NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
61 reportsClear category filterMileage unknown · Jun 8, 2007
Steering
I RECEIVED A RECALL NOTICE ON MY 2005 JEEP LIBERTY AROUND THE END OF MARCH STATING THAT THE BALL JOINTS COULD CORRODE AND COME APART WHILE THE VEHICLE IS BEING DRIVEN CAUSING A CRASH. MY HUSBAND AND I PURCHASED THE VEHICLE FROM AUTO WORLD IN BIG STONE GAP, VIRGINIA. WE HAVE CALLED THEM SEVERAL TIMES SINCE RECEIVED THE RECALL N…
Read full complaint
I RECEIVED A RECALL NOTICE ON MY 2005 JEEP LIBERTY AROUND THE END OF MARCH STATING THAT THE BALL JOINTS COULD CORRODE AND COME APART WHILE THE VEHICLE IS BEING DRIVEN CAUSING A CRASH. MY HUSBAND AND I PURCHASED THE VEHICLE FROM AUTO WORLD IN BIG STONE GAP, VIRGINIA. WE HAVE CALLED THEM SEVERAL TIMES SINCE RECEIVED THE RECALL NOTICE WAS RECEIVED. HOWEVER THE PROBLEM STILL HAS NOT BEEN CORRECTED. WE CALLED THEM AGAIN ABOUT A MONTH AGO AND WAS TOLD THAT DAIMERLER CHRYSLER IS NOT SENDING THEM THE PARTS THAT THEY NEED TO FIX THE RECALLED VEHICLES AND THAT THEY ARE ONLY GETTING 1 OR 2 SETS OF BALL JOINTS PER MONTH FROM THEM. AT THAT TIME THEY TOLD US THAT WE WERE #12 ON THEIR LIST AND WE HAVE NOT HEARD ANYTHING SINCE. I FIND THIS TOTALLY UNACCEPTABLE. THIS IS MY ONLY MEANS OF TRANSPORTATION TO AND FROM WORK SO I DO NOT HAVE ANY CHOICE BUT TO DRIVE IT AND HOPE THAT I DO NOT GET KILLED WHILE DOING SO. ALSO, IT HAS COME TO MY ATTENTION THAT THE INITIAL RECALL NOTICE APPEARED IN CONSUMER REPORTS MAGAZINE IN NOVEMBER OF 2006. I DID NOT RECEIVE A RECALL NOTICE UNTIL MARCH/APRIL OF 2007. I CAN ASSURE THEM THAT IF ANY OF MY FAMILY MEMBERS ARE INJURED OR KILLED DUE TO THIS PROBLEM I WILL OWN THEIR COMPANY. I WOULD APPRECIATED ANY ASSISTANCE WITH THIS MATTER.
NHTSA ODI #10192767
Mileage unknown · Apr 23, 2007
SteeringWheels
I PURCHASED THIS LIBERTY RENEGADE IN OCTOBER OF 2006 AND HAVE BEEN EXPERIENCING PROBLEMS WITH IT SINCE. THE MAIN SYMPTOM IS THAT WHEN IT IS (OR HAS BEEN) RAINING, THERE IS A VERY LOUD HUMMING NOISE THAT COMES FROM THE AREA OF THE WHEELS, ESPECIALLY WHEN TURNING ONE DIRECTION OR ANOTHER. I HAD THE RECALL WORK DONE ON THE LOWER …
Read full complaint
I PURCHASED THIS LIBERTY RENEGADE IN OCTOBER OF 2006 AND HAVE BEEN EXPERIENCING PROBLEMS WITH IT SINCE. THE MAIN SYMPTOM IS THAT WHEN IT IS (OR HAS BEEN) RAINING, THERE IS A VERY LOUD HUMMING NOISE THAT COMES FROM THE AREA OF THE WHEELS, ESPECIALLY WHEN TURNING ONE DIRECTION OR ANOTHER. I HAD THE RECALL WORK DONE ON THE LOWER BALL JOINT AND ON THE MATERIAL OF THE BRAKES (TWICE) AND THE SAME SYMPTOM IS HAPPENING. THE REASON I BOUGHT THIS VEHICLE WAS BECAUSE I HAVE TO DRIVE OVER SNOW COVERED MOUNTAINS TO GET TO AIR NATIONAL GUARD DUTY, AND I CERTAINLY DO NOT FEEL VERY SAFE. I AM GOING TO HAVE TO TAKE THE CAR BACK FOR A 4TH TIME AND THERE ARE ONLY 18.000 MILES ON IT. *JB
NHTSA ODI #10188632
36,000 miles · Apr 5, 2007
Steering
TL*THE CONTACT OWNS A 2005 JEEP LIBERTY. THE CONTACT STATED THAT THE STEERING WHEEL COLUMN SWITCH DISENGAGED WITHOUT WARNING AND CAUSED THE POSITION OF THE STEERING WHEEL TO FLUCTUATE. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE, AND THE CONTACT FELT ITWAS A SAFETY ISSUE. THE CURRENT AND FAILURE M…
Read full complaint
TL*THE CONTACT OWNS A 2005 JEEP LIBERTY. THE CONTACT STATED THAT THE STEERING WHEEL COLUMN SWITCH DISENGAGED WITHOUT WARNING AND CAUSED THE POSITION OF THE STEERING WHEEL TO FLUCTUATE. THE VEHICLE HAS NOT BEEN INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE, AND THE CONTACT FELT ITWAS A SAFETY ISSUE. THE CURRENT AND FAILURE MILEAGE WERE 36,000. *AK
NHTSA ODI #10187114
24,000 miles · Mar 26, 2007
SteeringCrash
TL* - THE CONTACT OWNS A 2005 JEEP LIBERTY. THE CONTACT STATED THAT IT HAD RAINED ON AND OFF THROUGHOUT THE NIGHT AND MORNINGE WHILE DRIVING 15 MPH DOWN A ROAD TO MAKE A RIGHT TURN AND SUDDENLY THE VEHICLE HAD NO STEERING, IT WENT OVER THE MEDIAN, AND HIT ANOTHER VEHICLE AND THEN BOUNCED BACK INTO HER LANE. THE VEHICLE …
Read full complaint
TL* - THE CONTACT OWNS A 2005 JEEP LIBERTY. THE CONTACT STATED THAT IT HAD RAINED ON AND OFF THROUGHOUT THE NIGHT AND MORNINGE WHILE DRIVING 15 MPH DOWN A ROAD TO MAKE A RIGHT TURN AND SUDDENLY THE VEHICLE HAD NO STEERING, IT WENT OVER THE MEDIAN, AND HIT ANOTHER VEHICLE AND THEN BOUNCED BACK INTO HER LANE. THE VEHICLE HIT THE DRIVER'S SIDE CORNER OF THE CONTACT'S VEHICLE. NO POLICE REPORT WAS TAKEN, BUT THE POLICE WAS CALLED. THE CONTACT STATED THAT THERE WAS A LOT OF FRONT END DAMAGE DONE TO THE VEHICLE. *AK
NHTSA ODI #10186198
39,000 miles · Feb 6, 2007
Fuel System, GasolineSteeringCrash
MY 2005 JEEP LIBERTY 4X4 WAS SERVICED ON JANUARY 11, 2007 AT ITS PLACE OF PURCHASE (BROWN DAUB CHRYSLER IN EASTON, PA). I HAD DESCRIBED TO MY SERVICE TECH THE CAR WAS MAKING A LOUD SCREECHING NOISE WHEN TURNING AND THAT THE CAR HAD PULLED TO THE RIGHT OFF AND ON (EVERY FEW DAYS) WHILE I WAS DRIVING. THE MECHANIC STATED THAT HE F…
Read full complaint
MY 2005 JEEP LIBERTY 4X4 WAS SERVICED ON JANUARY 11, 2007 AT ITS PLACE OF PURCHASE (BROWN DAUB CHRYSLER IN EASTON, PA). I HAD DESCRIBED TO MY SERVICE TECH THE CAR WAS MAKING A LOUD SCREECHING NOISE WHEN TURNING AND THAT THE CAR HAD PULLED TO THE RIGHT OFF AND ON (EVERY FEW DAYS) WHILE I WAS DRIVING. THE MECHANIC STATED THAT HE FOUND A "NORMAL NOISE" RELATED TO AN AIR VALVE IN THE POWER STEERING, AND THERE WERE NO REPAIRS MADE TO THE VEHICLE. I WAS OPERATING THE JEEP LIBERTY ON SATURDAY, FEBRUARY 3RD. I HAD THE VEHICLE IN PARK AT A DRIVE-UP ATM. WHEN I SHIFTED THE CAR BACK INTO DRIVE, THE FRONT TIRES GRABBED, THE CAR KICKED FORWARD AND THE STEERING WHEEL PULLED TO THE RIGHT. THE JEEP RODE UP OVER A CONCRETE CURB AND STRUCK A CEMENT POLE, SHATTERING THE PASSENGER'S SIDE FRONT WINDOW, RIPPING OFF THE DOOR HANDLE, CAUSING A DENT AND PAINT DAMAGE TO THE PASSENGER'S SIDE OF THE VEHICLE. BEYOND THIS PROBLEM, THE JEEP HAS BEEN SERVICED FOR A BROAD RANGE OF MECHANICAL PROBLEMS AT LEAST SEVEN OTHER TIMES SINCE THE PURCHASE DATE (OCTOBER 2004). THE FUEL SENDING UNIT HAS BEEN REPLACED TWICE, THE VEHICLE HAS HAD TWO RECALLS, AND FOUR MONTHS AFTER I PURCHASED THE VEHICLE THE SENSOR WIRES HAD "RUBBED THROUGH COMPLETELY" ON THE TRANSMISSION. RIGHT NOW, THE VEHICLE IS AT A BODY SHOP FOR REPAIR AND INSPECTION. IT WILL THEN BE RETURNED TO BROWN DAUB FOR A THOROUGH DIAGNOSTIC CHECKUP OF THE POWER STEERING AND/OR STEERING COLUMN. BEYOND THE STEERING ISSUE, THIS IS NOT THE FIRST TIME THE CAR HAS 'KICKED FORWARD' - NORMALLY THIS OCCURS AFTER STOPPING ON WET ROADS (AT TRAFFIC LIGHTS) MY MAIN CONCERN, AGAIN, IS THE STEERING ISSUE THAT CONTRIBUTED TO THIS ACCIDENT. I BELIEVE IT NEEDS TO BE FURTHER INVESTIGATED. *JB
NHTSA ODI #10181822
Mileage unknown · Dec 29, 2006
Steering
MY 2005 JEEP LIBERTY HAS A RECALL FOR SAFETY CHRYSLER SAFETY RECALL F23- AND WE ONLY FOUND OUT BY ACCIDENT, IN SPEAKING TO MANY OTHER PEOPLE WHO HAVE THE SAME TYPE OF VECHILE AND SAME YEAR NONE OF THESE PEOPLE EVER RECEIVED ANY NOTICE FROM DAIMLER CHRYSLER- WHEN WE FOUND OUT ABOUT THIS RECALL - 60 DAYS AGO WE CALLED THE DEALER …
Read full complaint
MY 2005 JEEP LIBERTY HAS A RECALL FOR SAFETY CHRYSLER SAFETY RECALL F23- AND WE ONLY FOUND OUT BY ACCIDENT, IN SPEAKING TO MANY OTHER PEOPLE WHO HAVE THE SAME TYPE OF VECHILE AND SAME YEAR NONE OF THESE PEOPLE EVER RECEIVED ANY NOTICE FROM DAIMLER CHRYSLER- WHEN WE FOUND OUT ABOUT THIS RECALL - 60 DAYS AGO WE CALLED THE DEALER AND I ALSO CONTRACTED DAIMLER CHRYSLER - I WAS TOLD THAT THE DEALERS ONLY GET ABOUT 3 FIX KITS PER WEEK- AND WE ARE NOW NUMBER 96 ON A WAIT LIST. NHTS NEEDS TO LITE A FIRE UNDER DAIMLER CHRYSLER TO GET MORE FIX KITS OUT AND TO MAKE THEM NOTIFY OWNER AND WE ARE THE ORGINAL OWER OF ANY FURTHER RECALLS
NHTSA ODI #10177345
10,000 miles · Oct 18, 2006
Steering
MY VEHICLE HAS A STEERING PROBLEM; I UNDERSTAND THAT THE BALL JOINTS HAVE BEEN RECALLED. THE DEALER (BERRY, IN CORSICANA, TEXAS), SAYS THAT THERE IS NO RECALL FOR MY VEHICLE AND REFUSES TO WORK ON IT. I HAVE ALREADY HAD IT IN FOR SERVICE, PRIOR TO LEARNING ABOUT THE RECALL, THREE TIMES WITH NO RESOLUTION. THIS HAS BEEN ONGOIN…
Read full complaint
MY VEHICLE HAS A STEERING PROBLEM; I UNDERSTAND THAT THE BALL JOINTS HAVE BEEN RECALLED. THE DEALER (BERRY, IN CORSICANA, TEXAS), SAYS THAT THERE IS NO RECALL FOR MY VEHICLE AND REFUSES TO WORK ON IT. I HAVE ALREADY HAD IT IN FOR SERVICE, PRIOR TO LEARNING ABOUT THE RECALL, THREE TIMES WITH NO RESOLUTION. THIS HAS BEEN ONGOING SINCE THERE WERE 22,000 MILES ON THE VEHICLE. NOW, THERE ARE 31,000 MILES. *NM
NHTSA ODI #10171220
26,000 miles · Jul 23, 2006
SteeringTires
I PURCHASED A 2005 JEEP LIBERTY LIMITED ON 05/23/2006. PRIOR TO TAKING DELIVERY OF THE VEHICLE, I TOOK IT FOR A TEST DRIVE AND I NOTICED THAT THE VEHICLE WAS PULLING TO THE RIGHT AND WAS TOLD BY THE SALESPERSON THAT IT PROBABLY JUST NEEDED AN ALIGNMENT. I RECEIVED AN "WE OWE YOU" FOR THE ALIGNMENT. THE VEHICLE WAS TAKEN BACK TO …
Read full complaint
I PURCHASED A 2005 JEEP LIBERTY LIMITED ON 05/23/2006. PRIOR TO TAKING DELIVERY OF THE VEHICLE, I TOOK IT FOR A TEST DRIVE AND I NOTICED THAT THE VEHICLE WAS PULLING TO THE RIGHT AND WAS TOLD BY THE SALESPERSON THAT IT PROBABLY JUST NEEDED AN ALIGNMENT. I RECEIVED AN "WE OWE YOU" FOR THE ALIGNMENT. THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP FOR THE ALIGNMENT. THE MECHANIC STATED ON THE SERVICE SLIP THAT AFTER HE PERFORMED THE ALIGNMENT THE LIBERTY STILL PULLED TO THE RIGHT AND HE STATED THAT IT WAS DUE TO THE CROWNING OF THE ROADWAY. THE ROAD HAD NOTHING TO DO WITH IT. IT HAS GOTTEN WORSE AND I EVEN DROVE IT ON A FLAT SURFACED PARKING LOT, FIRST DOING ABOUT 25 MPH AND IT PULLED RIGHT AND THEN LETTING LIBERTY COAST AND IT STILL PULLED RIGHT. I HAVE OWNED AND HAVE DRIVEN SEVERAL VEHICLES AND I HAVE NEVER HAD THIS PROBLEM. RECEIVED A CALL FROM A CUSTOMER SERVICE REP REGARDING THE VISIT TO THE SERVICE DEPT. FOR THE ALIGNMENT AND THEY WERE TOLD THAT THE VEHICLE WAS STILL PULLING TO THE RIGHT AND THAT I WAS NOT HAPPY WITH MY EXPERIENCE PURCHASING THIS JEEP, THEY INFORMED ME THAT THEY WOULD NOTIFIED THE SERVICE MANAGER. I HAVE NOT BEEN CONTACTED BY THE SERVICE MANGER. AFTER DOING SOME RESEARCH ON THE INTERNET, I SEE THAT JEEP HAS HAD SOME PROBLEMS WITH THE PULLING RIGHT ISSUE, AND HAS HAD SOME RECALLS. IT STILL PULLS TO THE RIGHT AND SEEMS TO BE WORSE. NUMBER OF FAILURES WOULD BE EVERYTIME I DRIVE THE THING. THIS IS A MAJOR SAFETY ISSUE THAT JEEP CHRYSLER NEEDS TO GET FIXED. THE OTHER CONCERN I HAVE IS WITH THE GOODYEAR WRANGLER HP TIRES. THESE ARE NOT SAFE FOR THIS VEHICLE. I WAS AT A STOP LIGHT WAITING TO MAKE A LEFT TURN, COMPLETELY STOPPED WAITING FOR THE LIGHT TO TURN GREEN. IT HAD JUST STARTED TO SPRINKLE. WHEN THE LIGHT TURNED GREEN, I STARTED TO GO FORWARD AND WAS JUST MAKING MY TURN WHEN THE VEHICLE FISHTAILED AND I SPUN COMPLETELY AROUND AND WAS FACING ONCOMING TRAFFIC. HOW COULD A VEHICLE SPIN OUT UPON STARTING FROM A COMPLETE STOP AT A STOP LIGHT??? *NM
NHTSA ODI #10163238
52 miles · Nov 6, 2005
SteeringSuspensionTires
PURCHASED 2005 JEEP LIBERTY 9/29/05. THE TIRE PRESSURE SENSOR LIGHT WAS ON IMMEDIATELY. TOOK VEHICLE BACK TO DEALERSHIP AND COMPLAINED THAT THE VEHICLE PULLS BADLY TO THE RIGHT, ESPECIALLY AT 65+ MPH. THE DEALERSHIP FIXED THE TIRE PRESSURE SENSOR, BUT TOLD ME THE PULLING TO THE RIGHT MUST BE DUE TO ROAD CONDITIONS. AFTER READIN…
Read full complaint
PURCHASED 2005 JEEP LIBERTY 9/29/05. THE TIRE PRESSURE SENSOR LIGHT WAS ON IMMEDIATELY. TOOK VEHICLE BACK TO DEALERSHIP AND COMPLAINED THAT THE VEHICLE PULLS BADLY TO THE RIGHT, ESPECIALLY AT 65+ MPH. THE DEALERSHIP FIXED THE TIRE PRESSURE SENSOR, BUT TOLD ME THE PULLING TO THE RIGHT MUST BE DUE TO ROAD CONDITIONS. AFTER READING OTHER CUSTOMER COMPLAINTS, I DOUBT IT. WHEN DRIVING AT HIGHWAY SPEEDS IT IS DIFFICULT TO MAINTAIN IN LANE. IF LARGE TRACTOR-TRAILER TRUCKS PASS THIS WILL CREATE EVEN MORE INTENSE STRUGGLE TO KEEP VEHICLE ON THE ROAD. SAFETY CONCERNS REGARDING WINTER SNOW CONDITIONS ARE A DECIDING FACTOR ON KEEPING THE VEHICLE. *NM
NHTSA ODI #10141848
45 miles · May 27, 2005
Electrical SystemEngine And Engine CoolingSteering
2005 JEEP LIBERTY CRD WILL "SLING SHOT" ITSELF WHEN STARTING FROM A STOP WITH THE A/C ON. WHEN YOU START TO ACCELERATE MAKING A TURN FROM BEING STOPPED THE VEHICLE WILL START TO MOVE AND YOU CAN FEEL, HEAR THE ENGINE GAINING RPM BUT NOT MOVEMENT THEN A SUDDEN SLINGSHOT EFFECT WILL TAKE PLACE. THE SELLING DEALER SAID IT WAS NORMA…
Read full complaint
2005 JEEP LIBERTY CRD WILL "SLING SHOT" ITSELF WHEN STARTING FROM A STOP WITH THE A/C ON. WHEN YOU START TO ACCELERATE MAKING A TURN FROM BEING STOPPED THE VEHICLE WILL START TO MOVE AND YOU CAN FEEL, HEAR THE ENGINE GAINING RPM BUT NOT MOVEMENT THEN A SUDDEN SLINGSHOT EFFECT WILL TAKE PLACE. THE SELLING DEALER SAID IT WAS NORMAL FOR A DIESEL ENGINE WITH A TURBO TO DO THIS. ALSO STATED IT WAS IN THE ELECTRONICS AND THERE WASN'T ANY THING THEY COULD DO TO REPAIR IT. I WOULD HAVE TO WAIT FOR A FACTORY BULLETIN TO COME OUT. THIS NEW VEHICLE PULLS TO THE RIGHT CONSTANTLY, I REQUESTED THE ALIGNMENT TO BE CORRECTED DURING THE SAME DEALERSHIP VISIT AS ABOVE. I WAS TOLD MY ALIGNMENT WAS CHECKED AND THERE WAS NO ABNORMAL TIRE WEAR SO IT MUST BE THE CROWN OF THE ROAD CAUSING THE PULL OR DRIFT. THIS VEHICLE ALSO SURGES WHEN THE CRUISE CONTROL IS ENGAGED AND YOU START UP AN INCLINE, IT WILL CONTINUE TO SURGE AS LONG AS THE INCLINE LASTS. AFTER PICKING THE VEHICLE UP AT THE DEALERSHIP TODAY I STARTED HOME AND ALL THREE OF THE FAULTS OCCURRED. I RETURNED TO THE DEALERSHIP AND THE SHOP FOREMAN WENT WITH ME , WHERE THE VEHICLE AGAIN ACTED UP. HE SAID THERE WAS NOT ANY THING THEY COULD DO ABOUT THE SURGING AND THE ALIGNMENT AND THE SLING SHOTTING WAS TURBO LAG. I HAVE NOT DIVEN THE VEHICLE ON WET OR SNOW COVERED PAVEMENT, HOWEVER, WITH WHAT DOES I NOT SURE I WANT TO.
NHTSA ODI #10122324
Official recalls
5May 1, 2018
Chrysler (FCA US LLC) is recalling certain 2004-2007 Jeep Liberty vehicles. The rear suspension lower control arms can fracture due to excessive corrosion, causing a loss of vehicle control.
Consequence & remedy
Consequence: A fractured control arm can cause a loss of vehicle control, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the rear lower control arms, free of charge. The recall began June 26, 2018. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is U38. Note: This recall is an expansion of recall 12V-085. Vehicles included in that campaign are not included in this recall.
Jun 19, 2013
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Additional source detail variants (2)
Structure
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Fuel System, Gasoline:storage:tank Assembly
Chrysler Group LLC (Chrysler) is recalling certain model year 1993-1998 Jeep Grand Cherokee and 2002-2007 Jeep Liberty vehicles. The fuel tanks in these vehicles are at risk of failure and leakage in certain rear impacts.
Consequence: A fuel leak in the presence of an ignition source may result in a fire.
Remedy: Owners may take their vehicles to dealers and the dealers will perform a free inspection of the rear structure. On vehicles in the recall that are not equipped with a tow hitch, Chrysler will install a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles in the recall that are equipped with an aftermarket tow hitch, Chrysler will assess whether the hitch and surrounding areas show evidence of sharp edges or other puncture risks. If so, Chrysler will replace the tow hitch with a Chrysler designed tow hitch free of charge, provided the condition of the vehicle can support proper installation. On vehicles already equipped with a Chrysler designed tow hitch, Chrysler will inspect the area around the tow hitch installation, and if any installation issues are identified, they will be repaired free of charge. The recall began on August 1, 2014. Owners may contact Chrysler at 1-800-247-9753. Chrysler's recall campaign numbers are N45 (for the Grand Cherokee vehicles) and N46 (for the Liberty vehicles).
Mar 5, 2012
IN JUNE 2012, CHRYSLER EXPANDED THIS RECALL TO INCLUDE MODEL YEAR 2006 AND 2007 JEEP LIBERTY VEHICLES, REPRESENTING AN ADDITIONAL 137,176 VEHICLES. THIS RECALL NOW CONCERNS CERTAIN MY 2004-2007 JEEP LIBERTY VEHICLES. THE TOTAL NUMBER VEHICLES BEING RECALLED IS NOW 346,900. THESE VEHICLES WERE MANUFACTURED FROM JULY 3, 2003 THROUGH JUNE 29, 2007. THE RECALL ADDRESSES THOSE VEHICLES ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA. SOME VEHICLES MAY BE EQUIPPED WITH REAR LOWER CONTROL ARMS THAT CAN EXPERIENCE A REAR SUSPENSION LOWER CONTROL ARM FRACTURE DUE TO EXCESSIVE CORROSION DUE TO APPLICATION OF ROAD SALTS DURING WINTER WEATHER CONDITIONS.
Consequence & remedy
Consequence: A FRACTURE OF THE REAR LOWER CONTROL ARM MAY RESULT IN A LOSS OF VEHICLE CONTROL AND MAY LEAD TO A VEHICLE CRASH.
Remedy: CHRYSLER WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE REAR LOWER CONTROL ARMS ON ALL AFFECTED VEHICLES ORIGINALLY SOLD IN, OR CURRENTLY REGISTERED IN, CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, WISCONSIN, AND THE DISTRICT OF COLUMBIA, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 26, 2012. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Aug 3, 2006
ON CERTAIN TRUCKS, THE CONSTANT TENSION FRONT LOWER BALL JOINTS MAY EXPERIENCE CONTAMINATION. IF THE VEHICLE IS OPERATED FOR AN EXTENDED PERIOD WITH THIS CONDITION, THE BALL JOINT MAY EVENTUALLY EXPERIENCE WEAR AND LOOSENESS.
Consequence & remedy
Consequence: WHEN THE DRIVER CONTINUES TO OPERATE THE VEHICLE WITH THIS CONDITION, THE CONTAMINATION CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE CAUSING A LOSS OF VEHICLE STEERING CONTROL INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE FRONT LOWER BALL JOINTS FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 11, 2006. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Oct 6, 2005
ON CERTAIN PICKUP TRUCKS, SPORT UTILITY AND PASSENGER VEHICLES EQUIPPED WITH 42RLE AUTOMATIC TRANSMISSIONS, THE CUP PLUG THAT RETAINS THE PARK PAWL ANCHOR SHAFT MAY BE IMPROPERLY INSTALLED. IF THE SHAFT MOVES OUT OF POSITION, THE VEHICLE MAY NOT BE ABLE TO ACHIEVE 'PARK' POSITION.
Consequence & remedy
Consequence: IF THIS OCCURS AND THE PARKING BRAKE IS NOT APPLIED, THE VEHICLE MAY ROLL AWAY AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE TRANSMISSIONS AND INSTALL A BRACKET TO ENSURE THE PARK PAWL ANCHOR SHAFT IS RETAINED IN THE PROPER POSITION. THE RECALL BEGAN ON NOVEMBER 28, 2005. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5EA12005 · Crash Related Fuel Tank Fires
Opened Jun 12, 2012 · Closed Nov 14, 2014
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Additional source detail variants (4)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap
ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by
EA11013 · Rear Suspension Control Arm Failure
Opened Sep 15, 2011 · Closed Mar 14, 2012
Status: closed (inferred from source dates) · Suspension; Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Additional source detail variants (2)
Suspension
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
Suspension:rear
In a letter dated March 2, 2012 Chrysler Group LLC (Chrysler) submitted a Defect Information Report (NHTSA recall No. 12V-085) to the NHTSA identifying a safety defect regarding rear suspension lower control arm corrosion in approximately 210,000 model year (MY) 2004 and 2005 Jeep Liberty vehicles, originally sold or currently registered in a Salt-belt state (Connecticut, Delaware, Iowa, Illinois, Indiana, Kentucky, Massachusetts, Maine, Maryland, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).According to Chrysler, excessive corrosion could result in fracture of a rear suspension lower control arm which may result in a loss vehicle control.In analysis of both Vehicle Owner Questionnaire (VOQ) data submitted to the Office of Defects Investigation (ODI) and consumer complaint data submitted to Chrysler, ODI identified 54 non-duplicative reports alleging failure of one or both rear lower control arms due to excessive corrosion.Thirteen of these complaints allege that the failure resulted in some loss of vehicle control.For purposes of this analysis, loss of control events involve alleged complete or partial departure from the intended lane of travel.An additional 11 complaints reported difficulty maintaining control of the vehicle when the rear lower control arm failed.All of the complainant vehicles were either originally sold or registered at the time of the incident in a Salt-belt state.ODI did not identify any reports (complaints or warranty claims) related to rear lower control failure due to excessive corrosion in the approximately 138,000 MY 2004 and 2005 Liberty vehicles that are not included in this recall (i.e., not sold or currently registered in a Salt-belt state).In Chrysler?s Defect Information Report, Chrysler stated that during the investigation a field survey of MY 2004 and 2005 Jeep Liberty vehicles was conducted.In total, Chrysler is aware of 83 incidents alleging rear control arm fracture (including complaints and field study results).Based on Chrysler?s decision to conduct a safety recall this investigation is closed. The associated VOQs are: 10449912, 10448981, 10448406, 10448119, 10447069,10446737, 10445029, 10443863, 10443222, 10441248, 10438681, 10437308, 10436416, 10436231, 10436024, 10434927, 10434157, 10433963, 10430852, 10429346, 10428006, 10427087, 10426644, 10426393, 10419094, 10417697, 10416623, 10410148, 10409668, 10402048, 10397413, 10392160, 10388448, 10365118, 10360057, 10360049, 10345985
PE11013 · Rear Suspension Control Arm Failure
Opened Apr 18, 2011 · Closed Sep 15, 2011
Status: closed (inferred from source dates) · Suspension:rear
During Preliminary Evaluation (PE11-013), the Office of Defects Investigation (ODI) conducted an analysis of consumer field data from its Vehicle Owner Questionnaire (VOQ) database and from complaint data submitted to ODI by Chrysler. ODI's analysis of VOQ data identified 13 complaints alleging failure of either the right or left rear lower control arm due to excessive corrosion.All of these complaints were associated with vehicles originally sold or registered in a salt belt state (for the purposes of this investigation, 'salt belt' includes Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia).All of the complaints were associated with vehicles manufactured in model years (MY) 2004 or 2005. Three of these complaints also allege a loss of vehicle control due to the rear lower control arm failure. No complaints related to the alleged defect were identified on vehicles manufactured during MYs 2002 or 2003. Similarly an analysis of Chrysler complaint data identified 11 complaints (2 of which are duplicative of VOQs) alleging failure of a rear lower control arm due to excessive corrosion.All 11 of these complaints were from consumers operating vehicles in a salt belt state and vehicles manufactured in either MY 2004 or 2005. Three of these complaints (not duplicative of VOQs) also allege a loss of vehicle control due to the rear lower control arm failure.The original scope of PE11-013 included MY 2002 through 2005 Jeep Liberty vehicles as they were in the same generation.In response to an Information Request (IR) letter sent by ODI, Chrysler provided information and sample components identifying a substantial design change of the rear lower control arms after MY 2003 and beginning with MY 2004.Analysis of complaint data from both data sources (ODI and Chrysler) did not identify any applicable complaints (lower control arm failures due to excessive corrosion) from vehicles manufactured during MY 2002 or 2003.Similarly no complaints from either data source were found in states outside of those identified as salt belt states.Chrysler stated in its IR letter response that its investigation and analysis is ongoing to determine the scope, possible root causes of the unusual lower control arm corrosion, and define possible consequences to motor vehicle safety. Based on ODI's data analysis from both sources (ODI and Chrysler data), this investigation has been upgraded to an Engineering Analysis (EA11-013) focused on vehicles originally sold or registered in a salt belt state and produced during MY 2004 and 2005, to further assess the scope and potential safety consequences of the alleged defect.
PE07041 · Diesel Fuel Leak
Opened Aug 8, 2007 · Closed Dec 7, 2007
Status: closed (inferred from source dates) · Fuel System, Diesel; Fuel System, Diesel: PRE-HEATER
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Additional source detail variants (2)
Fuel System, Diesel
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
Fuel System, Diesel: PRE-HEATER
OVERHEATING OF THE ELECTRICAL CONNECTOR AT THE FUEL HEATER ON THE FUEL FILTER / WATER SEPARATOR ASSEMBLY CAN CAUSE A FUEL LEAK THROUGH THE ELECTRICAL CONNECTION.OPERATORS REPORT THE SMELL OF DIESEL FUEL, SMOKE, DIFFICULTY STARTING AND/OR POOR ENGINE OPERATION.THE FUEL LEAKAGE IS REPORTED BY SOME OPERATORS AS SEEPAGE, WETNESS, SEVERAL DROPS, AND AN OZ PER MINUTE.EVIDENCE OF OVERHEATING OF THE CONNECTION WAS OBSERVED BY SOME OPERATORS AND REPORTED AS BURNED OR DISCOLORED ELECTRICAL CONNECTION AT THE FUEL HEATER.SEVEN OPERATORS REPORT SMELLING OR SEEING SMOKE.ONE REPORTED A VEHICLE ENGINE COMPARTMENT FIRE HOWEVER THE CAUSE OF THE FIRE WAS NOT IDENTIFIED, AND LINKAGE OF THE FIRE CAUSE TO THIS ISSUE IS NOT LIKELY TO BE ESTABLISHED.THE LOCATION OF THE FUEL FILTER / WATER SEPARATOR ASSEMBLY IS NOT NEAR THE LOCATION OF THE TURBO CHARGER WHICH IS LOCATED ON THE OPPOSITE SIDE OF THE ENGINE.THE TURBO CHARGER WOULD PRESENT A POTENTIALLY HOT SURFACE HOWEVER DUE TO THE LAYOUT OF THE ENGINE COMPARTMENT AND ITS COMPONENTS, DIESEL FUEL LEAKAGE FROM THE ELECTRICAL CONNECTION WOULD NOT LIKELY MIGRATE TO THE TURBO CHARGER.AT THIS TIME, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY DEFECT DOES NOT EXIST.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
EA06008 · Front Suspension Ball Joint Separation
Opened May 31, 2006 · Closed Aug 24, 2006
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JANUARY 6, 2006, THE OFFICE OF DEFECTS INVESTIGATION (ODI) OPENED A PRELIMINARY EVALUATION TO INVESTIGATE ALLEGED FRONT SUSPENSION LOWER BALL JOINT SEPARATIONIN CERTAIN MODEL YEAR (MY) 2004 JEEP LIBERTY VEHICLES.ODI SENT A LETTER TO THE MANUFACTURER ON FEBRUARY 7, 2006 REQUESTING INFORMATION ABOUT THESE AND OTHER JEEP LIBERTY VEHICLES.CONSEQUENTLY, THE INVESTIGATION WAS UPGRADED TO AN ENGINEERING ANALYSIS ON MAY 31, 2006 AND THE RANGE OF SUBJECT VEHICLES UNDER INVESTIGATION WAS EXPANDED TO INCLUDE ALL MY 2002-2006 JEEP LIBERTY VEHICLES.ODI IS AWARE OF 566 NON-DUPLICATIVE COMPLAINTS ALLEGING INVOLUNTARY FRONT SUSPENSION LOWER BALL JOINT SEPARATION IN THE SUBJECT VEHICLES.ODI IS ALSO AWARE OF ONE NON-INJURY CRASH AND THREE ALLEGED INJURY INCIDENTS (TWO CRASH INCIDENTS AND ONE NON-CRASH INCIDENT) RELATED TO THE ALLEGED DEFECT RESULTING IN MINOR INJURIES.THE COMPLAINT COUNTS REPORTED ABOVE ONLY INCLUDE THOSE MY 2002-03 LIBERTY VEHICLES WHERE THE ALLEGED BALL JOINT SEPARATION OCCURRED AFTER PRIOR RECALL REPAIRS WERE PERFORMED (SEE BELOW) OR IF THE VEHICLE WAS NOT INCLUDED IN THE PRIOR RECALL.THE MANUFACTURER CONDUCTED A PRIOR SAFETY RECALL (03V-460) TO ADDRESS THE SUBJECT ISSUE IN CERTAIN MY 2002-03 JEEP LIBERTY VEHICLES.ACCORDING TO DAIMLERCHRYSLER?S NOVEMBER 4, 2003, DEFECT INFORMATION REPORT (SUBMITTED IN ACCORDANCE WITH 49 CFR PART 573), ?THE CONSTANT TENSION LOWER CONTROL ARM BALL JOINTS MAY EXPERIENCE A LOSS OF LUBRICATION WHICH CAN LEAD TO CORROSION, ACCELERATED WEAR AND POSSIBLY SEPARATION FROM THE STEERING KNUCKLE.A CONSTANT TENSION BALL JOINT WHICH HAS SEPARATED FROM THE KNUCKLE MAY RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL WITH MINIMAL ADVANCED WARNING.?HOWEVER, EVIDENCE INDICATES THAT SOME VEHICLES SERVICED UNDER RECALL 03V-460 CONTINUED TO EXPERIENCE INVOLUNTARY BALL JOINT SEPARATIONS.THE MANUFACTURER HAS MADE NUMEROUS CHANGES IN THE DESIGN, MATERIAL COMPOSITION, MANUFACTURE, QUALITY CONTROL, SUPPLY, AND INSTALLATION OF THE SUBJECT BALL JOINTS SINCE THE PRIOR SAFETY RECALL WAS INITIATED IN AN EFFORT TO IMPROVE PERFORMANCE WITH RESPECT TO SEALING, LUBRICATION, AND JOINT RETENTION CAPABILITY.BY LETTER DATED AUGUST 1, 2006, DAIMLERCHRYSLER CORPORATION HAS NOTIFIED THE AGENCY THAT IT WILL CONDUCT A SAFETY RECALL TO ADDRESS POTENTIALLY DEFECTIVE FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS IN APPROXIMATELY 826,687 MODEL YEAR 2002-2006 JEEP LIBERTY VEHICLES MANUFACTURED BETWEEN JANUARY 2, 2001 AND MARCH 15, 2006, INCLUDINGALL VEHICLES SUBJECT TO THE PRIOR RECALL.THE NHTSA CAMPAIGN NUMBER ASSIGNED TO THIS RECALL IS 06V-288 (DAIMLERCHRYSLER RECALL CAMPAIGN F23).DAIMLERCHRYSLER WILL REPLACE BOTH LEFT AND RIGHT FRONT SUSPENSION LOWER CONTROL ARM BALL JOINTS WITH IMPROVED COMPONENTS FREE OF CHARGE.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.
Illustration