2020 Kia Telluride

The vehicle began burning oil around 61,000 miles, shortly after the 5-year/60,000-mile powertrain warranty period ended. The issue was confirmed by an independent mechanic, who identified leaking lower engine seals and excessive oil consumption. The mechanic advised that the engine will likely need replacement due to internal seal failure. This condition presents a potential safety risk if oil levels drop unexpectedly, leading to engine seizure or loss of power while driving. There were no dashboard warning lights or messages prior to discovering the problem; the only symptom was an oil smell and the dipstick reading consistently below normal levels between changes. The problem has been confirmed by an independent mechanic. The vehicle has been regularly maintained according to the manufacturer’s service schedule. The manufacturer has declined to offer assistance, citing warranty expiration and second-owner status, despite the failure occurring only 1,000 miles past coverage and appearing consistent with a latent manufacturing defect. The vehicle and documentation remain available for inspection upon request.

For a while now i have had to add extra oil about a quart every so often (didnt chart mileage )between oil changes and I thought its just burning some oil. Last few months it went up to adding 2 quarts and recently I had to add 3 quarts of oil and I had just checked it 2 weeks ago. There is never a light or any kind of notice on dash panel about low oil. I have a epiletic daughter that requires a safe vehicle to get her to the hospital. So this is a real safety concern. I have been reading this is problem with Tellurides. Because of the oil consumption problem tellurides have been stalling while driving. This could be a life threatening situation with my daughter not to mention for anyone driving the vehicle. The dealer will not do an oil consumption test since I'm at 113,000 miles. I paid $40,000.00 for a quailty vehicle. It should not have these kind of problems. KIA manufacurer said call the local dealer, so its just a run around Please help us figure this out.

The contact owns a 2020 Kia Telluride. The contact stated that the sunroof failed to close after being opened. The vehicle was taken to the dealer, who diagnosed that the cables for the sunroof had fractured and needed to be replaced. The vehicle was not repaired. The dealer secured the sunroof using duct tape as a temporary fix. The contact found information on Technical Service Bulletin, NHTSA ID: 10239743 (Visibility, Structure), which was related to the failure. The manufacturer was made aware of the issue, and a case was opened. The failure mileage was approximately 45,000.

Subject: Ongoing Issue with Excessive Oil Consumption – 2020 Kia S V6 To Whom It May Concern, I am writing to formally express my concern and frustration regarding a recurring issue with my 2020 Kia S V6 related to excessive oil consumption. Despite multiple visits to the dealership and attempted repairs, the issue remains unresolved and continues to affect the safety and reliability of my vehicle. Vehicle Information: Year: 2020 Make: Kia Model: S V6 VIN: [XXX] Current Mileage: Approximately 85,808 miles Timeline of Events: September 6, 2024 – Oil change completed at Kia dealership in Easton. No prior issues reported at this time. [XXX] – After about a week of shaking and stuttering during acceleration, the vehicle shut off completely at a stoplight. Upon checking, the oil level was found to be empty. I added 6–7 quarts of oil. No oil warning light appeared on the dashboard at any time. January 14, 2025 – Brought the vehicle to the Easton Kia dealership. Diagnosed with a broken and leaking oil filter housing, which was replaced. Another oil change was completed. [XXX] – After the engine light came on, I checked the oil at 77,021 miles and found it to be low again. I added 1 quart of oil. The engine light was later determined to be due to a loose gas cap. Once again, no oil warning light appeared. [XXX] – At 78,000 miles, I checked the oil, as advised by Kia, to monitor consumption. The oil level was completely empty. I added another 6–7 quarts of oil. No warning light appeared on the dashboard. [XXX] -- Kia for oil change and consumption test at 82,177 miles. Consumption was read after 1,000 miles and I was advised it was good. I was told to come back at 86,075 miles as per Kia recommendation. [XXX] -- A few hundred miles before the deadline, at approx 85,790 miles I checked oil before a trip, it was empty. Again, no warning light came on the dashboard to warn me of low/no oil. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Oil consumption- I have had to keep oil in the car to top off my oil in between oil changes. It will get low before I can make to another appointment and start shaking or making a loud noise when driving or braking. Oil consumption test says I’m burning 2 qt /1000 miles. Checking online and different forums this is a know issue for these models of vehicles