IllustrationEVERY TIME I FILL UP MY GAS TANK IT OVERFLOWS, SPILLING GAS DOWN MY JEEP BEFORE AUTOMATICALLY SHUTTING OFF THE GAS COMING OUT OF THE HOSE. THIS HAS HAPPENED EVERY TIME SINCE I PURCHASED IT NEW FROM THE DEALERSHIP. MANY OTHER JEEP FRIENDS HAVE VOICED THE SAME PROBLEM.
2006 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2006 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
22925–50K
11950–75K
4675–100K
25100–150K
4150K+
624 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 355 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports7 fire reports17 injury reports
What owners actually said
730 reportsEVERY TIME I FILL THE TANK ON MY JEEP, IT DUMPS FUEL WHEN IT IS FULL. USUALLY SPRAYING ALL OVER ME AND THE SIDE OF THE JEEP.
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 50 MPH THE CHECK ENGINE WARNING LIGHT ILLUMINATED, FOLLOWED BY A RAPID DECREASE IN THE RPMS. THE ENGINE STALLED AND RESTARTED. THE FAILURE OCCURRED TEN TIMES WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE FOR THE SIMILAR FAI…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE DRIVING APPROXIMATELY 50 MPH THE CHECK ENGINE WARNING LIGHT ILLUMINATED, FOLLOWED BY A RAPID DECREASE IN THE RPMS. THE ENGINE STALLED AND RESTARTED. THE FAILURE OCCURRED TEN TIMES WHILE DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TWICE FOR THE SIMILAR FAILURE. THE TECHNICIAN WAS UNABLE TO DUPLICATE OR LOCATE THE FAILURE . THE MANUFACTURER WAS NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 34,000. UPDATED 07/28/11 *BF UPDATED 11/18/11
EVERYTIME I FILL UP THE GAS TANK, GAS POURS OUT ON ME. *TR
I OWN A 2006 JEEP WRANGLER. MANY TIMES WHEN I FILL THE GAS TANK THE FUEL DOES NOT SHUT OFF AND SPILLS FUEL ON THE VEHICLE AND GROUND. *TR
WHEN OPERATING THE VEHICLE AT HIGHWAY SPEEDS, STRIKING A SMALL BUMP IN THE ROADWAY CAUSES SEVERE FRONT END OSCILLATION FROM THE AXEL. THE VIBRATION IS SO VIOLENT, IT CAUSES THE VEHICLE TO FEEL AS THOUGH IT WILL COME APART. THE ONLY WAY TO STOP THE VIBRATIONS IS TO ABRUPTLY REDUCE SPEEDS TO A STOP. *TR
MY 2006 JEEP WRANGLER SPITS GASOLINE OUT AT ME WHEN FILLING THE VEHICLE! IT ALWAYS HAPPENS WHEN NEARING FULL, NO MATTER WHAT I DO TO TRY TO AVOID IT FROM HAPPENING. SOMETIMES IT SPITS FORCEFULLY, HARD ENOUGH TO GET GASOLINE ON ME, SOMETIMES IT'S JUST A MINOR SPIT THAT JUST DRIBBLES DOWN THE VEHICLE. EITHER WAY, IT OCCURS EVER…
Read full complaint
MY 2006 JEEP WRANGLER SPITS GASOLINE OUT AT ME WHEN FILLING THE VEHICLE! IT ALWAYS HAPPENS WHEN NEARING FULL, NO MATTER WHAT I DO TO TRY TO AVOID IT FROM HAPPENING. SOMETIMES IT SPITS FORCEFULLY, HARD ENOUGH TO GET GASOLINE ON ME, SOMETIMES IT'S JUST A MINOR SPIT THAT JUST DRIBBLES DOWN THE VEHICLE. EITHER WAY, IT OCCURS EVERY TIME I ATTEMPT TO FILL THE TANK TO FULL. I HAVE RESORTED TO ONLY PUTTING 10 GALLONS OF GASOLINE IN AT A TIME, AND ONLY IF THE FUEL GAUGE READS BELOW 1/4, TO ENSURE I DON'T HAVE TO EXPERIENCE THE GASOLINE SPIT-BACK. NO PARTS HAVE BEEN REPLACED OR REPAIRED YET. *TR
MY 2006 JEEP WRANGLER SPEWS GAS OUT WHEN I'M FILLING THE TANK. IT HAPPENS EVERY TIME I PUT GAS IN IT. IT COMES OUT IN A GUSH, SPLASHING ALL OVER ME AND THE SIDE OF THE JEEP. I HAVEN'T HAD ANY PARTS REPAIRED OR REPAIRED YET. *TR
WHEN FILLING THE GAS TANK ON MY JEEP WRANGLER IT OVERFLOWS BEFORE THE PUMP AUTOMATICALLY SHUTS OFF. THIS HAPPENS AT MANY DIFFERENT GAS STATIONS, SO I DO THINK IT'S A PARTICULAR PUMP OR STATION. *TR
EVERY TIME I TRY TO FILL THE GAS TANK UP TO FULL, THE FUEL WILL OVERFLOW OUT OF THE FILLER NECK. ALSO, WHEN I PUMP GAS, THE FUEL WILL OFTEN BACKFLOW INTO THE PUMP, CAUSING IT TO SHUT OFF PREMATURELY (ABOUT EVERY 10 SECONDS, REGARDLESS OF AMOUNT OF GAS IN TANK). THIS HAS BEEN AN ONGOING PROBLEM EVER SINCE I FIRST PURCHASED THE…
Read full complaint
EVERY TIME I TRY TO FILL THE GAS TANK UP TO FULL, THE FUEL WILL OVERFLOW OUT OF THE FILLER NECK. ALSO, WHEN I PUMP GAS, THE FUEL WILL OFTEN BACKFLOW INTO THE PUMP, CAUSING IT TO SHUT OFF PREMATURELY (ABOUT EVERY 10 SECONDS, REGARDLESS OF AMOUNT OF GAS IN TANK). THIS HAS BEEN AN ONGOING PROBLEM EVER SINCE I FIRST PURCHASED THE VEHICLE. MY ONLY CHOICE IS TO NEVER FILL MY GAS TANK ALL THE WAY, AND PUMP THE GAS SLOWLY. *TR
Official recalls
315V222000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
Apr 15, 2015
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
06V147000 · Power Train:clutch Assembly
May 3, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.