NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
80 reportsClear category filter50,000 miles · May 1, 2020
Steering
STEERING STICKS WHILE DRIVING. THERE IS A TIGHT SPOT IN THE STEERING THAT MAKES DRIVING IN A STRAIGHT LINE DIFFICULT. THE VEHICLE REQUIRES CONSTANT CORRECTION TO CONTINUE DRIVING IN A STRAIGHT LINE. THIS IS NOT ONLY UNSAFE IT IS EXHAUSTING TO DRIVE. THE ISSUE ALSO CAUSES PREMATURE TIRE WEAR. A SET OF 80000 MILE MICHELIN TIRES…
Read full complaint
STEERING STICKS WHILE DRIVING. THERE IS A TIGHT SPOT IN THE STEERING THAT MAKES DRIVING IN A STRAIGHT LINE DIFFICULT. THE VEHICLE REQUIRES CONSTANT CORRECTION TO CONTINUE DRIVING IN A STRAIGHT LINE. THIS IS NOT ONLY UNSAFE IT IS EXHAUSTING TO DRIVE. THE ISSUE ALSO CAUSES PREMATURE TIRE WEAR. A SET OF 80000 MILE MICHELIN TIRES WAS WORN OUT IN UNDER 20000 MILES. THIS STARTED AT ABOUT 50000 MILES IN OUR VEHICLE,BUT WAS NOT DIAGNOSED UNTIL TODAY,75000 MILES. PRIOR TO THE WARRANTY EXPIRING THE DEALER SAID THEY DID NOT NOTICE THE PROBLEM. TODAY THE DEALER SAYS STEERING COLUMN IS DEFECTIVE. KIA FORUMS ARE FULL OF DRIVERS WITH THIS SAME ISSUE STARTING AS EARLY AS 30000 MILES.
NHTSA ODI #11322975
78,000 miles · Feb 22, 2020
Steering
WHEN DRIVING THE STEERING HAS RESISTANCE AND CAN PULL THE CAR IN A DIFFERENT DIRECTION THAN WHAT YOU ARE TRYING TO DO. THEN IT WILL FREE UP AND YOU HAVE MORE CONTROL. ALSO YOU CAN BE TURNING THE STEERING WHEEL AND THE WHEELS ARE HARDLY MOVING IN THE DIRECTION YOU ARE TURNING THEM TO.
NHTSA ODI #11310695
85,000 miles · Feb 4, 2020
Steering
WHILE IN MOTION THE STEARING WHEEL HAS A FEEL OF RESISTANCE TO DIRECTIONAL CONTROL THEN SECONDS LATER A FEELING OF RELEASE OF THE RESISTANCE. THIS HAPPENS INTERMITTENTLY ON STRAIGHT SECTIONS OF HIGHWAY.
NHTSA ODI #11307010
50,000 miles · Jan 14, 2020
Steering
I NOTICED AROUND 48,000 MILES THAT AFTER DRIVING FOR 30+ MINUTES OR ON AND OFF DRIVING FOR 45+ MINUTES, MY STEERING BECOMES "STICKY"/"NOTCHED" WHEN IT IS CENTERED AND I AM DRIVING 35 MPH OR MORE. IT BECOMES MUCH MORE PRONOUNCED WHEN ON A FLAT, STRAIGHT SURFACE AND I AM DRIVING 60+ MPH. THIS MAKES MINOR CORRECTIONS HARD TO DO …
Read full complaint
I NOTICED AROUND 48,000 MILES THAT AFTER DRIVING FOR 30+ MINUTES OR ON AND OFF DRIVING FOR 45+ MINUTES, MY STEERING BECOMES "STICKY"/"NOTCHED" WHEN IT IS CENTERED AND I AM DRIVING 35 MPH OR MORE. IT BECOMES MUCH MORE PRONOUNCED WHEN ON A FLAT, STRAIGHT SURFACE AND I AM DRIVING 60+ MPH. THIS MAKES MINOR CORRECTIONS HARD TO DO WHEN DRIVING TO STAY IN MY LANE AS THE VEHICLE SEEMS TO REQUIRE SIGNIFICANT PRESSURE TO TURN RIGHT OR LEFT. THIS ENDS UP BECOMING A SERIES OF CONSTANT CORRECTIONS FROM INADVERTENTLY OVERSTEERING. THIS IS VERY FATIGUE INDUCING AND CAN BE FRUSTRATING, EVEN WHEN I AM VERY WELL RESTED AND ALERT. I'M CONCERNED IT'LL AFFECT OTHER DRIVERS AS THEY MAY DRIVE ERRATICALLY WHEN PASSING AS THEY MATCH MY STEERING CORRECTIONS. MY LOCAL KIA DEALERSHIP HAS BEEN VERY HELPFUL AND RECEIEVED PERMISSION TO REMEDY IT UNDER WARRANTY AND WILL REPLACE THE ENTIRE STEERING COLUMN AND ASSOCIATED PARTS. CURRENTLY THE STEERING COLUMN IS ON BACKORDER AND HAS BEEN FOR AT LEAST THREE WEEKS. I BELIEVE THE STEERING COLUMN ISSUE MAY BE BIGGER THAN INDICATED VIA REPORTS JUDGING BY THE BACKORDER ISSUE. DATE ENTERED IN THE "EVENT DATE" SECTION IS BASED ON WHEN I HAD AN APPOINTMENT FOR AN INITIAL DIAGNOSIS.
NHTSA ODI #11299269
45,000 miles · Jan 10, 2020
Steering
MY 2016 EX TURBO SORRENTO HAS A STEERING ISSUE. THE STEERING FEELS LIKE IT STICKS OR HESITATES. THE FEELING IS DIFFICULT TO DESCRIBE AS IT IS NOT LIKE ANY STEERING I HAVE EXPERIENCED BEFORE . IT IS AS THOUGH SOMETHING MECHANICAL IN THE LOWER PART OF THE ASSEMBLY IS HESITATING OR SLIGHTLY JERKING AND NOT GIVING THE CORRECT FEEDBA…
Read full complaint
MY 2016 EX TURBO SORRENTO HAS A STEERING ISSUE. THE STEERING FEELS LIKE IT STICKS OR HESITATES. THE FEELING IS DIFFICULT TO DESCRIBE AS IT IS NOT LIKE ANY STEERING I HAVE EXPERIENCED BEFORE . IT IS AS THOUGH SOMETHING MECHANICAL IN THE LOWER PART OF THE ASSEMBLY IS HESITATING OR SLIGHTLY JERKING AND NOT GIVING THE CORRECT FEEDBACK AND NOT ACCEPTING THE DRIVERS INPUT CORRECTLY . I KNOW THERE ARE BOTH ELECTRICAL AND MECHANICAL SYSTEMS INVOLVED IN THE STEERING AND SOMETHING BETWEEN THEM IS NOT WORKING CORRECTLY. THERE ARE CERTAIN DRIVING CONDITIONS WHEN THIS IS NO DOUBT A SAFETY ISSUE , LIKE IN THE RAIN WHEN YOU ARE NOT GETTING THE CORRECT FEEDBACK FROM THE STEERING AND ARE ARE DRIVING BETWEEN 2 SEMI TRUCKS AT 70 MPH. THIS ISSUE NEEDS TO BE A SAFETY RECALL AND FIXED BEFORE THERE ARE PEOPLE INJURED OR WORSE FROM THE EFFECTS OF THIS DEFECT. I HAVE TAKEN THIS TO A KIA DEALER AND THEY SAID THE DROVE IT AND DID NOT FEEL A PROBLEM. I HAVE REPORTED IT TO KIA CONSUMER AFFAIRS BEFORE THE CAR WAS OUT OF WARRANTY AND AGAIN NOW THAT IT IS OUT OF WARRANTY . THIS ISSUE CAN BE FELT WHEN DRIVING OR WHEN STATIONARY . TO BE CLEAR , THE DRIVER HAS TO CONSTANTLY MAKE SMALL ADJUSTMENTS TO KEEP THE CAR DRIVING IN A STRAIGHT LINE , AND WHEN MAKING THESE ADJUSTMENTS THE STEERING FEELS STICKY SO IT REQUIRES EXTRA FORCE TO MOVE. I WOULD LIKE TO ADD THAT OTHER THAN THE DESCRIBED STEERING ISSUE THIS VEHICLE HAS BEEN EXCELLENT IN EVERY WAY AND VERY DEPENDABLE .
NHTSA ODI #11298503
30,000 miles · Jan 9, 2020
Steering
MY 2016 SORENTO (EX) HAS STICKY STEERING. KIA IS AWARE OF THIS PROBLEM AND ISSUES AN UPGRADE TO THE CARS COMPUTER SYSTEM BUT IT DID NOT FIX THE PROBLEM. WHEN TRYING TO MOVE THE STEERING WHEEL, IT INITIALLY STICKS AND REQUIRES EXTRA FORCE TO GET IT TO PROVIDE A STEERING INPUT. ONCE IT GETS PAST THE INITIAL RESISTANCE, IT JER…
Read full complaint
MY 2016 SORENTO (EX) HAS STICKY STEERING. KIA IS AWARE OF THIS PROBLEM AND ISSUES AN UPGRADE TO THE CARS COMPUTER SYSTEM BUT IT DID NOT FIX THE PROBLEM. WHEN TRYING TO MOVE THE STEERING WHEEL, IT INITIALLY STICKS AND REQUIRES EXTRA FORCE TO GET IT TO PROVIDE A STEERING INPUT. ONCE IT GETS PAST THE INITIAL RESISTANCE, IT JERKS THE CAR IN THE DIRECTION YOU ARE TRYING TO GO WHICH REQUIRED COMPENSATION IN THE OTHER DIRECTION. UPON CORRECTION, IT JERKS THE CAR IN THE OPPOSITE DIRECTION CAUSING A CONTINUAL NEED TO CORRECT THE STEERING WHEEL TO KEEP THE CAR STRAIGHT AND CAUSING THE CAR TO NOT BE ABLE TO MAINTAIN PERFECTLY STRAIGHT TRAVEL. ON LARGE SWEEPING CORNERS, THIS PROBLEM IS EVEN MORE PRONOUNCED AND FEELS DANGEROUS. MY CAR IS OUT OF ITS BUMPER TO BUMPER WARRANTY AND DESPITE ME HAVING THE CAR INTO KIA DEALERSHIPS TWICE WHILE IN WARRANTY AND THE ORIGINAL COMPUTER "FIX" NOT WORKING, KIA IS NOT GUARANTEEING THAT WHEN I BRING THE CAR BACK THAT IT WILL BE FIXED UNDER WARRANTY. THE FIX FOR THE PROBLEM IS REPLACING THE STEERING RACK OR OTHER STEERING COMPONENTS. THE STICKING ISSUE IS INTERMITTENT BUT WHEN IT IS ACTING UP IT CAN BE FELT WHILE STATIONARY AND IN MOTION. THIS INTERMITTENT ISSUE STARTED AROUND 30,000 MILES AND CONTINUES THROUGH 70,000 MILES.I BELIEVE A RECALL SHOULD OCCUR TO CORRECT THIS POTENTIALLY SERIOUS SAFETY ISSUE.
NHTSA ODI #11298071
27,000 miles · Dec 31, 2019
Steering
WHEN DRIVING THE STEERING WHEEL WILL GO TO THE LEFT AND STICK ,THEN I WILL HAVE TO BRING BACK TO RIGHT OR THE STEERING WILL STAY TO THE LEFT.THIS HAS HAPPEN MANY TIMES.THIS IS A POTENTIAL DANGEROUS SITUATION.THERE ARE MULTIPLE REPORTS ON THIS SITUATION.I AM CONCERNED...
NHTSA ODI #11292319
Mileage unknown · Oct 23, 2019
EngineSteering
MY KIA WAS BOUGHT 1/2016 AND SINCE THEN MY STEERING COLUMN HAS HAD TO BE REPLACED 3 TIMES, CADILLAC CONVERTER ONCE, AND MY CAR IS NOW READY AFTER 23 DAYS BECAUSE OF A MOTOR LEAK THAT HAD CRACKED THE BLOCK. EVERYONE OF THESE HAVE BEEN DEFECTS THAT KIA HAS COVERED AND YET I CAN'T SEEM TO GET ANYONE FROM THE ESCALATIONS DEPARTMENT …
Read full complaint
MY KIA WAS BOUGHT 1/2016 AND SINCE THEN MY STEERING COLUMN HAS HAD TO BE REPLACED 3 TIMES, CADILLAC CONVERTER ONCE, AND MY CAR IS NOW READY AFTER 23 DAYS BECAUSE OF A MOTOR LEAK THAT HAD CRACKED THE BLOCK. EVERYONE OF THESE HAVE BEEN DEFECTS THAT KIA HAS COVERED AND YET I CAN'T SEEM TO GET ANYONE FROM THE ESCALATIONS DEPARTMENT TO TALK TO ME ABOUT A BUYBACK OR GETTING ME INTO ANOTHER CAR. IT HAD 5 MILES ON IT WHEN I BOUGHT IT AND NOW IS AROUND 80,000.
NHTSA ODI #11270432
Mileage unknown · Sep 13, 2019
Steering
STEERING IS WHAT'S CALLED NOTCHY OR STICKY. WHEN DRIVING (WHETHER IT BE STRAIGHT ON A CITY STREET, STRAIGHT ON A HIGHWAY, OR EVEN ON CURVY ROADS, SLOW OR FAST) STEERING WHEEL TAKES EFFORT TO TURN THEN LETS GO, CAUSES OVER STEER REACTION. DANGEROUS. STEERING EVEN MOVES ON ITS OWN AT A COMPLETE STOP. I BEGAN NOTICING IT IN JANUA…
Read full complaint
STEERING IS WHAT'S CALLED NOTCHY OR STICKY. WHEN DRIVING (WHETHER IT BE STRAIGHT ON A CITY STREET, STRAIGHT ON A HIGHWAY, OR EVEN ON CURVY ROADS, SLOW OR FAST) STEERING WHEEL TAKES EFFORT TO TURN THEN LETS GO, CAUSES OVER STEER REACTION. DANGEROUS. STEERING EVEN MOVES ON ITS OWN AT A COMPLETE STOP. I BEGAN NOTICING IT IN JANUARY OF 2019. SINCE THEN, ITS GOTTEN WORSE.
NHTSA ODI #11255246
64,000 miles · Aug 19, 2019
Steering
DURING NORMAL VEHICLE OPERATION, BOTH ON THE HIGHWAY AND CITY STREETS, THE VEHICLE WOULD SUDDENLY LOSE POWER STEERING AND THE POWER STEERING WARNING LIGHT WILL ILLUMINATE. THIS HAPPENED SEVERAL TIMES RANDOMLY WITHOUT WARNING, STEERING WAS NORMAL AND THERE WERE NO AUDIBLE NOISES WHEN STEERING PRIOR TO POWER STEERING FAILURE. PUTT…
Read full complaint
DURING NORMAL VEHICLE OPERATION, BOTH ON THE HIGHWAY AND CITY STREETS, THE VEHICLE WOULD SUDDENLY LOSE POWER STEERING AND THE POWER STEERING WARNING LIGHT WILL ILLUMINATE. THIS HAPPENED SEVERAL TIMES RANDOMLY WITHOUT WARNING, STEERING WAS NORMAL AND THERE WERE NO AUDIBLE NOISES WHEN STEERING PRIOR TO POWER STEERING FAILURE. PUTTING THE VEHICLE IN PARK, TURNING OFF AND RESTARTING THE CAR FIXED THE PROBLEM A FEW TIMES, SOMETIMES FOR A FEW DAYS BETWEEN OCCURENCES. EVENTUALLY POWER STEERING WAS LOST FOR GOOD AND NEEDED TO BE TAKEN TO A MECHANIC FOR REPAIRS. THERE WERE A FEW CLOSE CALLS LOSING POWER STEERING IN THE MIDDLE OF TURNS THAT NEARLY LED TO ACCIDENTS.
NHTSA ODI #11244963
Official recalls
8Sep 19, 2022
Kia America, Inc. (Kia) is recalling certain 2016-2022 Sorento, 2021-2022 Sorento Hybrid (HEV), 2022-2023 Sorento Plug-In Hybrid (PHEV), and 2017-2022 Sportage vehicles equipped with a tow hitch harness installed as original equipment, or purchased as an accessory through a Kia dealership. Debris and moisture accumulation on the tow hitch harness module printed circuit board (PCB) may cause an electrical short, which can result in a fire.
Consequence & remedy
Consequence: A fire while parked or driving can increase the risk of injury.
Remedy: Owners are advised to park outside and away from structures until the recall repair is complete. Dealers will inspect the vehicle, and, as necessary, replace the fuse and/or tow hitch harness module, free of charge. Owner notification letters were mailed August 11, 2023. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC249.
Aug 10, 2022
Kia America, Inc. (Kia) is recalling certain 2016 Sedona and Sorento vehicles. The vehicles may have been manufactured with faulty automatic transmission shift lever assembly components, preventing the shift lever from locking, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: A vehicle rollaway increases the risk of a crash and injury.
Remedy: Dealers will inspect and replace the automatic transmission shift lever assembly components, as necessary, free of charge. Owner notification letters were mailed October 7, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC246.
Dec 19, 2018
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Additional source detail variants (2)
Engine
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
Kia Motors America (Kia) is recalling certain 2011-2017 Optima, 2012-2017 Sorento and 2011-2018 Sportage vehicles that previously received an engine replacement under recall number 17V-224, warranty, or the Knock Sensor Detection System (KSDS) Product Improvement Campaign. The high pressure fuel pipe that connects to the fuel pump outlet may have been damaged, misaligned or improperly torqued during the engine replacement procedure, possibly causing a fuel leak.
Consequence: A fuel leak in the presence of an ignition source can increase the risk of a fire.
Remedy: Kia has notified owners, and dealers will inspect and replace the fuel pipe, as necessary, free of charge. The recall began January 17, 2019. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC172.
Nov 30, 2016
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Additional source detail variants (2)
Trailer Hitches
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Electrical System
Kia Motors America (Kia) is recalling certain model year 2016-2017 Sorento vehicles manufactured October 27, 2014, to August 25, 2016, and 2017 Sportage vehicles manufactured December 10, 2015, to August 26, 2016. The affected vehicles are equipped with an accessory trailer hitch wiring harness that, due to a malfunction of the tow hitch module, may result in the trailer brake lights being constantly illuminated. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: If the trailer brake lights stay illuminated while being used, other drivers may be confused, increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the trailer tow hitch harness, free of charge. The recall began January 18, 2017. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC142.
Oct 24, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured March 3, 2016 to March 21, 2016. The driver's seatback frame may have been produced with inadequate weld joints and, as a result, the seatback may not function as designed in the event of a rear-end collision.
Consequence & remedy
Consequence: In the event of a crash, the driver seatback frame could break and fail to restrain a seat occupant, increasing the risk of injury.
Remedy: Kia will notify owners, and dealers will inspect the welds and replace the driver seatback frame, as necessary, free of charge. The recall began on December 9, 2016. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC140.
Jun 29, 2016
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles. A component of the rear suspension may not be properly welded.
Consequence & remedy
Consequence: The improper weld may break, affecting the rear suspension alignment, thereby increasing the risk of a crash.
Remedy: Kia will notify owners, and dealers will inspect the welds at the rear suspension cross-member, replacing the rear cross-member assembly, as necessary, free of charge. The recall began July 27, 2016. Owners may contact Kia Customer Service Department at 1-800-333-4542. Kia's number for this recall is SC137.
Jul 14, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Kia Sorento vehicles manufactured October 23, 2014, to December 10, 2014. The affected vehicles have a front passenger seat belt whose buckle latch assembly may prevent the front passenger from fastening the seat belt.
Consequence & remedy
Consequence: If the front passenger seat belt cannot be latched, an occupant sitting in the front passenger seat has an increased risk of injury in the event of a crash.
Remedy: Kia will notify owners, and dealers will replace the front passenger seat belt buckle cover, free of charge. The recall began on August 18, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC123.
Feb 13, 2015
Kia Motors America (Kia) is recalling certain model year 2016 Sorento vehicles manufactured October 27, 2014, to January 29, 2015. Due to an improperly soldered component in the accelerator pedal assembly, the driver may not be able to accelerate the vehicle.
Consequence & remedy
Consequence: If the vehicle is unable to be accelerated, there is an increased risk of a crash.
Remedy: Kia will notify owners, and dealers will replace the accelerator assembly, free of charge. The recall began on February 19, 2015. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC115.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3PE23019 · Loss Of Motive Power
Opened Nov 13, 2023 · Closed Jul 23, 2024
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:seals/gaskets
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
On November 13, 2023, the Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE23-019) to investigate allegations of loss of motive power relating to head gasket and/or head bolt failure in Model Year (MY) 2016-2017 Kia Sorento vehicles equipped with the 3.3 L Lambda II engine. When the investigation was opened, ODI had received 13 Vehicle Owner Questionnaires (VOQs) related to reports of loss of motive power. In an information request letter dated November 30, 2023, ODI requested technical information and failure data relating to the alleged defect in the subject MY 2016-2017 Kia Sorento as well as several peer vehicle populations which share the 3.3 L engine. In its February 26, 2024, response to ODI’s information request, Kia provided 2022 customer complaints (including techline and field reports) and 1738 warranty claims representing 2411 unique vehicles within the subject vehicle population. Of the customer complaints provided by Kia, they identified only 53 unique allegations of a loss of motive power resulting from the alleged defect. Kia determined that the remaining reports were minor vehicle drivability or engine performance issues. ODI reviewed the information provided by Kia, along with additional VOQs submitted to NHTSA following the opening of the investigation. When eliminating duplicative reports across the data sources, the total number of allegations of loss of motive power relating to the alleged defect in the subject vehicles is 77, representing an incident report rate of 59 per 100,000 vehicles. The MY 2016 Kia Sorento exhibited both the highest overall complaint rate and loss of motive power report rate across all subject and peer vehicle populations, representing an incident report rate of 102 per 100,000 vehicles. Across all data sources, there are no allegations of crashes or fires relating to the alleged defect. The one injury incident reflected in the failure summary table above is related to a consumer who was reportedly burned (minor burn requiring medical attention) while attempting to remove the coolant reservoir cap following a loss of motive power event. In their response to ODI, Kia described that if the threads of a head bolt hole in the subject engine becomes damaged, the clamping force between the cylinder head and engine block can decrease in the area of the affected head bolt. Kia’s assessment of the alleged defect is that when the failure occurs, drivers are provided with numerous warning signs prior to a potential loss of motive power event. According to Kia, potential warning signs associated with this failure include coolant leak/consumption or noticeable coolant odor, engine oil leak/consumption, engine temperature gauge rising to “H” (hot), check engine light illuminating, engine cooling fan remaining on following the engine being shut off, HVAC system not functioning properly, unusual engine noise, difficulty starting the vehicle, and smoke/condensation emitting from the engine compartment or exhaust. Through both its review of the information provided by Kia and outreach to consumers, ODI confirmed that there is reasonable detectability present in the vast majority of occurrences of the alleged defect. To mitigate the alleged defect, Kia increased the engagement depth of the head bolt threads for all subject engines, beginning in May 2017. ODI’s analysis of the failure data demonstrates that this corrective action correlates with a much lower incident report rate for engines produced following the change (8 per 100,000 vehicles for the MY 2018-2020 Kia Sorento). In December 2023, Kia launched extended warranty campaign WTY035 covering failures associated with the alleged defect in the subject vehicle population through 15 years or 180,000 miles, whichever comes first. Through its investigation, ODI identified the following peer vehicle populations, which were produced prior to the corrective action and exhibit failure rates comparable to the subject vehicles: MY 2014-2015 Kia Sorento, MY 2015-2016 Kia Sedona, and MY 2014-2017 Kia Cadenza equipped with the 3.3 L engine. Through discussions with ODI during the investigation, Kia decided to launch extended warranty campaign WTY039 in May 2024, which covers these peer vehicle populations through 15 years or 180,000 miles, whichever comes first. Based on analysis of the failure data indicating a low incident report rate of loss of motive power for the alleged defect, and in consideration of the warning signs which frequently occur from head gasket and/or head bolt failure in the subject engines, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22003 · Loss Of Motive Power
Opened Sep 12, 2022 · Closed Dec 12, 2023
Status: closed (inferred from source dates) · Engine
The National Highway Traffic Safety Administration (NHTSA) received a letter dated July 13, 2022, petitioning the Agency to initiate a safety defect investigation into loss of motive power allegations attributed to oil drain pan assembly failures on certain Hyundai Motor America, Inc. and Kia America, Inc. vehicles spanning Model Years (MY) 2005-2021. The Petitioners cited examples of complaints indicating that the subject vehicles were experiencing rapid loss of engine oil due to oil drain plug back outs, resulting in loss of motive power and/or catastrophic engine damage. Additional complaints were provided which alleged that the oil drain pans lack sufficient structural integrity and are susceptible to cracking. The petition itself can be reviewed at NHTSA.gov under ODI number 11481745. On September 12, 2022, the Office of Defects Investigation (ODI) opened Defect Petition (DP22-003) to evaluate the Petitioners’ request. The Petitioners have provided additional complaints within four supplemental letters dated January 31, 2023, March 21, 2023, May 23, 2023, and August 4, 2023. ODI’s evaluation included the review and analysis of the complaints and supporting information submitted by the Petitioners, as well as additional complaints submitted directly to NHTSA which referenced either the oil drain plug or a crack in the oil pan. After reviewing the available data, ODI has not identified evidence that would support opening a defect investigation into the oil drain pan assemblies of the subject vehicles. Based on a review of the available information, a loss of motive power resulting from an oil drain plug back out has not occurred between the initial sale of a vehicle and the completion of its first oil change. If during an oil change service, a technician fails to remove the existing drain plug gasket before installing a new gasket, it is likely that a proper seal between the drain plug and the oil pan will not be made. An improper seal between the drain plug and oil pan could lead to the backing out on the drain plug, resulting in the sudden loss of oil while driving. Additionally, the provided examples of oil pan cracks were localized to the immediate vicinity of the oil drain plug and/or appeared to be the result of direct-contact with a tool during servicing. There is no information to support that a vehicle-based defect exists relating to the oil pan assembly, and instead the documented incidents are related to the failure to follow the proper maintenance procedures during oil change service. In October 2023, Hyundai published a Technical Service Bulletin (TSB) that provided detailed instructions for oil change service on its gasoline powered vehicles, specifically highlighting the need to remove and replace the existing drain plug gasket prior to reinstalling the drain plug. After a thorough review of the material submitted by the petitioner, the information already in NHTSA's possession, and the potential risks to motor vehicle safety implicated by the petitioners' allegations, NHTSA does not believe that a formal investigation is warranted. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA’s reasons for denial of the petition will be published. The reference numbers for the complaints to NHTSA cited by the petitioner can be found in the petition submission documents in the public file for DP22-003. To review those complaints and the additional complaints ODI added to its evaluation which are cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP21002 · Engine Oil Pressure Switch Leak
Opened Nov 12, 2021 · Closed Jun 26, 2023
Status: closed (inferred from source dates) · Engine; Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Additional source detail variants (2)
Engine And Engine Cooling:engine:oil/lubrication:pressure/temperature Sensor
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Engine
In a letter dated September 30, 2021, Mr. Gerald James (the petitioner) requested that NHTSA conduct an investigation of the Model Year (MY) 2015-2017 Kia Sorento equipped with 3.3L V6 ?Lambda? engines for ?severe oil leaks? from the oil pressure switch (OPS) that could ?lead to engine failure? with little warning to the driver. Mr. James based this request on his own experience and data found in NHTSA?s Vehicle Owner Questionnaire (VOQ) database. NHTSA reviewed the material cited by the petitioner, information submitted by Kia, NHTSA?s testing, and other pertinent information in NHTSA databases.On November 12, 2021, ODI opened Defect Petition DP21-002 to evaluate the petitioner?s request. ODI performed an analysis that included evaluation of the petitioner?s vehicle, searches of ODI complaints from vehicle owners, non-dealer field reports, manufacturers? supplemental information relating to design of the component, and component testing performed by ODI.On December 16, 2021, ODI and Kia North America performed a joint inspection on the petitioner?s vehicle. ODI and Kia agreed the OPS was leaking oil and observed oil in the crevices atop the engine block. The vehicle received a new replacement OPS and was delivered back to the petitioner. The original part that was removed from the subject vehicle was retained by ODI for further analysis.As of December 30, 2022, for the MY 2015-2017 Kia Sorento population of 161,519 vehicles with 3.3L engine, NHTSA reviewed internal data and has identified no consumer complaints or field reports in its database, with unique Vehicle Identification Numbers (VIN), citing engine failure or stalling related to the petition?s allegation of defective OPS. When combined with the supplemental warranty and technical analysis from the manufacturer, field report and customer complaint data in response to the Information Request letter sent, NHTSA identified no unique VINs alleging engine failure or stalls caused by OPS leaking on the subject vehicles named in the petition.On April 4, 2022, the Vehicle Research and Test Center (VRTC) performed testing of the petitioner?s component (OPS) based on testing protocol consistent with Kia?s specifications for the subject vehicle. The testing involved the petitioner?s original OPS in a controlled system to replicate the subject vehicle?s oil pressure, flow, and temperature. VRTC determined that a vehicle would have to miss more than a dozen oil change intervals to reach low engine oil capacity. Testing also revealed the OPS would operate, as manufacturer intended, illuminating the vehicle?s MIL to alert the driver of lower oil pressure.In April of 2022, Kia North America issued a warranty extension that extended the coverage of the Oil Pressure Switch from 5 years/60,000 miles to 15 years/150,000 miles on MY 2014-2018 Sorento, MY 2014-2016 Cadenza, and MY 2015-2018 Sedona vehicles, all equipped with the 3.3L Lambda engine. The extended warranty coverage includes diagnosis, repair, and applies to customers experiencing engine oil leaking from the engine or if the engine oil pressure warning light stays illuminated after the engine is turned on.After a thorough review of the material submitted by the petitioner, information already in NHTSA's possession, testing performed by VRTC, technical information provided by Kia, the potential risks to safety implicated by the petitioner's allegation, NHTSA does not believe that an engine failure due to the alleged defect is likely and does not warrant a formal investigation. Therefore, the petition is denied. A Federal Register Notice (FRN) further detailing NHTSA?s reasons for denial of the petition will be publi
Illustration