NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
107 reportsMileage unknown · Sep 6, 2004
Air BagsCrashInjury
MY 2002 KIA OPTIMA WAS IN AN ACCIDENT ON AUGUST 30TH 2004. MY DAUGHTER WAS DRIVING WEST BOUND, A SCHOOL BUS DRIVING EAST BOUND MADE A LEFT TURN IN FRONT OF MY DAUGHTER. SHE HIT THE BUS AT ABOUT 50 MPH. NO AIR BAG DEPLOYED. I AM INTERESTED IN KNOWING IF THIS HAS HAPPENED BEFORE. IT WAS A FULL FRONTAL IMPACT. THANK GOD FOR …
Read full complaint
MY 2002 KIA OPTIMA WAS IN AN ACCIDENT ON AUGUST 30TH 2004. MY DAUGHTER WAS DRIVING WEST BOUND, A SCHOOL BUS DRIVING EAST BOUND MADE A LEFT TURN IN FRONT OF MY DAUGHTER. SHE HIT THE BUS AT ABOUT 50 MPH. NO AIR BAG DEPLOYED. I AM INTERESTED IN KNOWING IF THIS HAS HAPPENED BEFORE. IT WAS A FULL FRONTAL IMPACT. THANK GOD FOR SEAT BELTS. *AK
NHTSA ODI #10090517
11,800 miles · Aug 19, 2004
Electrical System
WHILE DRIVING, A BURNING SMELL WAS DETECTED, THEN THE AIR BAG LIGHT CAME ON. AFTER PULLING INTO A SERVICE STATION THE VEHICLE WOULD NOT START. IT WAS DISCOVERED THE ALTERNATOR, COMPUTER AND AIR BAG MODULE WAS DEFECTIVE. AFTER THE REPAIR THE AIR BAG LIGHT REMAINED ON. *JB
NHTSA ODI #10089331
55,000 miles · Jul 31, 2004
Service Brakes, Hydraulic
ROTORS WARPED, NOT WORN OUT, WARPED COMPLETELY AROUND 55,000 MILES. CAR HAS A 60,000 MILEAGE/5 YEAR BUMPER TO BUMPER WARRANTY AND KIA WILL NOT HONOR IT. CONTACTED LANGHORNE KIA SERVICE DEPT. AND WAS TOLD THAT I WAS LUCKY THAT THEY LASTED SO LONG. I WAS INFORMED THAT KIA CHANGED THE WAY THEY MAKE THE ROTORS AND THAT THE NEW R…
Read full complaint
ROTORS WARPED, NOT WORN OUT, WARPED COMPLETELY AROUND 55,000 MILES. CAR HAS A 60,000 MILEAGE/5 YEAR BUMPER TO BUMPER WARRANTY AND KIA WILL NOT HONOR IT. CONTACTED LANGHORNE KIA SERVICE DEPT. AND WAS TOLD THAT I WAS LUCKY THAT THEY LASTED SO LONG. I WAS INFORMED THAT KIA CHANGED THE WAY THEY MAKE THE ROTORS AND THAT THE NEW ROTORS HEAT QUICKLY CAUSING THEM TO WARP WHEN THE MILAGE IS USUALLY UNDER 30,000 MILES.*AK
NHTSA ODI #10083065
18,500 miles · Jun 28, 2004
Fuel System, Gasoline
VEHICLE HESITATES WHEN PRESSING ON THE GAS. IT TAKES APPROXIMATELY 5-10 SECONDS BEFORE THE VEHICLE RESPONDS TO DEPRESSION OF ACCELERATOR PEDAL CONSUMER INDICATES THAT SHE HAS ALMOST BEEN REAR-ENDED DUE TO STALLING WITHOUT WARNING. *AK
NHTSA ODI #10080067
3,600 miles · Jun 22, 2004
Air BagsCrash
THE AIR BAG WARNING LIGHT CAME ON 7 TIMES WHILE DRIVING. DEALERSHIP REPLACED THE DRIVER'S SIDE SEAT THAT CONTAINED THE SIDE AIR BAG BECAUSE IT WAS FAULTY, AND INSTALLED A NEW AIR BAG CONTROL MODULE. ALSO, THEY REPROGRAMMED THE AIR BAG SENSOR SEVERAL TIMES, BUT THE LIGHT STILL CAME BACK ON. VEHICLE WAS INVOLVED IN 2 FRONTAL C…
Read full complaint
THE AIR BAG WARNING LIGHT CAME ON 7 TIMES WHILE DRIVING. DEALERSHIP REPLACED THE DRIVER'S SIDE SEAT THAT CONTAINED THE SIDE AIR BAG BECAUSE IT WAS FAULTY, AND INSTALLED A NEW AIR BAG CONTROL MODULE. ALSO, THEY REPROGRAMMED THE AIR BAG SENSOR SEVERAL TIMES, BUT THE LIGHT STILL CAME BACK ON. VEHICLE WAS INVOLVED IN 2 FRONTAL COLLISIONS IN WHICH THE AIR BAGS DID NOT DEPLOY. *AK
NHTSA ODI #10079670
8,000 miles · Jun 8, 2004
Air BagsSeat BeltsSeatsCrashInjury
WHILE AT A COMPLETE STOP BECAUSE OF ROAD CONSTRUCTION, THE CONSUMER'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE AT 40 MPH. UPON IMPACT, NONE OF THE FRONTAL AIR BAGS DEPLOYED, AND THE DRIVER'S SIDE SEAT BELT FAILED TO RETRACT. ALSO, DRIVER'S SIDE SEAT BACK RECLINED BACKWARDS ONTO THE REAR SEAT. DRIVER SUSTAINED SEVERE BRUISES …
Read full complaint
WHILE AT A COMPLETE STOP BECAUSE OF ROAD CONSTRUCTION, THE CONSUMER'S VEHICLE WAS REAR ENDED BY ANOTHER VEHICLE AT 40 MPH. UPON IMPACT, NONE OF THE FRONTAL AIR BAGS DEPLOYED, AND THE DRIVER'S SIDE SEAT BELT FAILED TO RETRACT. ALSO, DRIVER'S SIDE SEAT BACK RECLINED BACKWARDS ONTO THE REAR SEAT. DRIVER SUSTAINED SEVERE BRUISES TO CHEST/BREAST BONE/LUNGS/HEART/LOWER ABDOMINAL, AND LEFT LEG. *AK *LA
NHTSA ODI #10075894
23,668 miles · Jun 7, 2004
Service Brakes, Hydraulic
I BOUGHT A USED KIA OPTIMA 2002 IN JANUARY OF 2003. IT HAD ABOUT 23000 MILES ON IT. WE TOOK A TRIP TO LAKE TAHOE IN FEB.2003 AND ON THE RIDE HOME EVERY TIME I BRAKED COMMING DOWN THE MOUNTAIN THE CAR WOULD JERK AND SHAKE VIOLENTLY. WHEN WE GOT HOME I TOOK THE CAR INTO THE DEALER AND THEY REPAIRED IT FOR ME AFTER I PLEADED AND AR…
Read full complaint
I BOUGHT A USED KIA OPTIMA 2002 IN JANUARY OF 2003. IT HAD ABOUT 23000 MILES ON IT. WE TOOK A TRIP TO LAKE TAHOE IN FEB.2003 AND ON THE RIDE HOME EVERY TIME I BRAKED COMMING DOWN THE MOUNTAIN THE CAR WOULD JERK AND SHAKE VIOLENTLY. WHEN WE GOT HOME I TOOK THE CAR INTO THE DEALER AND THEY REPAIRED IT FOR ME AFTER I PLEADED AND ARGUED WITH THEM. LESS THAN 8 MONTHS LATER THE SAME POBLEM STARTED HAPPENING AGAIN SO I TOOK MY IN AND THEY AUTOMATICALY PLACED THE BLAME ON ME. THEY TOLD ME THAT I MUST BE DRIVING MY CAR WAY TO HARD AND DON'T KNOW HOW TO PROPERLY APPLY THE BRAKES. THAT CAME FROM THE SERVICE DEPARTMENT MANAGER. THEY THEN TOLD ME THAT THAY ARE NOT REASPONSIBLE FOR REPAIRES THAT ARE CAUSED BY BAD DRIVING. WE'LL HERE IT IS LESS THAN FOUR MONTHS LATER AND I'M ABOUT TO PAY ANOTHER $700 FOR A PROBLEM THAT IS NOT MY FAULT AND MY BRAKES ARE THE WORST YET. OH AND BY THE WAY THE LAST TIME THAT I HAD MY CAR FIXED THEY REFUSED TO SHOW ME THE PARTS THAT THEY TOOK OFF MY CAR. SAID THAT IT IS UNUSUAL TO SHOW THE PARTS TO THE OWNER. I FIND THAT STRANGE. SOMEONE NEEDS TO REFRESH THEM ON THE LAWS. WHEN I PURCHASED MY CAR I ALSO PURCHASED A 5 YR BUMPER TO BUMPER WARRENTY WHICH IS GOOD UNTIL 82000 MILES AND MY CAR KNOW HAS 47000 AND ABOUT TO GO THROUGH ITS THIRD COMPLETE BRAKE JOB. *AK
NHTSA ODI #10074935
Mileage unknown · Jun 1, 2004
Latches/locks/linkages
DOOR LOCKS DON'T LOCK CONSISTENTLY. THE MASTER SWITCH HAS BEEN REPLACED TWICE.*AK
NHTSA ODI #10074605
Mileage unknown · Apr 12, 2004
Visibility
CONSUMER STATED WINDOWS DID NOT ROLL DOWN. DEALERSHIP REPLACED WINDOWS ON SEVEN DIFFERENT OCCASIONS, BUT PROBLEM RECURRED. *AK
NHTSA ODI #10066981
60,233 miles · Mar 21, 2004
Visibility
BOTH FRONT WINDOWS WILL NOT GO UP OR DOWN. YOU CAN HERE THE MOTOR BUT NOTHING IS HAPPENING. *JB
NHTSA ODI #10062726
Official recalls
3May 27, 2009
KIA MOTORS CORPORATION (KMC) IS RECALLING 36,538 MODEL YEAR 2001-2004 OPTIMA VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. ROAD SALT APPLIED IN THESE STATES DURING THE WINTER MONTHS MAY RESULT IN PROGRESSIVE, INTERNAL CORROSION OF THE FRONT SUBFRAME. OVER TIME, SUCH SUBFRAME CORROSION NEAR THE CONNECTION TO THE LOWER CONTROL ARM CAN LEAD TO WHEEL MISALIGNMENT AND/OR OTHER NOTICEABLE STRESS IN STEERING, OR ACCELERATED ABNORMAL TIRE WEAR.
Consequence & remedy
Consequence: CORROSION OF THE FRONT SUBFRAME COULD LEAD TO SEPARATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: KMC WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 15, 2009. OWNERS MAY CONTACT KIA'S CONSUMER ASSISTANCE CENTER AT 1-800-333-4542.
Apr 12, 2004
SOME PASSENGER VEHICLES MAY CONTAIN A FUEL TANK ASSEMBLY VALVE THAT MAY NOT CLOSE PROPERLY. IF A VEHICLE WITH A FUEL TANK ASSEMBLY VALVE THAT IS NOT PROPERLY CLOSED WERE TO ROLL OVER, FUEL SPILLAGE MAY OCCUR.
Consequence & remedy
Consequence: FUEL SPILLAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: DEALERS WILL INSTALL AN ADDITIONAL FUEL TANK ASSEMBLY VALVE. OWNER NOTIFICATION BEGAN JUNE 25, 2004. OWNERS SHOULD CONTACT KIA AT 1-800-333-4542.
Mar 4, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.5 AND 2.7 LITER V6 ENGINES, THE CRANKSHAFT POSITION SENSOR (CKP) CASES DID NOT MEET DIMENSIONAL SPECIFICATIONS.
Consequence & remedy
Consequence: INTERNAL GAPS WITHIN THE CASES ALLOWED EPOXY TO CONTACT THE PRINTED CIRCUIT BOARD, WHICH RESULTED IN CRACKING OF THE CIRCUIT BOARD CAPACITOR. A DAMAGED CKP CAPACITOR COULD RESULT IN ENGINE STALLING.
Remedy: DEALERS WILL REPLACE THE CKP. OWNER NOTIFICATION BEGAN MARCH 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT KIA AT 1-800-333-4542.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration