2021 Jeep Wrangler

Glendale Dodge (CA) is actively using Federal Fire Risk Recall 68C to fraudulently conceal a separate, critical High-Voltage hardware failure on my 2021 Jeep Wrangler 4xe. Upon intake, my vehicle’s internal VIP diagnostic scan showed an active P0E15 code (Electric Coolant Heater Failure). Per Stellantis Technical Service Bulletins, this code indicates a severe failure requiring a physical hardware replacement to ensure the high-voltage system operates safely. To avoid performing this costly warranty repair, the dealership deliberately falsified the diagnosis on Final Invoice #31349. Under Line C (Customer States Check Engine Light is On), the dealership officially recorded the cause and correction as: 'DUE TO RECALL MODULE UPDATES AND BAD BATTERY.' This is an affirmatively false written diagnosis. A dead 12V battery and a recall software update do not cause, nor do they resolve, a P0E15 High-Voltage Electric Coolant Heater failure. The dealership lied on the legal invoice to scrub the hardware defect from the record. They then applied the 68C software patch as a smokescreen, falsified the 'Date Out' to 12/26/2025 to prematurely close the federal recall ticket, and attempted to return a vehicle that remains mechanically compromised and unsafe. This is intentional warranty fraud masking a high-voltage system failure. Stellantis and its authorized repair facility are refusing to properly remedy the vehicle. The vehicle is currently held at the dealership pending an active fraud investigation by the California Bureau of Automotive Repair (Case #6596-WS4PV6).

I own a 2021 Jeep Wrangler Rubicon 392 with the 6.4L engine (VIN: [XXX] ). The vehicle has a dangerous condition where the engine stalls unexpectedly when the fuel level is approximately 1/4 tank or lower and the vehicle is traveling downhill. When the vehicle is positioned on a decline or downhill slope, the engine suddenly shuts off without warning. This appears to be fuel starvation on decline when the fuel level is below approximately 1/4 tank, resulting in engine stall and loss of power steering and braking assist after stall. This has occurred multiple times and creates a significant risk of crash due to the sudden loss of engine power and reduced steering and braking assistance while the vehicle is in motion. The issue is particularly concerning when descending hills or driving on angled terrain. The vehicle was taken to an authorized dealership (Carvana Jeep San Diego) where technicians determined the likely cause is a defective fuel pump module associated with the Wrangler Rubicon 392 6.4L fuel pump module. However, the dealership informed me the replacement fuel pump module is currently on national backorder from the manufacturer (Stellantis/Jeep). They stated there is no confirmed availability date and that many vehicles may be waiting for the same component. My vehicle has been awaiting repair for approximately four months due to the unavailable fuel pump module. Because the vehicle can stall unexpectedly while traveling downhill, this defect presents an ongoing safety hazard and potential risk of crash. This complaint is being submitted so the issue can be evaluated as a potential safety defect involving fuel delivery failure, fuel pump module malfunction, and engine stall under low fuel conditions in the Jeep Wrangler Rubicon 392. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My 2021 Jeep Wrangler Rubicon (3.6L eTorque, automatic transmission) has experienced recurring drivetrain instability beginning at approximately 2,000 miles while under factory warranty. The vehicle intermittently exhibits a high-RPM flare during acceleration, where the engine speed increases without a commensurate increase in vehicle acceleration. The transmission then abruptly engages, causing sudden jerking. At low speeds (approximately 10–5 mph), the vehicle shudders and harshly downshifts, creating a sudden grabbing sensation. Engine RPMs fluctuate during deceleration as if the transmission cannot smoothly match engine speed. Braking feels inconsistent, and at times it feels as though the vehicle is accelerating or resisting braking input before abruptly slowing. The vehicle has felt as though it would stall at low speeds and has stalled intermittently. Additionally, the forward collision warning / automatic emergency braking system has activated without an obstacle present. There have also been intermittent instances of loss of power steering assist. The engine has developed a ticking noise and a high-pitched ringing/whining sound from the engine area during operation. In January 2026, the transmission catastrophically failed and required replacement of the transmission, torque converter, cooler, and control module. The vehicle was out of service for over 24 days. Following installation of a Mopar remanufactured transmission and torque converter, the same symptoms have recurred, including RPM flare, delayed shifting, shuddering, harsh downshifts, unstable deceleration, and abnormal engine noises. These conditions present a safety concern due to loss of expected acceleration, unpredictable torque engagement, unintended braking activation, intermittent power steering loss, stalling behavior, and drivetrain instability. The vehicle is currently under further diagnostic evaluation. I have multiple documents, but the file is too large to upload

There has been an electrical issue with this car since it was purchased in May 2021. The start stop system has always said service it and each time the dealership has said the temperature in the car has to be prime. It still doesn’t work. The key fobs continue to disconnect even with new batteries. The screen at times delays and needs an upgrade. The battery or both batteries even in the summer dies if the car isn’t driven for more than 3 days. We spend more time jumping the vehicle than driving it. It’s a 2021 and only has 35000 miles on it. Why pay for a vehicle that spends more time in the shop than in the driveway?

My engine light came on shortly after my first warranty oil change August 23,2025 at the Tonkin Hillsboro dealership. During my 2nd warranty oil change January 9,2026 at Tonkin Hillsboro dealership I let them know my engine light came on after their last service and they wanted to charge me the diagnosis fee. After continued discussion learned they already checked the code indicator and mentioned possible gas cap seal and it was not fixed. Today I received an Updated Carfax of my recent service and saw a recall for my vehicle dated on October 30, 2025 re: Urgent Fire Risk When Parked. NHTSA Recall Number 25V741000 Manufacturer Recall Number68C NHTSA Recall Number25V-741 Recall StatusRecall Incomplete This safety was not checked, fixed or completed within the consumer regulatory requirement of recalls while my vehicle was in service and in their observation. If the recall notice is dated October 30, 2025, there should be no reason for an oversight in providing clear communication and corrective action immediately while the vehicle was in service on January 9,2025 and communication/information before I picked up the vehicle and drove it off the lot. This is a certified vehicle that so far has not given me any confidence of proper dealership quality and car for vehicle safety and consumer co concern.

Vehicle started and put in reverse. after backing up approximately 15 ft, vehicle put into driver and once accelerator was pressed, vehicle stalled. Tried to restart, engines turned over but stalled again after 1 second. Waited 10 seconds and tried to restart again, stalled again 1 second after turnover. Turned vehicle completely off, opened door, waited 30 seconds, tried starting again and system attempted to stat for 5-10 seconds (push to start ignition so I had no control over how long it tried this), but engine would not turn over. Vehicle also could not be shifted out of park (turned vehicle off and tried to put in “On” position without ever depressing the brake). Vehicle now stuck in driveway and unable to be moved. Acting like an issue with the fuel pump, which is a recall that was announced for some vehicles of this make and model, but NHTSA check shows no open recalls on vehicle. No warning lights or check engine lights came on.

Multiple failed recalls to stop vehicle High Voltage battery fires. I've already had the battery pack replaced once and now another recall of a software flash (68c) to test the battery cells separators for damage. So again the issue is still there and this is just another band-aid to catch it before it catches fire. This has been a ongoing issue for over a year and the issue is still not properly corrected. Multiple months of no charging, no parking in garage or near other vehicles/structures just to have another band-aid of a software flash, to stop the fire before it starts doesn't make me feel safe enough to put my family in this vehicle or to still want to charge or park anywhere near other vehicles or structures. This is the same process that "fixed" this issue the last time that obviously isn't a fix at all. The new battery they installed in 07/22/25 is just more of the same junk batteries without a proper fix.

Jeep has a design defect in vehicles equipped with the 2.0L turbocharged engine where the coolant reservoir is positioned directly adjacent to the turbocharger and turbo heat source with insufficient heat shielding. Due to the constant high heat exposure, the plastic coolant reservoir and/or connecting plastic fittings degrade, warp, and become brittle over time, eventually leading to coolant leaks, erratic coolant temperature readings, and/or sudden coolant loss. This failure often occurs without warning, and many vehicles do not initially trigger a check engine light. In my case, the vehicle exhibited intermittent coolant temperature readings, abnormal fan operation, and heating inconsistencies before the leak was discovered. Multiple repair attempts are frequently made before the root cause is identified. Mechanics often replace components such as the thermostat housing, coolant temperature sensors, or related assemblies, not realizing the coolant reservoir heat damage is the underlying cause. This results in unnecessary repairs, significant consumer expense, and extended vehicle downtime.This defect poses a serious safety risk, as coolant loss can result in: •Engine overheating •Sudden loss of power •Potential engine failure while driving •Increased risk of breakdown in traffic or unsafe driving conditions Numerous owners report similar failures, indicating this is not an isolated incident but a widespread design flaw affecting Jeep vehicles equipped with the 2.0L turbo engine.Jeep has not issued a Technical Service Bulletin or recall addressing the placement of the coolant reservoir or providing guidance to technicians to inspect for heat-related degradation in this area.I am requesting that NHTSA investigate this design defect and require Jeep to issue a Technical Service Bulletin or recall addressing this. The vehicle was properly maintained and not modified and The issue occurred at relatively low mileage.

I purchased (traded into) a 2021 Jeep Wrangler on October 31, 2024. The vehicle already had an open safety recall (68C) at the time of purchase. Shortly after, the vehicle began experiencing severe and dangerous safety failures. While driving, the Jeep suddenly goes into “turtle mode,” loses power without warning, and drops to 7–12 mph in traffic. The engine light comes on and the vehicle becomes almost undrivable. This creates an extremely hazardous situation where I could be rear-ended or left stranded on the road. This is a serious safety risk to me and to other drivers. I contacted Jeep/Stellantis Recall Customer Care to report the issue. Only after calling did I receive an email telling me I must pay out of pocket for a rental vehicle, even though the vehicle is unsafe and the recall remedy is not available. I immediately responded saying I cannot pay upfront. Since November 25, Jeep/Stellantis has ignored my messages completely. The vehicle remains unsafe, undrivable, and under a recall with no available parts. Jeep has refused to provide a direct-billed rental or any safe alternative transportation. I have been left without a usable vehicle while the manufacturer fails to communicate or offer assistance. This is a major safety defect, and the lack of manufacturer response puts me in danger. If this vehicle loses power in traffic again, it could cause an accident. I am requesting NHTSA intervention because Jeep/Stellantis is not addressing this safety issue, not providing a remedy, and not honoring their recall responsibilities. Symptoms: •Sudden power loss •Turtle mode activation •Speed dropping to 7–12 mph unexpectedly •Engine warning light on •Vehicle unsafe to operate Manufacturer Failure: •Recall 68C remedy unavailable •Denied direct-billed rental •Required me to pay upfront for rental •No response to my communication since Nov 25 •Left me without transportation

In June 2025, I brought my vehicle to the dealership (Hendricks Chrysler Dodge Birmingham, AL) for a full diagnostic inspection, and at that time I was told everything was fine. There were no warnings, no notes about electrical issues, airbags, coolant leaks, engine leaks, or any of the major concerns now being reported. On my most recent visit (October 2025), the dealership suddenly reported multiple “Immediate Attention” failures, including: • Airbag system issues • Electrical system failure • Coolant system leak • Water pump leak • Engine oil separator leak These items were never mentioned during my previous full diagnostic despite being safety-related components that typically show symptoms or codes. Because these new issues involve critical components like the airbags, engine, and electrical system, my safety was put at risk. I have been driving the vehicle daily under the belief that it had passed a full diagnostic months earlier. If these problems really existed at that time, then I was unknowingly operating an unsafe vehicle. If they did NOT exist, then the sudden appearance of multiple major failures raises concerns about incorrect diagnostics or improper prior inspection. I have not received any warning lights except the airbag light. The dealership has not provided a clear explanation as to how these issues appeared only months after a full inspection. This has caused significant concern regarding vehicle safety, diagnostic reliability, and whether the previous inspection was performed correctly. I am requesting NHTSA review because the dealership failed to identify or disclose major safety-related failures, which has potentially placed me in danger without any warning.