NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
125 reportsClear category filter31,000 miles · Nov 13, 2020
Exterior Lighting
SINCE AUGUST 2019, I HAVE BEEN EXPERIENCING INTERMITTENT HEADLIGHTS FAILURE WHILE DRIVING AND THE HEADLIGHTS WAS SET ON AUTO. THE HEADLIGHTS WOULD SHUT OFF FOR 5-10 SECONDS UNEXPECTEDLY AND WILL TURN ON AGAIN. WHEN IT HAPPENS AGAIN THIS PAST SATURDAY (11/7) , I NOTICED WHEN THE HEADLIGHTS WENT OFF, ONLY THE HEADLIGHTS SYMBOL…
Read full complaint
SINCE AUGUST 2019, I HAVE BEEN EXPERIENCING INTERMITTENT HEADLIGHTS FAILURE WHILE DRIVING AND THE HEADLIGHTS WAS SET ON AUTO. THE HEADLIGHTS WOULD SHUT OFF FOR 5-10 SECONDS UNEXPECTEDLY AND WILL TURN ON AGAIN. WHEN IT HAPPENS AGAIN THIS PAST SATURDAY (11/7) , I NOTICED WHEN THE HEADLIGHTS WENT OFF, ONLY THE HEADLIGHTS SYMBOL WAS LIGHTED ON THE DASH. NORMALLY, WHEN THE HEADLIGHTS WERE SWITCHED ON AUTO BOTH THE FRONT AND REAR TAILLIGHTS AND HEADLIGHTS SYMBOL WOULD BE LIGHTED ON THE DASH. I HAVE SPOKEN TO FAIRFAX KIA SERVICE TECHNICIAN ABOUT THIS PROBLEM BUT SINCE THE PROBLEM COULD NOT BE REPRODUCED, HE WAS UNABLE TO RESOLVE THE ISSUE. IN REVIEWING YOUR SITE, IT APPEARS OTHER OWNERS OF 2017 KIA SORENTO HAVE HAD SIMILAR ISSUES WITH THE HEADLIGHTS SHUTTING OFF WHILE USING THE AUTO HEADLIGHTS FEATURE. I FEEL THIS IS A SERIOUS SAFETY CONCERN, THEREFORE, I AM HOPING YOUR AGENCY WILL INITIATE AN INVESTIGATION ON THE MATTER TO RESOLVE THE ISSUE BEFORE SOMEONE GETS SERIOUSLY INJURED OR DIE AS A RESULT OF THIS ISSUE.
NHTSA ODI #11374616
Mileage unknown · Nov 13, 2020
Exterior Lighting
MY 2017 KIA SORENTO HEADLIGHTS SHUT OFF FOR NO REASON WHEN I AM DRIVING. WHEN THEY ARE IN AUTO MODE THEY WILL TURN OFF FOLLOWED BY A WARNING ON MY SCREEN SAYING THEY HAVE SWITCHED FROM AUTO TO MANUAL. I HAVE TO TURN THE KNOB TO OFF THEN BACK ON. THEY ALSO SHUT OFF IN MANUAL MODE. THIS IS EXTREMELY DANGEROUS AND FRIGHTENING,ESPEC…
Read full complaint
MY 2017 KIA SORENTO HEADLIGHTS SHUT OFF FOR NO REASON WHEN I AM DRIVING. WHEN THEY ARE IN AUTO MODE THEY WILL TURN OFF FOLLOWED BY A WARNING ON MY SCREEN SAYING THEY HAVE SWITCHED FROM AUTO TO MANUAL. I HAVE TO TURN THE KNOB TO OFF THEN BACK ON. THEY ALSO SHUT OFF IN MANUAL MODE. THIS IS EXTREMELY DANGEROUS AND FRIGHTENING,ESPECIALLY WITH MY TODDLER IN THE BACK SEAT. I AM TOLD A TSB HAS BEEN STARTED AND POSSIBLY A CLASS ACTION LAWSUIT. WHEN WILL KIA DO A RECALL? ONE DEALERSHIP TOLD ME THEY HAVE NO IDEA WHAT IT COULD BE BECAUSE IT HASNT HAPPENED TO THEM, ANOTHER DEALERSHIP SAID THEY HAVE NEVER HEARD OF IT BUT ARE WILLING TO TAKE A LOOK TO SEE IF THEY CAN FIX THIS BUT I WILL HAVE TO PAY. THIS IS NOT RIGHT SINCE THIS IS A KIA DEFECT WITH MULTIPLE COMPLAINTS.
NHTSA ODI #11374578
43,000 miles · Sep 11, 2020
Exterior Lighting
TL* THE CONTACT OWNS A 2017 KIA SORENTO. THE CONTACT STATED THAT THE AUTO LIGHT SWITCH FAILED TO TURN OFF THE LIGHTS WHEN THE VEHICLE WAS SHUTOFF. THERE WAS NO WARNING LIGHT. THE FAILURE RECURRED TWICE. THE CONTACT STATED THAT ON ONE OF THE OCCASIONS IT RAINED. THE CONTACT CALLED THE GATEWAY KIA OF NORTH BRUNSWICK NJ DEALER LOCA…
Read full complaint
TL* THE CONTACT OWNS A 2017 KIA SORENTO. THE CONTACT STATED THAT THE AUTO LIGHT SWITCH FAILED TO TURN OFF THE LIGHTS WHEN THE VEHICLE WAS SHUTOFF. THERE WAS NO WARNING LIGHT. THE FAILURE RECURRED TWICE. THE CONTACT STATED THAT ON ONE OF THE OCCASIONS IT RAINED. THE CONTACT CALLED THE GATEWAY KIA OF NORTH BRUNSWICK NJ DEALER LOCATED AT 720 CAROLIER LN, NORTH BRUNSWICK TOWNSHIP, NJ 08902, AND WAS INFORMED TO TURN THE AUTO SWITCH TO THE OFF POSITION. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN TO THE SAME DEALER. THE TECHNICIAN CHECKED THE VEHICLE AND TOLD THE CONTACT THAT THERE WAS NOTHING WRONG WITH THE VEHICLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 43,000.
NHTSA ODI #11354387
75,335 miles · Aug 25, 2020
Electrical SystemExterior Lighting
WHILE IN THE AUTO POSITION AT RANDOM TIMES ALL MY EXTERIOR LIGHT WILL TURN OFF. I DRIVE A LOT FOR MY JOB. THE LAST TIME MY LIGHTS TURNED OUT WAS LAST NIGHT ON THE FREEWAY IN A RURAL AREA COMPLETE BLACK OUT. I QUICKLY TURNED THE SWITCH TO THE OFF POSITION AND THEN BACK TO AUTO. THIS HAS HAPPENED FEW TIME WITH IN THE LAST FEW WEE…
Read full complaint
WHILE IN THE AUTO POSITION AT RANDOM TIMES ALL MY EXTERIOR LIGHT WILL TURN OFF. I DRIVE A LOT FOR MY JOB. THE LAST TIME MY LIGHTS TURNED OUT WAS LAST NIGHT ON THE FREEWAY IN A RURAL AREA COMPLETE BLACK OUT. I QUICKLY TURNED THE SWITCH TO THE OFF POSITION AND THEN BACK TO AUTO. THIS HAS HAPPENED FEW TIME WITH IN THE LAST FEW WEEKS. A FEW MONTHS AFTER I PURCHASED THE CAR, I NOTICED THE TURN SIGNAL WOULD SWITCH TO THE OPPOSITE DIRECTION AFTER I COMPLETED MY TURN. THE TURN SIGNAL SWITCH WOULD BE IN THE NEUTRAL POSITION WHEN THIS OCCURRED. THIS ALSO HAPPENS INTERMITTENTLY, WHILE DRIVING CITY OR HIGHWAY. I CAN NOT TURN IT OFF. I HAVE TO WAIT UNTIL IT STOPS ON ITS OWN, WHICH LUCKILY HAS JUST BEEN THE SAME LENGTH OF TIME AS A LANE CHANGE.
NHTSA ODI #11351061
47,000 miles · Aug 20, 2020
Exterior Lighting
IN AUTO MODE WHEN DRIVING AT NIGHT THE HEADLIGHTS AND DASHBOARD LIGHTS TURN OFF WITHOUT WARNING.
NHTSA ODI #11350436
66,127 miles · Aug 11, 2020
Exterior Lighting
WHILE DRIVING AT NIGHT I ATTEMPTED TO DIM LIGHTS FOR ONCOMING TRAFFIC WHEN MY LIGHTS WENT COMPLETELY OUT.
NHTSA ODI #11348667
86,000 miles · Jul 31, 2020
Exterior Lighting
AT RANDOM TIMES, ALL AT DIFFERENT SPEEDS AND DIFFERENT TIMES OF THE DAY, MY EXTERIOR LIGHTS WILL TURN OFF ON THEIR OWN. I ALWAYS KEEP MY LIGHTS SET TO AUTO. THIS HAS HAPPENED QUITE A FEW TIMES WHILE DRIVING AT NIGHT, WHICH HAS ALMOST CAUSED A FEW ACCIDENTS WHEN I FIND MYSELF IN THE PITCH BLACK, WHEN I WASN'T AROUND ANY STREET L…
Read full complaint
AT RANDOM TIMES, ALL AT DIFFERENT SPEEDS AND DIFFERENT TIMES OF THE DAY, MY EXTERIOR LIGHTS WILL TURN OFF ON THEIR OWN. I ALWAYS KEEP MY LIGHTS SET TO AUTO. THIS HAS HAPPENED QUITE A FEW TIMES WHILE DRIVING AT NIGHT, WHICH HAS ALMOST CAUSED A FEW ACCIDENTS WHEN I FIND MYSELF IN THE PITCH BLACK, WHEN I WASN'T AROUND ANY STREET LAMPS. SOMETIMES THE LIGHTS WILL COME BACK ON WHEN I SWITCH THE LIGHTS TO OFF AND THEN BACK TO AUTO. BUT NOT ALWAYS.
NHTSA ODI #11342576
Mileage unknown · Jul 17, 2020
Exterior Lighting
I HAVE OWNED THE CAR FOR TWO YEARS ON ONE OCCASION WHILE DRIVING THE HEADLIGHTS SHUT OFF I TURNED SWITCH TO OFF THEN BACK TO AUTO AND THE LIGHTS CAME ON. ON TWO OCCASIONS THE LIGHTS WERE ON AFTER THE CAR WAS SHUT OFF, PARKED AND LOCKED PRESSING THE REMOTE LOCK BUTTON SHUT OFF THE LIGHTS. ON ONE OCCASION THE PARKING LIGHTS TURN…
Read full complaint
I HAVE OWNED THE CAR FOR TWO YEARS ON ONE OCCASION WHILE DRIVING THE HEADLIGHTS SHUT OFF I TURNED SWITCH TO OFF THEN BACK TO AUTO AND THE LIGHTS CAME ON. ON TWO OCCASIONS THE LIGHTS WERE ON AFTER THE CAR WAS SHUT OFF, PARKED AND LOCKED PRESSING THE REMOTE LOCK BUTTON SHUT OFF THE LIGHTS. ON ONE OCCASION THE PARKING LIGHTS TURNED ON AT 2AM (NEIGHBOR'S CAMERA PICKED IT UP) PRESSING REMOTE LOCK BUTTON SHUT OFF THE LIGHTS ANOTHER OCCASION I TRIED STARTING THE CAR IN THE MORNING AND THE BATTERY WAS DEAD, I SUSPECT THAT THE LIGHTS TURNED ON AT NIGHT AND DIDN'T SHUT OFF.
NHTSA ODI #11339895
38,000 miles · Jul 6, 2020
Electrical SystemExterior Lighting
TL* THE CONTACT OWNS A 2017 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLAMPS FAILED TO REMAIN ILLUMINATED WITH THE HEADLAMP SWITCH IN THE AUTO POSITION. THE TURN SIGNALS WERE ALSO INOPERABLE. THE CONTACT STATED THAT HEADLIGHT SUGGESTED MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT …
Read full complaint
TL* THE CONTACT OWNS A 2017 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE HEADLAMPS FAILED TO REMAIN ILLUMINATED WITH THE HEADLAMP SWITCH IN THE AUTO POSITION. THE TURN SIGNALS WERE ALSO INOPERABLE. THE CONTACT STATED THAT HEADLIGHT SUGGESTED MESSAGE WAS DISPLAYED ON THE INSTRUMENT PANEL. THE CONTACT STATED THAT THE HEADLAMPS OPERATED AS DESIGNED WITH THE HEADLAMP SWITCH IN THE ON POSITION. THE VEHICLE WAS TAKEN TO GREENWAY KIA WEST LOCATED AT (8701 E COLONIAL DR, ORLANDO, FL 32817) TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE MULTI-FUNCTION SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND A CASE WAS OPENED. THE FAILURE MILEAGE WAS APPROXIMATELY 38,000.
NHTSA ODI #11337770
30,000 miles · Jun 25, 2020
Exterior Lighting
2017 KIA SORENTO, AWD, MILEAGE ~30K. WHEN THE HEADLIGHTS ARE SET TO "AUTO", THEY WILL RANDOMLY TURN OFF, USUALLY WHEN I ACTIVATE A TURN SIGNAL. IT HAPPENS AT ALL SPEEDS, ON ALL TYPES OF ROAD, MOST OFTEN WHEN I'M TURNING. I'VE HAD SEVERAL 'CLOSE CALLS' AT NIGHT. OBVIOUSLY, IF THE LIGHTS TURN OFF UNEXPECTEDLY, NOT ONLY CAN I N…
Read full complaint
2017 KIA SORENTO, AWD, MILEAGE ~30K. WHEN THE HEADLIGHTS ARE SET TO "AUTO", THEY WILL RANDOMLY TURN OFF, USUALLY WHEN I ACTIVATE A TURN SIGNAL. IT HAPPENS AT ALL SPEEDS, ON ALL TYPES OF ROAD, MOST OFTEN WHEN I'M TURNING. I'VE HAD SEVERAL 'CLOSE CALLS' AT NIGHT. OBVIOUSLY, IF THE LIGHTS TURN OFF UNEXPECTEDLY, NOT ONLY CAN I NOT SEE MY PATH FORWARD, BUT OTHERS CAN'T SEE ME EITHER. THIS IS SERIOUS ISSUE, WELL KNOWN TO KIA AND SHOULD BE SUBJECT TO A RECALL BEFORE SOMEONE DIES OR IS SERIOUSLY INJURED. IT HAS HAPPENED NUMEROUS TIMES, MOST RECENTLY ON THE DATE SHOWN BELOW. *TR
NHTSA ODI #11330935
Official recalls
4Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Sep 21, 2017
Kia Motors America (Kia) is recalling certain 2017 Sorento vehicles equipped with 3.3L engines. The engine crankshaft may have been improperly heat treated and may fail.
Consequence & remedy
Consequence: If the crankshaft fails, the engine will stall, increasing the risk of a crash. A failed crankshaft also increases the risk of a fire.
Remedy: Kia will notify owners, and dealers will inspect the crankshaft, and, as necessary, replace the engine sub assembly, free of charge. The recall began November 6, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC153.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE23019 · Loss Of Motive Power
Opened Nov 13, 2023 · Closed Jul 23, 2024
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Illustration