← New search

2003 Jeep Grand Cherokee

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Jeep Grand Cherokee do not stand out strongly from the model-year median of 726.

About this comparison →

When problems were reported

Mileage at the reported incident

488 reports with mileage · 274 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 256 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Visibility. Review the 167 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Seats. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

48 crash reports14 fire reports48 injury reports

What owners actually said

762 reports
Mileage unknown · Sep 26, 2005
Engine And Engine Cooling

MY 2003 JEEP GRAND CHEROKEE, WITH LESS THAN 33,000 MILES, WAS REPAIRED FOR THE SAME PROBLEM TWICE THIS YEAR, ON 9 FEB AND 26 JUL 2005. THE REPAIRS WERE DONE AT 2 DIFFERENT JEEP-CERTIFIED SERVICE FACILITIES, AND FOCUSED ON DECARBONIZATION CLEANINGS. BASED ON THE INVOICES AND MY OWN RESEARCH, IT'S CLEAR THIS PROBLEM HAS SEVERAL IN…

Read full complaint

MY 2003 JEEP GRAND CHEROKEE, WITH LESS THAN 33,000 MILES, WAS REPAIRED FOR THE SAME PROBLEM TWICE THIS YEAR, ON 9 FEB AND 26 JUL 2005. THE REPAIRS WERE DONE AT 2 DIFFERENT JEEP-CERTIFIED SERVICE FACILITIES, AND FOCUSED ON DECARBONIZATION CLEANINGS. BASED ON THE INVOICES AND MY OWN RESEARCH, IT'S CLEAR THIS PROBLEM HAS SEVERAL INTERRELATED FACTORS: MULTIPLE CYLINDER MISFIRES, AND EXHAUST VALVE OBSTRUCTION WITH EXCESSIVE CARBON BUILDUP. FURTHER, IT IS DIRECTLY LINKED TO SHORT-TRIP/CITY DRIVING. A FEW WEEKS AFTER THE SECOND REPAIR, I HAD AN INDEPENDENT (NON-JEEP) ACE-CERTIFIED MECHANIC INSPECTION. HIS FINDINGS INDICATE THAT THE MISFIRES CONTINUE; THE UNDERLYING PROBLEM APPARENTLY PERSISTS. IN THE BIG PICTURE, JEEP DID ACKNOWLEDGE THE PROBLEM IN TSB-09-003-03, ENCOMPASSING A SPAN OF MODELS, FROM 1999 TO 2004, W/ 4.0L ENGINES. THE TSB PRESCRIBES A VALVE CHECK AND POSSIBLE CLEANING, BUT DOES NOT ADDRESS THE ROOT CAUSE OF THE MISFIRES AND CARBON BUILD-UP. IN THE SMALLER PICTURE, I MIGHT MENTION: THE JEEP REPRESENTATIVE A/W THE JULY REPAIR TOLD ME THIS PROBLEM WAS THE RESULT OF USING 'CHEAP GASOLINE'. THIS THEORY IS NOT SUPPORTED BY ANYTHING I'VE LEARNED IN MY OWN RESERACH. IT IS JUST NOT FEASIBLE THAT GASOLINE GRADE COULD CAUSE SUCH AN EXTENT OF CARBON BUILD-UP TWICE IN 6 MONTHS, ESP WITH SUCH LOW MILEAGE. I SHOULD PROBABLY ALSO ADD THAT I DON'T KNOW THE ABSOLUTE ANSWER TO THIS PROBLEM. THERE IS A GOOD DEAL OF REFERENCE MATERIAL ONLINE ID'ING THIS AS A CHRONIC PROBLEM W/ GRAND CHEROKEE, YET NO CLEARCUT PERMANENT SOLUTION. I HAVE SUPPORTING DOCUMENTATION ON WHAT I STATE HERE, AND WILL BE HAPPY TO FOLLOW UP IN WRITING IF THAT WILL HELP. LASTLY- SINCE MOST OF MY VEHICLE USE IS SHORT-TRIP CITY DRIVING, I AM WORRIED THAT I MAY FACE LONG-TERM INCONVENIENCE, EXPENSE, AND SAFETY RISKS. MY INTENT IS NOT TO CAUSE PROBLEMS FOR JEEP- I SIMPLY WANT MY VEHICLE TO BE FUNCTIONING AND SAFE FOR MY FAMILY. *JB

NHTSA ODI #10137551

31,000 miles · Sep 13, 2005
Tires

DT: 2003 JEEP GRAND CHEROKEE. THE CONSUMER STATED DRIVER'S SIDE REAR TIRE SIDEWALL DISINTEGRATED. THERE IS ONLY 31,000 MILES ON THE VEHICLE. THE REST OF THE TIRES WERE WEATHER ROTTED. THESE TIRES HAVE NEVER BEEN REPAIRED. THEY WERE THE ORIGINAL TIRES ON THE VEHICLE. GOODYEAR, P255/75R16. THE TIRE WAS TAKEN TO THE D…

Read full complaint

DT: 2003 JEEP GRAND CHEROKEE. THE CONSUMER STATED DRIVER'S SIDE REAR TIRE SIDEWALL DISINTEGRATED. THERE IS ONLY 31,000 MILES ON THE VEHICLE. THE REST OF THE TIRES WERE WEATHER ROTTED. THESE TIRES HAVE NEVER BEEN REPAIRED. THEY WERE THE ORIGINAL TIRES ON THE VEHICLE. GOODYEAR, P255/75R16. THE TIRE WAS TAKEN TO THE DEALERSHIP. INSTEAD, IT SHOULD HAVE BEEN TAKEN TO GOODYEAR. THERE WAS NO WRECK WHEN THIS HAPPENED. THE TIRES WERE PROPERLY MAINTAINED. IT IS A LEASED VEHICLE.*AK

NHTSA ODI #10136358

69,000 miles · Sep 6, 2005
Electrical System

DT: THE WIRING HARNESS RUBBED THE CHASSIS WHICH RESULTED IN THE WIRES MELTING AND EXPOSING THEM WHICH ALMOST CAUSED A FIRE. SMOKE CAME FROM UNDER THE INSTRUMENT PANEL FROM THE FUSE BOX AREA. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND FIXED. THE REAR WIPER DIDN'T WORK BECAUSE OF THE PROBLEM. *JB THE DEALER STATED THERE WA…

Read full complaint

DT: THE WIRING HARNESS RUBBED THE CHASSIS WHICH RESULTED IN THE WIRES MELTING AND EXPOSING THEM WHICH ALMOST CAUSED A FIRE. SMOKE CAME FROM UNDER THE INSTRUMENT PANEL FROM THE FUSE BOX AREA. THE VEHICLE WAS TAKEN TO THE DEALERSHIP AND FIXED. THE REAR WIPER DIDN'T WORK BECAUSE OF THE PROBLEM. *JB THE DEALER STATED THERE WAS A MAJOR SHORT IN THE WIRING HARNESS ON THE DRIVERS SIDE IN TWO DIFFERENT LOCATIONS. *JB

NHTSA ODI #10126317

18,000 miles · Aug 1, 2005
Service Brakes, Hydraulic

DT: CONSUMER OWNED A 2003 JEEP GRAND CHEROKEE,, IT HAD 50,000 MILES ON IT. VEHICLE HAS GONE THROUGH THREE SETS OF ROTORS. WHEN BRAKING THE VEHICLE SHOOK;. ROTORS WERE FIRST REPLACED AT 18,000 MILES. THE SECOND TIME THEY WERE REPLACED 35,000 MILES, AND THE ROTORS NEEDED TO BE REPLACED AGAIN. CONSUMER STATED THE WHEEL…

Read full complaint

DT: CONSUMER OWNED A 2003 JEEP GRAND CHEROKEE,, IT HAD 50,000 MILES ON IT. VEHICLE HAS GONE THROUGH THREE SETS OF ROTORS. WHEN BRAKING THE VEHICLE SHOOK;. ROTORS WERE FIRST REPLACED AT 18,000 MILES. THE SECOND TIME THEY WERE REPLACED 35,000 MILES, AND THE ROTORS NEEDED TO BE REPLACED AGAIN. CONSUMER STATED THE WHEELS WERE CHROME, AND THE FRONT WERE BLACK LIKE CARBON HAS GOT ON THEM. THE REAR WHEELS WERE STILL SHINY. THREE SETS ON THE FRONT AND ONE SET ON THE REAR WERE REPLACED. THE BRAKE PADS WERE EFFECTIVE, BUT THE ROTORS WERE WARPED. THE VEHICLE IS CURRENTLY AT THE FIRESTONE SERVICE CENTER. *AK

NHTSA ODI #10130893

9,000 miles · Jul 30, 2005
Service Brakes, Hydraulic

MY 2003 JEEP GRAND CHEROKEE HAS FAULTY BRAKE ROTORS. WHEN THE BRAKES ARE APPLIED AT SPEEDS ABOVE 35 MPH, THE CAR SHAKES AND CONTROL OF THE CAR IS LOST. IT DOES NOT STOP PROPERLY OR QUICKLY. THE DEALER REPLACED THE FIRST SET OF ROTORS AND BRAKES AT 9,000 MILES. THE SAME PROBLEM IS HAPPENING AGAIN AT 17,000 MILES. THE DEALER AND …

Read full complaint

MY 2003 JEEP GRAND CHEROKEE HAS FAULTY BRAKE ROTORS. WHEN THE BRAKES ARE APPLIED AT SPEEDS ABOVE 35 MPH, THE CAR SHAKES AND CONTROL OF THE CAR IS LOST. IT DOES NOT STOP PROPERLY OR QUICKLY. THE DEALER REPLACED THE FIRST SET OF ROTORS AND BRAKES AT 9,000 MILES. THE SAME PROBLEM IS HAPPENING AGAIN AT 17,000 MILES. THE DEALER AND CHRYSLERDAIMLER CORP. IS NOT ACCEPTING ANY RESPONSIBILITY IN THE DEFECTIVE BRAKE ROTORS. (THE IS A CLASS ACTION LAW SUIT AGAINST CHRYSLERDAIMLER CORP. CURRENTLY). *JB

NHTSA ODI #10130664

Mileage unknown · Jul 15, 2005
Power TrainCrash

DT: CONTACT STATES VEHICLE SHIFTED OUT OF PARK WHILE IN A PARKING AREA. *AK CONTACT AND HER SON WERE IN THE VEHICLE WHEN IT STARTED ROLLING DOWN A HILL, THE VEHICLE HIT A POOL FENCE. THE SERVICE DEALER WOULD NOT SAY WHY THE VEHICLE SHIFTED OUT OF PARK. *AK *NM

NHTSA ODI #10125353

9,388 miles · Jun 24, 2005
Service Brakes, HydraulicWheels

THE FRONT BRAKES ON THE CONSUMERS 2003 JEEP CHEROKEE WORE OUT IRREGULARLY.(NAR) *JB THE FRONT BRAKE ROTORS CAUSED THE VEHICLE TO SHIMMY EXCESSIVELY ESPECIALLY AT HIGHER SPEEDS. EACH TIME THE VIBRATION WOULD TAKE PLACE, THE FRONT ROTORS WOULD HAVE TO BE REPLACED. THE CONSUMER REQUESTED A REFUND OF REPAIR MONIES. THE CHROM…

Read full complaint

THE FRONT BRAKES ON THE CONSUMERS 2003 JEEP CHEROKEE WORE OUT IRREGULARLY.(NAR) *JB THE FRONT BRAKE ROTORS CAUSED THE VEHICLE TO SHIMMY EXCESSIVELY ESPECIALLY AT HIGHER SPEEDS. EACH TIME THE VIBRATION WOULD TAKE PLACE, THE FRONT ROTORS WOULD HAVE TO BE REPLACED. THE CONSUMER REQUESTED A REFUND OF REPAIR MONIES. THE CHROME PEELED OFF OF THE WHEELS. *SC *JB

NHTSA ODI #10127946

46 miles · Jun 24, 2005
Electrical SystemUnknown Or OtherInjury

MY 23 MONTH OLD WAS ROLLING UP THE WINDOW ON THE DRIVER SIDE OF THE CAR WHEN HER LEFT HAND RING FINGER WAS CAUGHT IN THE POWER WINDOW, BETWEEN THE WINDOW AND THE WEATHER STRIPPING. THE WINDOW WOULD NOT UNROLL. THE POWER WINDOW FAILED TO UNROLL.HER FINGER WAS CAUGHT INSIDE. WE WERE FINALLY ABLE TO PULL THE WEATHER STRIPPING ENO…

Read full complaint

MY 23 MONTH OLD WAS ROLLING UP THE WINDOW ON THE DRIVER SIDE OF THE CAR WHEN HER LEFT HAND RING FINGER WAS CAUGHT IN THE POWER WINDOW, BETWEEN THE WINDOW AND THE WEATHER STRIPPING. THE WINDOW WOULD NOT UNROLL. THE POWER WINDOW FAILED TO UNROLL.HER FINGER WAS CAUGHT INSIDE. WE WERE FINALLY ABLE TO PULL THE WEATHER STRIPPING ENOUGH TO UNROLL THE WINDOW. IT NEARLY SEVERED HER FINGER. HER FINGER WAS BROKEN AND CUT ALL THE WAY AROUND.

NHTSA ODI #10126500

Mileage unknown · Jun 12, 2005
Electrical SystemPower TrainSuspension

TRANSMISSION MAKING NOISE 1 WEEK AFTER PURCHASE, TOOK IT IN EVERY 2 WEEKS TO HAVE IT FIXED FOR FIRST 2 MONTHS. VEHICLE HAD 40,000 KM. CHRYSLER DEALERSHIP ANSWER WAS FOR US TO DO TRANSMISSION FLUID CHANGE (OUR EXPENSE), DID NOT STOP THE NOISE, GAVE UP AFTER WE TOOK VEHICLE BACK 5 TIMES, TERRIBLE SERVICE. HEATER MOTOR FAILED W…

Read full complaint

TRANSMISSION MAKING NOISE 1 WEEK AFTER PURCHASE, TOOK IT IN EVERY 2 WEEKS TO HAVE IT FIXED FOR FIRST 2 MONTHS. VEHICLE HAD 40,000 KM. CHRYSLER DEALERSHIP ANSWER WAS FOR US TO DO TRANSMISSION FLUID CHANGE (OUR EXPENSE), DID NOT STOP THE NOISE, GAVE UP AFTER WE TOOK VEHICLE BACK 5 TIMES, TERRIBLE SERVICE. HEATER MOTOR FAILED WITHIN 1 WEEK OF PURCHASE, REPLACE MOTOR SWITCH, HEATER FAN MAKING NOISE. REAR END WAS REBUILT 2 TIMES WITHIN FIRST 2 MONTHS OF OWNING VEHICLE. STRUTS NEEDED REPLACING WITHIN FIRST MONTH. SMOKE COMES FROM ENGINE WHEN STOPPED (INTERMITTENT), WHEEL ALIGNMENT WITHIN FIRST MONTH (OUR EXPENSE AGAIN). THIS IS OUR FIRST AND LAST JEEP/CHRYSLER PRODUCT.

NHTSA ODI #10125039

Mileage unknown · Jun 10, 2005
Service Brakes, Hydraulic

MY PROBLEMS BEGAN AT 9300 MILES. BRAKES PULSATING AND SHAKING IN THE STEERING. FRONT ROTORS WHERE WARPED AND NEEDED TO BE RESURFACED. HAD FRONT ROTORS RESURFACED 2 TIMES AND REPLACED 1 TIME, ALL OCCURED UNDER 20,000 MILES. AT 21,000 MILES THE REAR ROTORS WHERE RESURFACED AND NOW I HAVE TO RETURN TO THE SERVICE CENTER FOR THE…

Read full complaint

MY PROBLEMS BEGAN AT 9300 MILES. BRAKES PULSATING AND SHAKING IN THE STEERING. FRONT ROTORS WHERE WARPED AND NEEDED TO BE RESURFACED. HAD FRONT ROTORS RESURFACED 2 TIMES AND REPLACED 1 TIME, ALL OCCURED UNDER 20,000 MILES. AT 21,000 MILES THE REAR ROTORS WHERE RESURFACED AND NOW I HAVE TO RETURN TO THE SERVICE CENTER FOR THE FIFTH TIME WITH 23000 MILES ON MY VEHICLE BRAKES ARE PULSATING AGAIN. FOUND THAT THERE WAS A SERVICE BULLETIN THAT WAS ISSUED ON DEC.02 REGARDING FRONT BRAKES PULSATING DURING LIGHT TO MODERATE BRAKE APPLICATION FOR 1999 TO 2002 JEEP GRAND CHEROKEES. THIS IS DUE TO EXCESSIVE THICKNESS VARIATION OF THE BRAKE ROTORS. OBVIOUSLY THIS PROBLEM STILL EXISTS IN 2003 MODELS AND DAIMLERCHYRSLER STILL REFUSES TO FIX THE PROBLEM AT NO COST TO THE CONSUMER.

NHTSA ODI #10124885

Official recalls

4

15V046000 · Air Bags:frontal

Jan 28, 2015

Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.

12V527000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE

Nov 8, 2012

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Air Bags

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

09V117000 · Seats:front Assembly:seat Heater/cooler

Apr 9, 2009

CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.

Consequence & remedy

Consequence: OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V197000 · Seats:front Assembly:seat Heater/cooler

Jun 7, 2006

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HEATED SEATS, THE FRONT PASSENGER SEAT ELECTRIC HEATER ELEMENT COULD OVERHEAT.

Consequence & remedy

Consequence: OVERHEATING COULD POTENTIALLY CAUSE A FIRE.

Remedy: DEALERS WILL REPLACE THE HEATED SEAT ELEMENTS. THE RECALL BEGAN ON JULY 24, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

RQ14001 · Jeep Inadvertent Air Bag Deployment

Opened May 29, 2014 · Closed Nov 13, 2015

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window; Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Additional source detail variants (24)

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

PE10031 · Crash Related Fuel Tank Fires

Opened Aug 23, 2010 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

DP09005 · Fuel Storage System Crash Related Fires

Opened Nov 6, 2009 · Closed Aug 23, 2010

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Go deeper into Jeep Grand Cherokee problems