2006 Kia Sedona

I obtained this vehicle from a relative in Ohio. They tried twice to have the recall repaired and twice they showed for an appointment to find out parts were not available. I bought and brought the car to Florida. I started the same process here with Daytona Kia {(386) 252-7000}. I have had 2 appointments. The first on 8/31/2021 I cancelled having called the day before to be told the part was not in. As I was not communicated with despite being told I would be called, I initiated another effort in October. After being assured the part was in I made an appointment for November 20, 2021. That Saturday morning I sat in their waiting room for 1 1/2 hours just to be finally told the part was not in and they would inform me when it was. Parts still backordered.

The contact owns a 2006 Kia Sedona. The contact stated while the vehicle was parked in a parking lot, the vehicle erupted in flames without warning. Fire marshals were called and extinguished the fire. No one was injured and a report was taken. The contact mentioned a possible smoke inhalation from the smoke. The vehicle was towed to the contact's residence. The manufacturer was informed of failure and was awaiting a response. The failure mileage was approximately 150,000.

The contact owns a 2006 Kia Sedona. The contact stated that while driving at various speeds, the vehicle would stall with the check engine warning light illuminated. The contact also stated that the vehicle would fail to reverse once placing the gear shifter into reverse. The contact had initially taken the vehicle to an independent mechanic who was unable to service the vehicle and referred him to another mechanic who replaced the transmission. Almost a year later, the failure recurred, and the contact bought a code scanner that informed him that the catalytic converter was defective. The contact bought a new catalytic converter and had the catalytic converter replaced. Recently, the contact stated that while driving at various speeds, the vehicle began to hesitate upon depression of the accelerator pedal with the throttle body warning light illuminated. The contact used the code reader to clear the warning light and the vehicle resumed normal operation. On another occasion while driving 45 MPH, the vehicle stalled with the check engine warning light illuminated. Due to the failure, the contact had the vehicle towed to an independent mechanic who replaced the throttle body. Soon after the test drive, the transmission failed. The contact agreed to have the transmission replaced and the vehicle remained in the possession of the dealer. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was approximately 60,000.

Driving slowly out of parking lot a loud bang was heard. Scraping noise was heard from under van, drove about 25 yards then stopped at side of road. Left rear wheel was crooked and under van the left rear lower control arm was broken in half and was dragging on ground, left rear wheel was off ground. No one was injured, no other damage to this vehicle or others. This vehicle was previously serviced on Kia Service Campaign SC102, unknown date. Would have been serious accident if this occurred at highway speeds. Both lower control arms have been replaced, parts saved for inspection. Pictures attached. Kia was notified of this, case #[XXX]. Vehicle has one owner since new. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

BOUGHT A VAN THE NEXT DAY MY BREAKS WERE METAL ON METAL. I FOUND OUT IT WAS FLOODED. THE SECOND DAY THE KEY STUCK IN THE IGNITION, THE MIDDLE SEATS GOT STUCK AND WILL NOT FOLD UP. THE DEALER SAID THEIR MECHANIC WENT ALL OVER THE VAN AND SAID IT WAS IN GOOD CONDITION. THE CALIPERS ARE IN VERY BAD SHAPE. HE SAID THEY NEED REPLACED SOON.*DT*JB

TL* THE CONTACT OWNS A 2006 KIA SEDONA. THE CONTACT STATED THAT WHILE MAKING A TURN, A POPPING NOISE OCCURRED COMING FROM THE RACK AND PINION STEERING. NO WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND WAS DIAGNOSED THAT THE RACK & PINION STEERING NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED WITH A NEW RACK & PINION HOWEVER, THE FAILURE RECURRED. THE TECHNICIAN INFORMED THE CONTACT THAT THERE WAS A PROBLEM WITH THE RACK AND PINION. THE TECHNICIAN INFORMED THE CONTACT THAT A KIA DEALER RACK & PINION WAS TESTED AND FAILED, AND WAS UNABLE TO CORRECT THE FAILURE. THE CONTACT MENTIONED THAT SIX MONTHS AGO, WHEN THE VEHICLE WAS PURCHASED, THE RACK AND PINION WAS REPLACED. NEITHER THE DEALER NOR THE MANUFACTURER WERE NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 112,000. THE VIN WAS NOT AVAILABLE.