EVERY SINGLE TIME I FILL UP THE GAS TANK ON MY 2006 JEEP WRANGLER TJ UNLIMITED, THE FUEL SHOOTS OUT OF THE TANK BECAUSE THE NOZZLE STOP MUST BE SET TO SHUT OFF HIGHER THAN THE JEEP FUEL TANK WILL ALLOW FOR IT TO FILL. I HAVE EVEN TRIED TO TRICKLE FUEL IN AT THE END OF THE FILL UP AND IT STILL SHOOTS FUEL EVERYWHERE. THIS IS AN…
Read full complaint
EVERY SINGLE TIME I FILL UP THE GAS TANK ON MY 2006 JEEP WRANGLER TJ UNLIMITED, THE FUEL SHOOTS OUT OF THE TANK BECAUSE THE NOZZLE STOP MUST BE SET TO SHUT OFF HIGHER THAN THE JEEP FUEL TANK WILL ALLOW FOR IT TO FILL. I HAVE EVEN TRIED TO TRICKLE FUEL IN AT THE END OF THE FILL UP AND IT STILL SHOOTS FUEL EVERYWHERE. THIS IS AN EVERY FILL UP OCCURRENCE AND NOT JUST FROM TIME TO TIME.
NHTSA ODI #10321619
30,000 miles · Mar 23, 2010
Fuel System, Gasoline
FUEL OVERFLOW WHEN FILLING UP, HAPPENS EVERY TIME.
NHTSA ODI #10321553
38,000 miles · Mar 22, 2010
Fuel System, Gasoline
1. WHEN FILLING GAS TANK AT STATION, FUEL SPRAYS AND SPILLS OUT OF FILLER NECK WHEN TANK IS FULL. 2. THIS HAPPENS EVERY TIME I FILL UP AND CAN RESULT IN QUITE A LARGE AMOUNT OF GAS BEING SPILLED SOMETIMES. IT BEGAN HAPPENING ABOUT 9 MONTHS AGO. 3. NOTHING, JEEP SAYS IT IS NOT A SAFETY ISSUE AND THE VEHICLE IS OUT OF WARRANTY.*DT
NHTSA ODI #10321488
33,000 miles · Mar 22, 2010
Fuel System, GasolineFuel System, Other
WHEN FILLING FUEL TANK TO FULL CAPACITY, PUMPS SPILLS FUEL OUT OF TANK FILLER TUBE. POSSIBLE ROLL OVER VALVE STICKING CAUSING FUEL TANK TO OVERFILL SPILLING FUEL OUTSIDE OF VEHICLE BECAUSE THE PUMP DON'T STOP WHEN THE TANK IS FULL. *DT
NHTSA ODI #10321476
50,000 miles · Mar 21, 2010
Fuel System, Gasoline
2006 JEEP WRANGLER; STARTING IN 2009, FUEL TANK OVERFLOWS EVER TIME TANK IS FILLED AT GAS STATION. THE FUEL TANK IS DEFECTIVE, AND THE RECOMMENDED REMEDY IS TO REPLACE THE TANK. CREATES A SIGNIFICANT FUEL SPILL. THIS IS A COMMON DEFECT ON JEEP WRANGLER FUEL TANKS.*TR
NHTSA ODI #10321239
18,000 miles · Mar 20, 2010
Fuel System, Gasoline
WHEN FILLING UP THE FUEL TANK, THE PUMP ALWAYS OVERFLOWS. EVERY TIME. AS FOR THE APPROXIMATE INCIDENT DATE, IT IS EVERY OTHER WEEK. *TR
NHTSA ODI #10321130
Mileage unknown · Mar 19, 2010
Fuel System, Gasoline
EVERY TIME I FILL MY CARS GAS TANK UP THE FUEL SPILLS OUT I HAVE COMPLAINED TO CHRYSLER AND JEEP BOTH HAVE SAID THEY ARE AWARE OF THE PROBLEM BUT ITS NOT A SAFETY CONCERN THOUGH GAS SPILLING OUT OF A VEHICLE I WOULD HAVE TO SAY IS PRETTY UNSAFE THIS HAPPENS EVERY TIME I FILL THE TANK. *TR
NHTSA ODI #10320995
Mileage unknown · Mar 17, 2010
Fuel System, Gasoline
2006 JEEP WRANGLER - WHEN FILLING WITH FUEL AT ANY SERVICE STATION THE FUEL TANK WILL OVERFILL CAUSING FUEL TO RUSH OUT OF THE FILLER NECK AND ONTO ANYONE OR ANYTHING STANDING IN THE WAY. SEVERAL TIMES I HAVE BEEN COVERED IN FUEL BECAUSE IT WOULD NOT SHUT OFF WHEN FULL. THIS IS A POTENTIAL FIRE HAZARD AND HEALTH HAZARD W…
Read full complaint
2006 JEEP WRANGLER - WHEN FILLING WITH FUEL AT ANY SERVICE STATION THE FUEL TANK WILL OVERFILL CAUSING FUEL TO RUSH OUT OF THE FILLER NECK AND ONTO ANYONE OR ANYTHING STANDING IN THE WAY. SEVERAL TIMES I HAVE BEEN COVERED IN FUEL BECAUSE IT WOULD NOT SHUT OFF WHEN FULL. THIS IS A POTENTIAL FIRE HAZARD AND HEALTH HAZARD WITH FUEL BEING DUMPED ON THE GROUND AT SERVICE STATIONS. MANY COMPLAINTS HAVE BEEN FILED AND MORE CAN BE READ AT JEEPFORUMS.COM. PLEASE DO SOMETHING ABOUT THIS! IT IS A DANGER! *TR
NHTSA ODI #10320451
Mileage unknown · Mar 17, 2010
Fuel System, Gasoline
WHENEVER I FILL UP MY 06 JEEP WRANGLER, IT ALWAYS OVERFLOWS WHEN. THIS IS A WASTE OF GAS AND HAZARDOUS TO THE ENVIRONMENT. *TR
NHTSA ODI #10320356
6,000 miles · Mar 15, 2010
Fuel System, Gasoline
VEHICLE SPRAYS OUT GASOLINE WHENEVER I FILL IT UP. 2006 JEEP WRANGLER UNLIMITED RUBICON IT HAPPENS AT RANDOM FILL UPS, USUALLY 3 OUT OF 5 TIMES. IT ONLY HAPPENS WHEN I FILL THE TANK TO FULL. THE DEALER HAS ATTEMPTED TO FIX THIS ISSUE A FEW TIMES ALREADY. UPON FURTHER RESEARCH, THIS ISSUE APPEARS TO BE HAPPENING ON ALOT OF J…
Read full complaint
VEHICLE SPRAYS OUT GASOLINE WHENEVER I FILL IT UP. 2006 JEEP WRANGLER UNLIMITED RUBICON IT HAPPENS AT RANDOM FILL UPS, USUALLY 3 OUT OF 5 TIMES. IT ONLY HAPPENS WHEN I FILL THE TANK TO FULL. THE DEALER HAS ATTEMPTED TO FIX THIS ISSUE A FEW TIMES ALREADY. UPON FURTHER RESEARCH, THIS ISSUE APPEARS TO BE HAPPENING ON ALOT OF JEEP VEHICLES. *TR
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration