Heard a loud pop noise as I was driving. Check Electrical System warning immediately flashed on the dash and vehicle slowed down while I was driving. Moments later, vehicle entered "turtle mode" allowing for restricted speeds. Vehicle then flashed error message about 12V battery having low charge. Vehicle continued to reduce max…
Read full complaint
Heard a loud pop noise as I was driving. Check Electrical System warning immediately flashed on the dash and vehicle slowed down while I was driving. Moments later, vehicle entered "turtle mode" allowing for restricted speeds. Vehicle then flashed error message about 12V battery having low charge. Vehicle continued to reduce maximum speed until it came to a stop minutes later. No previous symptoms and all TSBs and recalls had been performed on the vehicle. Tow truck was necessary to get the vehicle to a dealer. Vehicle currently with the dealer awaiting assessment and diagnostics.
NHTSA ODI #11578756
Mileage unknown · Mar 15, 2024
Electrical System
Premature failure (23 months) of the 12 volt battery Dealer unwilling to replace battery under 3-year warranty Vehicle taken to dealership - supposedly submitted to tech support under case# 16248382 (see attached)
NHTSA ODI #11577549
Mileage unknown · Mar 12, 2024
Electrical System
12v battery died suddenly, prematurely, and unexpectedly while driving at highway speeds. All vehicle safety functions failed and car immediately lost all power. Was able to pull over safely at which point vehicle shut it self off and would not start again
NHTSA ODI #11577024
Mileage unknown · Mar 11, 2024
Electrical SystemPower TrainVehicle Speed Control
While driving my car on March 7th, 2024 around 2:30pm an error message popped up "Stop vehicle and check power supply" and speed of the car was noticeably limited. Thankfully I was able to pull to side of the road and called road side assistance as car was undrivable, the 12 volt battery was completely dead. When tow truck arriv…
Read full complaint
While driving my car on March 7th, 2024 around 2:30pm an error message popped up "Stop vehicle and check power supply" and speed of the car was noticeably limited. Thankfully I was able to pull to side of the road and called road side assistance as car was undrivable, the 12 volt battery was completely dead. When tow truck arrived, a jump park was required to put car into neutral in order to get onto tow truck. If this happened in a freeway this could be a risk if we are not able to stop at a safe location. Towing services was able to tow my car to the dealership about 15 minutes away, upon unloading vehicle onto lot, taking an Uber home as no loaners are available, asked the next day about getting car into diagnosis and was told that it would take 2 weeks to get in to be looked at, and now it sits until they are able to diagnose a known problem, even the sales manager at this dealership has had same issue on 3 different EV6's. He assured me they know what to look for when it comes to the issue. After doing some research this issue, it is a well known issue with Hyundai/Kia cars and it looks like the ICCU module needs to be replaced. And Hyundai/Kia EVs and was supposedly addressed in a recall done in late September of last year, yet I have gone back and made a complaint with Kia regarding this issue, but in their eyes it was fixed in the recall. This new issue now goes under same case number associated with the charging interrupted error, where charging stops after 10 mins, took to dealership had the update done and still same issue. Continued to have problems charging on level 2 charger, even at a lowered amps. Lowering the amount that is recommended by the manufacturer and still having the same issue. Thank You.
NHTSA ODI #11576702
Mileage unknown · Mar 11, 2024
Electrical SystemExterior LightingLane Departure
While driving at normal road speeds, the vehicle suddenly lost all electronics (infotainment, air conditioning, dash). After 2-3 minutes these systems came back online but the car continued to have a warning light for the Lane Keeping system not functioning. This warning now comes on periodically after this incident
NHTSA ODI #11576576
Mileage unknown · Mar 10, 2024
Electrical SystemPower Train
When driving at 35 mph on level ground, a loud "pop" was heard and the vehicle immediately lost power and warning messages having to do with the 12V system appeared on the instrument panel warning that the car needed to be pulled over in a safe spot and turned off. The vehicle was transported to a local KIA dealer via flatbed an…
Read full complaint
When driving at 35 mph on level ground, a loud "pop" was heard and the vehicle immediately lost power and warning messages having to do with the 12V system appeared on the instrument panel warning that the car needed to be pulled over in a safe spot and turned off. The vehicle was transported to a local KIA dealer via flatbed and has now been at the dealer for more than 30 day. So far, the 12V battery, the ICCU, the inverter and ICCU fuse have been replaced.
NHTSA ODI #11576449
Mileage unknown · Mar 9, 2024
Electrical System
While driving my car on [XXX] around [XXX] an error message popped up "Stop vehicle and check power supply" and speed of the car started to decline. I could not drive more than 20mph on a main street that had a speed limit of 35 mph. Thankfully I was able to park at a Ralphs in a safe place before the car died. The 12 Volt batte…
Read full complaint
While driving my car on [XXX] around [XXX] an error message popped up "Stop vehicle and check power supply" and speed of the car started to decline. I could not drive more than 20mph on a main street that had a speed limit of 35 mph. Thankfully I was able to park at a Ralphs in a safe place before the car died. The 12 Volt battery died. If this happened in a freeway this could be a risk if we are not able to stop at a safe location. Towing services was able to tow my car home but I had to keep a portable jumper connected to the car so I can move the car on the flatbed since I couldn't put the car in Neutral for towing. I replaced the 12 Volt battery the next day, but the issue persists and the next available appointment is on April 1st. Upon researching this issue, it is a well known issue with Hyundai/Kia cars and it looks like the ICCU module needs to be replaced. Please look into this issue. Here are some links for reference: [XXX] [XXX] Thank You. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11576403
Mileage unknown · Mar 9, 2024
Electrical SystemFuel/propulsion SystemVehicle Speed Control
While driving, EV vehicle suddenly lost most of its power. Normal driving on 45 mph street until came to stop light. Would not accelerate over 28 mph upon light changing to green. 12v battery warning light came on.
NHTSA ODI #11576389
Mileage unknown · Mar 8, 2024
Electrical System
Charging stops after 10 mins, took to dealership had the update done. Still continue to have problems charing on level 2 charger. Lowered the amps on charger. Lowered the amount fully in recommended by the manufacturer still have the same issue.
NHTSA ODI #11576134
Mileage unknown · Mar 5, 2024
Electrical System
12 Battery drains out so fast and so often . Even if it is charged overnight externally . it drains out so fast that after driving some distance and after switching off , it does not come back up and we cannot start the car and have to use a jumper to start the car . My car is car dealer for 2 weeks and they are unable to find f…
Read full complaint
12 Battery drains out so fast and so often . Even if it is charged overnight externally . it drains out so fast that after driving some distance and after switching off , it does not come back up and we cannot start the car and have to use a jumper to start the car . My car is car dealer for 2 weeks and they are unable to find fix , though they have opened a ticket with Kia Tech and they have 7 such cars as of today facing the same issue.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 and 2024 EV9 vehicles. The high voltage battery cells may contain misaligned electrodes, which can lead to a fire while parked or driving.
Consequence & remedy
Consequence: A fire increases the risk of injury.
Remedy: Owners are advised to park outside and away from structures and limit their charge to a maximum of 80% until the recall repair is complete. Dealers will replace the high voltage battery system assembly, free of charge. Owner notification letters are expected to be mailed August 7, 2026. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC375. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov beginning July 17, 2026.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Electrical SYSTEM:12V/24V/48V Battery
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-volt battery, which can result in a loss of drive power.
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters were mailed December 13, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC327. This recall expands and replaces previous recall number 24V-200. Vehicles previously repaired under recall 24V-200 will need to have the new remedy completed.
Kia America, Inc. (Kia) is recalling certain 2022-2024 EV6 vehicles. The Integrated Charging Control Unit (ICCU) may become damaged and stop charging the 12-Volt battery, which can result in a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will inspect and replace the ICCU and its fuse, as necessary. In addition, dealers will update the ICCU software. All repairs will be performed free of charge. Owner notification letters are expected to be mailed April 29, 2024. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC302.
Kia Motor America (Kia) is recalling certain 2022 EV6 vehicles. A software error in the Shifter Control Unit (SCU) may disengage the parking mechanism, which can allow the vehicle to rollaway.
Consequence & remedy
Consequence: Vehicle rollaway can increase the risk of a crash or injury.
Remedy: Drivers are recommended to park their vehicles on level ground and avoid parking on a slope/inclined surface whenever possible until the remedy has been performed. Dealers will update the Shifter Control Unit software, free of charge. Owner notification letters were mailed May 25, 2022. Owners may contact Kia customer service at 1-800-333-4542. Kia's number for this recall is SC236.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Electrical SYSTEM:12V/24V/48V Battery
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
On July 3, 2023, the Office of Defect Investigation (ODI) opened PE23012 to investigate allegations of loss of motor power on model year (MY) 2022 Kia EV6 vehicles. Some consumers reported loss of motor power immediately after warning lamp illumination or reduction of motive power while the vehicle was in motion. This investigation found that the Integrated Charing Unit (ICCU) may become damaged over time from transient high voltage and thermal cycling. A damaged ICCU may not be able to charge the 12-volt battery which can discharge gradually while driving with a reduction of motive power. The vehicle could eventually experience a complete loss of motive power thereby increasing the risk of a crash. On July 13, 2023, Kia conducted a service campaign to inspect the ICCU and install an improved over-current detection software logic in certain 2022-2023 EV6 vehicles. On March 15, 2024, Kia filed recall 24V-200 for 48,232 MY 2022-2024 Kia EV6 vehicles. The recall remedy provides an inspection of the ICCU, and if necessary, a replacement of the ICCU and the associated fuse. The ICCU software reduces the risk of overcurrent and implements voltage peak reduction at the end of EV battery charging. The recall also includes a software update that revises the electric water pump operational threshold to reduce thermal loading during charging and driving. In view of the recall action being taken by Kia, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2022 Kia EV6 Problems, Complaints & Recalls | Skip That Year
Illustration