Engine. Review the 551 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Exterior Lighting. Review the 130 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 98 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

33 crash reports69 fire reports24 injury reports

Engine complaints

551 reports

Clear category filter

132,000 miles · May 9, 2023

Engine

Read full complaint

The contact owns a 2014 Kia Soul. The contact received notification of the NHTSA Campaign Number: 20V750000 (Engine) however, the contact stated that while driving at an undisclosed speed, she smelled a burning odor then the oil warning light illuminated. The vehicle was taken to a Valvoline Service Center where an oil change was performed; however, the failure recurred. The contact stated that while the accelerator pedal was depressed, the vehicle failed to respond, with the check engine warning light illuminated. The vehicle was then taken to the dealer where it was diagnosed that the spark plugs, an engine flush, and the valve cover gasket needed to be replaced; however, the failure recurred. The vehicle was taken back to the dealer where it was determined that the vehicle needed to be taken back to Valvoline where the oil change was performed. The vehicle was taken back to Valvoline where the oil type was changed, and the vehicle diagnosed and determined that the exhaust needed to be replaced. The vehicle was repaired; however, the contact stated that while the accelerator pedal was depressed, the RPMs rapidly increased to 4,000 but the vehicle failed to respond. The check engine warning light illuminated, and an alert illuminated on the touch screen that displayed “Engine compartment failure emergency contact Kia”. The vehicle was taken back to the dealer where it was diagnosed that the ignition coils and wiring harness needed to be replaced. Additionally, the knock sensor detection system (KSDS) software was upgraded; however, the failure recurred. No warning lights were illuminated. The contact notified the dealer of the failure, and the contact was informed that due to the check engine warning light not being illuminated, the vehicle could not be diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was provided a case number and advised to take the vehicle back to the dealer, but no further assistance was provided. The failure mileage was approximately 132,

NHTSA ODI #11521134

116,119 miles · May 8, 2023

EngineVehicle Speed Control

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated that while driving at low speeds, the accelerator pedal was depressed but the vehicle failed to respond. The brake pedal was depressed to the floorboard. The vehicle was slow to respond and failed to move. After the vehicle responded, the vehicle failed to exceed 35 MPH. The check engine warning light was illuminated. The vehicle was taken to the local dealer where it was diagnosed that the heat sensor and protector shield needed to be replaced. The vehicle was repaired but the failure persisted. The manufacturer was contacted but no additional assistance was provided. The failure mileage was approximately 116,119.

NHTSA ODI #11520973

Mileage unknown · May 2, 2023

Electrical SystemEngine

Read full complaint

I brought my vehicle into an authorized dealer when my check engine light came on, having just been made aware of the recall notice when I took it in for an oil change earlier that day. He said the recall came about when cars of my make/model/year started catching fire out of nowhere due to engine issues. Given that my car is still under the mileage warranty, at 95k miles, the person at the dealership service center said it would likely be covered & the recall would qualify me for a new engine altogether. I got a call back a few days later that my catalytic converter was plugged, and that I would owe just under $3000 for the repair, as my vehicle did not show the correct diagnostic code to be covered. Once I spoke with KIA's corporate consumer satisfaction line, they agreed to bring the car out & retest it. The woman from the service center informed me that the whole engine does in fact need to be replaced now, not just the converter as they initially said, but that it still isn't spitting out the code necessary during diagnostic testing, to qualify it for a recall replacement. Under SC176, my issues exactly are being described as the symptoms & causation for the recall, and yet the diagnostic code does not match. My car is currently still at the dealership's service center, and I am getting some consultation as to whether or not this is a fix that's worth it, at this point.

NHTSA ODI #11520017

146,000 miles · May 1, 2023

EngineEngine And Engine Cooling

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate. The check engine warning light was illuminated. The contact related the failure to NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The vehicle was taken to the dealer, who informed the contact the catalytic converter needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 146,000.

NHTSA ODI #11519840

Mileage unknown · Apr 27, 2023

EnginePower TrainUnknown Or Other

Catalytic Converter malfunction and it was check by my mechanic at Hillebrand Automotive. It causes my 2014 Kia Soul to stop running in the middle of the highway. There were no warning lights, massages or any other symptoms of the problem prior to the failure. This happened 3 months ago. On January 21, 2023. It's still down beca…

Read full complaint

NHTSA ODI #11519239

94,000 miles · Apr 24, 2023

EngineEngine And Engine Cooling

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated that while driving at various speeds and depressing the accelerator pedal, the vehicle jerked significantly and hesitated to respond. The contact stated that the failure occurred while driving under 40 MPH. The check engine warning light was illuminated. Additionally, the contact stated that the vehicle would jerk while at a complete stop. The vehicle was taken to the dealer where it was diagnosed that the catalytic converter needed to be replaced. The dealer informed the contact that the manufacturer declined to cover the repair as the vehicle had passed the bearing clearance test. The contact related the failure to the NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling); however, the VIN was not included. The vehicle was not repaired. The failure mileage was approximately 94,000. The VIN was unavailable.

NHTSA ODI #11518736

Mileage unknown · Apr 20, 2023

Electrical SystemEngineFuel/propulsion System

Read full complaint

Since I bought this car, I have experienced hesitation, stalling, high RPM idle, fluctuating idle, burning smell, lurching, running though gas very fast (not due to increased driving), engine noises, dash panel half lighting up, hard to accelerate when the headlights are on, or heat, or air con, odd noises..and through this entire time, check engine light comes on and off and on and off...along with my gas gauge saying empty when its full. I have reported ALL of this throughout the entire time since all bought it. Every single time they say "software update" and send me home with nothing ever fixed. EVER. Now again check engine and false fuel reading, hesitations, etc....again! This engine and fuel pump is bad and explains all of my complaints since 10kmiles. My car has under 80k mi on it, its been a lemon from the start. Hesitation with no pick-up at an intersection and noises....just beyond dangerous. I have not driven my car on the freeway in 5 years because itis not safe, but Kia NEVER checks out problems. They charge for inspection and say "software update". Its maddening.

NHTSA ODI #11518079

Mileage unknown · Apr 13, 2023

Engine

Read full complaint

I own a 2014 Kia soul with 78000 miles. Engine light came on just changed my oil it was almost dry. I’m going through 2 quarts every two weeks due to KIAS power train warranty of 100000 miles I was sold on as a second owner. The dealer will not cover to replace the engine since the second owner warranty is inky warranted at 60k. Millions of people owning Kia’s are now trashing their cars because of this horrible situation! It’s in the courts I’m sure you know. This is criminal my safety and those behind me are at dramatic risk if my car fails on the highway which they are! I want this investigated for my safety. Several calls to Kia corporate no answer!

NHTSA ODI #11516954

Mileage unknown · Apr 3, 2023

EngineFuel/propulsion SystemPower TrainFire

Read full complaint

check engine light came on the evening of 3/08/2023. Auto zone said it was a knock sensor code and was listed as a recall. Next morning while driving on highway to ft Wayne Kia dealership my car engine lost rpm while driving at 65 mph on i-69 chapel exit in ft Wayne indiana. The car engine compartment almost immediately ignited into flames with an explosion. Driver barely got out before fire was in the dash. The front interior dash and front seat areas were caught on fire. Shrapnel blown from car started a grass fire as well. The fire department arrived to get both fires under control. My car was still under warranty at 108 months and 89,000 miles. Never had any problem with my Soul until that next day after light came on. I was not notified of the recalls except only recently received an airbag recall on 3/30/2023. I have contacted Kia to file a claim with them.

NHTSA ODI #11515317

127,000 miles · Mar 9, 2023

Engine

Read full complaint

The contact owns a 2014 Kia Soul. The contact stated that the vehicle was consuming an excessive amount of engine oil. The contact stated that oil had to be added once every month. The contact then received notification of NHTSA Campaign Number: 20V750000 (Engine) and the vehicle was taken to the dealer to be inspected. The contact stated that a software update was performed. The contact stated that shortly after receiving the repair, while driving approximately 75 MPH, the vehicle suddenly shifted into LIMP Mode. The contact stated that the vehicle decelerated to 20 MPH. The vehicle was taken to the dealer where it was determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and informed the contact that due to the warranty limitations and recall repairs that were performed, the engine would not be replaced free of charge. The approximate failure mileage was 127,000.

NHTSA ODI #11511033

Official recalls

22V096000 · Air Bags: Air Bag/restraint Control Module:software; Air Bags:frontal

Feb 18, 2022

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence & remedy

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

Remedy: Dealers will update the ACU software, free of charge. Owner notification letters were mailed April 4, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC229.

Additional source detail variants (2)

Air Bags: Air Bag/restraint Control Module:software

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

Remedy: Dealers will update the ACU software, free of charge. Owner notification letters were mailed April 4, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC229.

Air Bags:frontal

Kia Motors America (Kia) is recalling certain 2014 Soul vehicles. The front air bags may not deploy during a crash if the Air Bag Control Unit (ACU) loses communication with the front impact sensors.

Consequence: Front air bags that do not deploy as intended can increase the risk of injury in a crash.

20V750000 · Engine

Dec 2, 2020

Kia Motors America (Kia) is recalling certain 2012-2013 Sorento, 2012-2015 Forte and Forte Koup, 2011-2013 Optima Hybrid, 2014-2015 Soul, and 2012 Sportage vehicles. An engine compartment fire can occur while driving.

Consequence & remedy

Consequence: An engine compartment fire increases the risk of injury.

Remedy: Kia will notify owners, and dealers will inspect the engine compartment for fuel and/or engine oil leaks, perform an engine test and make any repairs, including engine replacement, as necessary, free of charge. In addition, Kia dealers will update the Knock Sensor Detection System (KSDS) software, free of charge. The recall began January 27, 2021. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC200.

19V120000 · Engine; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Feb 22, 2019

Kia Motors America (Kia) is recalling certain 2012-2016 Kia Soul vehicles equipped with 1.6L Gasoline Direct Injection (GDI) engines. High exhaust gas temperatures may damage the catalytic converter, possibly resulting in abnormal engine combustion and damage to one or more of the engine's pistons and possible piston connecting rod failure.

Consequence & remedy

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Additional source detail variants (2)

Engine

Consequence: Piston damage may result in an engine stall, increasing the risk of a crash. A broken connecting rod may puncture the engine block allowing engine oil to escape. The leaking oil may contact the exhaust, increasing the risk of a fire.

Remedy: Kia will notify owners, and dealers will upgrade the Catalytic Overheating Protection Engine Control Unit logic to prevent overheating of the catalytic converter. In addition, the catalytic converter will also be replaced if it has been damaged. Depending on the extent of any damage, the engine may also be replaced, free of charge. The recall began April 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC176.

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

17V608000 · Steering

Sep 29, 2017

Kia Motors America (Kia) is recalling certain 2014-2016 Soul and Soul EV vehicles. The pinion plug may allow the pinion gear to separate from the steering gear assembly.

Consequence & remedy

Consequence: If the pinion gear separates, steering will be lost, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will inspect and secure the pinion plug or replace the steering gear assembly, as necessary, free of charge. The recall began November 16, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC155. Note: This recall supersedes campaigns 14V-332 and 15V-736. Vehicles previously remedied under those numbers are being recalled again under this campaign.

15V123000 · Vehicle Speed Control:accelerator Pedal

Mar 2, 2015

Kia Motors America (Kia) is recalling certain model year 2014-2015 Soul and Soul electric vehicles manufactured July 21, 2013, to January 8, 2015. A section of the accelerator pedal may bend and fracture.

Consequence & remedy

Consequence: If the vehicle has a bent or broken accelerator pedal, the driver may have difficulty accelerating the vehicle, increasing the risk of a crash.

Remedy: Kia will notify owners, and dealers will add a supporting rubber underneath the pedal stopper, free of charge. The recall began on March 24, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC116.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21003 · Engine Fires

Opened Dec 22, 2021 · Closed Feb 5, 2024

Status: closed (inferred from source dates) · Engine

On March 29, 2019, the Office of Defects Investigation (ODI) opened two Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) to broadly investigate incidents of non-crash fires (regardless of origin or operational status of the vehicle) on various model year Hyundai and Kia vehicles. During the PE investigations, Hyundai and Kia issued several recalls to address vehicle fires, including those due to engine failures involving various engine types. The remedies for the engine failure recalls typically involve engine inspection (to detect existing damage), and if necessary, engine replacement. Additionally, both manufacturers have been installing an engine control software modification known as Knock Sensor Detection Software (KSDS) which is intended to detect impending engine failure, alert the driver, and limit engine power (to lessen likelihood of engine failure).KSDS is being installed under recalls and non-safety field actions, and both companies have extended limited engine warranties (see recall files). On December 22, 2021, ODI upgraded PE19-003 and PE19-004 to this Engineering Analysis (EA21-003, covering both Hyundai and Kia) to evaluate the scope of the prior recalls related to engine failures/fires and the efficacy of the recall remedies for the recalls, as well as the long-term viability of related programs and non-safety field actions being conducted by Hyundai and Kia. The former issue involved approximately 550,000 MY 2013 Hyundai Elantra, MY 2011 Kia Sorento, and MY 2012-2015 Kia Rio. The latter issue involved approximately 2.5 million recalled vehicles, which have been identified as displaying potential remedy concerns: Hyundai recalls 15V-568, 17V-226, 20V-746, and 21V-727; and Kia recalls 17V-224, 19V-120, 20V-750, and 21V-844. Regarding the recall scope issue, among all of the scope vehicles identified at EA opening, ODI found only the MY 2011 Kia Sorento vehicles equipped with both the Theta II 2.4L 4-cylinder Multi-Point Injection (MPI) and the Lambda II 3.5L 6-cylinder MPI engines experienced relatively high rates of reported fires. In December 2023, Kia issued recall 23V-877 that will cover about 80,000 MY 2011 Kia Sorento vehicles equipped with the Theta II 2.4L MPI engines. The remedy will involve an inspection, and if necessary, a replacement of the engine, as well as the installation of KSDS. It should be noted that in 2021 these vehicles were included in a KSDS product improvement campaign with warranty extension. For the MY 2011 Sorento vehicles equipped with the Lambda II 3.5L engines, ODI believes that future engine failures/fires involving these vehicles will likely be due to a lax in adhering to the proper or scheduled engine maintenance (regular engine oil changes), rather than a design or manufacturing engine issue. Regarding the issue of the efficacy of the recall remedies, ODI found the majority of the recalled Hyundai and Kia vehicles, by model, experienced lower reported fire rates after the remedies were applied. Furthermore, ODI found that for most vehicles that did not receive the recall remedies, by model, experienced relatively high fire rates. To address this problem, Hyundai informed ODI in December 2023, that it will renotify all of its owners covered by the Hyundai recalls of engine failures/fires every 8 months for the next 3 years. In December 2023, Kia stated that it will renotify the majority of its owners every 8 months for the next 3 years.Several previously recalled Kia models are excluded from the renotification due to their lower reported rates of engine fires. Overall, the renotification actions will help to increase the recall completion rates, thus reduce the frequency of engine fires in the future. In view of the recall action being taken by Kia and renotification actions being taken by both Kia and Hyundai, ODI is closing this Engineering Analysis. Also, both companies have been released from the 2020-iniated Consent Orders (Kia since November 2022 and Hyundai since November 2023). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

PE19004 · Non-crash Vehicle Fires

Opened Mar 29, 2019 · Closed Dec 22, 2021

Status: closed (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring:front Underhood; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting; Exterior Lighting:back Up Lights; Exterior Lighting:back Up Lights:switch; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

During this Preliminary Evaluation (PE), the Office of Defects Investigation (ODI) assessed the scope, frequency and potential safety-related consequences of non-crash vehicle fires caused by both engine failures and failures of other vehicle systems/components in model year (MY) 2011-2014 Kia Optima, MY 2011-2014 Kia Sorento and MY 2010-2015 Kia Soul vehicles equipped with Theta II, Gamma, Nu and Lambda II engines (approximately 1.7 million vehicles). ODI also reviewed field and other data on other Kia vehicles (approximately 3.6 million additional vehicles) equipped with the same engines used in the above-mentioned vehicles.As a result of this PE, Kia has issued NHTSA Recalls 20V-750 and 21V-844 to address potential engine failures and fires in certain Kia vehicles equipped with various engine types.Additional information on these and other related recall actions is available in the downloadable version of this resume available at NHTSA.gov.In addition, ODI has upgraded this PE to an Engineering Analysis (EA) 21-003 which will focus on potential recall scope concerns and recall remedy concerns related to the engine failure-related recalls mentioned above and conducted previously.See the EA21-003 Opening Resume available at NHTSA.gov for more information.Also available in the downloadable version of this resume is a list of the reference numbers for the 444 ODI reports, or Vehicle Owner Questionnaires (VOQs), cited above which ODI received through mid-November 2021.Note that the Manufacturer reports cited above are customer complaints received through March 2019.

Additional source detail variants (392)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:back Up Lights

Exterior Lighting:back Up Lights:switch

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal:switch

Unknown Or Other

DP18003 · Non-crash Vehicle Fires

Opened Aug 21, 2018 · Closed May 10, 2019

Status: closed (inferred from source dates) · Electrical System; Electrical System: Instrument Cluster/panel; Electrical SYSTEM:12V/24V/48V Battery; Electrical SYSTEM:12V/24V/48V Battery:cables; Electrical System:alternator/generator/regulator; Electrical System:ignition; Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module; Electrical System:ignition:module; Electrical System:ignition:switch; Electrical System:propulsion System:traction Battery; Electrical System:starter Assembly; Electrical System:starter Assembly:relay; Electrical System:starter Assembly:solenoid; Electrical System:wiring; Electrical System:wiring: Rear Compartment/trunk; Electrical System:wiring:front Underhood; Electrical System:wiring:fuses And Circuit Breakers; Electrical System:wiring:interior/under Dash; Engine; Engine And Engine Cooling; Engine And Engine Cooling:cooling System; Engine And Engine Cooling:cooling System:fan; Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings; Engine And Engine Cooling:cooling System:radiator Assembly; Engine And Engine Cooling:engine; Engine And Engine Cooling:engine:gasoline; Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys; Engine And Engine Cooling:engine:gasoline:turbo/supercharger; Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control ; Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor; Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv); Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve); Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Exterior Lighting:brake Lights; Exterior Lighting:brake Lights:switch; Exterior Lighting:fog Lights; Exterior Lighting:fog Lights:switch; Exterior Lighting:hazard Flashing Warning Lights; Exterior Lighting:hazard Flashing Warning Lights:switch; Exterior Lighting:hazard Flashing Warning Lights:unit; Exterior Lighting:headlights; Exterior Lighting:headlights:concealment Devices; Exterior Lighting:headlights:high/low Beam Dimmer Switch; Exterior Lighting:headlights:switch; Exterior Lighting:tail Lights; Exterior Lighting:tail Lights:switch; Exterior Lighting:turn Signal; Exterior Lighting:turn Signal:flasher Unit; Exterior Lighting:turn Signal:switch; Unknown Or Other

In a letter dated June 11, 2018, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a safety defect investigation into non-collision related fires on model year (MY) 2011-2014 Kia Optima and Sorento, and Hyundai Sonata and Santa Fe vehicles. In a letter dated July 24, 2018, CAS requested that MY 2010-2015 Kia Soul vehicles be added to the petition. CAS stated that there is a higher number of complaints to NHTSA regarding non-crash fires on these vehicles compared to other similar vehicles. The Office of Defects Investigation (ODI) had already opened Recall Queries (RQ17-003 and RQ17-004) on all Kia and Hyundai vehicles equipped with Theta II engines for engine failures that may cause stalling and fires.The queries cover most of the petition subject Optima, Sorento, Sonata, and Santa Fe vehicles but not any of the subject Soul vehicles.On August 21, 2018, ODI opened a Defect Petition (DP18-003) to evaluate whether to grant or deny the CAS petition. ODI sent Information Request letters to Kia and Hyundai (September and October 2018) requesting information on all engine and non-engine related fires in the petition vehicles.ODI performed extensive analysis on the information obtained from Kia and Hyundai. During the DP18-003 analysis, Kia and Hyundai each initiated three additional safety recalls related to engine compartment fires on certain petitioned and non-petitioned vehicles (nearly 740,000 total vehicles: Recalls 18V-907, 18V-934, 19V-101, 19V-063, 19V-120, and 19V-204). Based on ODI?s review of the applicable materials, including responses to Information Requests sent to multiple manufacturers, Vehicle Owner Questionnaires (VOQ), and Early Warning Data, NHTSA decided to grant the petition.The CAS petition was granted on March 29, 2019. Preliminary Evaluations (PE19-003 on Hyundai and PE19-004 on Kia) have been opened to assess the scope, frequency, and potential safety-related consequences of alleged defects relating to non-collision vehicle fires in the 2011-2014 Kia Optima and Sorento, 2011-2014 Hyundai Sonata and Santa Fe, and 2010-2015 Kia Soul.Attached is a list of the reference numbers for the 404 VOQs cited above.

Additional source detail variants (208)

Electrical SYSTEM:12V/24V/48V Battery:cables

Electrical SYSTEM:12V/24V/48V Battery

Electrical System:alternator/generator/regulator

Electrical SYSTEM:IGNITION:ANTI-THEFT:CONTROL Module

Electrical System:ignition

Electrical System:ignition:module

Electrical System:ignition:switch

Electrical System: Instrument Cluster/panel

Electrical System

Electrical System:propulsion System:traction Battery

Electrical System:starter Assembly

Electrical System:starter Assembly:relay

Electrical System:starter Assembly:solenoid

Electrical System:wiring:front Underhood

Electrical System:wiring:fuses And Circuit Breakers

Electrical System:wiring:interior/under Dash

Electrical System:wiring

Electrical System:wiring: Rear Compartment/trunk

Engine And Engine Cooling:cooling System:fan

Engine And Engine Cooling:cooling System:hoses/lines/piping/fittings

Engine And Engine Cooling:cooling System

Engine And Engine Cooling:cooling System:radiator Assembly

Engine And Engine Cooling:engine:gasoline:belts And Associated Pulleys

Engine And Engine Cooling:engine:gasoline

Engine And Engine Cooling:engine:gasoline:turbo/supercharger

Engine And Engine Cooling:engine

Engine And Engine Cooling:engine:other Fuel Types:turbo/supercharger

Engine And Engine Cooling:exhaust System:emission Control:catalytic Convertor

Engine And Engine Cooling:exhaust System:emission Control:crankcase (pcv)

Engine And Engine Cooling:exhaust System:emission Control:gas Recirculation Valve (egr Valve)

Engine And Engine Cooling:exhaust System:emission Control

Engine And Engine Cooling:exhaust System

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Engine And Engine Cooling

Engine

Exterior Lighting:brake Lights

Exterior Lighting:brake Lights:switch

Exterior Lighting:fog Lights

Exterior Lighting:fog Lights:switch

Exterior Lighting:hazard Flashing Warning Lights

Exterior Lighting:hazard Flashing Warning Lights:switch

Exterior Lighting:hazard Flashing Warning Lights:unit

Exterior Lighting:headlights:concealment Devices

Exterior Lighting:headlights:high/low Beam Dimmer Switch

Exterior Lighting:headlights

Exterior Lighting:headlights:switch

Exterior Lighting:tail Lights

Exterior Lighting:tail Lights:switch

Exterior Lighting:turn Signal:flasher Unit

Exterior Lighting:turn Signal

Exterior Lighting:turn Signal:switch

Unknown Or Other