WHEN MY 2006 JEEP WRANGLER HITS A BUMP OR AN IMPERFECTION IN THE ROAD WHILE TRAVELLING AT 45MPH AND ABOVE, THE JEEP WILL BEGIN TO SHAKE SO SEVERELY THAT A CRASH SEEMS INEVITABLE UNLESS I SLAM ON THE BRAKES AND PULL OVER ON THE SHOULDER. THIS HAS HAPPENED TO ME MORE THAN I CAN COUNT AND CONTINUES TO BE A DANGEROUS PROBLEM. PLEAS…
Read full complaint
WHEN MY 2006 JEEP WRANGLER HITS A BUMP OR AN IMPERFECTION IN THE ROAD WHILE TRAVELLING AT 45MPH AND ABOVE, THE JEEP WILL BEGIN TO SHAKE SO SEVERELY THAT A CRASH SEEMS INEVITABLE UNLESS I SLAM ON THE BRAKES AND PULL OVER ON THE SHOULDER. THIS HAS HAPPENED TO ME MORE THAN I CAN COUNT AND CONTINUES TO BE A DANGEROUS PROBLEM. PLEASE HELP!!! *TR
NHTSA ODI #10459923
Mileage unknown · Nov 15, 2011
SteeringSuspensionWheels
MY 2006 JEEP WRANGLER SHAKES SO BAD IT IS SCARY. AT 45-65 MPH AND FOR NO REASON START SHAKING VIOLENTLY. I SPENT $1600.00 ON NEW PARTS. NEW SHOCKS, NEW RIMS,NEW STEERING DAMPER,NEW TRACKING BAR. NEW CAMBER,NEW BUSHING, NEW CONTROL ARMS. NOTHING WORKS. I MUST PULL OFF THE HIGHWAY TO MAKE IT STOP. THIS JEEP IS DANGEROUS!!!! …
Read full complaint
MY 2006 JEEP WRANGLER SHAKES SO BAD IT IS SCARY. AT 45-65 MPH AND FOR NO REASON START SHAKING VIOLENTLY. I SPENT $1600.00 ON NEW PARTS. NEW SHOCKS, NEW RIMS,NEW STEERING DAMPER,NEW TRACKING BAR. NEW CAMBER,NEW BUSHING, NEW CONTROL ARMS. NOTHING WORKS. I MUST PULL OFF THE HIGHWAY TO MAKE IT STOP. THIS JEEP IS DANGEROUS!!!! *TR
NHTSA ODI #10435994
39,400 miles · Apr 21, 2009
SuspensionTiresWheels
ENTERING THE INTERSTATE AND DRIVING UP TO APPROXIMATELY 60-65MPH, THE STEERING WHEEL SHOOK VIOLENTLY TO THE POINT WHERE I NEEDED TO SLOW DOWN DRASTICALLY TO STOP THE VIBRATION. I TOOK THE VEHICLE IN FOR SERVICE ON THE13TH OF MARCH AT EWALD JEEP IN FRANKLIN WHEN THEY TOLD ME TO REPLACE THE FRONT TIRES BECAUSE THEY WERE 2/32. I TO…
Read full complaint
ENTERING THE INTERSTATE AND DRIVING UP TO APPROXIMATELY 60-65MPH, THE STEERING WHEEL SHOOK VIOLENTLY TO THE POINT WHERE I NEEDED TO SLOW DOWN DRASTICALLY TO STOP THE VIBRATION. I TOOK THE VEHICLE IN FOR SERVICE ON THE13TH OF MARCH AT EWALD JEEP IN FRANKLIN WHEN THEY TOLD ME TO REPLACE THE FRONT TIRES BECAUSE THEY WERE 2/32. I TOLD THEM THE TIRES HAVE ONLY 15,000 MILES ON THEM THEN THEY TOLD ME TO SEE THE PLACE (POMPS IN RACINE) THAT SOLD ME THE TIRES. POMPS SAID I NEEDED AN ALIGNMENT. THEN, ON THE 8TH OF APRIL DRIVING AT 40MPH ON A BUMPY ROAD, THE STEERING WHEEL SHOOK VIOLENTLY AGAIN WITH WHAT FELT LIKE THE FRONT WHEELS WERE LOOSE. TO STOP THIS VIBRATION, I NEEDED TO SLOW TO 10 TO 20 MPH. I CALLED FOR SERVICE ONCE AGAIN TO EWALD ON THE10TH OF APRIL. THEY REPLACED THE STEERING DAMPER ($126.28 AND $98 FOR LABOR). THEY ALSO PERFORMED A 2 WHEEL FRONT END ALIGNMENT. THEN ON SATURDAY THE 18TH OF APRIL, IT HAPPENED AGAIN. AS SOON AS I GOT HOME, I CALLED EWALD AND TOLD THEM THE SHAKES ARE BACK. WENT IN ON MONDAY THE 20TH AND HAD A SERVICE TECH DRIVE IT. HE SAID NOTHING OUT OF THE ORDINARY OCCURRED WHILE HE DROVE IT. MINOR SHAKES IN THE STEERING WHEEL BUT 'THAT'S THE NATURE OF THE BEAST', HE SAID. THEY PROCEEDED TO LOOK INTO IT MORE AND 20 MINUTES LATER, THEY TOLD ME THEY WERE REPLACING THE STEERING DAMPER THEY REPLACED ONLY 10 DAYS EARLIER. I OWNED A 1997 JEEP WRANGLER AND NEVER EXPERIENCED THIS THEN. AFTER TALKING WITH OTHER JEEP OWNERS, I BELIEVE IT TO BE A BAD DESIGN AND HOPE CHRYSLERJEEP CAN CORRECT THIS PROBLEM. *TR
NHTSA ODI #10266312
12,800 miles · Jun 25, 2007
Wheels
ROTATED TIRES, 2 FRONT WHEEL STUDS BROKE AT LESS THAN 100 FEET. TOOK VEHICLE TO TIRE RETAILER TO REPLACE BROKEN STUDS, AND THEY DISCOVERED 3 OTHER STUDS WERE SEVERELY STRETCHED. 5 OF THE 10 FRONT WHEEL STUDS WERE REPLACED. I HAVE ALL 5 DEFECTIVE STUDS.*AK
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration