IllustrationTHE CAR RANDOMLY STARTS. WHEN THE CAR IS FINALLY STARTED SOMETIMES THE POWER STEERING GOES OUT, THE WINDOWS RANDOMLY ROLL DOWN, THE LOCKS RANDOMLY LOCK AND UNLOCK THEMSELVES. I HAVE TAKEN THE CAR TO SEVERAL MECHANIC SHOPS INCLUDING ELECTRICAL SPECIALIST AND THE DEALERSHIP. NONE OF THEM ARE ABLE TO DETERMINE WHAT THE PROBLEM IS.
2008 Kia Spectra
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2008 Kia Spectra do not stand out strongly from the model-year median of 96.
About this comparison →How this year compares
Owner complaints by model year
Compare all Spectra years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1225–50K
1550–75K
1775–100K
24100–150K
5150K+
93 reports with mileage · 28 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Air Bags. Review the 61 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 15 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports3 fire reports16 injury reports
Electrical System complaints
14 reportsTL* THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE DRIVING AT VARIOUS SPEEDS, THE CRUISE CONTROL FAILED TO ENGAGE AND THE BRAKE LIGHTS FAILED TO ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURES RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STOP LAMP SWITCH FAILED A…
Read full complaint
TL* THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE DRIVING AT VARIOUS SPEEDS, THE CRUISE CONTROL FAILED TO ENGAGE AND THE BRAKE LIGHTS FAILED TO ILLUMINATE WHEN THE BRAKE PEDAL WAS DEPRESSED. THE FAILURES RECURRED CONTINUOUSLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE STOP LAMP SWITCH FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS TEMPORARILY REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V114000 (EXTERIOR LIGHTING, SERVICE BRAKES, HYDRAULIC). THE FAILURE MILEAGE WAS APPROXIMATELY 102,000. UPDATED 05/24/16*LJ
I BOUGHT MY 2008 KIA SPECTRA IN JUNE OF 2015. ABOUT A MONTH AFTER THE PURCHASE MY DOOR LOCKS STARTED ACTING UP OCCASIONALLY. NOW IT IS AN ALMOST EVERYTIME OCCURANCE. I WILL UNLOCK MY DOOR VIA KEY FOB, AND IT WILL INSTANTLY, AND AUTOMATICALLY, RELOCK ITSELF(ALL DOORS). WHEN IT DOES DECIDE TO UNLOCK, AND STAY THAT WAY UNTIL I ENTE…
Read full complaint
I BOUGHT MY 2008 KIA SPECTRA IN JUNE OF 2015. ABOUT A MONTH AFTER THE PURCHASE MY DOOR LOCKS STARTED ACTING UP OCCASIONALLY. NOW IT IS AN ALMOST EVERYTIME OCCURANCE. I WILL UNLOCK MY DOOR VIA KEY FOB, AND IT WILL INSTANTLY, AND AUTOMATICALLY, RELOCK ITSELF(ALL DOORS). WHEN IT DOES DECIDE TO UNLOCK, AND STAY THAT WAY UNTIL I ENTER THE VEHICLE, AS SOON AS I OPEN THE DRIVERS DOOR ALL DOORS WIL LOCK. I FIND THIS QUITE ANNOYING, AND DANGEROUS DUE TO THE FACT THAT I HAVE A CHILD, AND A WIFE, AND I WOULD RATHER NOT HAVE MY VEHICLE PREVENT THEM FROM ENTERING, OR EXITING THE VEHICLE SAFETLY. I HAVE BEEN IN TOUCH WITH KIA DEALERS AND HAVE BEEN TOLD THAT IT WILL BE A 300-750 DOLLAR FIX, AND KIA MOTORS THEMSELVES STATED THAT SOME SPECTRA'S HAVE THIS ISSUE, BUT MINE DOES NOT BECAUSE THERE IS NO SERVICE CAMPAIGN FOR MY VIN.
DASHBOARD AIRBAG LIGHT ILLUMINATED, AND NOTHING I TRIED--SCANNER, CALLING THE DEALER, AND INSPECTING IT MYSELF--SEEMS TO BE ADDRESSING THE ISSUE. I SEE MULTIPLE PEOPLE ARE EXPERIENCING SIMPLER SYMPTOMS. THE LIGHT ILLUMINATES AS USUAL UPON IGNITION AND SHUTS OFF AS NORMAL. IT THEN COMES BACK ON AROUND 10 TO 20 SECONDS AFTER THE C…
Read full complaint
DASHBOARD AIRBAG LIGHT ILLUMINATED, AND NOTHING I TRIED--SCANNER, CALLING THE DEALER, AND INSPECTING IT MYSELF--SEEMS TO BE ADDRESSING THE ISSUE. I SEE MULTIPLE PEOPLE ARE EXPERIENCING SIMPLER SYMPTOMS. THE LIGHT ILLUMINATES AS USUAL UPON IGNITION AND SHUTS OFF AS NORMAL. IT THEN COMES BACK ON AROUND 10 TO 20 SECONDS AFTER THE CAR STARTS, AND IT DOES NOT SHUT OFF UNTIL I TURN OFF THE CAR. THE IT SOUNDS LIKE A WARRANTY ISSUE.
TL* THE CONTACT OWNED A 2008 KIA SPECTRA. WHILE DRIVING AT APPROXIMATELY 40 MPH, THERE WAS AN ABNORMAL NOISE AND SUDDENLY THERE WAS SMOKE INSIDE OF THE VEHICLE. THE CONTACT VEERED TO THE SIDE OF THE ROAD AND THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE AND A POLICE REPORT WER…
Read full complaint
TL* THE CONTACT OWNED A 2008 KIA SPECTRA. WHILE DRIVING AT APPROXIMATELY 40 MPH, THERE WAS AN ABNORMAL NOISE AND SUDDENLY THERE WAS SMOKE INSIDE OF THE VEHICLE. THE CONTACT VEERED TO THE SIDE OF THE ROAD AND THE VEHICLE BECAME ENGULFED IN FLAMES. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FIRE. A FIRE AND A POLICE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 67,500. ACCORDING TO THE LETTER FROM THE CONSUMER'S LAWYER, THE VEHICLE WAS DESTROYED BY AN ELECTRICAL FIRE ARISING UNDER THE DASHBOARD, APPARENTLY FROM THE BLOWER/VENTILATION SYSTEM. UPDATED 09/14/15. *JB MA 10/5 STATUS UPDATED 11/19/15.*JB THE CONSUMER STATED THE MANUFACTURER DENIED ANY LIABILITY. THEY BLAMED THE FIRE ON A PAST INCIDENT, WHERE THE VEHICLE WAS FILLED WITH TOO MUCH OIL. UPDATED 04/25/16.*JB *CN
TL*THE CONTACT OWNS A 2008 KIA SPECTRA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A KNOCKING NOISE EMITTED FROM THE FRONT DRIVER SIDE OF THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE FRONT DRIVER SIDE WINDOW FAILED TO ROLL DOWN. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 8…
Read full complaint
TL*THE CONTACT OWNS A 2008 KIA SPECTRA. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, A KNOCKING NOISE EMITTED FROM THE FRONT DRIVER SIDE OF THE VEHICLE. ALSO, THE CONTACT MENTIONED THAT THE FRONT DRIVER SIDE WINDOW FAILED TO ROLL DOWN. THE VIN WAS NOT AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 85,000. UPDATED 4/15/15*CN UPDATED 9/28/2017*CN
I WAS DRIVING NORMALLY GOING 45 MPH ON A RURAL STREET USING MY CRUISE CONTROL. WHEN I WAS COMING UP TO THE STOP, I HIT THE BRAKES TO SLOW DOWN, AND THE ENGINE IMMEDIATELY ACCELERATED. I SLAMMED ON THE BRAKES AND THE ENGINE RAN FASTER. I PUT THE CAR IN NEUTRAL (THE ENGINE RPMS RED-LINED), AND TURNED THE KEY OFF AND THE VEHICLE…
Read full complaint
I WAS DRIVING NORMALLY GOING 45 MPH ON A RURAL STREET USING MY CRUISE CONTROL. WHEN I WAS COMING UP TO THE STOP, I HIT THE BRAKES TO SLOW DOWN, AND THE ENGINE IMMEDIATELY ACCELERATED. I SLAMMED ON THE BRAKES AND THE ENGINE RAN FASTER. I PUT THE CAR IN NEUTRAL (THE ENGINE RPMS RED-LINED), AND TURNED THE KEY OFF AND THE VEHICLE SLOWED UNDER NORMAL BRAKING. I STARTED THE VEHICLE BACK UP, AND TESTED THE PROBLEM. THE CRUISE CONTROL WAS NOT DISENGAGING WITH THE BRAKE PEDAL. WHEN I GOT HOME, I CHECKED THE BRAKE LIGHTS, AND THEY WERE NOT WORKING. I BOUGHT A REPLACEMENT SWITCH AND THE BRAKE LIGHTS WORK WITH THE REPLACEMENT SWITCH. IF I HAD NOT APPLIED THE BRAKES FAR ENOUGH IN ADVANCE, I AM CERTAIN THAT I WOULD HAVE GONE THROUGH THE BUSY INTERSECTION AND CAUSED A MAJOR ACCIDENT. *TR
I DRIVE A 2008 KIA SPECTRA. I'VE OWNED THE CAR FOR ROUGHLY 4 YRS. WITHIN THE LAST MONTH MY CAR CONTINUES TO STALL. THIS OCCURS GENERALLY WHEN I'M COMING TO A STOP AND TURNING. THE DASH LIGHTS WILL ALL COME ON AND MY WHEEL LOCKS UP IN THE DIRECTION I WAS TURNING. WHEN I TURN MY CAR OFF AND TURN IT BACK ON, THE LIGHTS WILL TURN OF…
Read full complaint
I DRIVE A 2008 KIA SPECTRA. I'VE OWNED THE CAR FOR ROUGHLY 4 YRS. WITHIN THE LAST MONTH MY CAR CONTINUES TO STALL. THIS OCCURS GENERALLY WHEN I'M COMING TO A STOP AND TURNING. THE DASH LIGHTS WILL ALL COME ON AND MY WHEEL LOCKS UP IN THE DIRECTION I WAS TURNING. WHEN I TURN MY CAR OFF AND TURN IT BACK ON, THE LIGHTS WILL TURN OFF, BUT MY RPM'S REV UP TO A MINIMUM OF 3. I HAVE TAKEN THE VEHICLE TO TWO AUTO MECHANICS. THEY HAVE CHANGED A FUEL TEMP. SENSOR AND SWITCHED OUT ALL MY SPARK PLUGS. BOTH MECHANICS HAVE PLUGGED THE VEHICLE UP TO THE MACHINE AND IT READS CLEAR. THEY CANNOT FIND AN ISSUE WITH THE VEHICLE. SINCE THE VEHICLE ACTS UP RANDOMLY, THEY ARE UNABLE TO IDENTIFY THE PROBLEM WHEN IT'S IN THEIR POSSESSION. *TR
THE DOOR LOCKS BEGAN RANDOMLY NOT WORKING WHEN USING THE DOOR LOCK/UNLOCK BUTTONS ON BOTH THE DRIVER SIDE, AS WELL AS THE FRONT PASSENGER SIDE. THERE DOES NOT SEEM TO BE A PROBLEM WHEN USING THE KEY FOB. I MENTIONED THIS PROBLEM TO MY LOCAL KIA DEALER WHO BRUSHED IT OFF. NOW, 2 YEARS LATER, IT HAS GOTTEN WORSE. I CAN RARELY UNLO…
Read full complaint
THE DOOR LOCKS BEGAN RANDOMLY NOT WORKING WHEN USING THE DOOR LOCK/UNLOCK BUTTONS ON BOTH THE DRIVER SIDE, AS WELL AS THE FRONT PASSENGER SIDE. THERE DOES NOT SEEM TO BE A PROBLEM WHEN USING THE KEY FOB. I MENTIONED THIS PROBLEM TO MY LOCAL KIA DEALER WHO BRUSHED IT OFF. NOW, 2 YEARS LATER, IT HAS GOTTEN WORSE. I CAN RARELY UNLOCK THE DOORS USING THE BUTTONS. I WOULD THINK THIS IS A SAFETY ISSUE IF I WAS UNABLE TO GET OUT OF MY CAR IN THE EVENT OF AN ACCIDENT OR FIRE. I AM NOT SURE IF THIS WOULD BE COVERED UNDER WARRANTY. THE CAR IS LESS THAN 10 YEARS OLD AND HAS JUST UNDER 73,000 MILES. *TR
TL*THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE TRAVELING AT 20 MPH THE CONTACT NOTICED BLACK SMOKE COMING INSIDE THE VEHICLE FROM THE AIR VENTILATION SYSTEM. SHE PULLED OVER TO THE SIDE OF THE ROAD AND SHUT THE ENGINE OFF. A LOUD CLICKING SOUND COULD BE HEARD COMING FROM THE ENGINE. AFTER EXAMINING THE FRONT END OF THE VEHICLE AN…
Read full complaint
TL*THE CONTACT OWNS A 2008 KIA SPECTRA. WHILE TRAVELING AT 20 MPH THE CONTACT NOTICED BLACK SMOKE COMING INSIDE THE VEHICLE FROM THE AIR VENTILATION SYSTEM. SHE PULLED OVER TO THE SIDE OF THE ROAD AND SHUT THE ENGINE OFF. A LOUD CLICKING SOUND COULD BE HEARD COMING FROM THE ENGINE. AFTER EXAMINING THE FRONT END OF THE VEHICLE AND FINDING NO SIGNS OF A FIRE OR SMOKE THE CONTACT RE ENTERED THE VEHICLE AND NOTICED THAT FLAMES WERE COMING OUT FROM UNDER THE DASHBOARD AND STEERING WHEEL. THE FIRE DEPARTMENT WAS CALLED TO EXTINGUISH THE FIRE AND A FIRE REPORT WAS FILED FOR THE INCIDENT. THE VEHICLE WAS DESTROYED. THE FAILURE AND CURRENT MILEAGES WERE 91,000.
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE15031 · Occupant Classification System
Opened Sep 1, 2015 · Closed Feb 11, 2016
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Additional source detail variants (4)
Air Bags:frontal
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:frontal:sensor/control MODULE-INACTIVE
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,
Air Bags:sensor:occupant Classification
The subject vehicle population is MY 2007-2009 Kia Spectra vehicles.Consumers report that the SRS (air bag) warning light is illuminated in their vehicle.The focus of the investigation was the failure of the front seat passenger Occupant Classification System (OCS) sensor mat.This sensor mat is embedded in the front passenger seat cushion and is intended to detect child seats and small statured occupants who could be harmed by deployment of the passenger frontal air bag.The OCS may develop a failure due to an open circuit in the sensor mat caused by the mat cracking during use.An open circuit in the OCS sensor mat is detected as a fault in the system by the air bag diagnostic. A trouble code will then be stored in the air bag control unit and the air bag warning light will be illuminated.If this fault is detected, the OCS will not suppress the front passenger air bag and in a crash of sufficient severity the front passenger air bag will deploy regardless of the nature or size of the child seat or occupant in the front passenger seat.The report counts shown above include only those reports that specifically address the issue covered by this investigation, failure of the OCS sensor mat.Reports alleging only that the ?air bag light is on with no cause stated, or where no cause was otherwise identified, were excluded as the air bag light could be illuminated for system faults other than an OCS malfunction.Kia's assessment was that the cracking was caused by owner abuse.The subject vehicles have been in service for an average of approximately eight (8) years.An analysis of Kia's warranty data for the subject vehicles, including a comparison with other agency and manufacturer data pertaining to similar OCS failure investigations, indicates that the subject vehicles experience a comparatively low complaint rate for this issue given the number of years the vehicles have been in service.Kia has implemented an extended warranty program for the OCS sensor mat providing for free replacement for 15 years regardless of vehicle mileage and will send owners of the subject vehicles letters notifying them of the potential hazards posed by OCS failure as well as the terms of the extended warranty.Consumers whose air bag warning light is illuminated will have the opportunity to have their vehicle diagnosed and, if a fault is indicated, have the OCS sensor mat repaired at no charge.In view of the comparatively low complaint rate and Kia's implementation of an extended warranty with owner notification, ODI has tentatively concluded that the actions taken by Kia mitigate any unreasonable risk to safety posed by OCS sensor mat failures in the subject vehicles.Accordingly, the investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the agency reserves the right to take additional action if warranted by new circumstances.Details on Kia's extended warranty program, including a copy of both Kia's letter to the consumer and Kia's letter to their dealers, for the subject vehicle population will be available in the public file for this investigation. The ODI reports cited above can be viewed at http://www?odi.nhtsa.dot.gov/owners/ SearchNHTSAID under the following identification (ODI) numbers: 10789130, 10787308, 10785138, 10777856, 10765359, 10745773, 10746133, 10745528, 10721336, 10715846, 10712140, 10712046, 10706009, 10705387, 10681321, 10677080, 10673071, 10654873, 10654522, 10652472, 10651525,10643205, 10639671, 10638251, 10627289, 10621507, 10620724, 10615883, 10609000, 10607838, 10606252,10577842, 10568029, 10564527, 10561224,