Status: open (inferred from source dates) · Electrical System; Electrical SYSTEM:12V/24V/48V Battery; Electrical System:alternator/generator/regulator; Electrical System:body Control Module/bcm; Electrical System:body Control Module:software; Engine; Engine And Engine Cooling:engine:engine Control Module (ecu/ecm); Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software; Hybrid Propulsion System; Hybrid Propulsion System: Inverter
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (10)
Electrical SYSTEM:12V/24V/48V Battery
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:alternator/generator/regulator
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:body Control Module/bcm
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System:body Control Module:software
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Electrical System
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm)
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine And Engine Cooling:engine:engine Control Module (ecu/ecm):software
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Engine
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Hybrid Propulsion System
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Hybrid Propulsion System: Inverter
The Office of Defects Investigation (ODI) has received 80 consumer complaints alleging an engine stall and loss of motive power on model year (MY) 2022 RAM 1500 pickup trucks and 2022 Jeep Wagoneer SUV vehicles. The particular engines in the subject vehicles are equipped with the Fiat Chrysler Automotive Group LLC (FCA) 5.7L Hemi eTorque system. The eTorque system is a mild hybrid system that lets the vehicle partially power itself. It accomplishes this by converting the captured energy from the braking system into electricity for the battery pack, which is then used to power a variety of electrical components. ETorque engines replace the alternator with a 48-volt battery-powered belt drive and a motor generator. The motor generator provides extra torque to the crankshaft during gear changes. Simultaneously, the motor generator uses the 48-volt battery pack to increase torque. Many of the complaints state that the vehicle's engine would shut off, often while travelling at slow speed, the vehicle would shift into park and apply the emergency brake. The vehicles were sometimes able to be restarted. In addition, complaints state that the malfunction warning light with the battery fault symbol appeared on the dash. Many complaints state that a low voltage condition fault is present, sometimes not being able to restart the vehicle. On April 13, 2023, FCA announced recall 23V-265 describing a defect in certain 2021 Ram 1500 vehicles equipped with 5.7L eTorque engines. The recall described a defect in the powertrain control module software can cause an incorrect fuel mixture condition in the engine, and result in an engine stall. In February of 2024, ODI provided the complaints on the 2022 Ram 1500 and Wagoneer vehicles to FCA. After reviewing the complaints, FCA stated that “the loss of motive power was likely not caused by an over rich fuel condition (as outlined in recall 23V-265), but rather some other cause (e.g., an electrical concern that causes the engine to shut down).” A Preliminary Evaluation has been opened to assess the scope, frequency, root cause(s) and consequences of these loss/stall of motive power incidents. Additionally, ODI may expand the scope of the subject population during the investigation, if needed. To review the ODI reports cited in the Opening Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration