Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
570–25K
2325–50K
4250–75K
3075–100K
25100–150K
4150K+
181 reports with mileage · 218 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine. Review the 219 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 62 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Power Train. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
14 crash reports27 fire reports17 injury reports
What owners actually said
399 reports
120,000 miles · Dec 21, 2023
Electrical SystemExterior LightingService Brakes
The contact owns a 2017 Kia Sportage. The contact stated while driving approximately 35 MPH and depressing the brake pedal to slow for traffic or a traffic signal, the contact required more force to depress the brake pedal before the vehicle would slow. The contact became aware that while making a right turn, excessive pressure …
Read full complaint
The contact owns a 2017 Kia Sportage. The contact stated while driving approximately 35 MPH and depressing the brake pedal to slow for traffic or a traffic signal, the contact required more force to depress the brake pedal before the vehicle would slow. The contact became aware that while making a right turn, excessive pressure was needed to depress the brake pedal. The contact stated there was no warning light illuminated. The contact also stated that while depressing the brake pedal to make an abrupt stop, the front brakes made an abnormal sound like loosened pieces of metal bouncing around in the front wheels. Additionally, the contact stated that her rear brake light bulbs were burning out frequently and the brake light wiring was melted. The contact stated that the failure was recurring. The contact took the vehicle to an independent mechanic who diagnosed that the rear taillight wiring needed to be replaced. The taillight bulbs and the wires were replaced. The mechanic also determined that the brake pads and calipers needed to be replaced. The vehicle was repaired. The contact stated that the failures reoccurred. The manufacturer had not been informed of the failure. The failure mileage was approximately 120,000.
NHTSA ODI #11561396
Mileage unknown · Nov 20, 2023
Electrical SystemEngineFuel/propulsion System
Driving as usual and all of a sudden no acceleration. No warning lights at all. Started smoking. Towed to Flynn’s. They said there is a known oil consumption issue and the motor locked up. Communicated with KIA and they say to have it looked at - at a cost. Said it’s not under warranty. But is a likely know issue!
NHTSA ODI #11556009
Mileage unknown · Nov 18, 2023
Engine
I purchased a used vehicle by way of a loan from "Affinity Plus Credit Union." On 7/27/20 from "Royal Drive Autos" with an extended warranty sold through Affinity Plus Credit Union. The warranty was issued by Route 66 CO. Both parties (Bank & Warranty CO.) granted the loan and warranty understanding there was a “Prior Salvage” t…
Read full complaint
I purchased a used vehicle by way of a loan from "Affinity Plus Credit Union." On 7/27/20 from "Royal Drive Autos" with an extended warranty sold through Affinity Plus Credit Union. The warranty was issued by Route 66 CO. Both parties (Bank & Warranty CO.) granted the loan and warranty understanding there was a “Prior Salvage” title and had been cleared to sell the vehicle. The vehicle has been serviced under recalls by KIA and Route 66 since the purchase of the vehicle. There was a major engine failure believed to be a recall issued by KIA. The vehicle had a “Flashing Engine” light and failed on 9/5/23. I took the vehicle to Luther Bloomington KIA to be serviced on 10/9/23, as this was the earliest appointment available. Once diagnosed the service advisor and the mechanics said that the engine would need to be replaced due to the failure of part. And cannot fix broken part if the engine is not working. KIA denied engine replacement due to "Branded Title." The service adviser then tried to contact Route 66 to see if they would cover the work, they also denied servicing due to having a branded title. Service adviser said to try and get to the bottom of it through route 66. So I called, and they said the bank should've never issued an extended warranty because of the branded title stated on page 2 of the warranty agreement. As it was void/never valid from the start. I talked to Gail Johnson, and she says that it was a mistake to sell the warranty and agreed it should not have been issued. She stated that it was a lack of training of the employee. I stated I would not have taken the loan or the vehicle with a branded title if it wasn't for the extended warranty covering the vehicle. It is now 11/18/23 and the Vehicle is still not fixed and have tried to reach out to Affinity Plus to resolve the issue. And would like KIA to fix the recall that caused the engine failure.
NHTSA ODI #11555854
67,000 miles · Nov 14, 2023
FirerelatedFireInjury
The contact owns a 2017 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the engine revved loudly. No warning light was illuminated. The contact pul…
Read full complaint
The contact owns a 2017 Kia Sportage. The contact received notification of NHTSA Campaign Number: 22V703000 (Trailer Hitches); however, the part to do the recall repair was not yet available. The contact stated that while driving at an undisclosed speed, the engine revved loudly. No warning light was illuminated. The contact pulled over to the side of the road, and then the vehicle slid into the ditch. The accelerator pedal was depressed when the contact noticed the rear end of the vehicle had caught fire. The contact panicked and exited the vehicle, injuring his left shin and right foot. Medical attention was received. The fire department arrived and extinguished the fire. The contact was unaware if a fire department report had been filed. The vehicle was towed to a tow yard; however, the vehicle was not deemed totaled by the insurance company. The manufacturer was not made aware of the failure. The failure mileage was approximately 67,000. VIN tool confirms parts not available.
NHTSA ODI #11555028
Mileage unknown · Nov 5, 2023
Engine
My car keeps burning oil at a rapid rate. I have to replace every 3 weeks.
NHTSA ODI #11553621
Mileage unknown · Nov 3, 2023
Engine
My car has a circuit problem and that is causing my engine light go off. Kia is not taking any responsibility os this issue
NHTSA ODI #11553410
Mileage unknown · Nov 2, 2023
EngineStructureUnknown Or OtherFire
My daughter and I were driving home from my brother's house, when we stopped by McDonald's to grab food, we noticed our car smoking really bad. I had her pull away from the drive-thru and into the empty parking lot. We got out just seconds before the car burst into flames from underneath the hood of the car.
NHTSA ODI #11553266
Mileage unknown · Oct 30, 2023
Electrical SystemEngineVehicle Speed Control
The vehicle went into limp mode while driving on the interstate but the dealership is telling me there is nothing wrong with the vehicle. They are also telling me that there is no powertrain coverage on this vehicle since I am the second owner. With as many problems as Kia has had, I think it should be across the board for cover…
Read full complaint
The vehicle went into limp mode while driving on the interstate but the dealership is telling me there is nothing wrong with the vehicle. They are also telling me that there is no powertrain coverage on this vehicle since I am the second owner. With as many problems as Kia has had, I think it should be across the board for coverage on these so no one else suffers irreparable damage. I’ve had the car shut down on me many times but every single time I’ve taken it in for diagnostic testing I’ve been told there is nothing wrong with it. I call BS. If there was nothing wrong with it, it wouldn’t shut down on me while I’m driving it.
NHTSA ODI #11552612
82,365 miles · Oct 4, 2023
Engine
The contact owns a 2017 Kia Sportage. The contact stated that while driving at various speeds, the vehicle was consuming an excessive amount of engine oil. The contact stated that 5-quarts of oil were added every three months. The check engine warning light was illuminated. The vehicle had been diagnosed by an independent mechan…
Read full complaint
The contact owns a 2017 Kia Sportage. The contact stated that while driving at various speeds, the vehicle was consuming an excessive amount of engine oil. The contact stated that 5-quarts of oil were added every three months. The check engine warning light was illuminated. The vehicle had been diagnosed by an independent mechanic who determined that cylinders #2, #3, and #4 were misfiring. The vehicle had not been repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 82,365.
NHTSA ODI #11548220
107,000 miles · Sep 28, 2023
Engine
The contact owns a 2017 Kia Sportage. The contact stated while driving 55 MPH, the check engine and the low oil pressure warning lights illuminated. The contact stated that she veered to the side of the road. The contact stated that she inspected the engine oil level and noticed that there was no oil in the engine. The contact s…
Read full complaint
The contact owns a 2017 Kia Sportage. The contact stated while driving 55 MPH, the check engine and the low oil pressure warning lights illuminated. The contact stated that she veered to the side of the road. The contact stated that she inspected the engine oil level and noticed that there was no oil in the engine. The contact stated that she added oil to the vehicle and drove to an independent mechanic, where it was diagnosed that oil was leaking into the combustion chamber, and that the engine needed to be replaced. The vehicle was not repaired. The vehicle was towed to the dealer to be diagnosed. The dealer informed the contact that they could not duplicate the failure because the warning lights were no longer illuminated and there was oil in the engine. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 17V224000 (Engine and Engine Cooling) however, the VIN was not included. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 107,000.
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Kia Motors America (Kia) is recalling certain 2017-2021 Sportage and Cadenza vehicles. The electrical circuit in the Hydraulic Electronic Control Unit (HECU) may short-circuit, which can cause a fire in the engine compartment.
Consequence & remedy
Consequence: An engine compartment fire can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures as a precaution until the recall repair is complete. Kia will notify owners, and dealers will replace certain fuses in the electrical junction box. Vehicles equipped with an electronic parking brake (EPB) will also receive a HECU software update. Repairs will be performed free of charge. The recall began on April 30, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC206.
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
AQ23002 · Hyundai And Kia Abs Module Fires
Opened Nov 17, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip:control Unit/module
The Office of Defects Investigation (ODI) has received eight Hyundai Motor America (Hyundai) and eight Kia America, Inc. (Kia) Part 573 Recall Reports between 2016 and 2023. The combined 16 safety recalls all involve the antilock braking system (ABS) modules or Hydraulic Electronic Control Units (HECU) manufactured by the equipment supplier Mando. The Part 573 Recall Reports contain varying defect descriptions and differing remedy descriptions for the same or similar equipment supplied by Mando. Safety recalls included in this Audit Query (AQ) review include: Hyundai recalls 20V-520, 20V-543, 21V-161, 21V-160, 21V-303, 22V-056, 22V-810, and 23V-651. Kia recalls 16V-815, 20V-518, 20V-519, 21V-137, 21V-331, 22V-051, 22V-800, and 23V-652 The purpose of this AQ is to evaluate the timeliness and scoping of Hyundai and Kia’s defect decision making and adherence with reporting requirements; and understand the varying defect descriptions and remedies between these recalls.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration