NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
114 reportsClear category filter17,500 miles · Aug 30, 2019
Engine
MY CAR STALLED AFTER BEING PARKED FOR 45 MIN. IN A PARKING LOT OF A LOCAL STORE, AS I ATTEMPTED TO BACK OUT OF THE SPACE. I RESTARTED IT AND AS I TRIED TO BACK OUT, WHILE MOVING ONLY A FOOT OR SO, IT STALLED AGAIN. IT MADE NO SOUND AT ALL WHILE TURNING THE KEY, BUT ALL THE ELECTRONICS WORKED, IE. LIGHTS, WINDOWS, RADIO, ETC. IT …
Read full complaint
MY CAR STALLED AFTER BEING PARKED FOR 45 MIN. IN A PARKING LOT OF A LOCAL STORE, AS I ATTEMPTED TO BACK OUT OF THE SPACE. I RESTARTED IT AND AS I TRIED TO BACK OUT, WHILE MOVING ONLY A FOOT OR SO, IT STALLED AGAIN. IT MADE NO SOUND AT ALL WHILE TURNING THE KEY, BUT ALL THE ELECTRONICS WORKED, IE. LIGHTS, WINDOWS, RADIO, ETC. IT WOULD NOT RESTART, AFTER MULTIPLE ATTEMPTS, I LEFT IT THERE OVER NIGHT AND THE NEXT DAY IT RESTARTED, AND I DROVE IT FOR ABOUT A COUPLE OF MINUTES TO THE END OF THE LOT WHERE IT STALLED AGAIN WHILE MOVING ABOUT 5 MPH. IT WOULD NOT RESTART, SO I HAD IT TOWED TO A SHOP WHERE A FRIEND WORKS. THEY COULD NOT FIND THE CAUSE, BUT DID GET A CODE FOR THE ECU/ECM. I DON'T KNOW WHAT NUMBER THE ERROR CODE WAS, BUT THEY DON'T DO THOSE TYPES OF REPAIRS. IT REMAINS IN THEIR LOT AT THIS TIME AS I TRY TO FIGURE OUT MY NEXT STEP. IT IS A JEEP PATRIOT SPORT (2.4 L) AUTOMATIC WITH ONLY 17,500 ACTUAL MILES.
NHTSA ODI #11252466
120,000 miles · Aug 16, 2019
Engine
VEHICLE WILL DIE DURING DRIVING. CAUSING EVERYTHING TO NOT FUNCTION CORRECTLY. UNTIL IT IS ABLE TO BE RESTARTED.
NHTSA ODI #11244352
96,000 miles · Jul 9, 2019
Electronic Stability Control (esc)EngineVehicle Speed Control
2 INCIDENTS SAME DAY. VEHICLE IN MOTION, LOST OF CONTROL, POOR RESPONSE OF STEERING WHEEL, BRAKES NOT RESPONDING, ENGINE AND/OR ELECTRICAL SYSTEM NOT WORKING PROPERLY. ENGINE CUTTING OFF. TIPM PROBLEM. ESC AND ENGINE LIGHTS ON. SOUNDS OF CAR SURGING. NO ACCELERATION IN SOME CASES AND UPHILL IN PARTICULAR. WE COULD HAVE GOT KILLE…
Read full complaint
2 INCIDENTS SAME DAY. VEHICLE IN MOTION, LOST OF CONTROL, POOR RESPONSE OF STEERING WHEEL, BRAKES NOT RESPONDING, ENGINE AND/OR ELECTRICAL SYSTEM NOT WORKING PROPERLY. ENGINE CUTTING OFF. TIPM PROBLEM. ESC AND ENGINE LIGHTS ON. SOUNDS OF CAR SURGING. NO ACCELERATION IN SOME CASES AND UPHILL IN PARTICULAR. WE COULD HAVE GOT KILLED IF IT HAD HAPPENED ON THE HIGHWAY FOR SURE.
NHTSA ODI #11230503
102,000 miles · Jun 14, 2019
Engine
TL* THE CONTACT OWNS A 2012 JEEP PATRIOT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUEL PUMP, BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT DIAGN…
Read full complaint
TL* THE CONTACT OWNS A 2012 JEEP PATRIOT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE FUEL PUMP, BUT THE FAILURE CONTINUED. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC, BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. ARRIGO DODGE CHRYSLER/JEEP SAWGRASS (5901 MADISON AVE, TAMARAC, FL) AND THE MANUFACTURER WERE NOTIFIED. THE FAILURE MILEAGE WAS 102,000.
NHTSA ODI #11219974
80,000 miles · May 24, 2019
Engine
ENGINE STALLS WHILE DRIVING. THE TRACTION CONTROL LIGHTS APPEARS WHEN ENGINE STALLS. IT MAY RESTART AFTER ABOUT 15 MINUTES. THIS REOCCURS RANDOMLY. AFTER IT STARTS BACK UP THE CHECK ENGINE LIGHT APPEARS.
NHTSA ODI #11209714
Mileage unknown · May 19, 2019
EnginePower Train
HELLO MY NAME IS [XXX] I HAD MY VEHICLE WORKED ON FOR THE LAST RECALL I HAD ON MY VEHICLE COM # [XXX] WHICH IS A 2012 JEEP PATRIOT LATITUDE 4AD 2.4L RECALL. U67 I HAD NO ENGINE LIGHTS ON MY DASH. THE ONLY ON DASH WAS HAD CAP AND I BOUGHT 3 OF THDM AND WITH THIS EMISSION ISSUE JUST THOUGHT IT WAS PART OF IT. DROVE IT OFF THE L…
Read full complaint
HELLO MY NAME IS [XXX] I HAD MY VEHICLE WORKED ON FOR THE LAST RECALL I HAD ON MY VEHICLE COM # [XXX] WHICH IS A 2012 JEEP PATRIOT LATITUDE 4AD 2.4L RECALL. U67 I HAD NO ENGINE LIGHTS ON MY DASH. THE ONLY ON DASH WAS HAD CAP AND I BOUGHT 3 OF THDM AND WITH THIS EMISSION ISSUE JUST THOUGHT IT WAS PART OF IT. DROVE IT OFF THE LINE THE DEALERSHIP DIDN'T LET ME TALK TOLD ME. TO EXIT THE DEALERSHIP AND THE ASST. SERVICE MANAGER THEY HAD ME SO LOST AND CONFUSED.AND DAZED THAT I THEY SAID THEY DID A CHECK-UP AND WENT OVER EVERYTHING BUT I DROVE HOME ON..A FLAT TIRE I HAVE TEXT FROM THEIR EMPLOYEE THAT SHE COULD NOT BELIEVE HOW I WAS BEING TREATED IN THE DEALERSHIP AND I WAS PICKING UP MY VEHICLE AFTER A RECALL THAT IS NOT RIGHT SINCE. THE RECALL I HAVE A ENGINE LIGHT AND IT WAS NOT ON THERE PRIOR TO THE RECALL I WAS TREATED POORLY AND MY JEEP PATRIOT IS WORSE NOW THAN WHEN I BROUGHT IT IN HAD A HORRIBLE EXPERIENCS.AND IT THE EMISSION AND I AM NERVOUS TO DRIVE IT NOW THE JEEP CORP SAID THAT I HAD TO TALK TO THE 2 PEOPLE WHO TREATED ME BADLY TO WHERE THE RECALL MADE MY CAR OR IT WAS MORE OR I DON'T KNOW IT'S COMING BACK EMISSIONS AND NONE OF THAT WAS THERE. I NEED HELP CAUSE NO ONE IS GOING TO SAY OR.TAKE FAULT BUT I WAS PUSHED OUT OF THE STORE WHEN I WAS THERE TO PICK UP AFTER RECALL NO ONE HAS HELPED ME OUT AND I DID NOTHING TO DESERVE THIS BUT TAKE IT TOO A DEALERSHIP THAT WOULD KICK AND TALK TO A CUSTOMER AND NO FOLLOW UP IT HAS BEEN A NIGHTMARE AND MY JEEP IS PAYING THE PRICE. WHEN I WAS THERE FOR A RECALL. THERE HAVE BEEN 4 AND THIS WAS NOT NOTHING I EVER WANT TO EXPERIENCE OR ANY ONE ELSE. MY NUMBER TO BE REACHED AT IS [XXX]. I ALSO HAVE THE TEXTS THAT I CAN SUBMIT THAT I WAS TREATED HORRIBLY AND PUSHED OUT AFTER THE RECALL. LITERALLY IN A LOST AND CONFUSED THIS IS A SOME THING THAT WAS NOT NORMAL AND MY VEHICLE PAID THE PRICE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #11208492
90,000 miles · Apr 23, 2019
Engine
TL* THE CONTACT OWNS A 2012 JEEP PATRIOT. WHILE DRIVING OVER 40 MPH, THE VEHICLE RANDOMLY STALLED WITHOUT WARNING. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS PUSHED OVER TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO TUNKHANNOCK AUTO MART: DODGE RAM CHRYSLER JEEP (LOCATED AT 509 JOSEPH HUNTER HIGHW…
Read full complaint
TL* THE CONTACT OWNS A 2012 JEEP PATRIOT. WHILE DRIVING OVER 40 MPH, THE VEHICLE RANDOMLY STALLED WITHOUT WARNING. THE FAILURE RECURRED FOUR TIMES. THE VEHICLE WAS PUSHED OVER TO THE SIDE OF THE ROAD. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO TUNKHANNOCK AUTO MART: DODGE RAM CHRYSLER JEEP (LOCATED AT 509 JOSEPH HUNTER HIGHWAY, TUNKHANNOCK, PA 18657), BUT A FAILURE CODE COULD NOT BE FOUND. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 5843398. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.
NHTSA ODI #11203208
61,000 miles · Mar 20, 2019
EngineFuel/propulsion System
ON MY WAY TO WORK, MY CAR STALLED 3 TIMES WHILE AT A STOP LIGHT AND ONCE WHILE MOVING. AFTER THE MOVING STALL, MY ENGINE LIGHT CAME ON. THE ERROR CODE IS P0339. IT ALSO STALLED TWICE ON MY WAY HOME FROM WORK. IT DIDN'T STALL WHILE I WAS MOVING ON THE SECOND TRIP BECAUSE MY FOOT HAPPENED TO BE ON THE GAS WHEN IT TRIED TO STALL. I…
Read full complaint
ON MY WAY TO WORK, MY CAR STALLED 3 TIMES WHILE AT A STOP LIGHT AND ONCE WHILE MOVING. AFTER THE MOVING STALL, MY ENGINE LIGHT CAME ON. THE ERROR CODE IS P0339. IT ALSO STALLED TWICE ON MY WAY HOME FROM WORK. IT DIDN'T STALL WHILE I WAS MOVING ON THE SECOND TRIP BECAUSE MY FOOT HAPPENED TO BE ON THE GAS WHEN IT TRIED TO STALL. I FELT THE CAR JERK BACKWARDS THEN RE-ENGAGE THE ENGINE BACK TO WHERE IT WAS BEFORE IT ALMOST STALLED. THE CAR HAD DONE A LITTLE JERK EVERY ONCE IN A WHILE, BUT NOW IT'S MULTIPLE TIMES IN A SINGLE TRIP.
NHTSA ODI #11190327
50,000 miles · Mar 17, 2019
EngineFuel/propulsion SystemVehicle Speed Control
AROUND 50000 MILES THE ENGINE STARTED TO STOP ACCELERATING DURING OPERATION. DURING DRIVING ON A HIGHWAY OR CITY STREET (AT ALL SPEEDS) THE ENGINE WOULD BEGIN TO MALFUNCTION WITHOUT WARNING AND THE MAXIMUM SPEED THAT COULD BE MET WAS ABOUT 10MPH WITH GAS FULLY ENGAGED. PULLINGNOVER AND RESTARTING THE VEHICLE WOULD OVERRIDE THIS …
Read full complaint
AROUND 50000 MILES THE ENGINE STARTED TO STOP ACCELERATING DURING OPERATION. DURING DRIVING ON A HIGHWAY OR CITY STREET (AT ALL SPEEDS) THE ENGINE WOULD BEGIN TO MALFUNCTION WITHOUT WARNING AND THE MAXIMUM SPEED THAT COULD BE MET WAS ABOUT 10MPH WITH GAS FULLY ENGAGED. PULLINGNOVER AND RESTARTING THE VEHICLE WOULD OVERRIDE THIS FOR A SHORT TIME. IT STARTED TO OCCUR MORE FREQUENTLY TO THE POINT I WOULD HAVE TO RESTART MY CAR A APPROXIMATELY 15 TIMES TO MAKE A 9 MILE TRIP TO WORK. HAPPENED SEVERAL TIMES DRIVING ON A HIGHWAY AT SPEEDS OF UP TO 65MPH AND ALMOST CAUSED ACCIDENTS SEVERAL TIMES BEFORE I COULD PULL OFF ON TO THE SHOULDER. EVENTUALLY AFTER MONTHS OF THIS OCCURRING AT RANDOM INTERVALS THE CAR SHUT OFF WHILE DRIVING RESULTING IN TOTAL LOSS OF ENGINE POWER AND STEERING ABILITY OF THE VEHICLE THANKFULLY ON A QUIET BACK STREET WHERE I WAS ABLE TO LEAVE IT AFTER PUSHING IT IN NEUTRAL AND HAVE IT TOWED. AFTER SEVERAL MONTHS OF BEING IN THE SHOP AND THOUSANDS OF DOLLARS LATER ITS RUNNING WITH A NEW ENGINE. MULTIPLE FRIENDS AND FAMILY MEMBERS WITH THE SAME VEHICLE MODEL MAKE AND YEAR HAVE THIS ISSUE ALL AROUND 50K MILES.
NHTSA ODI #11187315
95,000 miles · Jan 12, 2019
EngineService BrakesSteering
THE VEHICLE SHUTS OFF WHILE DRIVING. THE BATTERY IS FINE HOWEVER I LOSE ALL POWER. IT IS AS IF THERE IS NO FUEL EVEN THOUGH I HAVE A FUL TANK. THE TRACTION LIGHT COMES ON ALONG WITH THE CHECK ENGINE LIGHT. I ROLL TO A STOP AND LET THE JEEP SIT THEN TURN THE KEY AND IT STARTS RIGHT UP. THERE IS NO WARNING OR INDICATION WHEN IT WI…
Read full complaint
THE VEHICLE SHUTS OFF WHILE DRIVING. THE BATTERY IS FINE HOWEVER I LOSE ALL POWER. IT IS AS IF THERE IS NO FUEL EVEN THOUGH I HAVE A FUL TANK. THE TRACTION LIGHT COMES ON ALONG WITH THE CHECK ENGINE LIGHT. I ROLL TO A STOP AND LET THE JEEP SIT THEN TURN THE KEY AND IT STARTS RIGHT UP. THERE IS NO WARNING OR INDICATION WHEN IT WILL OVCUR. THE CHECK ENGINE LIGHT WILL DISAPPEAR AFTER DRIVING FOR A TIME AND SO I AM TOLD THERE IS NO CODE TO BE PULLED. IM STUCK DRIVING A MACHINE THAT MAY OR MAY NOT TRY TO END ME. TONS OF PEOPLE HAVE HAD A SIMILAR ISSUE HOWEVER MY VIN DOES NOT SEEM TO BE INCLUDED IN THE RECALL.
NHTSA ODI #11166670
Official recalls
4Sep 15, 2016
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence & remedy
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Additional source detail variants (3)
Seat Belts:pretensioner
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags:frontal:sensor/control MODULE-INACTIVE
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Air Bags
Chrysler (FCA US LLC) is recalling certain model year 2011-2014 Chrysler 200, 2010 Chrysler Sebring, 2010-2012 Dodge Caliber and 2010-2014 Jeep Patriot, Compass and Dodge Avenger vehicles. The Occupant Restraint Control (OCR) module may short circuit, preventing the frontal air bags, seat belt pretensioners, and side air bags from deploying in the event of a crash.
Consequence: If the frontal air bags, seat belt pretensioners, and side air bags are disabled, there is an increased risk of injury to the vehicle occupants in the event of a vehicle crash that necessitates deployment of these safety systems.
Remedy: Chrysler will notify owners, and dealers will replace the OCR, free of charge. Interim letters informing owners that parts are not available yet were mailed on October 26, 2016. The recall began on August 15, 2017. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S61.
Jun 4, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.
Consequence & remedy
Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.
Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.
Additional source detail variants (3)
Electrical System:software
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.
Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.
Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.
Seat Belts
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.
Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.
Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.
Air Bags:side/window
Chrysler Group LLC (Chrysler) is recalling certain model year 2010-2012 Jeep Compass and Patriot vehicles manufactured May 6, 2008, through July 20, 2012. The affected vehicles have a software error which may result in a delayed deployment or non-deployment of the seatbelt pre-tensioners and/or side airbags.
Consequence: In the event of a rollover necessitating airbag deployment, the software error can lead to a delayed deployment or non-deployment of the side curtain airbag and/or seatbelt pre-tensioners. As a result, vehicle occupants have an increased risk of injury in a crash.
Remedy: Chrysler will notify owners, and dealers will correct the software free of charge. The recall began June 21, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall number is N01.
Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2012 Jeep Patriot and Compass vehicles manufactured October 18, 2011, through May 7, 2012. Due to an incorrectly manufactured transfer tube, the transfer of fuel from the secondary side to the primary side of the fuel tank may be interrupted, causing the engine to stall.
Consequence & remedy
Consequence: If the engine stalls while driving it may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the fuel tank transfer tube free of charge. An interim letter was mailed to owners on May 30, 2013. Owners were notified by Chrysler on July 19, 2013, that parts are now available. Owners may contact Chrysler at 1-800-853-1403. Chrysler's recall campaign number is N17.
Apr 3, 2012
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2012 JEEP PATRIOT AND COMPASS VEHICLES MANUFACTURED FROM DECEMBER 17, 2011, THROUGH JANUARY 2, 2012. SOME VEHICLES MAY HAVE BEEN BUILT WITH A FUEL TANK ASSEMBLY CONTAINING A DAMAGED ROLL-OVER VALVE.
Consequence & remedy
Consequence: IN THE EVENT OF AN IMPACT OR ROLL-OVER, FUEL LEAKAGE COULD OCCUR, INCREASING THE RISK OF A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE FUEL TANK, FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR ABOUT MAY 25, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
PE19014 · Active Head Rest Inadvertent Deployment
Opened Sep 9, 2019 · Closed Feb 25, 2026
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Seats
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Seats:front Assembly:head Restraint
The Office of Defects Investigation (ODI) opened PE19014 on September 9, 2019, to investigate 128 consumer complaints alleging that the Active Head Rest (AHR) inadvertently deployed without the occurrence of a crash or other rear impact event in model year (MY) 2014 Jeep Grand Cherokee and Dodge Durango vehicles.When ODI opened the investigation, ODI was aware of thirteen alleged injuries.A small number of Early Warning Reports identified driver and/or passenger front seat AHR inadvertent deployments without a rear impact event.Reported safety consequences resulting from the AHR deployments include concussions, headaches, soft tissue injuries, disorientation, nausea, vomiting and/or loss of vehicle control as a result of being surprised and distracted by being struck in the head by the inadvertent AHR deployment. On September 24, 2019, ODI sent an Information Request (IR) letter to Fiat Chrysler Automobiles (FCA).ODI requested certain detailed information from FCA related to the following subject vehicles: MY 2010-2014 Dodge Avenger 200, MY 2010-2014 Dodge Calber, MY 2010-2014 Chrysler Sebring, MY 2013-2015 Ram Tradesman, MY 2012 Ram Van, MY 2010-2019 Dodge Grand Caravan, MY 2010-2016 Chrysler Town and Country, MY 2010-2017 Jeep Compass, MY 2011-2020 Dodge Durango, MY 2011-2020 Jeep Grand Cherokee, MY 2010-2019 Dodge Journey, MY 2010-2012 Jeep Liberty, MY 2010-2011 Jeep Nitro, and MY 2010-2011 Jeep Patriot vehicles.On December 2, 2019, ODI received a response from FCA that included vehicle production data, consumer complaints, field reports, warranty claims, manufacturer actions, production changes, and other data related to the alleged defect from the start of production (2010) through September 24, 2019.On January 27, 2020, ODI received an update to the December 2, 2019, IR response from FCA.On September 22, 2020, ODI requested additional subject vehicle AHR information from FCA.ODI received FCA's response on October 21, 2020.ODI subsequently received an update to FCA's October 21, 2020, response on February 16, 2021.During the investigation, ODI requested updates to certain IR questions on two occasions.FCA provided updates to question #2 on March 5, 2021, and questions #2 and #5 on May 26, 2023. FCA’s IR response data identified approximately 7.5 million subject vehicles (with approximately 15 million AHR assemblies).Due to the large number of vehicles and failure reports, ODI focused its analysis on the FCA vehicle model with the highest failure rate to represent the worst-case scenario.For this purpose, ODI focused on MY 2012-2015 Jeep Grand Cherokee vehicles for its analysis.This population includes 710,890 vehicles that FCA manufactured between August 19, 2011, and August 8, 2015.ODI identified 2,839 alleged AHR failures within this limited population.ODI identified 263 alleged injuries that were caused by AHR failures in MY 2012-2015 Grand Cherokees vehicles.Of these alleged injuries, ODI categorized them as eighty-two (82) soft tissue (neck/whiplash, bruise) injuries, four (4) concussions, fifty-nine (59) headaches, and one hundred eighteen (118) without a specific injury description.Although complainants have alleged injuries, ODI has been unable to obtain evidence to substantiate or validate any injuries where medical treatment was required.Consumer outreach was conducted by ODI, where sixty-three (63) FCA complainants with alleged injuries were contacted.Twelve of the sixty-three FCA consumers responded and were interviewed by ODI.ODI requested medical records, however, only one response was provided. Attorneys representing the responding complainant provided a synopsis that indicated they had experienced prior neck-related injuries dating to the mid-1990s.ODI also contacted one hundred (100) consumers who submitted Vehicle Owner Questionnaires (VOQ) in an attempt to validate alleged injuries. Despite the efforts of ODI, the office has been unsuccessful at obtaining substantive documentation/evidence supporting complaints that allege serious injuries (where pre-existing medical conditions did not already exist). In addition to the low severity of alleged injuries caused by AHR deployments, there have been eleven alleged crashes and two alleged lane departures within the entire subject vehicle population that has been in the field up to sixteen years (with over 8,500 AHR inadvertent deployments).ODI was not able to validate that the alleged crashes were the result of inadvertent head rest deployments, and the crashes were minor in nature. ODI has conducted a thorough investigation of the alleged safety defect and with up to sixteen years of exposure for some vehicles and over 8,500 inadvertent AHR deployments, no serious crashes or injuries could be validated in the sub-population of focus.The lack of serious injuries validated by ODI with such large period of field exposure is consistent with thework done by NHTSA’s Human Injury Research Division and the Biodynamic Research Corporation, which support that an inadvertent AHR deployment is not likely to cause serious injury.In addition to the low risk of injury, FCA released an extended warranty program that covers inadvertent AHR deployment for ten years / unlimited mileage from the vehicle's in-service date. PE19014 is closed with the FCA extended warranty program.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist, and the Agency reserves the right to take additional action if warranted by new circumstances. To review a complete closing summary, please the attached closing report. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE12032 · Engine Stall, Fuel Delivery Failure
Opened Oct 15, 2012 · Closed May 3, 2013
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery
In a letter dated April 3, 2013, Chrysler Group LLC submitted a Defect Information Report (DIR) to NHTSA identifying a safety defect in the fuel delivery system in approximately 20,532 model year (MY) 2012 Jeep Patriot (11,624) and Compass (8,908) vehicles manufactured from October 18, 2011 through May 7, 2012 and equipped with certain fuel tanks produced between October 18, 2011 and January 26, 2012 (Recall 13V-120).According to Chrysler, Jeep Patriot and Compass vehicles equipped with saddle type fuel tanks built during the affected period may experience low siphoning rate through the transfer tube from the secondary to the primary side of the fuel tank.Chrysler's investigation determined that a material change by the transfer tube supplier (TI Automotive) led to malformed tubes being shipped to the final tank assembly supplier (Kautex).The malformed transfer tubes may make the siphoning process more difficult to start and maintain under certain operating conditions.Sustained driving during this condition may deplete fuel in the primary side of the fuel tank and lead to engine stall without warning.Kautex established a 100% sort on January 26, 2012 as a countermeasure for the malformed tubes being used in production.Chrysler is able to trace fuel tank build dates by vehicle identification number and Recall 13V-120 only includes vehicles equipped withsaddle tanks made during the affected period.Approximately 97 percent of the recalled Patriot vehicles (11,277 out of 11,624) were from October 18, 2011 through January 26, 2012.Chrysler determined that a few suspect tanks were used on vehicles produced as late as May 7, 2012 and is including any such vehicles in the recall.The Office of Defects Investigation (ODI) analyzed complaint data provided by Chrysler as well as complaints submitted to ODI from consumers to identify stalling incidents related to fuel delivery.ODI's analysis identified a total of 64 engine stall incidents related to fuel delivery, all of which involved Patriot 4x4 vehicles equipped with saddle type fuel tanks.The Patriot 4x4 vehicles account for a little over half of the subject vehicle population (59,783 vehicles).Forty-nine (49) of the incidents involved the approximately 11,277 Patriot 4x4 vehicles that were built from October 18, 2011 and January 26, 2012 and equipped with tanks from the period associated with the transfer tube material change.This equates to a complaint rate of 434.5 incidents per 100,000 vehicles sold.Fifteen (15) fuel delivery related engine stalls were identified in the remaining 48,506 Patriot 4x4 vehicles, resulting in a complaint rate of 30.9 incidents per 100,000 vehicles.The rate in the non-recalled Patriot 4x4 vehicles increases to 68.0 incidents per 100,000 vehicles if stalls with no-restart and unknown cause are added to the analysis.The Patriot front-wheel drive vehicles are equipped with single reservoir fuel tanks and are not affected by the saddle-tank fuel delivery issue.Owners of the recalled vehicles will be notified to take their vehicle to a Jeep dealer, who will replace the fuel tank transfer tube to prevent any incidents related to this issue. Chrysler will begin notifying dealers and owners in May 2013. This preliminary evaluation is closed.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers (ODI Nos.): 10481572, 10481452, 10481279, 10481254, 10481222, 10481141, 10481126, 10481110, 10501057, 10478934, 10472705, 10470121, 10468517, 10467488, 10466357, 10464745, 10464449, 10464135, 10462338, 10459383, 10421019, 10410937, 10481392.