2024 Kia Sorento

I've had a couple of issues with the electrical components. One time the drivers side door controls wouldn't roll down any of the windows or lock/unlock the doors. This is a safety issue if you needed to roll the windows down/up or lock the doors for the security of your vehicle. I've also had it where the infotainment system has cut out while driving. As far as I can tell, the vehicle could still drive but I was unsure for a minute because the engine kind of revved at the same time. There were no warning lights when the windows and locks didn't work.

The contact owns a 2024 Kia Sorento. The contact stated that during a routine oil change, the mechanic added an unknown oil additive to the vehicle. The contact stated that on several occasions while driving, the accelerator pedal was depressed, and the vehicle lost motive power and drove sluggishly. The vehicle was taken to a dealer for an oil change, and the mechanic observed metal shavings in the oil. The vehicle was taken to another dealer, but it had not yet been diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 31,000.

On August 6, 2025, I discovered that both the driver and passenger front seat belts in my 2024 Kia Sorento were installed backwards from the factory, with the buckle facing inward instead of outward. This defect has been present since the vehicle was purchased brand new, but it was only discovered and documented on this date. The issue was confirmed by an authorized Kia dealership in an official service report and in a video recorded by the service technician. I also have photos and videos taken before the dealership visit showing the same defect. This is a manufacturing defect and poses a serious safety risk to occupants in the event of a collision, as the seat belts may not function as intended. Supporting documentation is available upon request.

Vehicle hesitation, transmission slippage at low speeds for up shifting and hard shifting. Pulled out of a parking lot onto a main road from stop and my vehicle would not upshift and sounded like I was in neutral and would not accelerate. I had a vehicle behind me that almost rear ended me, I pulled over and had to put the vehicle in park. Once restarted, it would shift again.

Both Horn units need to be replaced . It's been confirmed by Safford Brown Kia in Manassas ,Virginia. The dealership did not have the parts and I have to wait 3 to 4 days for the parts to come in. In the meantime I have been driving the vehicle without an active horn because I was not given a loaner vehicle . I did call Kia Customer service whom stated that they are not aware of an open recall for my issue .

On March 19 I completed my 8,000 mile oil change and then drove to Florida. I had a warning light to change my oil since the company did not reset it. Unsure of the other warning lights. As I was driving in Florida on the interstate the car started having issues. It was making a noise, then started smoking and by the time I got off the exit and got out the front right of the car was in flames. I was transported to the ER with smoke inhalation. The car in still in Clermont, FL with no resolution. The car has been inspected by the insurance and a third party inspector. The last I was told the inspection report is with the Kia engineers. I am unaware at this point what the failure was that led to the fire. No response from Kia for over a month.

Driving on interstate during a partly cloudy day at 53 degrees going 65 mph. There were vehicles approximately half a mile away in the front of us and approximately 2 car lengths behind us with no noticeable debris on the road. Moon roof was fully extended and the moon roof exploded without warning (not due to rocks). It sounded like a gun shot went off and we were covered in glass.