Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1480–25K
1525–50K
1150–75K
1275–100K
6100–150K
2150K+
194 reports with mileage · 564 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Exterior Lighting. Review the 183 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 142 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
8 crash reports9 fire reports8 injury reports
What owners actually said
758 reports
Mileage unknown · May 4, 2026
Service Brakes
There is a brake assist issue that comes up intermittently pedal can become stiff at times. This caused me to almost have an accident at an intersection when a car pulled out in front of me. Stopping was delayed and very difficult and frightening. Issue has not been reproduced or confirmed by deal or service center. It has n…
Read full complaint
There is a brake assist issue that comes up intermittently pedal can become stiff at times. This caused me to almost have an accident at an intersection when a car pulled out in front of me. Stopping was delayed and very difficult and frightening. Issue has not been reproduced or confirmed by deal or service center. It has not been inspected. No warning, messages or symptoms of any kind. I purchased it in Oct 2025 and it started in April 2026. After this happening quite a few times I am no longer driving it and can't afford to fix it.
NHTSA ODI #11735465
Mileage unknown · May 1, 2026
Engine
I was just driving down the block and stop at the stop light when I went to pull off and make a left turn the car completely shut off with no warning or anything. Just stopped completely went off in the middle of the road and all of the dash lights came on. It started right back up thankfully but it stopped and locked up
NHTSA ODI #11735220
Mileage unknown · May 1, 2026
Unknown Or Other
I was driving down the highway no cars were near me in any direction and I was not near an overpass it sounded like a giant explosion. I heard glass moving around and realized something happened to my sunroof.
NHTSA ODI #11735035
Mileage unknown · Apr 28, 2026
Unknown Or Other
Sunroof is stuck open after trying to retract it
NHTSA ODI #11734382
Mileage unknown · Apr 16, 2026
Engine
I was driving, no warning lights came on, and the car just stopped. Had it towed to a local mechanic and was told the engine froze.
NHTSA ODI #11731741
Mileage unknown · Apr 13, 2026
Electrical SystemEngineService Brakes
Oil leak that I’ve put so much effort in getting fixed or replaced and nothing is working. The seat belts suck. The seats are ripped.
NHTSA ODI #11730781
Mileage unknown · Apr 9, 2026
Visibility/wiper
Windshield spontaneously cracked. I know it was spontaneous because the car was parked and I was near it for the full hour, nothing hit the windshield and when I got back in the car the windshield was cracked.
NHTSA ODI #11730293
91,300 miles · Apr 9, 2026
Engine
The contact owns a 2020 Kia Telluride. The contact stated that while driving at 60 MPH, the vehicle stalled and lost automotive power. There was no warning light illuminated. The vehicle was unable to restart and was towed to the dealer, where it was diagnosed with battery and starter failure. The contact was informed that the s…
Read full complaint
The contact owns a 2020 Kia Telluride. The contact stated that while driving at 60 MPH, the vehicle stalled and lost automotive power. There was no warning light illuminated. The vehicle was unable to restart and was towed to the dealer, where it was diagnosed with battery and starter failure. The contact was informed that the starter and the battery needed to be replaced. After the replacement of the starter and the battery, the contact was informed by the dealer that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact stated that the vehicle was unsafe to drive. The approximate failure mileage was 91,300.
NHTSA ODI #11730240
Mileage unknown · Apr 9, 2026
Fuel/propulsion SystemPower Train
While driving on a highway at approximately 50 mph, the vehicle suddenly lost acceleration without warning and was unable to exceed approximately 10–15 mph. This created a dangerous situation requiring immediate maneuvering across multiple lanes of traffic to reach safety. At the time of the incident, the check engine light was…
Read full complaint
While driving on a highway at approximately 50 mph, the vehicle suddenly lost acceleration without warning and was unable to exceed approximately 10–15 mph. This created a dangerous situation requiring immediate maneuvering across multiple lanes of traffic to reach safety. At the time of the incident, the check engine light was illuminated. Diagnostic trouble codes P0191, P2177, and P2179 were later identified, indicating fuel pressure irregularities and air/fuel imbalance. The vehicle was inspected by a dealership, which diagnosed a purge valve vacuum leak and faulty high-pressure fuel system components. The repair required replacement of the purge valve and high-pressure fuel system components. The failure involved components within the fuel/propulsion system and engine systems, which are controlled in part by the electronic control module (ECM). This resulted in a sudden and unexpected loss of propulsion while driving at highway speed. Prior to the incident, there were issues with refueling, including difficulty filling the fuel tank when near empty, indicating a potential developing issue within the fuel system. This condition created a significant safety risk due to the sudden and unexpected loss of vehicle speed in active highway traffic, increasing the risk of collision.
NHTSA ODI #11730157
Mileage unknown · Apr 5, 2026
Unknown Or Other
The sunroof mechanism in the vehicle jammed and broke out of the track. When my wife drove the vehicle in the interstate the sunroof began to vibrate and move around. She was afraid the glass was about to fly out and possibly hit a vehicle behind her. She had to reduce her speed excessively and my daughter had to hold on to the…
Read full complaint
The sunroof mechanism in the vehicle jammed and broke out of the track. When my wife drove the vehicle in the interstate the sunroof began to vibrate and move around. She was afraid the glass was about to fly out and possibly hit a vehicle behind her. She had to reduce her speed excessively and my daughter had to hold on to the sunroof all the way home. The vehicle is well maintained with approx 50.000 miles. The warranty is out and I am being told that KIA will not cover the repairs. I am still trying to get customer affairs to approve a fully covered repair at no cost but it seems the are not being co operative so far.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.
Consequence & remedy
Consequence: A vehicle roll away increases the risk of a crash or injury.
Remedy: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.
Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.
Consequence & remedy
Consequence: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.
Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Additional source detail variants (3)
Forward Collision Avoidance: Adaptive Cruise Control
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Exterior Lighting:brake Lights
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Electrical System:wiring
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Additional source detail variants (2)
Seat Belts:rear/other
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Seat Belts:front
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE23002 · Complete Loss Of High Beams
Opened Jan 27, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Exterior Lighting:headlights
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23002 to investigate allegations of loss of high beams with no warning and no re-engagement resulting in reduced visibility at night in the 2020 Kia Telluride. The investigation revealed that the halogen bi-function projector beam, used in vehicles built between January 2019 and November of 2019, is composed of one halogen bulb light source that provides light for both low beam and high beam. The heat generated by the halogen bulb will inflict damage to the gear mechanism and as a result the shutter’s electric motor will no longer be able to move the shutter to the open position to reveal the high beams. A loss of high beams, prevents the driver from having proper distance illumination, therefore increasing the risk of a crash. On February 24, 2024, Kia filed recall 24V-148 for certain MY 2020 Kia Tellurides. The recall remedy provides an inspection of the high beam shield gear mechanism and will either apply a clip to secure the shield gear to the shaft or replace the headlamp assembly with one that is resistant to heat damagefrom the halogen bulb. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2020 Kia Telluride Problems, Complaints & Recalls | Skip That Year
Illustration