2021 Kia Telluride

After warranty work was performed on my Kia Telluride at an authorized Kia dealership, I discovered that the rear driver-side seatbelt had not been bolted back down. It was completely loose and hanging under the seat. This means my family could have been driving with no seatbelt protection at all. This is a serious safety failure and clear negligence. A seatbelt is one of the most basic, life-saving components in any vehicle. For a dealership to return a car to a customer without confirming all seatbelts are installed correctly shows a complete breakdown in safety inspection and quality control. When I contacted the dealership, I received no apology, explanation, or acknowledgment of responsibility. No one followed up or offered to inspect the vehicle. I also contacted Kia America Customer Relations, but I have not received any response. If such a fundamental safety step can be missed, I am extremely concerned about what other oversights may occur during Kia service work nationwide. This situation should be formally investigated by the NHTSA. I’m requesting a full investigation into Kia’s service procedures, technician training, and inspection protocols to ensure that no other vehicles are returned to customers in unsafe condition. Please treat this as a formal safety complaint. A loose seatbelt is not a minor error, it’s life-threatening negligence. I want this fully investigated and documented under my VIN, with confirmation of corrective action. My family’s safety, and that of other Kia owners, depends on it. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I drive a Kia Telluride and while driving down the highway two pieces of plastic fell down into the passenger seat. Next the window flew up into the air. I had to physically hold the window down while driving with children in the back seat. No warranty will cover the sunroof and I was quoted $6000 to fix it. Upon searching this information I found that this has happened to multiple people and Kia is not trying to fix it. I spent all of my savings on this car to be able to transport my family safely. This did not happen.

1. The engine consumed oil to where it soaked up all the oil in the engine likely as part of a piston ring failure. We have had it at the shop for the last 9 weeks, and cost to replace engine is $10,500 and because extended warranty explicitly wrote this out of the contract as this is a known issue and Kia has stated as such, but not a recall yet so nothing they will do to help. It is available for inspection, but we need the car back so likely not going to drag on much longer. 2. Yes, as no warning lights on the car came on, nothing out of the ordinary other than it just started acting weird and I took it in to get looked at, and was told there was no oil in the engine at all and this is known issue and engine is blown and we have to pay out of pocket to fix. This is extrememly alarming as we have 3 small kids that ride in that car daily and could have caught fire or broke down on the road at any point. 3. We have been told repeatedly by Kia and the extended warranty provider, JM&A, this is a known issue and many cases have been reported this year alone. 4. No, just the Kia dealership where we bought it. 5. There were no warning signs at all. No low oil light or notification came on at all leading us to believe there was a major problem.

Inspected by Kia for 2nd time due to vehicle suddenly shaking, overheating and turning off. First time fluids were low and replaced, kia stated should be fine but then while driving on the highway this past week same dangerous problem happened again suddenly where my vehicle started abruptly shaking making it hard to control, alerted overheating and immediately shut off. This time Kia diagnosed this issue is being caused by multiple hoses and seals failing due to degradation and leaking in multiple locations. Kia’s diagnostic repair inspection states heater core hoses(all), valve cover gaskets,Radiator Hoses upper & Lower, and other seals or connecting components are all leaking and need replaced. Have read online and communicated with other owners of the telluride in which many state same complaints of similar or same problem, therefore this seems to be a very common issue, a safety hazard and concern, not to mention a costly repair that seems to be a quality or manufacturing issue that may need to be evaluated further.

The rear frame of my 2021 Kia Telluride has a broken weld. This is a structural failure that compromises the safety and integrity of the vehicle. The Kia dealership mechanic who inspected it confirmed the weld was defective and also stated they have heard other Tellurides with the same issue. A broken frame weld poses a serious risk to vehicle occupants in the event of a crash and may affect handling, towing, and long-term durability. This appears to be a recurring defect and should be investigated as a potential safety hazard. After several trips to the dealership, for the loud metal to metal type bang, they have replaced struts, rear stab links and shock absorbers. On 9/17/2025 the mechanic was given a list of items to inspect and the dealership informed me that one of the items on the list was to check the frame welds. I was informed that they found the broken weld and have forward pictures to KIA engineers. I was informed that the car is safe to drive and they will get back to me within a couple weeks. They offered me a loaner car but it would be a KIA Soul which is too small for my wife that has bad knees to get in and out of. I do not have pictures of the problem and the dealership didn't want to copy me.

We own a 2021 Kia Telluride which we bought new, have changed the oil as expected and had the 100,000 mile check completed. It now has about 116,000 miles and has been a great and safe car, until now. On a random trip home, traveling on a busy highway, we had to pull over because we suddenly lost power. Our children were in the car and this was very dangerous on a very busy highway. We had it towed to our local garage and was told it was down 3-4 quarts of oil which wrecked the engine and we would need a new one! There were no warning lights for the engine or the oil at all. We are currently having the engine replaced at our very hefty expense as we have no other choice. I see this is quickly becoming an issue with the 21 Telluride and I hope that Kia will do something about it!