES WITH TRITON V-8 AND V-10 ENGINES.ODI RECEIVED A TOTAL OF 474 NON-DUPLICATIVE COMPLAINTS ON THE SUBJECT VEHICLES WHERE THE COMPLAINANT, OR THE DEALER REPAIRING THE VEHICLE, REPORTED THAT A SPARK PLUG DETACHED FROM THE CYLINDER AND/OR EJECTED FROM THE ENGINE.AS OF DECEMBER 8, 2005, ODI IS NOT AWARE OF ANY ALLEGATIONS WHERE THE ALLEGED DEFECT RESULTED IN A LOSS OF VEHICLE CONTROL, A CRASH, AN INJURY, OR A FATALITY IN ANY OF THE 10,319,810 SUBJECT VEHICLES.IN ADDITION, ODI IS AWARE OF ONLY TWO INCIDENTS WHERE THE VEHICLE STALLED WITHOUT RESTART.INFORMATION CONTAINED IN THE ODI CONSUMER COMPLAINTS AND OBTAINED FROM 72 TELEPHONE INTERVIEWS WITH COMPLAINANTS SHOWED THE FOLLOWING:(1) 99% OF THE COMPLAINTS WERE ON MY 1997 TO 2002 SUBJECT VEHICLES.(2) MOST THE COMPLAINANTS REPORTED HEARING A LOUD POP WHILE DRIVING OR UPON STARTING UP THE VEHICLE FOLLOWED BY A LOUD, REPETITIVE CLICKING OR POPPING SOUND.(3) MANY OF THE COMPLAINANTS REPORTED THAT THE POPPING SOUND WAS ACCOMPANIED BY SOME LOSS OF VEHICLE POWER; HOWEVER, IN 99% OF THE INCIDENTS REPORTED, THE VEHICLE DID NOT STALL.IN THE VERY FEW INCIDENTS WHERE THE VEHICLE DID STALL, MOST VEHICLES COULD BE RESTARTED.(4) ONLY A SMALL PERCENTAGE OF THE COMPLAINANTS CITED THAT THEY SMELLED GAS OR A SLIGHT BURNING SMELL WHEN THE INCIDENT OCCURRED.(5) IN ALL BUT A VERY FEW INCIDENTS, VEHICLE DAMAGE WAS LIMITED TO THE ENGINE.IN ONE INCIDENT, THE COMPLAINT REPORTED THAT THE FUEL RAIL WAS DAMAGED AND REPLACED AFTER ONE OF THE SPARK PLUGS EJECTED FROM THE ENGINE; HOWEVER, THE COMPLAINANT REPORTED THAT THE DAMAGE DID NOT RESULT IN ANY TYPE OF FUEL LEAK OR FIRE.IN ANOTHER INCIDENT, THE ONLY INCIDENT WHERE A FIRE WAS ALLEGED, THE COMPLAINANT REPORTED THAT NO FLUID LEAK WAS OBSERVED, BUT THAT A FIRE RESULTED AFTER THE SPARK PLUG HAD EJECTED FROM THE ENGINE AND HE HAD RESTARTED THE VEHICLE AND DRIVEN TO ANOTHER LOCATION.NONE OF THE COMPLAINANTS REPORTED ANY DAMAGE TO THE VEHICLE HOOD.(6) ONLY TWO COMPLAINANTS REPORTED THAT THEY OBSERVED WHAT APPEARED TO BE SOME DROPS OF FUEL COMING FROM THE CYLINDER WHERE THE SPARK PLUG HAD FAILED OR ON THE SPARK PLUG ITSELF; HOWEVER, EACH OF THESE COMPLAINANTS REPORTED THAT THERE WAS NO SMOKE OR FLAMES AS A RESULT OF HIS INCIDENT.AS THE PETITIONER NOTED, AND ODI?S ANALYSIS SHOWED, IT IS POSSIBLE FOR A SPARK PLUG TO DETACH FROM THE ENGINE CYLINDER THREADS IN THE SUBJECT VEHICLES.HOWEVER, ODI?S ANALYSIS OF 474 COMPLAINTS DESCRIBING SUCH INCIDENTS FOUND ONLY A VERY FEW ALLEGED ANY SAFETY-RELATED CONSEQUENCES.NONE OF THESE SHOWED ANY EVIDENCE OF A SERIOUS SAFETY CONSEQUENCE.GIVEN THE LARGE POPULATION AND RELATIVELY LONG EXPOSURE TIME OF THE SUBJECT VEHICLES, THE COMPLAINT ANALYSIS INDICATES THAT THE RISK TO MOTOR VEHICLE SAFETY FROM THE ALLEGED DEFECT IS VERY LOW.IN VIEW OF THE FOREGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF THE ALLEGED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THEREFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.
PE04078 · Speed Control Deactivation Switch Fire
Opened Nov 19, 2004 · Closed Mar 22, 2005
Status: closed (inferred from source dates) · Vehicle Speed Control:cruise Control
IN ITS LETTER DATED JANUARY 27, 2005 TO ODI, FORD INDICATED THAT IT WOULD CONDUCT A SAFETY RECALL (NHTSA RECALL # 05V-017) TO REMEDY AN OVERHEATING SPEED CONTROL DEACTIVATION SWITCH IN APPROXIMATELY 738,490 SUBJECT VEHICLES.THE VEHICLES AFFECTED BY THE RECALL ARE CERTAIN 2000 MODEL YEAR (MY) FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR EQUIPPED WITH SPEED CONTROL AND CERTAIN 2001 MODEL YEAR F150 SUPERCREW VEHICLES BUILT THROUGH AUGUST 7, 2000.SINCE OPENING PE04-078, ODI HAS IDENTIFIED OTHER REPORTS OF KEY OFF ENGINE COMPARTMENT FIRES IN FORD VEHICLES WITH SIMILAR SPEED CONTROL DEACTIVATION SWITCHES THAT WERE NOT THE SUBJECT OF THIS PRELIMINARY EVALUATION OR FORD'S RECALL 05V-017.FORD'S RESPONSE TO THE ODI INFORMATION REQUEST LETTER DATED DECEMBER 3, 2004, PROVIDED AN ADDITIONAL 107 ALLEGATIONS OF KEY OFF ENGINE COMPARTMENT FIRES THAT WERE ALSO IN VEHICLES NOT SUBJECT TO THIS INVESTIGATION OR INCLUDED IN THE FORD RECALL 05V-017.AN ENGINEERING ANALYSIS (EA) IS WARRANTED TO DETERMINE IF A SAFETY DEFECT TREND EXISTS RELATING TO KEY OFF ENGINE COMPARTMENT FIRES IN VEHICLES OUTSIDE THE SCOPE OF THIS PRELIMINARY EVALUATION.ODI WILL EXPAND THE SCOPE OF IT'S INVESTIGATION AT THE EA PHASE TO INCLUDE THE 1995 THROUGH 2002 MODEL YEARS OF THE FORD F150, FORD EXPEDITION AND LINCOLN NAVIGATOR VEHICLES.