2022 Kia Niro Ev

COMPONENT/SYSTEM: The 12-volt auxiliary battery system, the interior fuse box (Total Integrated Power Module) containing an auto-cutoff relay, and the high voltage battery system. All components are available for inspection. SAFETY RISK: The vehicle has lost power and died while being driven, and has left occupants stranded on multiple occasions. A sudden loss of motive power in traffic creates a serious risk of collision to occupants and to other motorists. The vehicle has failed to start dozens of times. FAILURE DESCRIPTION: The 12-volt battery in my 2022 Kia Niro EV has repeatedly discharged, leaving the vehicle dead and unable to start. ~Six 12V batteries have been installed between January 2025 and February 2026, between 60,431 and 77,130 miles. CONFIRMED BY DEALER: Yes. The condition has been reproduced and documented by the dealer across five separate repair orders. On 1/21/2025 at 60,431 miles, the technician found the 12V battery completely dead after sitting, jump-started the vehicle, and reported no abnormal draw on the electrical system. On 11/05/2025 at 74,355 miles the vehicle again required a jump start to be brought into the shop; the battery was replaced, and the technician reported the vehicle was operating as designed. On 1/22/2026 at 77,124 miles, a technician performed a parasitic draw test and measured 0.185 amps, exceeding the specification of below 50 milliamps by approximately 3.7 times. The technician documented that the auto-cutoff relay was remaining closed, continuously supplying current to 21 modules, and that the interior fuse box required replacement at a quoted cost of $2,048.48. This defect was present during the two prior visits but was not identified. On 2/13/2026 at 77,130 miles, the vehicle would not start when we came to pick up the car. The shop had to provide a loaner, and then another battery was installed, and the TIPM was replaced.

2022 NIRO EV PHANTOM BREAKING WARRENTY DENIED WITH NO DAMAGE VISABLE What component or system failed or malfunctioned, and is it available for inspection upon request? ACC SYSTEMS UNKNOWN KIA CLAIMS MY FRONT RADAR BRACKET IS OFF 1.9 DEGREES. THEY STATE THEIR NO NO PHYSICAL DAMAGE The text stating there was no damage, but Kia wants the bracket replaced, that’s reasonable but why they want you to pay for it I don’t yet understand. I will be looking into this as that’s a key point. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? nope Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? manufacturer PENDING STATE BAR REP How was your safety or the safety of others put at risk? cAR STOPPED ON STRAIGHT AWAY WENT TO 63mph TO 50 VERY QUICK NO INCLINE NO DECLINE NO TURN NOONE OR NOTHING IN FRONT OR AROUND ME