IllustrationLAND ROVER FREELANDER 2002 TRANSMISSION ISSUES, TRACTION CONTROL LIGHT STAYS ON AND CHECK ENGINE LIGHT. TRANSMISSION AND ENGINE ISSUES GALORE, CURRENTLY ONLY HAVE 54,000 MILES ON THE VEHICLE. *TR
2002 Land Rover Freelander
Owner reports · Recalls · Investigations
More warning signs than most Freelander years
Owner complaints for the 2002 Land Rover Freelander are substantially higher than the model-year median of 42.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Freelander years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
190–25K
3925–50K
6950–75K
3675–100K
13100–150K
3150K+
179 reports with mileage · 47 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 121 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 83 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Visibility. Review the 27 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
4 crash reports4 fire reports4 injury reports
Engine And Engine Cooling complaints
121 reportsI HAVE A 2002 LANDROVER FREELANDER. THIS VEHICLE HAS BEEN NOTHING BUT PROBLEMS. I BOUGHT THE CAR BACK IN LATE 2005 AND IT HAD 32K MILES ON IT. IN JANUARY OF 2007 IT WAS OVERHEATING AND HAD A VERY LOUD SOUND TO THE ENGINE. I TOOK IT INTO THE SHOP AND THEY TOLD ME THAT THE ENGINE WENT BAD AND NEEDED TO BE REPLACED. DURING THE TIME…
Read full complaint
I HAVE A 2002 LANDROVER FREELANDER. THIS VEHICLE HAS BEEN NOTHING BUT PROBLEMS. I BOUGHT THE CAR BACK IN LATE 2005 AND IT HAD 32K MILES ON IT. IN JANUARY OF 2007 IT WAS OVERHEATING AND HAD A VERY LOUD SOUND TO THE ENGINE. I TOOK IT INTO THE SHOP AND THEY TOLD ME THAT THE ENGINE WENT BAD AND NEEDED TO BE REPLACED. DURING THE TIME OF THE REPLACEMENT THE CAR ONLY HAD 59K MILES ON IT. NOW OVER YEAR LATER THE TRUCK IS OVERHEATING AGAIN AND I HAVE BEEN TOLD THE ENGINE IS FAILING AGAIN. I HAVE SPEND OVER 6,000 DOLLARS ON THIS SUV THAT IS CLEARLY A LEMON. *TR
VEHICLE WAS PURCHASED WITH 40,000 MILES ON IT FROM A DEALERSHIP IN DECEMBER OF 2004. DAY AFTER VEHICLE WAS PURCHASED REAR WINDOW MOTOR BROKE. DEALERSHIP REPLACED. TWO WEEKS LATER CAR BEGAN TO LOSE POWER, DEALERSHIP REPLACED SENSOR. LOSS OF POWER AGAIN DEALERSHIP ENDING UP PERFORMING ENGINE WORK. VEHICLE CONTINUALLY DISPLACED…
Read full complaint
VEHICLE WAS PURCHASED WITH 40,000 MILES ON IT FROM A DEALERSHIP IN DECEMBER OF 2004. DAY AFTER VEHICLE WAS PURCHASED REAR WINDOW MOTOR BROKE. DEALERSHIP REPLACED. TWO WEEKS LATER CAR BEGAN TO LOSE POWER, DEALERSHIP REPLACED SENSOR. LOSS OF POWER AGAIN DEALERSHIP ENDING UP PERFORMING ENGINE WORK. VEHICLE CONTINUALLY DISPLACED HILL DECENT / TRACK CONTROL LIGHT. DEALERSHIP REPLACED. AT 65000 MILES KEYLESS ENTRY STOPPED UNLOCKING ALL DOORS WITH THE EXCEPTION OF THE DRIVER'S SIDE DOOR. DOORS CAN NO LONGER BE UNLOCKED FROM THE INSIDE AS WELL. REAR PASSENGER WINDOW ON DRIVER'S SIDE DOES NOT GO DOWN. LOSS OF POWER ISSUE IS HAPPENING AGAIN NOW AT 75,000 MILES. *TR
WE PURCHASED A 02 FREELANDER BY LAND ROVER AND IT HAS TURNED OUT TO BE A LEMON. REPAIRS AFTER REPAIRS. IT OVERHEATS AND WHEN IT DOES IT OVERHEATS THE STARTER CAUSING IT TO FAIL AS WELL IF IT OVERHEATS TOO MUCH IT CAUSES THE HEAD GASKETS TO BLOW OR A CRACK ON THE ENGINE. *TR
AFTER BUYING THE CAR USED @ 42,000 MILES MY 2002 LAND ROVER FREELANDER WAS IMMEDIATELY DIAGNOSED A MONTH AFTER INTERMITTENT STARTING PROBLEMS WITH A BLOWN HEAD GASKET AND I NEEDED A NEW ENGINE. MY CAR IS A SAFETY HAZARD AS IT STOPPED RANDOMLY OF A HIGHWAY AND LEFT ME STRANDED. I AM NOT THE ONLY PERSON EXPERIENCING THIS BLOWN H…
Read full complaint
AFTER BUYING THE CAR USED @ 42,000 MILES MY 2002 LAND ROVER FREELANDER WAS IMMEDIATELY DIAGNOSED A MONTH AFTER INTERMITTENT STARTING PROBLEMS WITH A BLOWN HEAD GASKET AND I NEEDED A NEW ENGINE. MY CAR IS A SAFETY HAZARD AS IT STOPPED RANDOMLY OF A HIGHWAY AND LEFT ME STRANDED. I AM NOT THE ONLY PERSON EXPERIENCING THIS BLOWN HEAD GASKET PROBLEM AS IT IS AN ENGINEERING FAILURE OF THIS SUV. LAND ROVER WILL NOT HELP, THIS IS A DISGRACE THAT SO MANY PEOPLE HAVE SUFFERED FROM THIS PROBLEM AND NOTHING HAS BEEN DONE. *TR
WE BOUGHT A LAND ROVER FREELANDER 9 MONTHS AGO FROM A USED CAR DEALERSHIP. 2 WEEKS AGO WE NOTICED THE HEATING GAGE GOING UP AND DOWN AND WE NEEDED A LOT OF COOLANT. YESTERDAY, THE ENGINE FAILED AND WE WERE TOLD WE NEED A NEW ENGINE. ACCORDING TO THE MECHANIC IT WAS A PROBLEM IN THE HEATING SYSTEM BECAUSE THE COOLANT IS LEAKIN…
Read full complaint
WE BOUGHT A LAND ROVER FREELANDER 9 MONTHS AGO FROM A USED CAR DEALERSHIP. 2 WEEKS AGO WE NOTICED THE HEATING GAGE GOING UP AND DOWN AND WE NEEDED A LOT OF COOLANT. YESTERDAY, THE ENGINE FAILED AND WE WERE TOLD WE NEED A NEW ENGINE. ACCORDING TO THE MECHANIC IT WAS A PROBLEM IN THE HEATING SYSTEM BECAUSE THE COOLANT IS LEAKING INTO AN UNKNOWN AREA. LANDROVER SAYS SINCE WE DIDN'T BUY IT FROM THEM, THEY WILL NOT HELP US. IN ORDER TO FILE A COMPLAINT, WE MUST TOW THE CAR TO THE DEALERSHIP, PAY THE DEALERSHIP TO EXAMINE THE CARE AND THEN WANT 2 TO 6 MONTHS FOR AN ENGINE, POSSIBLY A TRANSMISSION AS WELL TO BE ORDER. THEY ARE BACKORDERED NATION WIDE. THE CAR HAS ON 40,000 MILES AND HAS HAD GOOD MAINTENANCE REGULARLY. *TR
CHECK ENGINE LIGHT , TICKING ENGINE, ANTIFREEZE , OIL LEAK, SMELLING COOLANT INSIDE CAR AND NUMEROUS OTHER ISSUES SUCH AS WINDOW REGULATOR , WIPER MOTOR AND RATTLING NOISES UNDERNEATH CAR HAS BEEN MY COMPLAINTS SINCE FEB 13,2008. PARTS WERE REPLACED THAT DIDN'T CORRECT THE PROBLEM OF THE TICKING ENGINE, COOLANT LEAKS, SMELL OF…
Read full complaint
CHECK ENGINE LIGHT , TICKING ENGINE, ANTIFREEZE , OIL LEAK, SMELLING COOLANT INSIDE CAR AND NUMEROUS OTHER ISSUES SUCH AS WINDOW REGULATOR , WIPER MOTOR AND RATTLING NOISES UNDERNEATH CAR HAS BEEN MY COMPLAINTS SINCE FEB 13,2008. PARTS WERE REPLACED THAT DIDN'T CORRECT THE PROBLEM OF THE TICKING ENGINE, COOLANT LEAKS, SMELL OF COOLANT INSIDE CAR,AND CHECK ENGINE LIGHT WHICH ALWAYS COMES ON A COUPLE OF HOURS AFTER THE DEALER RETURNS MY CAR TO ME. CAR WAS TOWED FROM FREEWAY DUE TO BREAKDOWN ON THE WAY HOME 15 MINUTES AFTER PICKING CAR UP FROM MADISON DEALERSHIP FOR ENGINE REPAIR. DEALERSHIP STATED THAT THIS WAS DUE TO AN OIL SEAL/OIL PLUG AND IT WAS NOT THEIR FAULT ALTHOUGH THEY JUST FINISHED WORKING ON THE ENGINE. I DID NOT HAVE MY CAR FOR A TOTAL OF 30 DAYS NOT INCLUDING THE PRIOR VISITS WHERE THEY TOOK ALMOST 2 WEEKS TO DIAGNOSE THE PROBLEM. I WAS CHARGED FOR A RENTAL CAR DURING THIS PERIOD. MILWAUKEE DEALERSHIP CLAIMED THEY CORRECTED THE ENGINE PROBLEM ON 3 DIFFERENT VISITS WHICH I PAID $600.00 FOR A TIMING BELT WHICH NEVER CORRECTED THE PROBLEM ALONG WITH A $100.00 DEDUCTIBLE FOR USING THE WARRANTY. THE PARTS REPLACED ON THE VEHICLE IS AS FOLLOWS; MANIFOLD ASSY. MOTOR ASSY FOR WIPER BLADES,WINDOW REGULATOR,TIMING BELT AND DIFFERENTIAL FRONT MOUNTING WHICH DID NOT RESOLVE RATTLING NOISE UNDERNEATH CAR. MILWAUKEE DEALERSHIP HAS ALSO ATTEMPTED TO CORRECT THESE SAME PROBLEMS WITH NO SUCCESS. THE COOLANT LEAK IS STILL APPARENT AND THE CHECK ENGINE LIGHT IS ON AGAIN. THE ONLY THING THE DEALERSHIP CAN TELL ME IS TO MONITOR HOW MANY TIMES I HAVE TO REPLACE COOLANT. IN THE MEAN TIME, THEY HAVE SENT ME HOME WITH A CAR THAT HAS A CHECK ENGINE LIGHT ON AND A DISAPPEARING COOLANT PROBLEM. I GUESS THEY WILL CONTINUE GIVING ME THE RUNAROUND UNTIL MY WARRANTY EXPIRES AUG 2,2008 JUST AS MANY OTHERS HAS REPORTED THEY DID TO THEM. PLEASE HELP!!!!! *TR
DATE ISSUEREPAIRS DATE RETURNED 6/7/06VEHICLE STALLED, WON'T STARTBATTERY REPLACED6/8/2006 6/16/2006VEHICLE STALLED, WON'T STARTREPLACED IGNITION SWITCH, KEY READER7/17/2006 8/15/2006VEHICLE STALLED, WON'T START, INTERMITTENT STARTREPLACED FUEL PUMP8/18/2006 6/5/2007VEHICLE STALLED, WON'T STARTSECURED STARTED WIRE6/6/2007 …
Read full complaint
DATE ISSUEREPAIRS DATE RETURNED 6/7/06VEHICLE STALLED, WON'T STARTBATTERY REPLACED6/8/2006 6/16/2006VEHICLE STALLED, WON'T STARTREPLACED IGNITION SWITCH, KEY READER7/17/2006 8/15/2006VEHICLE STALLED, WON'T START, INTERMITTENT STARTREPLACED FUEL PUMP8/18/2006 6/5/2007VEHICLE STALLED, WON'T STARTSECURED STARTED WIRE6/6/2007 6/7/2007VEHICLE STALLED, WON'T START, INTERMITTENT STARTREPLACED IMMOBOLIZER 2 TIMES8/20/2007 11/16/2007VEHICLE WON'T ACCELERATEREPLACED INTAKE MANIFOLD, ENGINE, HEATER CORE3/5/2008 5/16/2008VEHICLE WON'T ACCELERATEWANT TO REPLACE ENTIRE TRANSMISSION. *TR
THE ENGINE/HEAD GASKET ISSUE IS THE REPAIR THAT IS THE MOST CRITICAL AND TERMINAL CONDITION FOR THE VEHICLE. THE DEALERS MECHANICS WILL NEVER FIX THE GASKET, SO THEY WILL ONLY OFFER THE ENGINE REPLACEMENT, BUT EITHER REPAIR WILL COST YOU MORE THAN THE SUV IS WORTH. AND YES, THE BRAKE PADS AND THEN ROTORS WEAR OUT VERY QUICK…
Read full complaint
THE ENGINE/HEAD GASKET ISSUE IS THE REPAIR THAT IS THE MOST CRITICAL AND TERMINAL CONDITION FOR THE VEHICLE. THE DEALERS MECHANICS WILL NEVER FIX THE GASKET, SO THEY WILL ONLY OFFER THE ENGINE REPLACEMENT, BUT EITHER REPAIR WILL COST YOU MORE THAN THE SUV IS WORTH. AND YES, THE BRAKE PADS AND THEN ROTORS WEAR OUT VERY QUICKLY, BECAUSE OF THE WEIGHT OF THE VEHICLE (THE DEALER SAYS). I PERSONALLY THINK IT HAS MORE TO DO WITH THE FACT THAT THERE ARE 2 DISC FRONT BRAKES AND 2 DRUM REAR BRAKES ON THE VEHICLE, HENCE THE WEAR AND WEIGHT ALL GOES TO THE FRONT OF THE VEHICLE. ANOTHER POOR DESIGN FLAW ISSUE, AND I WAS TOLD THE DRUM BRAKES WERE THERE TO BETTER ALLOW THE OFF-ROADING. YEAH, WHO EVER COULD OFF ROAD THESE THINGS, THEY FALL APART ON THE DRIVEWAY! *TR
I HAVE A LAND ROVER FREELAND THAT STARTED HAVING COOLANT LEAKAGE IN EARLY FEBRUARY OF 2007. I TRIED TO GET THE CAR IN TO GET FIXED AND WAS PUT OFF BY LAND ROVER UNTIL MY WARRANTY EXPIRED. THEY NEVER FIXED IT. IT LEAKS COOLANT CONSTANTLY, IT LOOSES POWER, IT OVER HEATS AND STEAMS, THE COOLANT IS AN OILY BROWN COLOR NO MATTER H…
Read full complaint
I HAVE A LAND ROVER FREELAND THAT STARTED HAVING COOLANT LEAKAGE IN EARLY FEBRUARY OF 2007. I TRIED TO GET THE CAR IN TO GET FIXED AND WAS PUT OFF BY LAND ROVER UNTIL MY WARRANTY EXPIRED. THEY NEVER FIXED IT. IT LEAKS COOLANT CONSTANTLY, IT LOOSES POWER, IT OVER HEATS AND STEAMS, THE COOLANT IS AN OILY BROWN COLOR NO MATTER HOW MANY TIMES I FLUSH IT. THIS CAR HAS A BAD HEAD GASKET I'M AFRAID AND I'VE READ ABOUT AND KNOW MANY PEOPLE WITH THE EXACT SAME PROBLEM. I'VE REPLACED THE RESERVOIR BOTTLE, FLUSHED THE COOLANT, REPLACED THE THERMOSTAT AND NOTHING FIXES THE PROBLEM. I HAD A MONTH LONG BATTLE WITH LAND ROVER TO FIX IT AND THEY REFUSED. THIS ENTIRE ENGINE NEEDS TO BE RECALLED, THIS IS A TERRIBLE CAR AND A HAZARD ON THE ROAD, I'M SCARED EVERY TIME I SEE A FREELANDER THAT IT'S GOING TO BLOW SOMETHING AND KILL SOMEONE ON THE FREEWAY, LAND ROVER SHOULD BE ASHAMED AND ALL THE CARS SHOULD BE RECALLED. *TR
Official recalls
307V041000 · Exterior Lighting:brake Lights:switch
Feb 9, 2007
ON CERTAIN SPORT UTILITY VEHICLES, THE BRAKE LIGHTS MAY REMAIN ILLUMINATED EVEN WHEN THE BRAKE PEDAL IS NOT DEPRESSED. HILL DESCENT CONTROL (HDC), TRACTION CONTROL (TC) AND CRUISE CONTROL WARNING LIGHTS MAY ALSO BE ILLUMINATED.
Consequence & remedy
Consequence: FAILURE TO PROVIDE THE PROPER SIGNAL WHEN BRAKING COULD LEAD TO A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE BRAKE LAMP OPERATION AND WHERE REQUIRED, ADJUST AND/OR REPLACE THE BRAKE LIGHT SWITCHES WITH NEW SWITCHES OF THE SAME DESIGN UNTIL A NEWLY DESIGNED BRAKE LAMP SWITCH IS AVAILABLE IN MAY 2007. OWNERS WILL THEN BE RE-NOTIFIED TO BRING THEIR VEHICLES IN FOR THE NEW BRAKE LIGHT SWITCH. AN INTERIM LETTER FOR THE INITIAL INSPECTION WAS MAILED ON MARCH 26, 2007. THE SECOND LETTER FOR REPLACEMENT OF THE SWITCHES WAS MAILED BEGINNING JULY 30, 2007. OWNERS MAY CONTACT LAND ROVER AT 1-80-637-6837.
05V300000 · Latches/locks/linkages:doors:latch
Jun 28, 2005
ON CERTAIN FIVE DOOR SPORT UTILITY VEHICLES, IT IS POSSIBLE TO OPERATE THE INTERIOR DOOR HANDLE TO OPEN THE DOOR WHEN THE CHILD SAFETY LEVER IS IN THE "ON" POSITION.
Consequence & remedy
Consequence: THE OCCUPANT MAY OPEN THE DOOR INADVERTENTLY WHILE THE VEHICLE IS IN MOTION AND FALL OUT INTO THE TRAFFIC, PERSONAL INJURIES COULD OCCUR.
Remedy: DEALERS WILL INSPECT AND REPLACE THE LATCH ASSEMBLY. THE RECALL BEGAN ON SEPTEMBER 8, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
04V347000 · Structure:body:roof And Pillars
Jul 12, 2004
CERTAIN SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 201, "OCCUPANT PROTECTION IN INTERIOR IMPACT." DURING TESTING, THE FREE MOTION HEAD FORM REGISTERED A MEASUREMENT MARGINALLY ABOVE THE PERMITTED 1000 HEAD IMPACT CRITERIA. AT THE LEFT AND RIGHT HAND A-PILLAR TRIM AREA.
Consequence & remedy
Consequence: IN THE EVENT OF A VEHICLE CRASH, PERSONAL INJURY TO OCCUPANTS MAY OCCUR.
Remedy: DEALERS WILL REPLACE THE A-PILLAR TRIM WITH A REVISED COMPONENT THAT ENABLES THE VEHICLE TO FULLY MEET THE REQUIREMENTS OF FMVSS 201. THE RECALL BEGAN ON DECEMBER 6, 2005. OWNERS SHOULD CONTACT LAND ROVER AT 1-800-637-6837.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA05016 · Brake Light Switch Failure
Opened Oct 14, 2005 · Closed Feb 22, 2007
Status: closed (inferred from source dates) · Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Additional source detail variants (2)
Exterior Lighting:brake Lights
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN
Exterior Lighting:brake Lights:switch
ON JUNE 16, 2005, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION (PE05-034) TO INVESTIGATE ALLEGED STOP LAMP (BRAKE) SWITCH FAILURES IN CERTAIN MODEL YEAR (MY) 2004 LAND ROVER DISCOVERY SERIES II VEHICLES.ON OCTOBER 14, 2005, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS AND THE SCOPE EXPANDED TO INCLUDE CERTAIN MY 2002 THROUGH 2005 FREELANDER VEHICLES THAT USE A SUBSTANTIALLY SIMILAR SELF-ADJUSTING STOP LAMP SWITCH FURNISHED BY THE SAME SUPPLIER, METHODE ELECTRONICS MALTA, LTD. (METHODE).IN SEPTEMBER 2003, METHODE MOVED THE PRODUCTION OF AN INTERNAL SWITCH COMPONENT, KNOWN AS THE SLIDER MECHANISM, FROM A VALIDATED PLASTIC INJECTION-MOLDING TOOL (?CAVITY 1?) TO ANOTHER TOOL (?CAVITY 2?) THAT HAD NOT BEEN USED BEFORE TO PRODUCE PARTS FOR LAND ROVER.SLIDERS FROM CAVITY 2 MAY BE CHARACTERIZED BY POOR FILL, LACK OF DEFINITION IN THE SLIDER TEETH AND DIMENSIONAL INSTABILITY.CONSEQUENTLY, THE SLIDER MAY BE UNABLE TO RESTRAIN IMPROPER MOVEMENT OF THE PLUNGER DURING NORMAL BRAKE PEDAL OPERATION.THIS MAY CAUSE THE SWITCH TO FALL OUT OF ADJUSTMENT, THUS SIGNIFICANTLY REDUCING THE EFFORT REQUIRED TO ENERGIZE THE SWITCH AND ILLUMINATE THE STOP LAMPS.?CAVITY 2? SWITCHES WERE INSTALLED IN APPROXIMATELY 8,763 DISCOVERY SUBJECT VEHICLES BUILT FROM DECEMBER 2003 THROUGH MAY 2004 AND APPROXIMATELY 3,915 FREELANDER SUBJECT VEHICLES BUILT FROM OCTOBER 2003 THROUGH MAY 2004.ADDITIONALLY, STOP LAMP SWITCHES IN CERTAIN MY 2002 THROUGH 2005 FREELANDER SUBJECT VEHICLES MAY SLIP OUT OF ADJUSTMENT AS A RESULT OF SWITCH DAMAGE DUE TO AN INCORRECT SETTING PROCEDURE DURING VEHICLE MANUFACTURE OR AS A RESULT OF SWITCH MOUNTING BRACKET FLEX.ANALYSIS OF ALL AVAILABLE DATA INDICATES THE PREDOMINANT FAILURE MODE IS CONSTANT STOP LAMP ILLUMINATION.OTHER REPORTED CONSEQUENCES OF STOP LAMP SWITCH MALADJUSTMENT INCLUDE INOPERATIVE AUTOMATIC TRANSMISSION GEAR SELECTOR/BRAKE PEDAL SHIFT INTERLOCK, INOPERATIVE SPEED (CRUISE) CONTROL, AND TELLTALE ILLUMINATION AS DESCRIBED IN TECHNICAL SERVICE BULLETIN (TSB) NO. LT206-001 DATED OCTOBER 28, 2004 ISSUED BY THE MANUFACTURER TO LAND ROVER DEALERS IN THE UNITED KINGDOM (UK).TO DATE, ODI IS AWARE OF 77 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE STOP LAMP SWITCH FAILURE ON THE SUBJECT VEHICLES (10 COMPLAINTS ON MY 2004 DISCOVERY, 45 ON MY 2002 FREELANDER, 19 ON MY 2003 FREELANDER, AND 3 ON MY 2004 FREELANDER VEHICLES).ADDITIONALLY, 4,595 DISCOVERY AND 13,370 FREELANDER SUBJECT VEHICLES HAVE EXPERIENCED ONE OR MORE WARRANTY CLAIMS TO REPLACE THE STOP LAMP SWITCH.OF THE 5,170 WARRANTY CLAIMS PAID TO REPLACE STOP LAMP SWITCHES ON DISCOVERY SUBJECT VEHICLES, APPROXIMATELY 31% OCCURRED BEFORE THE VEHICLE WAS SOLD NEW AND APPROXIMATELY 88% OCCURRED WITHIN THE FIRST 12 MONTHS OF VEHICLE SERVICE.THE WARRANTY TREND ON DISCOVERY SUBJECT VEHICLES IS IN DECLINE WITH 3,545 CLAIMS PAID IN CALENDAR YEAR (CY) 2004, 1,303 CLAIMS PAID IN CY 2005, AND 322 CLAIMS PAID IN CY 2006 THROUGH SEPTEMBER 28, 2006 (WHICH IS WHEN ODI LAST RECEIVED UPDATED WARRANTY CLAIMS DATA FROM LAND ROVER), AND IT APPEARS THAT THE ALLEGED DEFECT ON DISCOVER SUBJECT VEHICLES HAS BEEN REMEDIED THROUGH WARRANTY REPAIRS.HOWEVER, ODI ANALYSIS OF THE MANUFACTURER?S WARRANTY AND COMPLAINT RECORDS INDICATES THE FAILURE TREND ON CERTAIN FREELANDER SUBJECT VEHICLES IS ONGOING.BY LETTER DATED FEBRUARY 2, 2007, LAND ROVER HAS NOTIFIED ODI THAT IT WILL CONDUCT A SAFETY RECALL (NHTSA RECALL NO. 07V-041) TO REPLACE DEFECTIVE STOP LAMP SWITCHES IN APPROXIMATELY 33,247 MY 2002 THROUGH 2005 FREELANDER VEHICLES BUILT AT THE SOLIHULL, UK ASSEMBLY PLANT FROM SEPTEMBER 5, 2001 THROUGH MAY 19, 2005. ALTHOUGH ODI HAS CONCERN