IllustrationRIGHT SIDE TIRE HITS THE CURB LANE TRIED TO CORRECT IT& LOSES CONTROL (FISH TAIL) ROLLS OVER SEVERAL TIMES & LANDS ON DITCH. BOTH SIDE AIRBAGS DID NOT DEPLOY THAT CAUSE SEVERE INJURY TO PERSON OCCUPYING PASSENGER SIDE.
2004 Lexus RX330
Owner reports · Recalls · Investigations
More warning signs than most RX330 years
Owner complaints for the 2004 Lexus RX330 are substantially higher than the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all RX330 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
2525–50K
2450–75K
2275–100K
26100–150K
10150K+
188 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports1 fire reports20 injury reports
What owners actually said
287 reportsHIGHWAY DRIVING @ 70 MPH DRIVING AFTER 360 MILES AND 250 MILES, CONDITIONS WERE DRY AND PAVEMENT SMOOTH AND CLEAR IN BOTH CASES, NO CONSTRUCTION IN THE AREA. VEHICLE STARTED WITH A SLIGHT VIBRATION AND EVENTUALLY IT LED UP TO A SIGNIFICANT VIBRATIONS THAT SHOOK THE CHASSIS INCLUDING THE STEERING WHEEL. VIBRATION WORSENED AS TH…
Read full complaint
HIGHWAY DRIVING @ 70 MPH DRIVING AFTER 360 MILES AND 250 MILES, CONDITIONS WERE DRY AND PAVEMENT SMOOTH AND CLEAR IN BOTH CASES, NO CONSTRUCTION IN THE AREA. VEHICLE STARTED WITH A SLIGHT VIBRATION AND EVENTUALLY IT LED UP TO A SIGNIFICANT VIBRATIONS THAT SHOOK THE CHASSIS INCLUDING THE STEERING WHEEL. VIBRATION WORSENED AS THE BRAKE WAS APPLIED TO PULL OVER. THE FIRST TIME WE CHECKED VEHICLE OUTSIDE AND NOTICED NOTHING UNUSUAL AND RESTARTED TESTING THE BRAKES THE FIRST FEW HUNDRED FEET AND THE VIBRATION WAS STILL THERE DURING BRAKING BUT NO LONGER THERE WHILE DRIVING. THE SECOND OCCURANCE I COULD FEEL THE VIBRATION BUILD UP SO I STARTED TO SLOW DOWN AND AGAIN BRAKING MADE IT WORSE. I THOUGHT THIS IS A BRAKE PROBLEM SO TO CORRECT THE PROBLEM I TRIED PUTTING MY FOOT UNDER THE BRAKE PEDAL AND PULLING BACK TOWARDS ME. AFTER DOING THIS I IMMEDIATELY FELT THE VIBRATION GO AWAY. HOWEVER, FOR THE NEXT SEVERAL BRAKE SITUATIONS, THE VEHICLE STILL VIBRATED WHILE THE BRAKES WERE APPLIED. I THOUGHT THIS MIGHT BE THE MAT, HOWEVER, THE PEDAL GOES STRAIGHT UP INTO THE IP AND THE MAT CAN NOT INTERFER WITH PEDAL TRAVEL. DURING THE NEXT SEVERAL HUNDRED WE WOULD PULL BACK ON THE PEDAL. MOST CASES THE PEDAL WOULD HAVE NO TRAVAL BACK BUT ON OCCASSION WE WOULD FEEL THAT IT WOULD HAVE TRAVEL BACK. I WILL BE TAKING THIS TO A DEALER TO HAVE THIS CHECKED OUT. IT WAS ALMOST AS IF THE BOOSTER WAS CREATING A NEGATIVE VACUMN PULLING THE PEDAL TO THE FLOOR APPLYING THE BRAKE. FIRST INCIDENT WAS ON 6/10/05 ON I-80 360 MILES EAST OF CHICAGO (IN OHIO) AND THE SECOND WAS ON 6/20/05, 250 MILES WEST OF NIAGARA FALLS.
OUR LEXUS RX330 WAS PURCHASED IN AUGUST OF 2003. FOR THE LAST SEVERAL MONTHS, THE VEHICLE HESITATES TO SHIFT GEARS WITH A LAG CAUSING THE VEHICLE TO JERK FORWARD. WE HAVE TROUBLE MERGING ONTO THE HIGHWAY AS WELL AS ACCELERATING FROM A STOP AND WHILE TURNING DUE TO THIS DANGEROUS CONDITION. DEALER KEEPS PERFORMING THE TSB TC005…
Read full complaint
OUR LEXUS RX330 WAS PURCHASED IN AUGUST OF 2003. FOR THE LAST SEVERAL MONTHS, THE VEHICLE HESITATES TO SHIFT GEARS WITH A LAG CAUSING THE VEHICLE TO JERK FORWARD. WE HAVE TROUBLE MERGING ONTO THE HIGHWAY AS WELL AS ACCELERATING FROM A STOP AND WHILE TURNING DUE TO THIS DANGEROUS CONDITION. DEALER KEEPS PERFORMING THE TSB TC005-03 "POOR SHIFT QUALITY" AND REPROGRAMS THE COMPUTER WITH NO IMPROVEMENT. WE ARE TOLD THERE IS NOTHING MORE THAT CAN BE DONE. AFTER MULTIPLE ATTEMPTS WITH LEXUS CUSTOMER SERVICE, THEY DENY A PROBLEM EXISTS AND STATES THAT THE VEHICLE PERFORMS WITHIN SPECIFICATIONS. CUSTOMER SERVICE EVEN FAILS TO DOCUMENT MY COMPLAINTS BY NOT ENTERING IT IN THE IR COMPUTER SYSTEMS IN AN ATTEMPT TO HIDE THE DEFECT. MANY OWNERS REPORT THIS PROBLEM ON INTERNET MESSAGE BOARDS. THIS IS A DANGEROUS AND UNACCEPTABLE DESIGN FLAW THAT NEEDS TO BE CORRECTED WITH A RECALL.
AROUND 11,000 MILES MY 2004 RX330 STARTED HAVING A THUMPING SOUND THAT OCCURRED INTERMITTENTLY WHILE DECELERATING ESPECIALLY AROUND 29 MPH AND THEN AGAIN AROUND 19 MPH. I TOOK IT TO THE DEALER AND THEY INFORMED ME THAT IT WAS MY TRANS COOLER LINE ASSEMBLY AND OIL COOLER HOSE WHICH WERE REPLACED AND THE PROBLEM WAS RESOLVED FOR …
Read full complaint
AROUND 11,000 MILES MY 2004 RX330 STARTED HAVING A THUMPING SOUND THAT OCCURRED INTERMITTENTLY WHILE DECELERATING ESPECIALLY AROUND 29 MPH AND THEN AGAIN AROUND 19 MPH. I TOOK IT TO THE DEALER AND THEY INFORMED ME THAT IT WAS MY TRANS COOLER LINE ASSEMBLY AND OIL COOLER HOSE WHICH WERE REPLACED AND THE PROBLEM WAS RESOLVED FOR ABOUT ONE WEEK THAT WAS BACK IN OCT. 2004. I HAVE TAKEN THE VEHICLE BACK ABOUT 4 MORE TIMES FOR THE THUMPING NOISE THAT CONTINUES TO OCCUR INTERMITTENTLY AND NOW THEY TELL ME THE NOISE IS NORMAL AND THAT THE VEHICLE IS OPERATING AS DESIGNED. I QUESTIONED HOW CAN IT BE CONSIDERED ABNORMAL BACK IN OCTOBER BUT NOW THAT THE THUMPING NOISE CAN'T BE FIXED THEY CONSIDER IT A DESIGN FLAW. THEY APPARENTLY UPGRADED IT AND THAT SHOULD HAVE ELIMINATED THE NOISE BUT IF IT DIDN'T THERE IS NOTHING ELSE TO DO BECAUSE THIS IS HOW THE VEHICLE WAS DESIGNED... I FEAR EVERYDAY THAT THIS THUMPING NOISE IS ONLY THE BEGINNING OF WHAT IS YET TO FOLLOW AS I READ ALL THE OTHER TRANSMISSION PROBLEMS THAT HAVE BEEN OCCURING AND SOME HAVE EXHIBITED THE THUMP SOUND...LEXUS NEEDS TO FIX THE PROBLEMS AND NOT JUST PUT A BAND-AID ON EACH ONE THAT OCCURS UNTIL THE NEXT MAJOR INCIDENT ... TAKE THIS VEHICLES OFF THE ROAD IF SO MANY CONSUMERS ARE PUTTING THEIR LIFE IN JEOPARDY DRIVING A VEHICLE THAT WAS APPARENTLY NOT MANUFACTURED PROPERLY AND SHOULD NOT BE CONSIDERED SAFE TO DRIVE.
PICKING UP MY DAUGHTER AT A FRIENDS HOUSE AND FORTUNATELY WAS ONLY GOING ABOUT 5-10MPH TO A STOP SIGN WHEN MY BRAKES FAILED WITHOUT WARNING. I HAD TO PUT MY ENTIRE BODY WEIGHT ON THE PEDAL TO SLOW THE VEHICLE DOWN. THE CAR WAS TOWED BY FLATBED TO DEALERSHIP AND DETERMINED IT WAS THE BRAKE BOOSTER ASSEMBLY. AT THE SAME TIME MY…
Read full complaint
PICKING UP MY DAUGHTER AT A FRIENDS HOUSE AND FORTUNATELY WAS ONLY GOING ABOUT 5-10MPH TO A STOP SIGN WHEN MY BRAKES FAILED WITHOUT WARNING. I HAD TO PUT MY ENTIRE BODY WEIGHT ON THE PEDAL TO SLOW THE VEHICLE DOWN. THE CAR WAS TOWED BY FLATBED TO DEALERSHIP AND DETERMINED IT WAS THE BRAKE BOOSTER ASSEMBLY. AT THE SAME TIME MY FUEL INJECTOR ASSEMBLY APPARENTLY NEEDED TO BE REPLACED WHICH I HAD NO IDEA OF UNTIL I RECIEVED MY WORK ORDER SHEET. I WAS ACCUSED OF USING CHEAP GAS WHICH I ABSOLUTELY NEVER USED. I ONLY USE THE HIGHEST GRADE OF FUEL IN MY VEHICLE SO THEY COULD GIVE ME NO OTHER REASON FOR THE COINCIDENCE. IT SEEMS LIKE MANY 2004 RX330'S HAVE BEEN HAVE ALOT OF BRAKE ISSUES BUT LEXUS' ANSWER TO THE PROBLEM IS THAT IF THE PROBLEM CAN BE FIXED THEN THE CAR IS RUNNING ACCORDING TO SPECIFICATIONS. MY QUESTION TO THEM WAS CAN THEY FIX THE PROBLEM OF THE LOSS OF A LIFE WHEN THIS UNSAFE VEHICLE PRODUCES THAT PROBLEM? I HAVE ALSO HAD TO HAVE BRAKE ROTOR PADS REPLACED AT 15,000 MILES WHICH ACCORDING TO THE SERVICE TECH WAS OUT OF THE ORDINARY BUT NOT ACCORDING TO A LEXUS CUSTOMER SATISFACTION ADMINISTRATOR. I FIND IT APPALLING THAT LEXUS IS NOT STANDING BEHIND ITS PRODUCT TO HAVE THESE UNSAFE VEHICLES TAKEN OFF THE ROAD INSTEAD THEY ARE WILLING TO RISK CONSUMERS LIVES NATIONWIDE.... SO MUCH FOR CUSTOMER SATISFACTION.
CONSUMER HAS 3 MAJOR COMPLAINTS ON THE 2004 LEXUS RX 330: SUN GLARE FROM THE DASHBOARD OBSTRUCTING VISIBILITY. THE HIGH INTENSITY LIGHTS DO NOT ILLUMINATE ENOUGH DOWN THE ROAD FOR THE CONSUMER TO SEE SAFELY. THERE IS SEVERE HESITATION AFTER SLOWING THE VEHICLE DOWN, FOLLOWED BY A SUDDEN SURGE OF POWER. *MR THE DEALER IS AWARE…
Read full complaint
CONSUMER HAS 3 MAJOR COMPLAINTS ON THE 2004 LEXUS RX 330: SUN GLARE FROM THE DASHBOARD OBSTRUCTING VISIBILITY. THE HIGH INTENSITY LIGHTS DO NOT ILLUMINATE ENOUGH DOWN THE ROAD FOR THE CONSUMER TO SEE SAFELY. THERE IS SEVERE HESITATION AFTER SLOWING THE VEHICLE DOWN, FOLLOWED BY A SUDDEN SURGE OF POWER. *MR THE DEALER IS AWARE OF THE PROBLEM BUT INDICATED THERE WAS NO WAY TO FIX THEM. *NM
ENGINE/TRANSMISSION HESITATION; MISSED SHIFT POINTS; AND STALLS IN TRAFFIC UPON ACCELERATION. USING AUTOMATIC CLIMATE CONTROL CAUSES ALL WINDOWS TO FOG UP TO THE EXTENT THAT YOU CAN NOT SEE OUT OF THE WINDOWS. LOAD ENGINE NOISES AND POPPING SOUNDS.
ON JANUARY 17, 2005 I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT IN MY 2004 LEXUS RX330. THIS ACCIDENT OCCURRED LESS THAN 1 MILE FROM MY HOME, ON MY OWN STREET, 1-2 MINUTES AFTER LEAVING MY HOME. IT HAD SNOWED THE NIGHT BEFORE AND THE ROADWAY WAS STILL SNOW/ICE COVERED, IT WAS A FRIGID MORNING. I WAS TRAVELING APPROXIMATELY 15 MI…
Read full complaint
ON JANUARY 17, 2005 I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT IN MY 2004 LEXUS RX330. THIS ACCIDENT OCCURRED LESS THAN 1 MILE FROM MY HOME, ON MY OWN STREET, 1-2 MINUTES AFTER LEAVING MY HOME. IT HAD SNOWED THE NIGHT BEFORE AND THE ROADWAY WAS STILL SNOW/ICE COVERED, IT WAS A FRIGID MORNING. I WAS TRAVELING APPROXIMATELY 15 MILES PER HOUR AND THE VEHICLE BRAKES FAILED TO ENGAGE. I ATTEMPTED TO PUSH THE BRAKE PETAL TO THE FLOOR WITHOUT RESULT. THE ANTI-LOCK BRAKES DID NOT FUNCTION. THE DAMAGE TO THIS VEHICLE EXCEEDED $8000. DAYS AFTER THE DAMAGE TO THE VEHICLE WAS FIXED MY HUSBAND TOOK THE VEHICLE TO THE LEXUS OF TOWSON DEALERSHIP TO HAVE THE BRAKING MECHANISM LOOKED AT. DURING THE DRIVE TO THE DEALERSHIP (IN SIMILAR, SNOW COVERED/FRIGID CONDITIONS) MY HUSBAND WAS ABLE TO REPRODUCE THIS PROBLEM, AGAIN JUST AFTER LEAVING OUR HOME. THE DEALERSHIP (A 40 MINUTE DRIVE FROM OUR HOME) WAS UNABLE TO REPRODUCE THIS PROBLEM AND TOLD US TO CALL BACK IF THE PROBLEM OCCURRED AGAIN. TODAY, MAY 24, 2005, WE WERE INFORMED DURING A ROUTINE OIL CHANGE THAT THERE MAY BE A PROBLEM WTH THE BRAKES AND THAT A CAMPAIGN WAS UNDERWAY TO INVESTIGATE. I WANTED TO FORMALLY ADD MY VEHICLE TO THIS LIST OF COMPAINTS.
MY 2004 LEXUS RX330 HAS NOISY RATTLING SUSPENSION WHEN DRIVING OVER UNDULATING SURFACES OR SPEED BUMPS, ALSO THE STEERING APEARS TO DRIFT WHEN TRAVELLING IN A STRIAGHT LINE,. DEALER HAS CHECKED ON NUMBER OF OCCASIONS BUT STATED IT IS JUST A CHARACTRISTIC OF THE VEHICLE, BUT I HAVE DRIVEN MANY OTHER SIMILAR CARS WITH NO SUCH NOI…
Read full complaint
MY 2004 LEXUS RX330 HAS NOISY RATTLING SUSPENSION WHEN DRIVING OVER UNDULATING SURFACES OR SPEED BUMPS, ALSO THE STEERING APEARS TO DRIFT WHEN TRAVELLING IN A STRIAGHT LINE,. DEALER HAS CHECKED ON NUMBER OF OCCASIONS BUT STATED IT IS JUST A CHARACTRISTIC OF THE VEHICLE, BUT I HAVE DRIVEN MANY OTHER SIMILAR CARS WITH NO SUCH NOISE OR DRIFT.
THE ACCELERATOR STUCK, AND CONSUMER WAS NOT ABLE TO STOP THE VEHICLE. CONSUMER LEFT THE VEHICLE, AND CONTACTED THE MANUFACTURER. THEY HAD THE VEHICLE TOWED, SUPPOSEDLY REPAIRED, BUT CONSUMER WAS NOT SATISFIED.*AK BECAUSE CONSUMER HAVE NO BRAKEBRAKES HE HAD TO USE THE EMERGENCY BRAKE WHICH SLOWED THE CAR DOWN ENOUGH TO PUT I…
Read full complaint
THE ACCELERATOR STUCK, AND CONSUMER WAS NOT ABLE TO STOP THE VEHICLE. CONSUMER LEFT THE VEHICLE, AND CONTACTED THE MANUFACTURER. THEY HAD THE VEHICLE TOWED, SUPPOSEDLY REPAIRED, BUT CONSUMER WAS NOT SATISFIED.*AK BECAUSE CONSUMER HAVE NO BRAKEBRAKES HE HAD TO USE THE EMERGENCY BRAKE WHICH SLOWED THE CAR DOWN ENOUGH TO PUT IT IN PARK WHILE MOVING, THEN HE SHUT OFF THE IGNITION. THIS VEHICLE CAME WITH NO CLIPS ON THE KICK PANEL. *BF
Official recalls
511V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
06V023000 · Seat Belts:rear/other
Jan 27, 2006
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE ANCHOR BOLT FOR THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE DIRECTLY BEHIND THE DRIVER'S SEAT DOES NOT HAVE SUFFICIENT STRENGTH.
Consequence & remedy
Consequence: THE REAR SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE FREE OF CHARGE THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE ANCHOR BOLT WITH AN IMPROVED ONE. THE RECALL BEGAN ON FEBRUARY 3, 2006. OWNERS MAY CONTACT LEXUS AT 800-255-3987.
04V558000 · Exterior Lighting:brake Lights:switch
Nov 22, 2004
CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.
Consequence & remedy
Consequence: IF THE SWITCH IS INOPERABLE, THE BRAKE LIGHTS WILL NOT ILLUMINATE AND CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH. THE RECALL BEGAN DURING DECEMBER 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
PE05009 · Vacuum Brake Booster Failure
Opened Feb 10, 2005 · Closed Jun 15, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:vacuum; Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (6)
Service Brakes, Hydraulic:foundation Components:master Cylinder
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.