Windshield replacement 2 times in three years and about to have it replaced again six months after replacing it. It seems little thing that hit the windshield will crack it. I asked KIA if they had complaints about windshields problems and was told no. I getting expensive replacing it every six months or ever year. I believe i…
Read full complaint
Windshield replacement 2 times in three years and about to have it replaced again six months after replacing it. It seems little thing that hit the windshield will crack it. I asked KIA if they had complaints about windshields problems and was told no. I getting expensive replacing it every six months or ever year. I believe it cheaply made and the won’t admit it.
NHTSA ODI #11603272
Mileage unknown · Jul 16, 2024
Unknown Or Other
2020 Kia Telluride Snow White Pearl paint chipping on top of windshield exposing primer. Known issue regarding Kia and white paint colors.
NHTSA ODI #11602788
Mileage unknown · Jul 16, 2024
Unknown Or Other
While driving the vehicle I opened the sunroof. The sunroof appeared to be stuck with a metal object attached to the wind reflector popped off and came inside the vehicle. Had it been closer to my face it could have caused grave danger, if it had struck my eyes. The piece appears to have attached to the wind reflector and frame …
Read full complaint
While driving the vehicle I opened the sunroof. The sunroof appeared to be stuck with a metal object attached to the wind reflector popped off and came inside the vehicle. Had it been closer to my face it could have caused grave danger, if it had struck my eyes. The piece appears to have attached to the wind reflector and frame of sunroof.
NHTSA ODI #11602711
Mileage unknown · Jul 8, 2024
Electrical SystemUnknown Or Other
Sunroof went off track and will not close. Took it to the dealership and it will need a totally new sunroof assembly totaling $5,000 because the sunroof got off track on its own.
NHTSA ODI #11600102
Mileage unknown · Jun 28, 2024
Unknown Or Other
There is no incident but there has been an interim recall notice on my car since February. This is the recall number 24V148. I rent this car out as part of my business and this recall is blocking me from being able to rent it out since February (6 months). Please get this resolved.
NHTSA ODI #11597536
Mileage unknown · Jun 17, 2024
Unknown Or Other
The window on the driver side and co-pilot behind the driver side have gotten stuck. Last time I was at a car wash and the rear co-pilot window did not go up and the inside of my car got wet.
NHTSA ODI #11594752
Mileage unknown · Jun 5, 2024
Unknown Or Other
Sunroof original from KIA. Track has broken and it had no out of ordinary use. I can understand seals, but the track of the sunroof should exceed any other issue.
NHTSA ODI #11592650
Mileage unknown · May 23, 2024
Unknown Or Other
The A/C system failed due to either corrosion or leaking at a fitting(Dealer has told us two different things). This is a 2020 car with a little over 100k miles, there is no reason for a failure due to corrosion or due to a leaking fitting. This is poor assembly, faulty factory parts, or faulty design. The Coolant used (1234y…
Read full complaint
The A/C system failed due to either corrosion or leaking at a fitting(Dealer has told us two different things). This is a 2020 car with a little over 100k miles, there is no reason for a failure due to corrosion or due to a leaking fitting. This is poor assembly, faulty factory parts, or faulty design. The Coolant used (1234yf) is flammable and could pose a safety hazard when it leaks. Photo attached that dealer provided for leak location.
NHTSA ODI #11590322
Mileage unknown · May 20, 2024
Forward Collision AvoidanceUnknown Or Other
Vehicle's paint located on the front of the hood and top of roof close to the front windshield has started to delaminate and peel away. The dealer said the vehicle is out of warranty for paint concerns. I know this is a large problem from Kia/Hyundia white vehicles. My son's 2015 Sonata, daughter's 2012 Sorento and now my wife's…
Read full complaint
Vehicle's paint located on the front of the hood and top of roof close to the front windshield has started to delaminate and peel away. The dealer said the vehicle is out of warranty for paint concerns. I know this is a large problem from Kia/Hyundia white vehicles. My son's 2015 Sonata, daughter's 2012 Sorento and now my wife's 2020 Telluride! All thease vehicles are white and all are peel or have been peeling for some time. I just want to get my wife's Telluride repaint to be paid for by Kia since they know this is a know problems and have fixed others.
NHTSA ODI #11589639
Mileage unknown · May 16, 2024
Unknown Or Other
On Tuesday, May 14th, the sunroof on my 2020 Kia Telluride broke and is now stuck in the open position. Despite forums indicating that this is a common issue with this vehicle, Kia refuses to cover the repair. This is the first time I've purchased a new vehicle and faced a major repair before paying it off. The sunroof problem i…
Read full complaint
On Tuesday, May 14th, the sunroof on my 2020 Kia Telluride broke and is now stuck in the open position. Despite forums indicating that this is a common issue with this vehicle, Kia refuses to cover the repair. This is the first time I've purchased a new vehicle and faced a major repair before paying it off. The sunroof problem is clearly an issue with Kia, yet they are not offering any assistance for this $3,500 repair on a car that is less than five years old with minimal sunroof use. I believe a recall is warranted, and customers should not have to bear the cost of this failure. It's disappointing that Kia is living up to a negative reputation that I thought they were trying to move away from. If I have to pay for this major repair, which is due to a flaw and not my usage, this will be my first and last Kia purchase.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob or an improper recall 24V407 repair, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install an electronic fuse assembly, free of charge. Owner notification letters are expected to be mailed August 13, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC374. This recall replaces NHTSA recall number 24V407. Vehicles already repaired under the previous recall will need to have the new remedy completed. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The front power seat motor may overheat due to a stuck power seat slide knob, which can result in a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a bracket for the power seat switch back covers and replace the seat slide knobs, free of charge. Owner notification letters were mailed July 30, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC316.
Kia America, Inc. (Kia) is recalling certain 2020-2024 Telluride vehicles. The intermediate shaft and right front driveshaft may not be fully engaged, which can result in vehicle roll away while in PARK.
Consequence & remedy
Consequence: A vehicle roll away increases the risk of a crash or injury.
Remedy: Owners are advised to manually engage the emergency parking brake prior to exiting the vehicle until the recall remedy is performed. Dealers will update the electronic parking brake software and replace any damaged intermediate shafts as necessary, free of charge. Owner notification letters were mailed May 15, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC303.
Kia America, Inc. (Kia) is recalling certain 2020 Telluride vehicles. The high beam headlights may fail.
Consequence & remedy
Consequence: Inoperable high beam headlights may reduce visibility, increasing the risk of a crash.
Remedy: Dealers will inspect and repair or replace the high beam headlights, as necessary free of charge. Owner notification letters were mailed August 9, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC299.
Kia America, Inc. (Kia) is recalling certain 2020-2022 Telluride vehicles potentially equipped with a Genuine Kia 4-pin tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will install a new fuse and a wiring harness extension. Dealers will also inspect and replace the tow hitch harness assembly, as necessary. All repairs will be performed free of charge. Owner notification letters were mailed April 12, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC247.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Additional source detail variants (3)
Forward Collision Avoidance: Adaptive Cruise Control
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Exterior Lighting:brake Lights
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Electrical System:wiring
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles equipped with Smart Cruise Control (SCC). When a trailer is connected to the vehicle, the trailer brake lights will not illuminate when the SCC applies the brakes. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
Consequence: Inoperative trailer brake lights can fail to warn other drivers that the vehicle is slowing, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will install an additional wire harness to the main fuse box to signal the trailer brake lights, free of charge. The recall began September 10, 2020. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC194.
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Additional source detail variants (2)
Seat Belts:rear/other
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Seat Belts:front
Kia Motors America (Kia) is recalling certain 2020 Telluride vehicles. The seat belt assemblies in the front passenger, second, and/or third row seats may not tightly secure a child restraint system in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 208, "Occupant Crash Protection."
Consequence: If a child seat is not properly secured, there is an increased risk of injury to the occupant in a crash.
Remedy: Kia will notify owners, and dealers will inspect the vehicles and replace any incorrect seat belt assemblies. The repair will also include replacing the driver's seat belt which has a non-U.S. specified label, with a U.S. specification seat belt. The repairs will be performed free of charge. The recall began August 30, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC181.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE23002 · Complete Loss Of High Beams
Opened Jan 27, 2023 · Closed Apr 17, 2024
Status: closed (inferred from source dates) · Exterior Lighting:headlights
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23002 to investigate allegations of loss of high beams with no warning and no re-engagement resulting in reduced visibility at night in the 2020 Kia Telluride. The investigation revealed that the halogen bi-function projector beam, used in vehicles built between January 2019 and November of 2019, is composed of one halogen bulb light source that provides light for both low beam and high beam. The heat generated by the halogen bulb will inflict damage to the gear mechanism and as a result the shutter’s electric motor will no longer be able to move the shutter to the open position to reveal the high beams. A loss of high beams, prevents the driver from having proper distance illumination, therefore increasing the risk of a crash. On February 24, 2024, Kia filed recall 24V-148 for certain MY 2020 Kia Tellurides. The recall remedy provides an inspection of the high beam shield gear mechanism and will either apply a clip to secure the shield gear to the shaft or replace the headlamp assembly with one that is resistant to heat damagefrom the halogen bulb. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
2020 Kia Telluride Problems, Complaints & Recalls | Skip That Year
Illustration