FUEL TANK HOSE IS DESIGNED TO RUN AGAINST THE DRIVE SHAFT TO AVOID BEING PINCHED BY SUSPENSION. BUT OVER TIME THE CONSTANT RUNNING OF THE DRIVE SHAFT AGAINST THE HOSE WILL DETERIORATE IT CAUSING THE FUEL HOSE TO LEAK AND POSSIBLE FIR CAN RESULT! LINCOLN DESIGNED THE PLASTIC HOLDER TO HOLD HOSE AGAINST DRIVE SHAFT. THE PORTION OF…
Read full complaint
FUEL TANK HOSE IS DESIGNED TO RUN AGAINST THE DRIVE SHAFT TO AVOID BEING PINCHED BY SUSPENSION. BUT OVER TIME THE CONSTANT RUNNING OF THE DRIVE SHAFT AGAINST THE HOSE WILL DETERIORATE IT CAUSING THE FUEL HOSE TO LEAK AND POSSIBLE FIR CAN RESULT! LINCOLN DESIGNED THE PLASTIC HOLDER TO HOLD HOSE AGAINST DRIVE SHAFT. THE PORTION OF MY DRIVE SHAFT THAT HAS BEEN RUBBING AGAINST THE FUEL HOSE HAS BEEN HIGHLY POLISHED TO A CHROME FINISH. FUEL HOSE IS LEAKING AT A GOOD RATE WHILE VEHICLE IS RUNNING. *JB
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE HEADLIGHTS CAN FLASH INTERMITTENTLY AS A RESULT OF THE CIRCUIT BREAKER OPENING. THE VEHICLE'S HEADLIGHTS CAN GO OUT FOR BRIEF INTERVALS.
Consequence & remedy
Consequence: LOSS OF HEADLIGHTS DURING VEHICLE OPERATION CAN AFFECT A DRIVER'S ABILITY TO NAVIGATE THE ROADWAY AND REDUCE THE VISIBILITY OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A HEADLIGHT SWITCH THAT INCORPORATES A CRICUIT BREAKER OF REVISED DESIGN AND INSTALLATION OF A WIRING HARNESS CONNECTOR AND WIRING, IF NEEDED.
THE LINK LEVER TRUNION ON THE SAFETY BELT RETRACTOR MAY HAVE BEEN DAMAGED DURING INSTALLATION.
Consequence & remedy
Consequence: THE DAMAGED COMPONENT MAY BECOME DISLODGED DURING VEHICLEOPERATION, MAKING THE RETRACTOR VEHICLE-SENSITIVE LOCKING SYSTEM INOPERATIVE.THIS INCREASES THE POSSIBILTY OF A SERIOUS INJURY IN A SUDDEN STOP OR ACCIDENT.
Remedy: THE RETRACTORS WILL BE REPLACED IN THE SUBJECT VEHICLES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA96019 · Headlight Failure
Opened Jul 31, 1996 · Closed Jan 26, 1998
Status: closed (inferred from source dates) · Exterior Lighting
EXCESSIVE HEAT IN AN IMPROPERLY MANUFACTURED CIRCUIT BREAKER WITHIN THE HEADLIGHT SWITCH CAUSED THAT CIRCUIT BREAKER TO OPEN FOR TIME PERIODS OF VARYING LENGTH TO COOL OFF.OPENING OF THE CIRCUIT BREAKER IN THIS MANNER INTERRUPTS ELECTRIC CURRENT FLOW TO THE HEADLIGHTS, SHUTTING THEM OFF.HEADLIGHT OUTAGES HAVE RANGER FROM BRIEF FLICKERS (LESS THAN ONE SECOND) TO GREATER THAN 20 SECONDS.OVER TIME, THE OUTAGES GROW IN LENGTH AND DURATION BECAUSE OF HEAT-INDUCED DETERIORATION OF THE SWITCH AND ASSOCIATED WIRING.RECALL 98V-009 WILL APPLY TO APPROXIMATELY 506,000 TAURUS, SABLE, MARK VIII, AND CONTINENTAL VEHICLES PRODUCED FROM 1-DEC.-92 THROUGH 30-SEP-93 AT THE ATLANTA, CHICAGO,AND WIXOM ASSEMBLY PLANTS.87% OF MY 1992-1995 TAURUS/SABLE AND 97% OF MY 1993-1995 MARK VIII WARRANTY REPAIRS (HEADLIGHT SWITCH REPLACEMENT) INVOLVED VEHICLES BUILT DURING THE DEC. 92 - OCT. 93 BUILD RANGE.
1993 Lincoln Mark Viii Problems, Complaints & Recalls | Skip That Year
Illustration