IllustrationSEVERE FUEL SPIT BACK WHEN FILLING UP MY JEEP WRANGLER. GAS SPILLED ALL OVER THE VEHICLE AND GROUND! *TR
2006 Jeep Wrangler
Owner reports · Recalls · Investigations
More warning signs than most Wrangler years
Owner complaints for the 2006 Jeep Wrangler are substantially higher than the model-year median of 265.
About this comparison →How this year compares
Owner complaints by model year
Compare all Wrangler years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2010–25K
22925–50K
11950–75K
4675–100K
25100–150K
4150K+
624 reports with mileage · 106 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Fuel System, Gasoline. Review the 355 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Fuel/propulsion System. Review the 118 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports7 fire reports17 injury reports
Fuel/propulsion System complaints
118 reportsOVERFLOW OF GAS WHEN FILLING 100% OF TIME. *TR
EVERY TIME I FUEL UP UNLESS I LISTEN VERY CAREFULLY TO THE CHANGE IN THE SOUND OF THE GASOLINE FROM THE PUMP INTO THE TANK THE FUEL FILLER FAILS TO AUTOMATICALLY CUT OFF WITHOUT OVERFLOWING. EVERY WRANGLE UNLIMITED OWNER I HAVE ASKED EXPERIENCES THE SAME PROBLEM, YET CHRYSLER FAILS TO ACKNOWLEDGE THE ISSUE. I AM PERSON…
Read full complaint
EVERY TIME I FUEL UP UNLESS I LISTEN VERY CAREFULLY TO THE CHANGE IN THE SOUND OF THE GASOLINE FROM THE PUMP INTO THE TANK THE FUEL FILLER FAILS TO AUTOMATICALLY CUT OFF WITHOUT OVERFLOWING. EVERY WRANGLE UNLIMITED OWNER I HAVE ASKED EXPERIENCES THE SAME PROBLEM, YET CHRYSLER FAILS TO ACKNOWLEDGE THE ISSUE. I AM PERSONALLY UNAWARE OF ANY FIRES RESULTING FROM THIS PROBLEM, BUT THE POTENTIAL DEFINITELY EXISTS. *JS
FUEL PUMP WILL NOT SHUT OFF WHEN THE TANK IS FULL RESULTING IN GASOLINE SPILLED ON THE VEHICLE AND ALL OVER THE GROUND. *TR
OBVIOUSLY THERE ARE MANY COMPLAINTS YET YOU GUYS ARE IGNORING THEM. YOU FILL UP WITH GAS AND AT TOP OFF IT SPITS GAS OUT THAT GETS ALL OVER THE PERSON FILLING CLOTHES. THIS IS A MAJOR PROBLEM THAT YOU NEED TO GET OFF YOUR ASSES AND GET THIS PROBLEM RESOLVED BEFORE SOMEONE GETS HURT. I PURCHASED THIS VEHICLE RECENTLY AND FILLE…
Read full complaint
OBVIOUSLY THERE ARE MANY COMPLAINTS YET YOU GUYS ARE IGNORING THEM. YOU FILL UP WITH GAS AND AT TOP OFF IT SPITS GAS OUT THAT GETS ALL OVER THE PERSON FILLING CLOTHES. THIS IS A MAJOR PROBLEM THAT YOU NEED TO GET OFF YOUR ASSES AND GET THIS PROBLEM RESOLVED BEFORE SOMEONE GETS HURT. I PURCHASED THIS VEHICLE RECENTLY AND FILLED UP 5 TIMES AND THIS OCCURRED EVERYTIME. FIX IT! *TR
WHEN FILLING THE FUEL TANK THE PUMP CUTS OFF TO LATE AND CREATES SPLASH BACK AND POURS GASOLINE ON THE GROUND AND ALL OVER WHOEVER IS NEAR BY. *TR
GAS PUMPS WILL NOT FILL VEHICLE PROPERLY. GASOLINE SPILLS FROM FILLER NECK ACROSS BACK END OF VEHICLE WHENEVER I FILL VEHICLE WITH FUEL. *TR
WHEN VEHICLE IS BEING FUELED UP, GAS LEAKS OUT OF TANK AND SPILLS. SEEMS THE CHECK VALVE IS STUCK OF BROKEN. I MUST MAKE SURE I STOP FILLING BEFORE IT GETS FULL SO IT DOESN'T SPILL. *TR
GAS SPURTS OUT OF TANK WHEN I FILL IT UP AND DRIPS ALL OVER GAS STATION FLOOR. THE GAS PUMP DOES NOT STOP ONCE ITS FULL LIKE OTHER CARS AND IM WORRIED SPILLED FUEL COULD IGNITE. ALSO BAD FOR ENVIRONMENT. *TR
OVER FILLS AT THE FUEL PUMP ALL THE TIME.
Official recalls
315V222000 · Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
Apr 15, 2015
Chrysler (FCA US LLC) is recalling certain model year 2006 Dodge Viper and Jeep Wrangler and Liberty vehicles manufactured July 1, 2005, to July 31, 2006. In the affected vehicles, the springs within the clutch pedal position switch that prevents the vehicle from starting unless the clutch pedal is pushed down may break. As a result, the vehicle may not be started when the clutch pedal is pushed down or the engine may crank and start without the clutch pedal being pushed down causing the vehicle to unexpectedly lurch.
Consequence & remedy
Consequence: If the vehicle unexpectedly moves there is an increased risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the clutch ignition interlock switch, free of charge. The recall began on August 31, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R13.
06V147000 · Power Train:clutch Assembly
May 3, 2006
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 6 SPEED MANUAL TRANSMISSIONS, THE HYDRAULIC CLUTCH MASTER CYLINDER LINKAGE ROD MAY BREAK. THIS MAY NOT ALLOW DISENGAGEMENT OF THE CLUTCH WHEN THE PEDAL IS DEPRESSED.
Consequence & remedy
Consequence: UNINTENTIONAL VEHICLE MOVEMENT, INCREASED STOPPING DISTANCE, AND ENGINE STALLING COULD OCCUR WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE CLUTCH MASTER CYLINDER LINKAGE ROD FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
05V460000 · Power Train:automatic Transmission
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE06015 · Clutch Linkage Failure
Opened Apr 20, 2006 · Closed Jun 13, 2006
Status: closed (inferred from source dates) · Power Train:clutch Assembly; Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Additional source detail variants (2)
Power Train:clutch Assembly
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.
Power Train:clutch Assembly:pedal/hand Lever(motorcycle)
ON MAY 2, 2006 DAIMLERCHRYSLER CORPORATION (DCC) SUBMITTED TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) A PART 573 REPORT ADVISING THAT CERTAIN MODEL YEAR 2006 JEEP WRANGLER VEHICLES WOULD BE VOLUNTARILY REC ALLED TO REPLACE A DEFECTIVE CLUTCH LINKAGE COMPONENT.THE RECALL ACTION IS IDENTIFIED BY NHTSA NO. 06V147 (DCC NO. F22).THE LINKAGE ROD BETWEEN THE CLUTCH PEDAL AND CLUTCH MASTER CYLINDER CAN BREAK WHEN THE CLUTCH PEDAL IS DEPRESSED; LINKAGE ROD FAILURE UNDER THESE CONDITIONS RESULTS IN IMMEDIATE ENGAGEMENT OF THE CLUTCH AND RENDERS THE CLUTCH PEDAL INEFFECTIVE THEREAFTER .THE 6,876 MANUAL TRANSMISSION VEHICLES INCLUDED IN THE RECALL ACTION WERE ALL MANUFACTURED BETWEEN 11/3/2005 AND 2/13/2006.DCC WILL REPLACE THE DEFECTIVE LINKAGE WITH A COMPONENT OF A PREVIOUS DESIGN LEVEL WHICH HAS NOT EXPERIENCED FIELD FAILURE.THE TIMING OF DCC'S ACTION HAS NOT BEEN DETERMINED.ACCORDINGLY, THIS PRELIMINARY EVALUATION IS CLOSED.