IllustrationI HAVE HARD TIME DEPRESSING BRAKE PEDAL. I WENT TO LEXUS DEALER TO GET IT CHECKED. I THINK I PAID 170 DOLLARS AND THEY SAID IT IS OK. BUT, I STILL DO NOT LIKE THE BRAKE PEDAL NEVER BEEN SMOOTH.
2004 Lexus RX330
Owner reports · Recalls · Investigations
More warning signs than most RX330 years
Owner complaints for the 2004 Lexus RX330 are substantially higher than the model-year median of 36.
About this comparison →How this year compares
Owner complaints by model year
Compare all RX330 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
810–25K
2525–50K
2450–75K
2275–100K
26100–150K
10150K+
188 reports with mileage · 99 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 34 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
37 crash reports1 fire reports20 injury reports
Service Brakes, Hydraulic complaints
58 reports2004 LEXUS RX330. CONSUMER STATES PROBLEMS WITH THE BRAKE FLUID AFTER THE VEHICLE WENT IN FOR A 30,000 MILE CLEAN UP. *KB THE CONSUMER STATED THE BRAKE LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONSUMER WAS INFORMED THAT AN AIR BUBBLE HAD FORMED IN THE BRAKE LINE, POSSIBLY CAUSED WHEN THE LIN…
Read full complaint
2004 LEXUS RX330. CONSUMER STATES PROBLEMS WITH THE BRAKE FLUID AFTER THE VEHICLE WENT IN FOR A 30,000 MILE CLEAN UP. *KB THE CONSUMER STATED THE BRAKE LIGHT ILLUMINATED ON THE DASHBOARD. THE VEHICLE WAS TAKEN TO THE DEALER. THE CONSUMER WAS INFORMED THAT AN AIR BUBBLE HAD FORMED IN THE BRAKE LINE, POSSIBLY CAUSED WHEN THE LINE WAS DRAINED DURING A 30,000 MILE CHECK-UP AND RESULTED IN THE BRAKE FLUID BEING SLIGHTLY LOW. THE FOLLOWING WEEK, THE BRAKE LIGHT ILLUMINATED AGAIN AND THE CONSUMER IMMEDIATELY RETURNED TO THE DEALER. IT WAS DISCOVERED THERE WAS ABSOLUTELY NO BRAKE FLUID IN THE RESERVOIR. THE BRAKE CYLINDER AND BRAKE BOOSTER WERE REPLACED. *JB
ON THE DATE OF THE ACCIDENT I WAS DRIVING MY 2004 LEXUS RX300 APPROACHING AN INTERSECTION WITH CARS STOPPED IN FRONT OF ME WAITING FOR THE TRAFFIC LIGHT TO CHANGE TO GREEN. ALTHOUGH I KEPT PRESSING ON THE BRAKES NOTHING HAPPENED AND I ENDED UP CRASHING INTO THE CAR AHEAD OF ME AND CAUSING A CHAIN REACTION INVOLVING FOUR (4) OTH…
Read full complaint
ON THE DATE OF THE ACCIDENT I WAS DRIVING MY 2004 LEXUS RX300 APPROACHING AN INTERSECTION WITH CARS STOPPED IN FRONT OF ME WAITING FOR THE TRAFFIC LIGHT TO CHANGE TO GREEN. ALTHOUGH I KEPT PRESSING ON THE BRAKES NOTHING HAPPENED AND I ENDED UP CRASHING INTO THE CAR AHEAD OF ME AND CAUSING A CHAIN REACTION INVOLVING FOUR (4) OTHER CARS, THEN SWERVING ONTO THE SIDE OF THE ROAD AND FINALLY COMING TO A STOP BY HITTING THE TRAFFIC LIGHT POLE. NONE OF THE AIR BAGS DEPLOYED. STILL VISIBLY IN SHOCK, I WAS HELPED OUT OF MY VEHICLE BY OTHERS WHO HAD STOPPED TO HELP INCLUDING THOSE INVOLVED IN THE ACCIDENT. THE POLICE ARRIVED SHORTLY AFTER ON THE SCENE AND BEGAN AN INVESTIGATION BY ASKING OTHER DRIVERS WHO HAD WITNESSED THE ACCIDENT. ACCORDING TO THE POLICE REPORTS, THE DRIVERS BEHIND ME CLEARLY SAW THE BRAKE LIGHTS ON THOUGH THE VEHICLE OBVIOUSLY CONTINUED MOVING. SINCE THE ACCIDENT WE HAVE TRIED TO WORK WITH OUR INSURANCE PROVIDER (METLIFE) TO DO A THOROUGH INSPECTION OF THE VEHICLE AND DETERMINE THE CAUSE OF THE ACCIDENT, BUT IT HAS BEEN ALL WITH NO AVAIL. WE HAVE BEEN KEPT IN THE DARK AS TO WHAT HAS EXACTLY BEEN DONE IF ANYTHING. THE VEHICLE IN THE MEAN TIME WAS DEEMED 'TOTALED' BY THE INSURANCE COMPANY WHO HAS SENT A CHECK. WE'D LIKE TO CLEARLY UNDERSTAND WHAT CAUSED THE ACCIDENT SINCE IT WAS NOT AN OPERATOR ERROR. PLEASE ADVISE ON HOW TO PROCEED. *TR
I HAVE 2004 LEXUS RX330. YESTERDAY, APRIL 26TH, 2010 WHILE DRIVING TO LOCAL BANK, I NEEDED TO APPLY THE BRAKES. I PUSHED ON THE BRAKE PEDAL AND IT MADE SOME WEIRD SOUND AND PEDAL WENT ALL THE WAY TO THE FLOOR AND VEHICLE HAD HARD TIME STOPPING. SOMEHOW I MANAGED TO COME BACK HOME SAFELY. THE PEDAL GOES TO FLOOR AND VEHICLE BA…
Read full complaint
I HAVE 2004 LEXUS RX330. YESTERDAY, APRIL 26TH, 2010 WHILE DRIVING TO LOCAL BANK, I NEEDED TO APPLY THE BRAKES. I PUSHED ON THE BRAKE PEDAL AND IT MADE SOME WEIRD SOUND AND PEDAL WENT ALL THE WAY TO THE FLOOR AND VEHICLE HAD HARD TIME STOPPING. SOMEHOW I MANAGED TO COME BACK HOME SAFELY. THE PEDAL GOES TO FLOOR AND VEHICLE BARELY STOPS. I DO NOT SEE ANY LEAKS IN MY GARAGE WHERE VEHICLE IS ALWAYS PARKED. I TOOK IT TO THE TOYOTA DEALER AND HE SAYS MASTER CYLINDER HAS INTERNAL LEAK AND NEED TO BE REPLACED ALONG WITH BRAKE PADS BOTH FRONT AND BACK. *TR
SOMEONE NEEDS TO LISTEN! I HAVE A 2004 LEXUS RX330. IT'S HAD TROUBLE FROM DAY ONE, AND I GOT NOWHERE! THEY HAVE DONE 5 UPDATES ON THE COMPUTER. NOW IT ONLY SEEMS TO HAVE TROUBLE AT 20 MPH, INSTEAD OF 40-50 AND 65-80, OF LURCHING, HESITATING, THEN TAKING OFF LIKE A BAT OUT OF HELL. IT'S HAD A "BULLETIN" ON THE FRONT BRAKES, A…
Read full complaint
SOMEONE NEEDS TO LISTEN! I HAVE A 2004 LEXUS RX330. IT'S HAD TROUBLE FROM DAY ONE, AND I GOT NOWHERE! THEY HAVE DONE 5 UPDATES ON THE COMPUTER. NOW IT ONLY SEEMS TO HAVE TROUBLE AT 20 MPH, INSTEAD OF 40-50 AND 65-80, OF LURCHING, HESITATING, THEN TAKING OFF LIKE A BAT OUT OF HELL. IT'S HAD A "BULLETIN" ON THE FRONT BRAKES, AND SHIMMIED ALL OVER THE ROAD. I HAVE PAPER WORK ON ALL OF THIS AND MORE. YOU, THE NTSB, CAN TAKE THE CAR AND GO THRU IT, I'LL GIVE YOU THE REPAIR RECORDS. I'VE CALLED THE TOYOTA HEADQUARTERS IN 04 OR 05 BEGGING THEM TO HELP ME. A WOMAN SAID, THE CAR WAS, "PERFORMING IN THE MANNER IT WAS DESIGNED:" I SAVED A LONG TIME TO BUY MY DREAM CAR WHEN I RETIRED, NOW I HAVE A DEFECTIVE CAR, WITH ONLY 48K MILES BECAUSE OF FEAR OF DRIVING IT. PLEASE PLEASE, LISTEN TO WHAT PEOPLE WROTE BACK IN 04 ABOUT THIS CAR. ONE MAN SAID A FRIEND WORKED FOR LEXUS AND TOLD HIM THAT HIS BOSS SAID THERE WILL NEVER BE A RECALL ON THIS CAR BECAUSE OF THE AMOUNT OF CARS SOLD IN THE US AND CANADA. WE NEED HELP. MY CAR IS A LEMON. I'VE MENTIONED NUMEROUS TIMES OF PAINTING IT YELLOW AND PUTTING LEMON ALL OVER IT. PLEASE TRY TO PULL UP RECORDS BACK THEN, ALL THESE PEOPLE WERE WRITING IN WITH THE SAME PROBLEMS. NO ONE LISTENED THEN OR NOW! PLEASE, I'M BEGGING YOU. I'VE HAD 4 TOYOTA'S IN THE PAST, AND ALL 4 TOTALLY, NEVER HAD THE TROUBLE THIS 1 LEXUS HAS. THEY WERE ACTUALLY TOYOTAS. THEIR COMPLETE STATURE HAS GONE FROM YEARS OF LOYALTY BY ME AND OTHERS, AFTER ALL THE BUILT UP TRUST, GONE IN AN INSTANT! ONE RUNAWAY CAR IS ENOUGH! IT'S NOW KILLING PEOPLE. I BOUGHT IT FOR IT'S COMFORT, LOOKS, BUT MOSTLY FOR SAFETY, AND TRUSTWORTHINESS! GONE. ALL GONE! I HAVE A 91 FORD VAN I DRIVE INSTEAD OF THE LEXUS. I CALL IT A PIECE OF JUNK, NOTHING BUT TROUBLE, AND LEXUS HAD IT MORE THAN I DID THE FIRST 4 YRS. PLEASE LOOK INTO THIS ALL YOU CAN. ALL THESE PEOPLE CAN'T BE WRONG. I CAN'T EVEN SELL IT NOW. SHAME ON YOU, TOYOTA. SHAME ON YOU! GREED! THAT'S WHAT IT IS, GREED. *TR
LOST THE POWER BRAKE ASSIST IN VAIL COLORADO COMING DOWN THE MOUNTAIN. *TR
2 TO 3 YEARS PRIOR TO THIS ACCIDENT I WAS COMING TO A STOP LIGHT AND THE BRAKES DID NOT WORK, BUT ONLY FOR A FEW SECONDS. I REPORTED THIS TO MY HUSBAND AND HE TOOK IT TO SEVERAL MECHANICS BUT DID NOT FIND ANYTHING WRONG WITH THE VEHICLE, MY HUSBAND HAS OWNED A AUTO PARTS STORE FOR 40 YEARS AND KNOWS A FEW QUALIFIED MECHANICS. …
Read full complaint
2 TO 3 YEARS PRIOR TO THIS ACCIDENT I WAS COMING TO A STOP LIGHT AND THE BRAKES DID NOT WORK, BUT ONLY FOR A FEW SECONDS. I REPORTED THIS TO MY HUSBAND AND HE TOOK IT TO SEVERAL MECHANICS BUT DID NOT FIND ANYTHING WRONG WITH THE VEHICLE, MY HUSBAND HAS OWNED A AUTO PARTS STORE FOR 40 YEARS AND KNOWS A FEW QUALIFIED MECHANICS. 3 PEOPLE WERE ON A FREEWAY ABOUT 1/4 MILE FROM OFF RAMP DOING ABOUT 65 MPH, WE STARTED TO MOVE OVER TO THE SLOWER LANE AS WE GOT TO THE SLOWER LANE I STEPPED ON THE BRAKES TO SLOW DOWN FOR THE OFF RAMP WHEN I FELT THE BRAKES WERE NOT WORKING, I PUMPED THE BRAKES SEVERAL TIMES TO MAKE SURE I WAS STEPPING ON THE BRAKES BUT INSTEAD OF SLOWING DOWN THE VEHICLE KEPT ACCELERATING. I DEPRESSED THE BRAKE PEDAL AS HARD AS I COULD AND HUNG ON FOR DEAR LIFE UPON ENTERING THE OFF RAMP I STRUCK ANOTHER VEHICLE AND FLIPPED THE CAR SEVERAL TIMES. I ENDED UP WITH A CRACKED STERNUM, THE PASSENGER BROKE 3 OR 4 OF HER VERTEBRA, AND PASSENGER IN THE REAR SEAT WAS FATAL. UPDATED 03/10/10 *BF *TR UPDATED IVOQ 09/28/10 UPDATE 9/19/2011*CW
IN MAY 2007, I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT IN MY 2004 LEXUS RX330. THIS ACCIDENT OCCURRED LESS THAN 10 MILES FROM MY HOME, IT WAS A FRIGID MORNING. I WAS TRAVELING APPROXIMATELY 5 MILES PER HOUR AND THE VEHICLE BRAKES FAILED TO ENGAGE. I ATTEMPTED TO PUSH THE BRAKE PETAL TO THE FLOOR WITHOUT RESULT. THE ANTI-LOCK BR…
Read full complaint
IN MAY 2007, I WAS INVOLVED IN AN AUTOMOBILE ACCIDENT IN MY 2004 LEXUS RX330. THIS ACCIDENT OCCURRED LESS THAN 10 MILES FROM MY HOME, IT WAS A FRIGID MORNING. I WAS TRAVELING APPROXIMATELY 5 MILES PER HOUR AND THE VEHICLE BRAKES FAILED TO ENGAGE. I ATTEMPTED TO PUSH THE BRAKE PETAL TO THE FLOOR WITHOUT RESULT. THE ANTI-LOCK BRAKES DID NOT FUNCTION. THE DAMAGE TO THIS VEHICLE EXCEEDED $9500. THE BRAKES SHAKE VIOLENTLY WHEN APPLIED AND THIS HAS HAPPENED SEVERAL TIMES BEFORE AND AFTER THE ACCIDENT. AT THE TIME OF THE ACCIDENT, MY AIRBAG DID NOT EVEN DEPLOY I WAS GOING SO SLOW. I REPORTED THIS PROBLEM TO LEXUS OF SEATTLE IN OCTOBER 2006 AND THEY SAID I NEEDED A FRONT BRAKE JOB, WHICH I DID, THE ACCIDENT OCCURRED LESS THAN 6 MONTHS LATER. *TR
I PURCHASED MY RX330 SEPT. 2004 WITH 8 MILES ON IT, HOWEVER I TRAVEL OVER 150 HIGHWAY MILES A DAY. I HAVE BEEN EXPERIENCING THE EVAPORATION OF BRAKE FLUID FROM MY FLUID RESERVOIR WHICH CAUSED MY BRAKE LIGHT TO COME ON. AFTER REPLACING THE BRAKE FLUID EVERY 3-DAYS I CALLED THE DEALER AND EXPRESSED THE PROBLEM. ONCE TAKING IT I…
Read full complaint
I PURCHASED MY RX330 SEPT. 2004 WITH 8 MILES ON IT, HOWEVER I TRAVEL OVER 150 HIGHWAY MILES A DAY. I HAVE BEEN EXPERIENCING THE EVAPORATION OF BRAKE FLUID FROM MY FLUID RESERVOIR WHICH CAUSED MY BRAKE LIGHT TO COME ON. AFTER REPLACING THE BRAKE FLUID EVERY 3-DAYS I CALLED THE DEALER AND EXPRESSED THE PROBLEM. ONCE TAKING IT IN THEY REPLACED THE FRONT BRAKES AND ADDED FLUID. THREE DAYS LATER THE BRAKE FLUID HAD EVAPORATED AND THE BRAKE LIGHT CAME ON AGAIN. I IMMEDIATELY CONTACTED THE MECHANICSBERG, PA DEALER AFTER KEEPING IT OVERNIGHT THEY STATED THAT NOTHING WAS WRONG WITH MY VEHICLE, HOWEVER I REFUSED TO TAKE IT UNTIL THEY REPRODUCED AND REPAIRED THE PROBLEM. AFTER READING THE OTHER 51 COMPLAINTS, I HAVE SEVERAL ISSUES TO DISCUSS WITH THEM. I AM VERY BLESSED THAT MY BRAKES HAVEN'T FAILED YET! I HOPE THAT ALL HAVE MADE FORMAL COMPLAINTS TO LEXUS. *NM
I NOTICED THE BRAKE PEDAL HAD TO BE PRESSED ALL THE WAY IN ORDER TO BRAKE AND WAS NOT RESPONSIVE. I HAD THE BRAKES CHECKED, AND THEY WERE FINE. I RECEIVED A LETTER FROM LEXUS REGARDING A RECALL FOR THE BRAKE BOOSTER. I WAS SCHEDULED FOR THIS SERVICE TWICE. BOTH TIMES I WAS TOLD THEY HAD NO BRAKE BOOSTERS REMAINING, AND I AM S…
Read full complaint
I NOTICED THE BRAKE PEDAL HAD TO BE PRESSED ALL THE WAY IN ORDER TO BRAKE AND WAS NOT RESPONSIVE. I HAD THE BRAKES CHECKED, AND THEY WERE FINE. I RECEIVED A LETTER FROM LEXUS REGARDING A RECALL FOR THE BRAKE BOOSTER. I WAS SCHEDULED FOR THIS SERVICE TWICE. BOTH TIMES I WAS TOLD THEY HAD NO BRAKE BOOSTERS REMAINING, AND I AM STILL AWAITING THEIR CALL BACK. I WAS RECENTLY IN A CAR ACCIDENT IN WHICH I WAS IN FULL CONTROL TRAVELING ABOUT 25 MPH AND THE BRAKES WERE NOT RESPONSIVE AGAIN. MY FOOT WAS PRESSED ALL THE WAY TO THE BOTTOM AND THE CAR DID NOT RESPOND APPROPRIATELY.*AK
Official recalls
511V539000 · Engine And Engine Cooling
Nov 9, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.
Consequence & remedy
Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
11V112000 · Vehicle Speed Control:accelerator Pedal
Feb 24, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.
Consequence & remedy
Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
06V253000 · Vehicle Speed Control:accelerator Pedal
Jul 13, 2006
ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.
Consequence & remedy
Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.
06V023000 · Seat Belts:rear/other
Jan 27, 2006
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE ANCHOR BOLT FOR THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE DIRECTLY BEHIND THE DRIVER'S SEAT DOES NOT HAVE SUFFICIENT STRENGTH.
Consequence & remedy
Consequence: THE REAR SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED IN THE EVENT OF A CRASH.
Remedy: DEALERS WILL REPLACE FREE OF CHARGE THE REAR, LEFT-HAND SIDE SEAT BELT BUCKLE ANCHOR BOLT WITH AN IMPROVED ONE. THE RECALL BEGAN ON FEBRUARY 3, 2006. OWNERS MAY CONTACT LEXUS AT 800-255-3987.
04V558000 · Exterior Lighting:brake Lights:switch
Nov 22, 2004
CERTAIN PASSENGER VEHICLES MAY BE EQUIPPED WITH AN IMPROPERLY DESIGNED BRAKE LIGHT SWITCH. A SILICON OXIDE BUILD-UP OCCURS ON THE CONTACTS INSIDE THE BRAKE LIGHT SWITCH, WHICH CAN MAKE IT INOPERABLE.
Consequence & remedy
Consequence: IF THE SWITCH IS INOPERABLE, THE BRAKE LIGHTS WILL NOT ILLUMINATE AND CAN INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH. THE RECALL BEGAN DURING DECEMBER 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ10003 · Unintended And Uncontrolled Acceleration
Opened Feb 16, 2010 · Closed Mar 1, 2011
Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Additional source detail variants (6)
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Electrical System:software
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
Vehicle Speed Control:accelerator Pedal
On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.
PE05009 · Vacuum Brake Booster Failure
Opened Feb 10, 2005 · Closed Jun 15, 2005
Status: closed (inferred from source dates) · Service Brakes, Hydraulic; Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:foundation Components:master Cylinder; Service Brakes, Hydraulic:power Assist; Service Brakes, Hydraulic:power Assist:vacuum; Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (6)
Service Brakes, Hydraulic:foundation Components:master Cylinder
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:foundation Components
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum:hoses, Lines/piping, And Fittings
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic:power Assist:vacuum
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Service Brakes, Hydraulic
ON FEBRUARY 10, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED LOSS OF BRAKE POWER-ASSIST IN CERTAIN 2004 MODEL YEAR (MY) LEXUS RX330 VEHICLES BUILT THROUGH APPROXIMATELY JUNE 30, 2004.THE SUBJECT VEHICLES WERE MANUFACTURED AT TOYOTA MOTOR MANUFACTURING CANADA, INC.?S CAMBRIDGE, ONTARIO ASSEMBLY PLANT AND WERE EQUIPPED WITH VACUUM BRAKE BOOSTER ASSEMBLIES SOURCED FROM AISIN SEIKI CO., LTD (AISIN) SUBSIDIARY ADVICS NORTH AMERICA, INC. (ADVICS-NA).TO DATE, ODI IS AWARE OF 146 NON-DUPLICATIVE REPORTS THAT ALLEGE LOSS OF BRAKE POWER-ASSIST AND 6 CRASHES ALLEGEDLY CAUSED BY LOSS OF BRAKE POWER-ASSIST (RESULTING IN 1 MINOR INJURY) ON THE SUBJECT VEHICLES.THE SUBJECT VEHICLES USE A CONVENTIONAL BRAKE BOOSTER ASSEMBLY THAT CONTAINS A RUBBER DIAPHRAGM TO SEPARATE THE FORE AND AFT PRESSURE CHAMBERS.THE OUTER EDGE OF THE RUBBER DIAPHRAGM IS HELD IN PLACE VIA A RETAINING GROOVE ON THE BRAKE BOOSTER BODY.IF THE BOOSTER LOSES VACUUM (E.G., OPERATOR DEPLETES THE VACUUM BY PRESSING THE BRAKE PEDAL SEVERAL TIMES WHILE THE ENGINE IS OFF), IT MAY CAUSE THE DIAPHRAGM TO DEFORM IN THE AREA OF THE RETAINING GROOVE TO THE POINT THAT INSUFFICIENT SEAL EXISTS BETWEEN DIAPHRAGM AND BOOSTER BODY, THUS CAUSING A MOMENTARY LOSS OF BRAKE POWER-ASSIST.THE ADVICS-NA SUPPLIED DIAPHRAGM HAS SLIGHTLY DIFFERENT MATERIAL PROPERTIES COMPARED TO THE DIAPHRAGM INSIDE BRAKE BOOSTERS SUPPLIED BY ADVICS JAPAN, CORP. (ADVICS-J) AND USED ON 2004MY LEXUS RX330 VEHICLES MANUFACTURED AT TOYOTA MOTOR KYUSHU, INC.?S ASSEMBLY PLANT.THE SOFTER RUBBER USED IN THE ADVICS-NA DIAPHRAGM ALLOWS GREATER DEFORMATION AND IS LESS RESILIENT WHEN COMPARED TO THE ADVICS-J DIAPHRAGM.LOSS OF BRAKE POWER-ASSIST MOST OFTEN OCCURS AT VEHICLE START-UP AND APPEARS TO BE MORE PREVALENT IN COLDER TEMPERATURES.MOST OWNERS REPORT THAT BRAKE SYSTEM OPERATION RETURNS TO NORMAL WITHIN A FEW SECONDS AFTER VEHICLE START-UP.TESTING CONDUCTED BY THE MANUFACTURER INDICATES THAT THE ADVICS-NA DIAPHRAGM?S REDUCED ABILITY TO RETURN TO SHAPE IS EXACERBATED BY COLDER TEMPERATURES AND THAT LOSS OF BRAKE POWER-ASSIST AT START-UP MAY LAST FOR A MAXIMUM OF 95 SECONDS AT TEMPERATURES BELOW ?20 DEGREES CELSIUS.HOWEVER, THE SUBJECT VEHICLES HAVE A BACK-UP SYSTEM THAT CAN SENSE A LOSS OF BRAKE POWER-ASSIST AND ENABLE THE ABS ACTUATOR FOR BRAKE HYDRAULIC PRESSURE SUPPORT (I.E., BRAKE PEDAL FORCE ASSIST).THE MANUFACTURER WILL CONDUCT A SERVICE CAMPAIGN (LEXUS SPECIAL SERVICE CAMPAIGN #5LA) TO REPLACE THE VACUUM BRAKE BOOSTER ASSEMBLY ON ALL AFFECTED SUBJECT VEHICLES.THE ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.