2022 Kia EV6

While driving in a major thoroughfare, a red warning came on to check the electrical system, and that propulsion power may be limited. We pulled over to a parking area and consulted the manual. It suggested turning the engine off and back on again - we did so, but the warning remained. We determined that we were 2-4mi from our Kia dealer. Based on the manual information, we believed we would be able to drive at a slow speed and selected a route towards the dealer that avoided the highway. However then the 'turtle' warning light came on and we we were reduced to walking pace. We pulled into a side road, but were unable to pull over completely before we lost all motion. We activated the warning lights, but after a minute or so there was not even sufficient power for those. This was a rainy day with not great visibility. We feel lucky and this could have been so much more dangerous. We had to redirect cars around us while we waited for towing. The vehicle was at the dealer for a voluntary service campaign the previous month related to the ICCU. The online version of the EV6 2022 manual has different instructions - it says to refrain from driving and have the vehicle towed. We would have followed those instructions.

The vehicle throws a "charge interrupted" error on any Level 2 AC chargers and stops charging within few minutes of starting charge. The charging occurs only for 10~15minutes and immediately stops. The issue has been persistent since 3-4 months now and consistent on every charging session. I have to unplug and replug the charger multiple times to be able to complete charging. This also happened to me on a DCFC 150kW charger as well.

To the questions listed: 1) For the last number of months the car will not fully charge when using a Level 2 charger (note: it will charge using a Level 3 charger). When charging I will get a message that "Charge Interrupted". When I go out to the car the charging has in fact stopped, and the charging cable connector is very hot to the touch. 2) In addition to the inconvenience, I worry the car is a fire hazard putting my family at risk. 3) The Kia dealers have not been able to replicate the problem and insist it is a problem with my charger at home. (Note: I have tested my charging unit on my son's Nissan Leaf and it works fine.) Note: they did apply the "Voluntary Service Campaign" however that did not fix the problem. 4) The car has not been inspected by anyone other then two Kia dealers. 5) After the last software upgrade, we had some random warning lights that would appear, and then disappear. This however, does not appear to be related to the charging issue as far as I can tell. Thank you.

2022 EV6 First Edition. Vehicle no longer accepts level 2 charging at the 11kWh window stick advertised speed. Providing car with any more than 9kwh and the charging port gets very hot and car will stop charging. Dealer is aware of the issue but as of now is unable to diagnose as none of their dealerships have power supplies that exceed 7kwh.

Inlet charging port overheats causing charging to be interrupted when using 40A or higher EVSE. This is dangerous because the charging port or the wiring harness behind it is overheating because of high electrical power which can cause a fire. Kia has acknowledged this problem by issuing a TSB which reduces the charging rate when the overheating is detected but this does not solve the actual problem with the port or wiring harness.

While driving the vehicle with the main propulsion battery charged to 85%, a battery failure warning light lit at the time the vehicle lost power, slowed down to a stop and lost all lighting. The fault was a failure of the 12 VDC auxiliary power system which resulted in a loss of vehicle speed, dash board buttons to not function, and vehicle controls including lights to be lost. The vehicle was unable to be locked. The vehicle lost power and speed in a remote location causing me to pull off of the road. The vehicle lost all lighting preventing me from warning other drivers of the hazard situation. The car was towed to the nearest Kia Dealership who has confirmed that the 12 VDC power system was de-energized, caused by a dead 12 VDC battery and failed charging module (Kia Part Number 36400-1XFA0) and is currently awaiting replacement under warranted repair when the parts become available.

On 5 May 2023 our 2022 Kia EV6 WIND AWD Automatic vehicle (~11,200 miles on the odometer) was being driven under normal conditions at approximately 30 mph in city traffic when the car lost motive power and a dashboard alerts appeared stating "stop vehicle and check power supply" and "check electrical vehicle system." The driver complied but the shutdown occurred on a heavily trafficked road and put the driver and other travelers at risk and caused the driver considerable distress. The incident was reported to the dealer and manufacturer via the Kia Access app, and the car was towed to the nearest Kia dealer and service center on May 8. The dealer diagnosed the problem as caused by a defective ICCU (a part of the electrical powertrain control system) requiring replacement. As of 12 July 2023, Kia has not provided a replacement part and it remains on backorder with no ETA for arrival. We have not been contacted by Kia and to our knowledge no one has inspected the vehicle other than the dealer service technicians.