Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
22925–50K
11950–75K
4675–100K
25100–150K
4150K+
624 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Gasoline. Review the 355 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel/propulsion System. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports7 fire reports17 injury reports
What owners actually said
730 reports
80,000 miles · May 6, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT FUEL SPILLED TO THE GROUND WHEN THE FUEL TANK WAS FILLED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED WHICH LOCATED THE FAILURE AT THE FUEL TANK VALVE. THE DEALER ADVISED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRE…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT FUEL SPILLED TO THE GROUND WHEN THE FUEL TANK WAS FILLED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED WHICH LOCATED THE FAILURE AT THE FUEL TANK VALVE. THE DEALER ADVISED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 85,000.
NHTSA ODI #10510755
48,000 miles · May 4, 2013
Fuel/propulsion System
WHEN FILLING UP THE GAS TANK, GAS WILL POUR OUT WHEN IT'S FULL/OVERFULL AND SOMETIMES SPRAY GAS EVERYWHERE. *TR
NHTSA ODI #10510637
45,000 miles · Apr 23, 2013
Fuel/propulsion System
FUELING THIS VEHICLE IS EXTREMELY DIFFICULT AND DANGEROUS DUE TO THE FACT THAT NO MATER HOW SLOW YOU TRY TO PUMP FUEL INTO IT SHOOTS BACK UP THE TANKS FUEL PIPE AND ONTO THE GROUND AND ON YOU IF YOU ARE NOT CAREFUL. THIS FUEL SYSTEM HAS AN OBVIOUS FLAW. NO VEHICLE SHOULD BE THIS DIFFICULT TO FUEL. IN 40 YEARS OF DRIVING I HAVE …
Read full complaint
FUELING THIS VEHICLE IS EXTREMELY DIFFICULT AND DANGEROUS DUE TO THE FACT THAT NO MATER HOW SLOW YOU TRY TO PUMP FUEL INTO IT SHOOTS BACK UP THE TANKS FUEL PIPE AND ONTO THE GROUND AND ON YOU IF YOU ARE NOT CAREFUL. THIS FUEL SYSTEM HAS AN OBVIOUS FLAW. NO VEHICLE SHOULD BE THIS DIFFICULT TO FUEL. IN 40 YEARS OF DRIVING I HAVE NEVER HAD ANYTHING LIKE THIS WITH ANY OTHER VEHICLE. I WON'T LET ANYONE ELSE PUT FUEL IN THIS 2006 JEEP WRANGLER BECAUSE I'M AFRAID A SERIOUS ACCIDENT COULD TO EASILY OCCUR. *TR
NHTSA ODI #10509248
15,000 miles · Apr 19, 2013
Fuel/propulsion System
FUEL SPILLS EVERY TIME I FILL THE TANK. THE THING THAT IS SUPPOSED TO SHUT OFF THE NOZZLE DOES NOT WORK. *TR
NHTSA ODI #10508884
65,000 miles · Apr 18, 2013
Electrical System
JEEP AT TIMES HAS COMPLETELY SHUT DOWN DURING OPERATION EVEN AT HIGHER SPEEDS. IF YOU PULL OVER AND WAIT A MINUTE OR TAP ON THE TIPM THE CAR WILL OPERATE AGAIN. ALSO AT TIMES THE HORN, WIPERS / FLUID, AND ALL LIGHTS COME ON CONSTANTLY WHILE DRIVING. YOU CAN TAKE THE KEY OUT OF THE CAR IT EVEN STAYS ON AND EVERYTHING STAYS ON …
Read full complaint
JEEP AT TIMES HAS COMPLETELY SHUT DOWN DURING OPERATION EVEN AT HIGHER SPEEDS. IF YOU PULL OVER AND WAIT A MINUTE OR TAP ON THE TIPM THE CAR WILL OPERATE AGAIN. ALSO AT TIMES THE HORN, WIPERS / FLUID, AND ALL LIGHTS COME ON CONSTANTLY WHILE DRIVING. YOU CAN TAKE THE KEY OUT OF THE CAR IT EVEN STAYS ON AND EVERYTHING STAYS ON UNTIL YOU EITHER TAP ON THE TIPM OR DISCONNECT THE BATTER COMPLETELY. FINALLY, AT TIMES WHEN YOU USE THE KEY FOB TO OPEN THE CAR AGAIN EVERYTHING WILL COME ON EVEN THE ENGINE WITHOUT THE KEY IN THE IGNITION. YOU THEN AGAIN HAVE TO TAP ON THE TIPM OR DISCONNECT THE BATTERY. *TR
NHTSA ODI #10508745
36,500 miles · Apr 18, 2013
Fuel/propulsion System
WHEN FUELING MY 2006 JEEP LJ GAS SPRAYS OUT ALL OVER THE SIDE OF THE JEEP AND ANYONE STANDING NEAR THE BACK OF THE JEEP WHEN THE TANK IS FULL AND THE PUMP TRIPS OFF. *TR
NHTSA ODI #10508741
80,000 miles · Apr 10, 2013
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT FUEL SPILLED OUT OF THE FUEL TANK AFTER IT WAS FILLED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE FUEL SENSOR THAT CONTROLLED THE FUEL LEVEL NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT FUEL SPILLED OUT OF THE FUEL TANK AFTER IT WAS FILLED. THE CONTACT TOOK THE VEHICLE TO THE DEALER AND WAS INFORMED THAT THE FUEL SENSOR THAT CONTROLLED THE FUEL LEVEL NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 80,000 AND THE CURRENT MILEAGE WAS 89,000. *TR...UPDATED 05/22/13 *BF
NHTSA ODI #10505761
33,000 miles · Mar 14, 2013
SteeringSuspensionUnknown Or Other
UNCONTROLLABLE WOBBLE IN FRONT AXLE/WHEELS AND SHAKING OF STEERING WHEEL.
NHTSA ODI #10504003
Mileage unknown · Mar 9, 2013
Suspension
WHEN DRIVING AT APPRX. 50 MILES PER HOUR, IF YOU HIT SEMI ROUGH/ROUGH ROADWAY THE FRONT END OF THE VEHICLE WOULD GO INTO A HORRIBLE TOTAL FRONT END SHAKE. IT WOULD ONLY GO AWAY BY PUTTING ON YOUR BRAKES, AND THIS IS NOT SUCH A GOOD IDEA WHEN EVERYONE ELSE ON THE ROADWAY IS GOING THE SPEED LIMIT AND YOU HAVE TO HIT YOUR BRAKES …
Read full complaint
WHEN DRIVING AT APPRX. 50 MILES PER HOUR, IF YOU HIT SEMI ROUGH/ROUGH ROADWAY THE FRONT END OF THE VEHICLE WOULD GO INTO A HORRIBLE TOTAL FRONT END SHAKE. IT WOULD ONLY GO AWAY BY PUTTING ON YOUR BRAKES, AND THIS IS NOT SUCH A GOOD IDEA WHEN EVERYONE ELSE ON THE ROADWAY IS GOING THE SPEED LIMIT AND YOU HAVE TO HIT YOUR BRAKES AND SLOW DOWN TO GET YOUR FRONT END UNDER CONTROL
NHTSA ODI #10502963
36,000 miles · Feb 28, 2013
Fuel/propulsion System
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT AFTER ADDING FUEL TO THE VEHICLE, THE FUEL PUMP AUTOMATICALLY SHUT OFF AND FUEL SPRAYED OUT OF THE FILLER NECK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE FUEL PURGE VALVE HAD TO BE REPLACED. THE VEHICLE WAS N…
Read full complaint
TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT AFTER ADDING FUEL TO THE VEHICLE, THE FUEL PUMP AUTOMATICALLY SHUT OFF AND FUEL SPRAYED OUT OF THE FILLER NECK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE FUEL PURGE VALVE HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration