NHTSA owner reports · September 18, 2026 snapshot.
Fuel System, Gasoline complaints
95 reportsClear category filter188,112 miles · May 23, 2018
EngineEngine And Engine CoolingFuel System, Gasoline
TL* THE CONTACT OWNS A 2008 JEEP LIBERTY. WHILE DRIVING UNKNOWN SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED AND THERE WAS AN ABNORMAL SOUND EMERGING FROM THE VEHICLE. THE CONTACT INSPECTED UNDERNEATH THE VEHICLE AND NOTICED THAT THE HEAT SHIELD BECAME DETACHED AND WAS ON THE DRIVETRAIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT…
Read full complaint
TL* THE CONTACT OWNS A 2008 JEEP LIBERTY. WHILE DRIVING UNKNOWN SPEEDS, THE CHECK ENGINE INDICATOR ILLUMINATED AND THERE WAS AN ABNORMAL SOUND EMERGING FROM THE VEHICLE. THE CONTACT INSPECTED UNDERNEATH THE VEHICLE AND NOTICED THAT THE HEAT SHIELD BECAME DETACHED AND WAS ON THE DRIVETRAIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND IT WAS DIAGNOSED THAT THE FUEL INJECTORS NEEDED TO BE REPLACED. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER (PORT JEFF CHRYSLER JEEP DODGE RAM, 5130 NESCONSET HWY, PORT JEFFERSON STATION, NY 11776) WHERE THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 188,112.
NHTSA ODI #11097583
Mileage unknown · Jan 4, 2017
EngineFuel System, Gasoline
FUEL SYSTEM, AFTER FILLING TANK WITH GAS VEHICLE STALLS AFTER DRIVING AWAY FROM PUMP. VEHICLE STALLS IN TRAFFIC, AT LIGHT AND IN INTERSECTIONS AFTER FILLING UP. MY INCIDENTS HAVE BEEN MANY ONE TIME WHILE MERGING INTO TRAFFIC FROM GAS STATION, AT A RED LIGHT AND HAS STALLED RIGHT IN MIDDLE OF INTERSECTION WITH TRAFFIC. UNKNOWN TH…
Read full complaint
FUEL SYSTEM, AFTER FILLING TANK WITH GAS VEHICLE STALLS AFTER DRIVING AWAY FROM PUMP. VEHICLE STALLS IN TRAFFIC, AT LIGHT AND IN INTERSECTIONS AFTER FILLING UP. MY INCIDENTS HAVE BEEN MANY ONE TIME WHILE MERGING INTO TRAFFIC FROM GAS STATION, AT A RED LIGHT AND HAS STALLED RIGHT IN MIDDLE OF INTERSECTION WITH TRAFFIC. UNKNOWN THE PROBLEM BUT VEHICLE IS HESITANT TO RESTART AFTER THE SHUT DOWN FOR APPROXINATELY 1 MINUTE. *TR
NHTSA ODI #10939581
164,000 miles · May 11, 2016
Fuel System, Gasoline
TL* THE CONTACT OWNS A 2008 JEEP LIBERTY. WHEN THE FUEL TANK WAS FILLED, THE FUEL SPILLED TO THE GROUND INSTEAD WITHOUT WARNING. THE FAILURE WAS NOT DIAGNOSED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 164,000. UPDATED 06/10/16*LJ
NHTSA ODI #10864367
105,000 miles · Jun 24, 2014
Fuel System, Gasoline
GAS TANK OVERFLOWS AT FILL UP. ALWAYS AT COSTCO AND MANY OTHER STATIONS. ATTENDANTS HAVE ATTEMPTED TO PUMP FOR ME AND HAD SAME RESULTS STATING THAT IT IS A COMMON PROBLEM FOR JEEPS. *TR
NHTSA ODI #10605513
45,000 miles · May 24, 2014
Fuel System, Gasoline
WHENEVER I FILL THE GAS TANK THE GAS PUMP CLICKS OFF WHEN THE TANK IS FULL, BUT GAS SURGES UP THE SPOUT AND DUMPS ON THE GROUND. THIS HAS NOTHING TO DO WITH THE TYPE OF GAS (PREMIUM OR REGULAR, OR ETHANOL OR NO ETHANOL) OR THE SETTING ON THE PUMP HANDLE (FAST OR SLOW). THIS IS A FIRE, EXPLOSION RISK AS WELL AS AN ENVIRONMENTA…
Read full complaint
WHENEVER I FILL THE GAS TANK THE GAS PUMP CLICKS OFF WHEN THE TANK IS FULL, BUT GAS SURGES UP THE SPOUT AND DUMPS ON THE GROUND. THIS HAS NOTHING TO DO WITH THE TYPE OF GAS (PREMIUM OR REGULAR, OR ETHANOL OR NO ETHANOL) OR THE SETTING ON THE PUMP HANDLE (FAST OR SLOW). THIS IS A FIRE, EXPLOSION RISK AS WELL AS AN ENVIRONMENTAL PROBLEM. I REALLY DON'T EXPECT YOU TO DO ANYTHING UNTIL AFTER PEOPLE ARE HURT OR KILLED, BUT WHEN THAT HAPPENS I WANT TO BE ABLE TO SAY "YOU KNEW ABOUT THE PROBLEM, AND DIDN'T CARE". *TR
NHTSA ODI #10593855
60,000 miles · Jan 13, 2014
Fuel System, Gasoline
WHEN THE TANK IS ALMOST FULL THE GAS WILL COME SPEWING OUT AND GO ALL OVER THIS HAPPENS ALL THE TIME THE NOZZLE DOES NOT SHUT OFF IT NOT THE STATION I FILL AT VARIOUS STATIONS. *TR
NHTSA ODI #10559651
58,000 miles · Dec 2, 2013
Electrical SystemEngineExterior Lighting
CHECK ENGINE LIGHT COME ON AND GAS CAP LIGHT ALSO COME ON THE AUTO START WILL NOT WORK & DASH LIGHT GETS REAL DIME ALSO GPS LIGHT GET REAL DIME/ AND THERE IS A REAL STRONG SMELL OF GAS THAT COMES INSIDE THE VEHICLE WHILE GOING DOWN THE ROAD. THE VEHICLE HAS BEEN TO 4 DIFFERENCE CHRYSLER DEALER SHIP AND COMPUTER HAS BEEN RE…
Read full complaint
CHECK ENGINE LIGHT COME ON AND GAS CAP LIGHT ALSO COME ON THE AUTO START WILL NOT WORK & DASH LIGHT GETS REAL DIME ALSO GPS LIGHT GET REAL DIME/ AND THERE IS A REAL STRONG SMELL OF GAS THAT COMES INSIDE THE VEHICLE WHILE GOING DOWN THE ROAD. THE VEHICLE HAS BEEN TO 4 DIFFERENCE CHRYSLER DEALER SHIP AND COMPUTER HAS BEEN REPLACED SENSOR HAVE ALL BEEN REPLACED GAS TANK REPLACED GAS CAP REPLACED .THIS VEHICLE HAS BEEN FOR THESE PROBLEM 11 TIMES AND HAS NEVER BEEN FIXED CALLED CHRYSLER CUSTOMER SERVICE 6 DIFFERENT TIMES ALL WE GET IS THE RUN AROUND . THE DEALER SHIPS DRIVE THE VEHICLE AND HAVE PUT 1,500 MILE ON THE VEHICLE DRIVING IT. NEED SOME KNOW TO WHY THIS CAN NOT BE FIXED. *TR
NHTSA ODI #10554567
20,000 miles · Nov 11, 2013
Fuel System, Gasoline
EVERY TIME I FUEL UP, IF I LEAVE IT FILLING UP AUTOMATICALLY, GAS SPEWS OUT WHEN IT GETS TO FULL AND GOES EVERYWHERE. EVEN IF I AM TRYING TO WATCH THE GALLONS AND STOP BEFORE IT GETS TO FULL, IT STILL SPEWS EVERYWHERE. I THOUGHT THIS WAS SPECIFIC TO MY VEHICLE, BUT I'VE NOW SEEN HUNDREDS OF REPORTS ON THE INTERNET REGARDING T…
Read full complaint
EVERY TIME I FUEL UP, IF I LEAVE IT FILLING UP AUTOMATICALLY, GAS SPEWS OUT WHEN IT GETS TO FULL AND GOES EVERYWHERE. EVEN IF I AM TRYING TO WATCH THE GALLONS AND STOP BEFORE IT GETS TO FULL, IT STILL SPEWS EVERYWHERE. I THOUGHT THIS WAS SPECIFIC TO MY VEHICLE, BUT I'VE NOW SEEN HUNDREDS OF REPORTS ON THE INTERNET REGARDING THE VERY SAME ISSUES WITH THIS YEAR AND MODEL OF JEEP, PLUS MANY OTHER YEARS AND MODELS. *TR
NHTSA ODI #10551791
18,000 miles · Jul 16, 2013
Fuel System, GasolineFuel/propulsion System
2008 JEEP LIBERTY 4X4 PURCHASED USED WITH 18,000 MILES. WHEN RE-FUELING THE PUMP WILL SHUT OFF AUTOMATICALLY AND GAS WILL BURP OUT EVERY TIME. SOMETIMES IT IS A LOT OF GAS AND VERY DANGEROUS. I'VE SEEN THIS ISSUE ALL OVER THE INTERNET. WHY ISN'T SOMETHING BEING DONE ABOUT THIS? *TR
NHTSA ODI #10525125
87,000 miles · Jun 19, 2013
Fuel System, Gasoline
WHEN I PUMP GAS THE SYSTEM DOES NOT STOP, THE GAS CONTINUES TO PUMP ONCE THE TANK IS FULL. GAS RUNS DOWN THE SIDE OF THE JEEP AND IS A HUGE SAFETY ISSUE. NO RECALL ON THIS ISSUE SO I WOULD HAVE TO PAY MYSELF THIS NEEDS BE INVESTIGATED. *TR
NHTSA ODI #10520779
Official recalls
4Apr 3, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence & remedy
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Additional source detail variants (3)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Air Bags
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Power Train:driveline:driveshaft
Chrysler Group LLC (Chrysler) is recalling certain model year 2007-2008 Dodge Nitro 4X2 vehicles manufactured March 21, 2006, through March 1, 2008; and 2008 Jeep Liberty 4X2 vehicles manufactured February 15, 2007, through March 1, 2008. The transfer case heat shield may drop down and rub on the drive shaft, weakening it and potentially causing the drive shaft to break.
Consequence: If the drive shaft breaks, a section of it can strike the transfer case tunnel with enough force that the airbag computer will believe the vehicle is in a crash and thus deploy the airbags. Additionally, the drive shaft failure will result in a loss of motive power. Either condition may increase the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will add a bracket to support the rear of the heat shield, free of charge. An interim letter was mailed to owners on May 29, 2013. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign number is N10.
Nov 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 JEEP LIBERTY VEHICLES. THE VEHICLES ARE EQUIPPED WITH WINDSHIELD WIPER MOTORS THAT CONTAIN EXCESS ADHESIVE THAT MAY ALLOW FOR WATER INTRUSION, WHICH COULD RESULT IN INTERMITTENT AND EVENTUALLY INOPERATIVE WINDSHIELD WIPER OPERATION.
Consequence & remedy
Consequence: A FAILING OR INOPERATIVE WINDSHIELD WIPER SYSTEM WILL REDUCE A DRIVER'S VISIBILITY WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 1, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Oct 8, 2008
CHRYSLER IS RECALLING 3,663 MY 2007-2008 DODGE NITRO AND MY 2008 JEEP LIBERTY VEHICLES EQUIPPED WITH MANUAL TRANSMISSIONS. THE PARK BRAKE LEVER CLUTCH DRUM MAY DISTORT AND REDUCE THE EFFECTIVENESS OF THE PARK BRAKE SYSTEM.
Consequence & remedy
Consequence: THIS COULD ALLOW THE VEHICLE TO MOVE INADVERTENTLY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL REPLACE THE PARK BRAKE LEVER ASSEMBLY FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 27, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Sep 9, 2008
CHRYSLER IS RECALLING 494 MY 2008 JEEP LIBERTY VEHICLES. THE WINDSHIELD AND/OR FIXED REAR QUARTER GLASS MAY HAVE BEEN ASSEMBLED USING INCORRECT URETHANE ADHESIVE. THIS COULD AFFECT GLASS RETENTION.
Consequence & remedy
Consequence: IF THE GLASS SEPARATES WHILE DRIVING, IT COULD STRIKE ANOTHER VEHICLE OR INJURE A PEDESTRIAN.
Remedy: DEALERS WILL REPLACE THE WINDSHIELD AND/OR FIXED REAR QUARTER GLASS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 13, 2008. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
Illustration