IllustrationGASOLINE SPILL EACH TIME FUEL TANK IS FILLED. AT ABOUT THE SAME TIME THE TANK REACHES FULL AND SHUTS OFF THE GAS FLOW AT THE NOZZLE A LARGE VOLUME OF GASOLINE RUSHES OUT OF THE FILLER NECK OF THE VEHICLE AND ONTO THE PAVEMENT. POTENTIALLY DANGEROUS SITUATION AND QUITE PREVALENT IN THIS MODEL VEHICLE. *TR
2006 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2006 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
22925–50K
11950–75K
4675–100K
25100–150K
4150K+
624 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 355 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports7 fire reports17 injury reports
What owners actually said
730 reportsEVERY TIME I FILL MY FUEL TANK WITHOUT METERING THE FUEL THE LAST GALLON, THE SHUT-OFF VALVE FAILS AND FUEL POURS OUT OF THE FILLER NECK ONTO THE GROUND, JEEP, AND MYSELF IF I'M CLOSE ENOUGH. *TR
GAS TANK OVERFLOW WHEN FILLING AT GAS PUMP. SPRAYS OUT OF FILL TUBE WHEN FILLING. *TR
EVERY TIME I FILL MY 2006 WRANGLER WITH GASOLINE, IT SPILLS. *TR
MULTIPLE INSTANCES OF GAS TANK IN MY 2006 JEEP WRANGLER UNLIMITED OVERFLOWING, DUE TO POSSIBLE CHECK VALVE MALFUNCTION AND/OR IMPROPER DESIGN FROM FACTORY. *TR WHEN FILLING ONES GAS TANK, YOU WOULD EXPECT THE PUMP TO STOP ONCE THE TANK HAS REACHED ITS CAPACITY. HOWEVER DUE TO A FAULTY IN-TANK CHECK VALVE, THE PUMP NEVER GET…
Read full complaint
MULTIPLE INSTANCES OF GAS TANK IN MY 2006 JEEP WRANGLER UNLIMITED OVERFLOWING, DUE TO POSSIBLE CHECK VALVE MALFUNCTION AND/OR IMPROPER DESIGN FROM FACTORY. *TR WHEN FILLING ONES GAS TANK, YOU WOULD EXPECT THE PUMP TO STOP ONCE THE TANK HAS REACHED ITS CAPACITY. HOWEVER DUE TO A FAULTY IN-TANK CHECK VALVE, THE PUMP NEVER GETS THE PRESSURE CHANGE AS A SIGNAL TO STOP THE FLOW. HENCE, EVERY TIME I FILL UP I END UP SPILLING A NOT-INSIGNIFICANT AMOUNT OF FUEL ON THE GROUND. THIS ISSUE IS ABSOLUTELY NOT OPERATOR ERROR, IT IS A KNOWN DEFECT BY JEEP/CHRYSLER.
THE GAS SPILLS OUT EVERYTIME I FILL UP. THE PUMP DOES NOT CLICK OFF UNTIL GAS SPRAYS OUT OF THE FILLER NECK. IT IS NOT THE GAS PUMP BECAUSE THIS IS AN ONGOING PROBLEM AND I FILL UP AND MAY DIFFERENT PLACES. *TR
GAS TANK OVERFLOWS EVERY TIME TANK IS FILLED. *TR
FUEL SPEWS FROM FUEL TANK DURING FILL UP. FUEL NOZZLE WOULD SHUT OFF NORMALLY UNTIL RECENTLY IT HAS NOW BECOME A PROBLEM. THIS SHOULD NOT HAPPEN AND THIS PROBLEM IS POTENTIALLY VERY DANGEROUS TO NOT ONLY MYSELF BUT TO OTHERS SHARING ADJACENT PUMPS NOT TO MENTION THE ENVIRONMENT. *TR
WHILE FUELING VEHICLE AT GAS STATION, FUEL SPLASHES OUT BEFORE FUEL PUMP SHUTS OFF AT FILL UP. REGARDLESS OF GAS STATION OR SPEED AT WHICH PUMP IS SET AT FUEL ALWAYS SPILLS UNTO VEHICLE AND GROUND. IT IS APPARENT THAT THE FUEL TANK'S ROLL OVER CHECK VALVE IS AT FAULT.
2006 JEEP WRANGLER RUBICON - DURING EVERY FUELING THE FUEL TANK WILL OVERFLOW, THIS ALLOWS GAS TO RUN ON THE GROUND AND ON MY PERSON IF STANDING TOO CLOSE TO THE VEHICLE. *TR
Official recalls
315V222000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
Apr 15, 2015
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
06V147000 · Power Train:clutch Assembly
May 3, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.