NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
22 reportsClear category filterMileage unknown · Jul 26, 2004
Engine And Engine CoolingFuel System, GasolinePower Train
PROBLEMS WITH VEHICLE STARTING UP AS WELL AS STALLING. *MR THE VEHICLE WAS HARD TO START AND THE GAS MILEAGE WAS DROPPING WAY DOWN AND THE VEHICLE WAS TAKEN IN FOR A TUNE UP BUT THE PROBLEM STILL EXISTED. WHEN THE VEHICLE WAS DRIVEN ON THE EXPRESSWAY, THE CONSUMER HIT A BUMP AND THE ENGINE STALLED. THE CONSUMER WAS INFORM…
Read full complaint
PROBLEMS WITH VEHICLE STARTING UP AS WELL AS STALLING. *MR THE VEHICLE WAS HARD TO START AND THE GAS MILEAGE WAS DROPPING WAY DOWN AND THE VEHICLE WAS TAKEN IN FOR A TUNE UP BUT THE PROBLEM STILL EXISTED. WHEN THE VEHICLE WAS DRIVEN ON THE EXPRESSWAY, THE CONSUMER HIT A BUMP AND THE ENGINE STALLED. THE CONSUMER WAS INFORMED THAT THE TRANSMISSION HAD TO BE SERVICED. THE FILLER NECK RUSTED AND THE FUEL CAP WAS LEAKING. THE FILLER NECK WAS REPLACED, BUT IMMEDIATELY AFTER THE PROBLEM RECURRED. THE TRANSMISSION FLUID WAS WORN AND THE TRANSMISSION WAS FLUSHED. *SC *JB
NHTSA ODI #10083971
39,593 miles · Jul 14, 2004
Electrical SystemPower Train
THE TRUCK WOULD NOT START AT TIMES AND KEPT BLOWING FUSES.. DEALER FOUND PROBLEM TO BE IN THE ENGINE HARNESS CONNECTOR. ALSO IN 10/03, ONE NIGHT WHILE I WAS DRIVING HOME FROM WORK LATE, MY TRUCK STULLED ON ME, AND THE SHIFTER WAS VERY LOOSE, TOOK TO DEALER AND THEY REPLACED THE DRIVE SHAFT AND REAR MAIN SEAL (X3). THEY HAVE ALS…
Read full complaint
THE TRUCK WOULD NOT START AT TIMES AND KEPT BLOWING FUSES.. DEALER FOUND PROBLEM TO BE IN THE ENGINE HARNESS CONNECTOR. ALSO IN 10/03, ONE NIGHT WHILE I WAS DRIVING HOME FROM WORK LATE, MY TRUCK STULLED ON ME, AND THE SHIFTER WAS VERY LOOSE, TOOK TO DEALER AND THEY REPLACED THE DRIVE SHAFT AND REAR MAIN SEAL (X3). THEY HAVE ALSO REPLACED THE CAT.CONVERTOR X3, TIMING BELT DUE TO ABNORMAL STRECHING,AND 2 IGNITION COILS.*AK
NHTSA ODI #10081035
35,488 miles · Jan 15, 2004
Engine And Engine CoolingPower TrainVisibility
WE HAD THE TRANSMISSION REPLACED IN APRIL OF 2003 AND THE CLUTCH REPLACED IN APRIL 2003. THE CLUTCH WAS NOT COVERED UNDER WARRANTY. WE PAID TOTAL COST $366.76. THE TRANSMISSION HAS NOW GONE OUT AGAIN. THE TRANSMISSION IS ONLY 2 MONTHS OLD. THIS WILL BE THE 6TH PROBLEM WE HAVE HAD WITH THIS CAR SINCE OCTOBER OF 2002: (1) C…
Read full complaint
WE HAD THE TRANSMISSION REPLACED IN APRIL OF 2003 AND THE CLUTCH REPLACED IN APRIL 2003. THE CLUTCH WAS NOT COVERED UNDER WARRANTY. WE PAID TOTAL COST $366.76. THE TRANSMISSION HAS NOW GONE OUT AGAIN. THE TRANSMISSION IS ONLY 2 MONTHS OLD. THIS WILL BE THE 6TH PROBLEM WE HAVE HAD WITH THIS CAR SINCE OCTOBER OF 2002: (1) CLUTCH SWITCH OCT 2002 (2) EXHAUST MANIFOLD CRACKED APR 2003 (3) PASSENGER SIDE FRONT WINDOW WOULD NOT GO UP APR 2003 (4) TRANSMISSION FAILURE APRIL 2003 (5) CLUTCH FAILURE APRIL 2003 (6) TRANSMISSION FAILURE JUNE 2003
NHTSA ODI #10070012
Mileage unknown · Dec 18, 2003
Power Train
WHILE DRIVING CHECK ENGINE LIGHT ILLUMINATED, SHORTLY AFTER THE TRANSMISSION FAILED. *AK
NHTSA ODI #10051771
Mileage unknown · Jul 30, 2003
Engine And Engine CoolingPower Train
TRANSMISSION LIGHT APPEARED ON THE DASHBOARD, ALSO ENGINE CHECK LIGHT. *AK
NHTSA ODI #10031615
Mileage unknown · Jun 11, 2003
Power TrainVisibility
LEFT REAR WINDOW STOPPED FUNCTIONING WITHIN 2 MONTHS OF PURCHASING CAR (NOVEMBER2001). DEALER REPLACED REGULATOR/MOTOR. RIGHT WINDOW FUNCTIONS MOST OF THE TIME, BUT WHEN I GET READY TO TAKE TO DEALER IT FUNCTIONS CORRECTLY. BOTH REAR WINDOWS STOPPED FUNCTIONING SUMMER OF 2003. TOOK TO DEALER & BOTH REGULATORS/MOTORS WERE REPLAC…
Read full complaint
LEFT REAR WINDOW STOPPED FUNCTIONING WITHIN 2 MONTHS OF PURCHASING CAR (NOVEMBER2001). DEALER REPLACED REGULATOR/MOTOR. RIGHT WINDOW FUNCTIONS MOST OF THE TIME, BUT WHEN I GET READY TO TAKE TO DEALER IT FUNCTIONS CORRECTLY. BOTH REAR WINDOWS STOPPED FUNCTIONING SUMMER OF 2003. TOOK TO DEALER & BOTH REGULATORS/MOTORS WERE REPLACED. GEAR SHIFT IS SLIPPING BETWEEN GEAR BY ITSELF. TOOK TO DEALER AND WAS ADJUSTED JUNE 2003.*AK
NHTSA ODI #10021401
5,000 miles · Feb 27, 2003
Engine And Engine CoolingEquipmentLatches/locks/linkages
OVER THE SPAN OF THE LAST 1 1/2 YEARS I HAVE HAD THE FOLLOWING PROBLEMS *REAR SEAT BELTS LOCKED UP WOULDN'T LOOSEN FAR ENOUGH TO GET MY CHILD OUT OF THE CAR. *FRONT SEAT BELTS (BOTH) WOULD COME OPEN WHILE THE VEHICLE WAS IN MOTION. *DRIVERS SIDE DOOR WOULDN'T LATCH WHEN TRYING TO CLOSE IT, HAD TO JIGGLE THE INSIDE HANDLE *SP…
Read full complaint
OVER THE SPAN OF THE LAST 1 1/2 YEARS I HAVE HAD THE FOLLOWING PROBLEMS *REAR SEAT BELTS LOCKED UP WOULDN'T LOOSEN FAR ENOUGH TO GET MY CHILD OUT OF THE CAR. *FRONT SEAT BELTS (BOTH) WOULD COME OPEN WHILE THE VEHICLE WAS IN MOTION. *DRIVERS SIDE DOOR WOULDN'T LATCH WHEN TRYING TO CLOSE IT, HAD TO JIGGLE THE INSIDE HANDLE *SPARE TIRE ARM WOULDN'T STAY IN THE LOCKED POSITION WHEN OPEN. STILL WON'T *FOUR WHEEL DRIVE WOULDN'T ENGAGE *LIFTER NOISE--COLLAPSED LIFTER *HEAD WARPED *CHECK ENGINE LIGHT HAD COME ON A FEW TIMES *CUP HOLDERS (FRONT AND REAR) FELL APART *OUTSIDE TRIM WAS FALLLING OFF. *JB
NHTSA ODI #10008205
Mileage unknown · Nov 19, 2002
Power Train
WHILE DRIVING AT ANY SPEED, CONSUMER STATES' VEHICLE GEAR SHIFTER WILL JUMP UP TO NUETRAL, VEHICLE SUDDENLY LOOSES POWER. CONSUMER FEELS THIS IS UNSAFE BECAUSE VEHICLE LOOSES POWER AT ANYTIME. COULD RESULT IN A REAR END COLLISION. PLEASE PROVIDE ANY FURTHER INFORMATION. TS
NHTSA ODI #8022985
Mileage unknown · Feb 7, 2002
Power Train
TRANSMISSION SURGES AND STOPS WITHOUT PRIOR WARNING. DEALERSHIP IS AWARE OF PROBLEM. *AK
NHTSA ODI #8003742
Mileage unknown · Jan 30, 2002
Power Train
WHILE DRIVING BETWEEN 20 AND 30 MPH SPEEDOMETER WOULD JUMP. COULD NOT TELL WHAT SPEED WAS DRIVING. TOOK TO DEALER, AND DEALER PUT IN NEW MODULATOR, BUT PROBLEM STILL EXISTS. *AK
NHTSA ODI #8003187
NHTSA investigations
2EA06007 · Fuel Tank Leakage
Opened May 9, 2006 · Closed Nov 30, 2007
Status: closed (inferred from source dates) · Fuel System, Gasoline; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
Illustration