HAVE HAD VEHICLE IN FOR BRAKE SERVICE 9X IN 2 YRS. ONLY 20 K MILES ON CAR.(2000 KIA SPORTAGE). 13 TIMES TOTAL FOR SERVICE . REPLACED ROTORS 3X AND NOW HAVE PROBLEMS AGAIN. THE DEALERSHIP YORK CHRYSLER KIA HAS NOT BEEN ABLE TO SOLVE THIS PROBLEM. THE FRONT WHEEL BEARINGS WERE LOOSE 3X. THEY TOLD US THEY NEVER SEEN THIS HAPPEN BEF…
Read full complaint
HAVE HAD VEHICLE IN FOR BRAKE SERVICE 9X IN 2 YRS. ONLY 20 K MILES ON CAR.(2000 KIA SPORTAGE). 13 TIMES TOTAL FOR SERVICE . REPLACED ROTORS 3X AND NOW HAVE PROBLEMS AGAIN. THE DEALERSHIP YORK CHRYSLER KIA HAS NOT BEEN ABLE TO SOLVE THIS PROBLEM. THE FRONT WHEEL BEARINGS WERE LOOSE 3X. THEY TOLD US THEY NEVER SEEN THIS HAPPEN BEFORE. BUT IT HAPPENED 3X TO US. THE 4 WHEEEL DRIVE WENT OUT. THEY SAID IT HAPPENS SINCE THERE IS NO DIRT SHIELD ON THE LINKAGE. THEY INSTALLED A RETROFIT KIT TO PROTECT AGAINST THIS BUT ONLY DO IT IF PEOPLE HAVE PROBLEMS. I THINK THEY ARE TRYING TO GET OUT OF HAVING A RECALL ON THIS ITEM. WITH OUR KIA THEY REPLACED THE ENTIRE BRAKE ASSEMBLEY AFTER ONLYU 3206 MI. WE HAD THE CAR IN 3X AFTER THAT FOR BRAKE SQUEEL WHICH WAS EXCESSIVE. THEY COULD NOT FIX IT. THEY REPLACED THE ROTORS AGAIN AT 10456 MILES. AT 12552 MILES THE 4 WHEEL DRIVE WENT OUT. AT 15882 MI THEY CHECKED AGAIN FOR BRAKE PULSATION AND BALANCED FRONT TIRE AND WHEEL ASSEM. SAID BRAKE AND ROTOR RUNOUT WELL WITHIN SPECS. AT 17488 HAD ROTORS REPLACED AGAIN. NOT EVEN 2K MILES AFTER THEY SAID EVERYTHING WAS WELL WITHIN SPECS. AT 20473 MILES BRAKE ROTOR WERE PULSING AGAIN. THEY WOULD NOT COVER UNDER WARRANTY. AFTER TALKING WITH KIA (CASE #K129955) THEY AGREED TO MACHINE THE ROTORS AGAIN USING THE ON CAR LATHE TO GET A BETTER FINISH. AT 20783 COMPLAINED ABOUT BRAKE PULSING AGAIN. AND AM GOING TO TAKE THE VEHICLE IN AGAIN TO FIND OUT WHAT IS GOING ON. I THINK THERE IS AN UNDERLING PROBLEM WITH THIS VEHICLE THAT THEY CANNOT FIGURE OUT. AT 7571 MI, 13777MI, AND AGAIN AT 20783 MI, THE WHEEL BEARINGS WERE LOOSE. THIS IS NOT NORMAL WEAR JUST LIKE THE ROTORS.
ON CERTAIN PASSENGER AND SPORT UTILITY VEHICLES, THE FRONT SAFETY BELT BUCKLES MAY EMIT A "CLICK" SOUND DURING THE BUCKLING PROCESS THAT IS SIMILAR TO THE SOUND EMITTED WHEN A BUCKLE IS BEING LATCHED, WHEN IT IS NOT.
Consequence & remedy
Consequence: THE LATCH CAN THEN PULL OUT OF THE BUCKLE WHEN TENSION IS APPLIED.
Remedy: DEALERS WILL REPLACE BOTH FRONT SEAT BELT BUCKLES. THE RECALL BEGAN AUGUST 16, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
VEHICLE DESCRIPTION: SPORT UTILITY VEHICLE. THESE VEHICLES WERE DISTRIBUTED WITH OWNERS MANUALS WITH AN INCORRECT JUMP START DIAGRAM. THE WRITTEN INSTRUCTIONS FOR JUMP STARTING ARE ACCURATE. HOWEVER, THE DIAGRAM DEPICTS THE JUMPER CABLES ATTACHED TO THE WRONG POLARITY TERMINALS. IF THE DIAGRAM WERE FOLLOWED WITHOUT REFERENCE TO THE INSTRUCTIONS, THE RESULTING IMPROPER CONNECTIONS COULD CAUSE THE BATTERY TO RUPTURE AGGRESSIVELY DUE TO INCREASED INTERNAL PRESSURES.
Consequence & remedy
Consequence: THIS COULD CAUSE POTENTIAL SERIOUS INJURY TO BYSTANDERS.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADHESIVE LABEL WITH THE CORRECT ILLUSTRATION TO PERMANENTLY AFFIX TO THEIR RESPECTIVE OWNERS MANUALS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Additional source detail variants (3)
Fuel System, Gasoline
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
Fuel System, Gasoline:storage:tank Assembly
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME.REVIEW OF THE WARRANTY DATA REVEALED ELEVATED TANK LEAKAGE EXPERIENCE IN VEHICLES PRODUCED FROM JUNE 1999 TO OCTOBER 2000.ANALYSIS OF COMPLAINTS AND WARRANTY CLAIMS IDENTIFIED MULTIPLE CAUSES AND ORIGINS OF FUEL TANK ASSEMBLY LEAKAGE.THE MAJORITY OF COMPLAINTS INVOLVE NON-SPECIFIC ALLEGATIONS OF FUEL LEAKAGE WHERE MORE THAN ONE FUEL SYSTEM COMPONENT WAS REPLACED.ODI'S ANALYSIS FOCUSED ON LEAKS OCCURRING ON THE UNDERSIDE OF THE TANK DUE TO CORROSIVE FAILURE CAUSED BY DISRUPTION OF THE PROTECTIVE PVC COATING.THE ANALYSISINDICATES THAT SUCH LEAKS ARE RARE AND DO NOT SHOW EVIDENCE OF AN INCREASING TREND. ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES. SEE DOCUMENT FILE FOR ADDITIONAL INFORMATION REGARDING THIS RESUME.
ON JANUARY 4, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FUEL LEAKAGE FROM THE STEEL FUEL STORAGE TANK IN CERTAIN MODEL YEAR 1999-2000 KIA SPORTAGE VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON JANUARY 25, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER KIA SPORTAGE VEHICLES.ODI IS AWARE OF 40 NON-DUPLICATIVE COMPLAINTS THAT ALLEGE FUEL STORAGE TANK LEAKAGE IN THE SUBJECT VEHICLES.ANALYSIS OF MANUFACTURER DATA INDICATES THAT ALLEGED FUEL LEAKAGE AT OR NEAR THE STORAGE TANK MAY BE ATTRIBUTED TO SEVERAL DIFFERENT FAILURE MODES INVOLVING THE FUEL CONTAINMENT AND DISTRIBUTION SYSTEM.KIA HAS IDENTIFIED CORROSION AS A PRIMARY CAUSAL FACTOR RELATED TO FUEL STORAGE TANK COMPLAINTS AND CONTINUED FUEL SYSTEM PART SALES.ACCORDING TO KIA, FUEL TANK CORROSION CLAIMS RELATED TO LEAKAGE CAN BE DIVIDED INTO TWO CATEGORIES: LOWER TANK CLAIMS ASSOCIATED WITH EXTERIOR CORROSION DUE TO DISRUPTION OF THE POLYVINYL CHLORIDE (PVC) PROTECTIVE COATING AND UPPER TANK CLAIMS ASSOCIATED WITH CORROSION AT THE FUEL SENDING UNIT MOUNTING PLATE AREA.THE MANUFACTURER'S INVESTIGATION INTO ALLEGED FUEL TANK CORROSION RESULTING IN LEAKAGE IS ONGOING.ACCORDINGLY, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS (EA06-007) TO FURTHER STUDY THE FREQUENCY, SCOPE, AND SAFETY CONSEQUENCES OF THE ALLEGED DEFECT.
EA04007 · Seat Belt Buckle False Latch/malfunction
Opened Feb 27, 2004 · Closed Jul 26, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
THE MANUFACTURER HAS INITIATED A SAFETY RELATED CAMPAIGN TO RECALL THE SUBJECT VEHICLES FOR CORRECTION OF THE SEAT BELT BUCKLE DEFECT.THE CORRECTIVE ACTION IS TO REPLACE THE SEAT BELTS/BUCKLES.THIS SAFETY RECALL PROGRAM HAS BEEN ASSIGNED NHTSA CAMPAIGN NO. 04V305.
RQ03007 · Seat Belt Buckle False Latch/malfunction
Opened Oct 14, 2003 · Closed Feb 27, 2004
Status: closed (inferred from source dates) · Seat Belts:front:buckle Assembly
INFORMATION RECEIVED AND ANALYZED DURING THIS RQ DISCLOSED THAT MY 1999 AND 2000 KIA SEPHIA AND SPORTAGE VEHICLES WERE EQUIPPED WITH MODIFIED VERSIONS OF THE SAME SAFETY BELT LATCH ASSEMBLY AS THOSE RECALLED IN CAMPAIGN NO. 02V-216.THESE LATCH ASSEMBLIES WERE IDENTIFIED AS TYPE A97. ODI ANALYSES INDICATE A CONTINUING TREND OF CONSUMER COMPLAINTS FOLLOWING A SERIES OF DESIGN MODIFICATIONS MADE BY KIA TO IMPROVE THE A97 LATCH ASSEMBLY.MY 2001 AND 2002 SUBJECT VEHICLES WERE EQUIPPED WITH DIFFERENT DESIGN LATCH ASSEMBLIES (TYPE DB-6 OR AUTOLIV) AND EXHIBIT A MUCH LOWER COMPLAINT COUNT.THIS RQ HAS BEEN UPGRADED TO AN EA IN ORDER TO FURTHER INVESTIGATE THIS MATTER FOR THE SUBJECT VEHICLES EQUIPPED WITH TYPE A97 LATCH ASSEMBLIES.
DP02006 · Vehicle Rollover
Opened Jun 5, 2002 · Closed Sep 23, 2002
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
PE00026 · Incorrect Battery JUMP-START
Opened Jul 10, 2000 · Closed Jul 31, 2000
Status: closed (inferred from source dates) · Electrical System
ALLEGE BATTETY MAY EXPLODE IF OWNER'S ATTEMPT TO JUMP-STATE THE VEHICLE BY FOLLOWING THE OWNER'S MANUAL DIAGRAM
Illustration