WHEN FILLING UP MY 2006 JEEP WRANGLER RUBICON GAS WILL SPRAY OUT ON INITIAL SHUT OFF OF THE GAS PUMP. I'VE HAD THIS PROBLEM LOOKED AT, BUT WAS TOLD IT WAS NORMAL FOR THAT TO HAPPEN FROM TIME TO TIME. THEN, I COMPLAINED TO JEEP AND THEY ALLOWED THE DEALERSHIP TO SWITCH OUT TANKS BECAUSE MY JEEP WAS UNDER WARRANTY. THIS WAS ONLY A…
Read full complaint
WHEN FILLING UP MY 2006 JEEP WRANGLER RUBICON GAS WILL SPRAY OUT ON INITIAL SHUT OFF OF THE GAS PUMP. I'VE HAD THIS PROBLEM LOOKED AT, BUT WAS TOLD IT WAS NORMAL FOR THAT TO HAPPEN FROM TIME TO TIME. THEN, I COMPLAINED TO JEEP AND THEY ALLOWED THE DEALERSHIP TO SWITCH OUT TANKS BECAUSE MY JEEP WAS UNDER WARRANTY. THIS WAS ONLY A TEMPORARY FIX...GAS STILL SPRAYS OUT!!! *TR
NHTSA ODI #10379910
40,000 miles · Jan 29, 2011
Fuel System, Gasoline
JEEP SPILLS OUT LARGE AMOUNT OF GASOLINE EVERY TIME IT IS FILLED UP. *LN
NHTSA ODI #10379526
57,000 miles · Jan 28, 2011
Fuel System, Gasoline
EVERY TIME I FILL UP MY GAS TANK, IT WILL OVERFLOW AND LEAK GAS ALL OVER THE GROUND AND ALONG THE SIDE OF THE CAR. *TR
NHTSA ODI #10379429
55,000 miles · Jan 26, 2011
Fuel System, Gasoline
FUEL OVERFLOWS AFTER NOZZLE CUTS OFF WHEN FILLING GAS TANK.
NHTSA ODI #10380242
53,050 miles · Jan 26, 2011
Fuel System, Gasoline
WHEN REFUELING OUR JEEP THE PUMP DOES NOT SHUT OFF IN TIME SPRAYING FUEL ALL OVER THE SIDE OF THE VEHICLE AND GROUND. TO FIX THIS THE DEALER WANTS TO REPLACE THE FUEL TANK. THIS IS A VERY COMMON ACROSS THE BOARD CHRYSLER PROBLEM THAT THEY ARE NOT OWNING UP TO. *TR
NHTSA ODI #10378875
92,693 miles · Jan 26, 2011
Fuel System, Gasoline
GASOLINE OVERFLOWS EVERY TIME WHEN FILLING TANK ON 2006 JEEP WRANGLER. IT IS RIDICULOUS THAT THIS DANGEROUS ISSUE HAS NOT BEEN RESOLVED. *TR
NHTSA ODI #10378847
49,000 miles · Jan 24, 2011
Fuel System, Gasoline
THE FUEL FILLER NECK/GAS TANK ON MY 2006 JEEP WRANGLER HAS FILLING PROBLEMS. ANY TIME I GO TO FILL UP ON GAS THE PUMP DOES NOT CLICK OFF IN TIME AND GAS LITERALLY SHOOTS OUT OF THE FILLER NECK ALL OVER THE BUMPER OF THE JEEP AND ON THE GROUND. I HAVEN'T TRIED TO MEASURE THE VOLUME OF GAS THAT SHOOTS OUT EACH TIME, BUT I WOULD …
Read full complaint
THE FUEL FILLER NECK/GAS TANK ON MY 2006 JEEP WRANGLER HAS FILLING PROBLEMS. ANY TIME I GO TO FILL UP ON GAS THE PUMP DOES NOT CLICK OFF IN TIME AND GAS LITERALLY SHOOTS OUT OF THE FILLER NECK ALL OVER THE BUMPER OF THE JEEP AND ON THE GROUND. I HAVEN'T TRIED TO MEASURE THE VOLUME OF GAS THAT SHOOTS OUT EACH TIME, BUT I WOULD ESTIMATE AT LEAST 6-8OZ OF FUEL. *TR
NHTSA ODI #10378544
33,056 miles · Jan 22, 2011
Fuel System, Gasoline
DURING FUELING, WHEN THE FUEL PUMP NOZZLE AUTOMATICALLY STOPS THE FLOW OF GASOLINE , FUEL SURGES BACK THROUGH THE FILLER TUBE AND VIGOROUSLY SPLASHES OUT ON THE SIDE OF THE VEHICLE AND ANYTHING OR PERSON WITHIN 2 TO 3 FEET OF THE FUEL FILLER. THIS OCCURS EVERY TIME THE FUEL TANK IS FILLED AND HAS DRENCHED THE PERSON FILLING THE…
Read full complaint
DURING FUELING, WHEN THE FUEL PUMP NOZZLE AUTOMATICALLY STOPS THE FLOW OF GASOLINE , FUEL SURGES BACK THROUGH THE FILLER TUBE AND VIGOROUSLY SPLASHES OUT ON THE SIDE OF THE VEHICLE AND ANYTHING OR PERSON WITHIN 2 TO 3 FEET OF THE FUEL FILLER. THIS OCCURS EVERY TIME THE FUEL TANK IS FILLED AND HAS DRENCHED THE PERSON FILLING THE VEHICLE FROM THE WAIST DOWN WITH GASOLINE ON TWO OCCASIONS. HAS SPILLED FUEL ON EVERY FILLUP (AT LEAST ONE CUP), DESPITE PRECAUTIONS (SLOWING FILLING RATE). MANUFACTURER AND DEALER HAVE DONE NOTHING TO CORRECT THIS PROBLEM, THIS HAPPENS ALMOST EVERY TIME I FILL UP. *TR
NHTSA ODI #10378281
49,712 miles · Jan 21, 2011
Fuel System, Gasoline
FUEL SPILLS OUT ON ME AND SURROUNDING AREA WHEN FILLING THE GAS TANK. THIS EVENT HAPPENS EVERY TIME I FILL THE TANK. I CANNOT USE THE AUTOMATIC FUEL SHUTOFF ON THE FUEL NOZZLES AS GAS IS SPILLED (ABOUT .5 CUP) ON THE SURROUNDING AREA. THIS IS A FIRE HAZARD. *TR
NHTSA ODI #10378116
50,094 miles · Jan 18, 2011
Fuel System, Gasoline
WHEN REFUELING THE VEHICLE, GASOLINE IS SPIT BACK OUT OF THE FILLER NECK WHEN THE AUTOMATIC SHUTOFF RELEASES AND THE TANK IS FULL. IF THE FILLER NOZZLE HAS SPLASH GUARD, SPILLED FUEL RUNS DOWN THE SIDE OF THE VEHICLE ON TO THE GROUND. OTHERWISE FUEL IS SHOT OUT UP TO 5 FEET AND COVER ANYTHING OR ANYBODY WITHIN THE RADIUS OF THE …
Read full complaint
WHEN REFUELING THE VEHICLE, GASOLINE IS SPIT BACK OUT OF THE FILLER NECK WHEN THE AUTOMATIC SHUTOFF RELEASES AND THE TANK IS FULL. IF THE FILLER NOZZLE HAS SPLASH GUARD, SPILLED FUEL RUNS DOWN THE SIDE OF THE VEHICLE ON TO THE GROUND. OTHERWISE FUEL IS SHOT OUT UP TO 5 FEET AND COVER ANYTHING OR ANYBODY WITHIN THE RADIUS OF THE SPILL. NO REMEDY FOUND, IT ALWAYS HAPPENS. *TR
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Illustration