Engine. Review the 90 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 29 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

7 crash reports12 fire reports4 injury reports

Service Brakes complaints

6 reports

Clear category filter

Mileage unknown · Jan 23, 2024

Forward Collision AvoidanceService Brakes

When pressing brake during operation, a noise comes from underneath vehicle. The warning lights goes off but come back on while driving and stays on. Kia dealer stated it was the ABS module going bad. Kia dealer recently replaced engine block due to manufacturer defect and completed two recalls. Dealer advised this was a new pr…

Read full complaint

NHTSA ODI #11567272

Mileage unknown · Sep 16, 2023

Service BrakesCrash

Breaks failed to ingage and caused me to hit the back of the vehicle in front of me.

NHTSA ODI #11544861

Mileage unknown · May 23, 2023

Service BrakesVehicle Speed Control

With the cruise control set at highway speed (65pmh, etc) If you push the foot controlled parking brake it will not cancel the cruise control. The vehicle increases the acceleration to maximum and overrides the parking brake input. If using the parking brake in an emergency you would stomp on the parking (emergency brake) and no…

Read full complaint

NHTSA ODI #11523371

33,000 miles · Sep 12, 2019

Electrical SystemService BrakesSteeringCrashInjury

ALL ELECTRICAL MALFUNCTION AND LOSS OF STEERING AND BRAKES RESULTING IN HEADING CRASH

NHTSA ODI #11255041

5,080 miles · Feb 2, 2019

EngineExterior LightingService Brakes

Read full complaint

I PURCHASED MY 2018 KIA SPORTAGE EX BRAND NEW 6-8-18. LESS THAN 100 MILES ON THE CAR AND THE DASHBOARD INSTRUMENT LIGHTS WENT DARK WHILE DRIVING ON THE HIGHWAY IN THE DARK. I BROUGHT IT BACK TO DEALER, THEY HAD TO ORDER A NEW GAUGE DIMMER CLUSTER BECAUSE THE ORIGINAL FAILED. SEVERAL WEEKS LATER THE BRAKES BEGAN VIOLENTLY SHAKING THE CAR WHEN BRAKING ON THE HIGHWAY. AGAIN, I BROUGHT IT BACK TO THE DEALER AND THEY RESURFACED THE BRAKE ROTORS DUE TO WARPING. SEVERAL MONTHS LATER ON 1-28-19 THE ENGINE DIED ON THE HIGHWAY PLACING THE VEHICLE INTO LIMP HOME MODE. I ALMOST GOT HIT BY A TRACTOR TRAILER TRYING TO GET TO THE BREAKDOWN LANE WITHOUT AMPLE ENGINE POWER. I IMMEDIATELY DROVE IT TO THE DEALER AND IT HAS BEEN THERE EVER SINCE. I GOT THE BBB INVOLVED NOW AND I AM TRYING TO GET THE LEMON LAW IN PLACE. I AM CURRENTLY IN A RENTAL.

NHTSA ODI #11173712

900 miles · Jul 24, 2018

Service BrakesCrash

2018 KIA SPORTAGE 4D 4X4 WHILE IN 'PARK' ROLLED DOWN HOME DRIVEWAY. VEHICLE ROLLED INTO STREET, WHILE WIFE HOLDING ONE YEAR OLD SON DODGED VEHICLE TO AVOID GETTING CRUSHED.

NHTSA ODI #11113458

Official recalls

22V703000 · Trailer Hitches

Sep 19, 2022

Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.

Consequence & remedy

Consequence: A fire while parked or driving can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.

21V137000 · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

Mar 4, 2021

Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment.

Consequence & remedy

Consequence: An engine compartment fire can increase the risk of injury.

Remedy: Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. The recall began on April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC206.

18V907000 · Engine; Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Dec 19, 2018

Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.

Consequence & remedy

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Additional source detail variants (2)

Engine

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ23002 · Hyundai And Kia Abs Module Fires

Opened Nov 17, 2023 · No close date supplied

Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module

The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.

Go deeper into Kia Sportage problems

Kia Sportage electrical problems →Kia Sportage transmission problems →