2024 Kia Niro

The 12-volt battery system in my 2024 Kia Niro (VIN: [XXX] ) has suffered two total failures in under one year of ownership (approx. 10,000 miles). In both instances, the vehicle was completely unresponsive, with no power to essential systems. Safety Risks and Incidents: 1. [XXX]: Vehicle experienced a total power loss. It would not start and all electrical systems were dead. 2. [XXX]: Identical failure. These failures create a significant safety risk by potentially stranding the driver in hazardous locations and disabling critical safety systems, including hazard lights, power steering assist, and emergency braking. If a total power loss occurs while the vehicle is in motion, it could result in a sudden loss of motive power and control, posing an unreasonable risk of accidents or injury. Dealer/Manufacturer Confirmation: The problem was confirmed by Ourisman Kia of [XXX] ). The dealer replaced the 12-volt battery after identifying diagnostic code D04 ("Insufficient Battery Charge Condition Identified"). Despite proof of regular use (1,000 miles/month), Kia America has denied warranty coverage, claiming "insufficient driving". Warning Symptoms: There were no warning lamps or messages prior to either failure. The vehicle functioned normally until it became completely inoperable. I have since installed a third-party battery monitor to mitigate the risk of being stranded by a third failure. Evidence of Trend: A technician at the dealership noted a similar 12V failure in another new 2024 model (Carnival). Numerous other 2024 Niro owners report identical "parasitic drain" issues on NHTSA and consumer forums, suggesting a systemic manufacturing or software defect in the charging system. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2024 Kia Niro. The contact stated that while driving at approximately 65-70 MPH on the highway, the radio panel went blank. The vehicle was blowing cold air on the driver's side while the passenger’s side was blowing hot air. The contact stated that there was slush on the driveway and the vehicle slid. There was a triangle symbol with an exclamation mark displayed. The message that the camera had disengaged was displayed. The contact turned off the vehicle, and the vehicle failed to restart. The contact attempted to start the vehicle and after several hours, the vehicle started. The vehicle was taken to the local dealer, where it was diagnosed that rodents had built a nest in the engine due to the soy-based insulated wires. The dealer noticed a mouse, nuts, and seeds after disassembling the vehicle. The dealer ordered an electrical wiring harness. The dealer called the tire manufacturer, who confirmed the tires were working as designed. The contact replaced the tires. The vehicle was not repaired. The contact called and notified the insurance company of the issues. The manufacturer was not contacted. The failure mileage was approximately 9,999. The VIN was not available.

What happened? While driving my 2025 KIA Niro on [XXX] , I stopped at a red light behind another vehicle. Suddenly, my car was rear-ended by another vehicle, causing a significant impact that pushed my car forward into the vehicle in front. The seat belts deployed but I sustained a broken nose from hitting the steering wheel. My daughter and I were taken to the hospital for treatment. Component or System that Failed or Malfunctioned: The floor wiring assembly beneath the front passenger seat, which may have prevented the front airbags and seat belts from deploying properly, and could have caused an unintended side curtain airbag deployment. The vehicle is available for inspection upon request. Safety Risk: The malfunction posed a serious safety risk as the airbags and seat belts may not have functioned as intended, increasing the risk of injury in the event of a crash. Reproduction of the Problem: The problem has not been reproduced or confirmed by a dealer or independent service center yet. Inspections: The vehicle has been inspected by the police and insurance representatives after the accident. Warning Lamps, Messages or Symptoms: There were no warning lamps, messages, or other symptoms of the problem prior to the failure. Best Assessment of Incident and Cause: The recall notice issued by KIA indicates that the floor wiring assembly beneath the front passenger seat may become damaged, which can prevent the front airbags and seat belts from deploying properly or cause an unintended side curtain airbag deployment. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)