← New search

2003 Jeep Grand Cherokee

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2003 Jeep Grand Cherokee do not stand out strongly from the model-year median of 726.

About this comparison →

When problems were reported

Mileage at the reported incident

488 reports with mileage · 274 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Air Bags. Review the 256 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Visibility. Review the 167 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Seats. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

48 crash reports14 fire reports48 injury reports

Power Train complaints

35 reports
Clear category filter
112,000 miles · Mar 22, 2010
Engine And Engine CoolingPower Train

TL*THE CONTACT OWNS A 2003 JEEP GRAND CHEROKEE. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE LUNGED FORWARD AND STALLED. THE VEHICLE WAS TOWED TO HER RESIDENCE. THE FOLLOWING DAY THE VEHICLE OPERATED NORMALLY; HOWEVER, THE IDENTICAL FAILURES OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHO…

Read full complaint

TL*THE CONTACT OWNS A 2003 JEEP GRAND CHEROKEE. THE CONTACT WAS DRIVING APPROXIMATELY 70 MPH WHEN THE VEHICLE LUNGED FORWARD AND STALLED. THE VEHICLE WAS TOWED TO HER RESIDENCE. THE FOLLOWING DAY THE VEHICLE OPERATED NORMALLY; HOWEVER, THE IDENTICAL FAILURES OCCURRED ON THREE SEPARATE OCCASIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE TECHNICIAN STATED THAT THE FAILURE WAS RELATED TO THE FRONT CONTROL MODULE. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 112,000. UPDATED 6/21/10 *CN THE CONSUMER STATED THE VEHICLE WOULD SHUT OFF WITH NO WARNING AND WOULD NOT RESTART. IT WAS DETERMINED THE CRANK SENSOR BECAME EXTREMELY HOT WHICH CAUSED THE VEHICLE TO SHUT DOWN. THE FAN RELAY ALSO FAILED WHICH CAUSED THE VEHICLE TO OVERHEAT AND THE INTERNAL TRANSMISSION SENSORS FAILED. UPDATED 07/01/10.*JB

NHTSA ODI #10321424

83,000 miles · Feb 21, 2008
Power Train

2003 JEEP GRAND CHEROKEE LAREDO THE JEEP WAS RUNNING AND IN PARK. I WAS STANDING OUTSIDE ABOUT 20 YARDS AWAY. THE GEARSHIFT POPPED FROM PARK TO REVERSE ON ITS OWN. I WAS LUCKILY ABLE TO STOP IT IN TIME. ALSO, WHEN I PARK IT AND TRY TO REMOVE THE KEY THE KEY IS LOCKED IN PLACE LIKE ITS STILL IN GEAR. I HAVE TO PUSH THE GEARSHIFT…

Read full complaint

2003 JEEP GRAND CHEROKEE LAREDO THE JEEP WAS RUNNING AND IN PARK. I WAS STANDING OUTSIDE ABOUT 20 YARDS AWAY. THE GEARSHIFT POPPED FROM PARK TO REVERSE ON ITS OWN. I WAS LUCKILY ABLE TO STOP IT IN TIME. ALSO, WHEN I PARK IT AND TRY TO REMOVE THE KEY THE KEY IS LOCKED IN PLACE LIKE ITS STILL IN GEAR. I HAVE TO PUSH THE GEARSHIFT WITH FORCE TO RELEASE THE KEY. A MECHANIC HAS SAID THAT THE LINKAGE WAS LOOSE. I HAVE TIGHTENED IT AND THE PROBLEM HAS HAPPENED AGAIN. *TR

NHTSA ODI #10218754

57,220 miles · Feb 8, 2008
Power TrainSeatsFireInjury

TL*THE CONTACT OWNS A 2003 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT ACTIVATED THE HEATED SEATS, WHICH TOOK APPROXIMATELY FIVE MINUTES TO WARM UP. THREE MINUTES LATER, THE SEAT WARMED UP EXCESSIVELY AND CAUSED MILD BURNS TO HER BODY. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN …

Read full complaint

TL*THE CONTACT OWNS A 2003 JEEP GRAND CHEROKEE. WHILE DRIVING APPROXIMATELY 60 MPH, THE CONTACT ACTIVATED THE HEATED SEATS, WHICH TOOK APPROXIMATELY FIVE MINUTES TO WARM UP. THREE MINUTES LATER, THE SEAT WARMED UP EXCESSIVELY AND CAUSED MILD BURNS TO HER BODY. THE DEALER STATED THAT HER VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 06V197000 (SEATS:FRONT ASSEMBLY:SEAT HEATER/COOLER), ALTHOUGH THE FAILURE WAS IDENTICAL. THE CONTACT WOULD HAVE TO REPAIR THE VEHICLE AT HER OWN EXPENSE. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE FAILURE MILEAGE WAS 57,220 AND CURRENT MILEAGE WAS 61,716. UPDATED 3/4/08 *CN THE DEALER STATED MALFUNCTION INDICATOR LIGHT ON, AND TRANSMISSION NOT SHIFTING PROPERLY. UPDATED 03/04/08 *TR

NHTSA ODI #10217459

61,000 miles · May 31, 2006
Power TrainCrashInjury

DROVE VEHICLE INTO GARAGE STALL. PUT VEHICLE IN PARK, OPENED DRIVERS DOOR, LEFT DOOR OPEN AND VEHICLE RUNNING TO RETRIEVE PERSONAL ITEM FROM HOUSE, WENT TO WALK OUT GARAGE AND VEHICLE STARTED BACKING OUT GARAGE. DRIVERS DOOR CAUGHT ON GARAGE SUPPORT POLE, TWISTING DOOR AROUND TO FRONT FENDER AS IT PROCEEDED OUT OF GARAGE. DRAGGE…

Read full complaint

DROVE VEHICLE INTO GARAGE STALL. PUT VEHICLE IN PARK, OPENED DRIVERS DOOR, LEFT DOOR OPEN AND VEHICLE RUNNING TO RETRIEVE PERSONAL ITEM FROM HOUSE, WENT TO WALK OUT GARAGE AND VEHICLE STARTED BACKING OUT GARAGE. DRIVERS DOOR CAUGHT ON GARAGE SUPPORT POLE, TWISTING DOOR AROUND TO FRONT FENDER AS IT PROCEEDED OUT OF GARAGE. DRAGGED MYSELF PAST TOOL BOX AND BY GARAGE DOOR. VEHICLE THEN PROCEEDED DOWN DRIVEWAY, DID U-TURN PAST NEIGHBORS VEHICLES AND LODGED ON BOULDER IN NEIGHBORS FRONT YARD. WENT TO EMERGENCY ROOM FOR TREATMENT, NO BROKEN BONES OR MAJOR INJURIES. SUSTAINED LOTS OF DEEP BRUISING, BAD SCRAPES AND SWELLING OF UPPER BODY, LEFT LOWER LEG, AND ARMS. *JB

NHTSA ODI #10158732

Mileage unknown · Jul 15, 2005
Power TrainCrash

DT: CONTACT STATES VEHICLE SHIFTED OUT OF PARK WHILE IN A PARKING AREA. *AK CONTACT AND HER SON WERE IN THE VEHICLE WHEN IT STARTED ROLLING DOWN A HILL, THE VEHICLE HIT A POOL FENCE. THE SERVICE DEALER WOULD NOT SAY WHY THE VEHICLE SHIFTED OUT OF PARK. *AK *NM

NHTSA ODI #10125353

Mileage unknown · Jun 12, 2005
Electrical SystemPower TrainSuspension

TRANSMISSION MAKING NOISE 1 WEEK AFTER PURCHASE, TOOK IT IN EVERY 2 WEEKS TO HAVE IT FIXED FOR FIRST 2 MONTHS. VEHICLE HAD 40,000 KM. CHRYSLER DEALERSHIP ANSWER WAS FOR US TO DO TRANSMISSION FLUID CHANGE (OUR EXPENSE), DID NOT STOP THE NOISE, GAVE UP AFTER WE TOOK VEHICLE BACK 5 TIMES, TERRIBLE SERVICE. HEATER MOTOR FAILED W…

Read full complaint

TRANSMISSION MAKING NOISE 1 WEEK AFTER PURCHASE, TOOK IT IN EVERY 2 WEEKS TO HAVE IT FIXED FOR FIRST 2 MONTHS. VEHICLE HAD 40,000 KM. CHRYSLER DEALERSHIP ANSWER WAS FOR US TO DO TRANSMISSION FLUID CHANGE (OUR EXPENSE), DID NOT STOP THE NOISE, GAVE UP AFTER WE TOOK VEHICLE BACK 5 TIMES, TERRIBLE SERVICE. HEATER MOTOR FAILED WITHIN 1 WEEK OF PURCHASE, REPLACE MOTOR SWITCH, HEATER FAN MAKING NOISE. REAR END WAS REBUILT 2 TIMES WITHIN FIRST 2 MONTHS OF OWNING VEHICLE. STRUTS NEEDED REPLACING WITHIN FIRST MONTH. SMOKE COMES FROM ENGINE WHEN STOPPED (INTERMITTENT), WHEEL ALIGNMENT WITHIN FIRST MONTH (OUR EXPENSE AGAIN). THIS IS OUR FIRST AND LAST JEEP/CHRYSLER PRODUCT.

NHTSA ODI #10125039

31,000 miles · Jun 7, 2005
Power Train

DT: PRIOR TO FAILURE, THE VEHICLE WAS HARD TO STEER. I TURNED INTO A PARKING LOT, AND IT SOUNDED LIKE A TIRE WAS BLOWN OUT. THE TIRES WERE FINE, AND AS I STARTED THE FRONT FELL OUTWARDS AND THE TIRE FELL SIDEWAYS. HAD IT TOWED TO THE DEALER, AND AN INVESTIGATOR FROM CHRYSLER IS LOOKING AT IT TODAY.

NHTSA ODI #10124501

23,548 miles · Apr 19, 2005
Power TrainCrashInjury

WIFE PARKED JEEP IN DRIVEWAY, PLACED IN PARK WITH KEY OUT OF THE IGNITION. WIFE EXITED THE VEHICLE, WALKED TO THE BACK DOOR, GOT MY 4 YEAR OLD OUT OF HER CAR SEAT AND PLACED HER ON THE DRIVEWAY NEXT TO THE VEHICLE. WIFE TURNED AROUND TO GET HER PURSE OFF THE FRONT SEAT WHEN THE VEHICLE TOOK OFF, ROLLING BACKWARDS DOWN THE DRIVE…

Read full complaint

WIFE PARKED JEEP IN DRIVEWAY, PLACED IN PARK WITH KEY OUT OF THE IGNITION. WIFE EXITED THE VEHICLE, WALKED TO THE BACK DOOR, GOT MY 4 YEAR OLD OUT OF HER CAR SEAT AND PLACED HER ON THE DRIVEWAY NEXT TO THE VEHICLE. WIFE TURNED AROUND TO GET HER PURSE OFF THE FRONT SEAT WHEN THE VEHICLE TOOK OFF, ROLLING BACKWARDS DOWN THE DRIVEWAY. WIFE JUMPED INTO VEHICLE AND TRIED TO STOP IT. OPEN DRIVER'S DOOR STRUCK MY FENCE, RETAINING WALL AND MY 4 YEAR OLD KNOCKING HER TO THE GROUND. THE DOOR WAS THEN BENT FORWARD, DESTROYING THE DOOR, FENDER, SCRATCHING THE SIDE AND THE REAR BUMPER AND TAILGATE. WIFE SUFFERED SCRAPES, BRUISES, DAUGHTER TRANSPORTED TO EMERGENCY ROOM THEN VIA CAR FLITE HELICOPTER - SUFFERED SCRAPES, BRUISES, LACERATED LIVER.*AK

NHTSA ODI #10118098

25,800 miles · Apr 12, 2005
Power TrainCrashInjury

(1) I PULLED THE JEEP GRAND CHEROKEE TO A STOP IN FRONT OF A SELF-SERVE CAR WASH BAY WHERE THE PREVIOUS USER HAD LEFT THE CAR WASH WAND HANGING IN THE MIDDLE OF THE BAY. WITH MY FOOT ON THE BRAKE, I OPENED THE DRIVER DOOR AND PUT THE VEHICLE IN PARK; THEN PROCEEDED TO EXIT THE VEHICLE TO MOVE THE WAND. (I DID NOT TURN THE IGN…

Read full complaint

(1) I PULLED THE JEEP GRAND CHEROKEE TO A STOP IN FRONT OF A SELF-SERVE CAR WASH BAY WHERE THE PREVIOUS USER HAD LEFT THE CAR WASH WAND HANGING IN THE MIDDLE OF THE BAY. WITH MY FOOT ON THE BRAKE, I OPENED THE DRIVER DOOR AND PUT THE VEHICLE IN PARK; THEN PROCEEDED TO EXIT THE VEHICLE TO MOVE THE WAND. (I DID NOT TURN THE IGNITION OFF SINCE I WAS ONLY GOING ABOUT 10 FEET TO MOVE THE WANDER OUT OF THE WAY.) WHILE I WAS STANDING BETWEEN THE DRIVER'S SEAT AND OPEN DOOR, THE VEHICLE STARTED ROLLING BACKWARDS. 2) THE FAILURE WAS THE VEHICLE GEAR SHIFT SLIPPING FROM "PARK" TO "REVERSE", OR BEING IN THE "PARK" GEAR ENOUGH TO STOP THE VEHICLE AND ALLOW ME TO GET OUT, BUT NOT "LOCKING" IN THE "PARK" GEAR, AND THUS SLIPPING BACK TO "REVERSE". AFTER I WAS STANDING OUTSIDE THE VEHICLE, IT STARTED TO ROLL BACKWARDS, TOO FAST FOR ME TO GET INSIDE TO APPLY THE BRAKE. THE DRIVER'S DOOR GOT CAUGHT ON A NEARBY VACUUM STRUCTURE, CAUSING THE DOOR TO SPRAIN. THE BACK END OF THE JEEP ROLLED OVER A LOW CEMENT WALL WHICH IS AROUND THE PERIMETER OF THE CAR WASH. THE CENTER OF THE VEHICLE GOT HUNG ON THE WALL, CAUSING THE VEHICLE TO STOP AND DAMAGE TO THE TRANSFER CASE AND UNDERBODY. (3) NOTHING HAS BEEN DONE TO CORRECT THE FAILURE AT THIS TIME. THE VEHICLE WILL REQUIRE A NEW DRIVER'S DOOR AND FRONT SIDE PANEL, AND A NEW TRANSFER CASE. TOTAL DAMAGE TO VEHICLE- APPROX. $5,000. *AK

NHTSA ODI #10116816

26,470 miles · Feb 27, 2005
Power TrainCrash

MY 2003 JEEP GRAND CHEROKEE WHEN PARKED IN FRONT OF MY HOME WHILE I RAN IN TO GET MY GLOVES JUMPED INTO REVERSE AFTER CLOSING THE DOOR. I WAS AWAY FROM THE TRUCK FOR LESS THEN 1 MIN. AND IT ROLLED IN REVERSE 75 FT STRIKING A NEIGHBORS MOBILE HOME. WHEN I GOT TO THE TRUCK IT WAS IN REVERSE AND HAD EXTENSIVE DAMAGE TO THE WHOLE T…

Read full complaint

MY 2003 JEEP GRAND CHEROKEE WHEN PARKED IN FRONT OF MY HOME WHILE I RAN IN TO GET MY GLOVES JUMPED INTO REVERSE AFTER CLOSING THE DOOR. I WAS AWAY FROM THE TRUCK FOR LESS THEN 1 MIN. AND IT ROLLED IN REVERSE 75 FT STRIKING A NEIGHBORS MOBILE HOME. WHEN I GOT TO THE TRUCK IT WAS IN REVERSE AND HAD EXTENSIVE DAMAGE TO THE WHOLE TAILGATE HATCH AND GLASS. DAMAGE WAS ALSO DONE TO THE MOBILE HOME. I AM CONTACTING A DEALER AS OF FEB. 28 2005. *JB

NHTSA ODI #10112245

Official recalls

4

15V046000 · Air Bags:frontal

Jan 28, 2015

Chrysler (FCA US LLC) is recalling certain model year 2002-2003 Jeep Liberty vehicles manufactured January 9, 2001, to March 28, 2003, 2002-2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, to May 23 2003, and 2003-2004 Dodge Viper vehicles manufactured November 1, 2001, to June 30, 2004. Due to electrical noise beyond the tolerance of the air bag electronic control module (ECM), a component in the ECM may fail, causing the front air bags, side air bags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the air bags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler dealers will replace the air bag control module and side impact sensors as required, free of charge. This recall remedy was applied during earlier recall campaigns of these vehicles under safety recalls 12V527 and 13V040. All owners that have not had the recall repair performed under safety recalls 12V527 or 13V040 are strongly encouraged to have it performed and not wait for the final remedy to be deployed to the field. The recall began on December 29, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R06.

12V527000 · Air Bags; Air Bags:frontal:sensor/control MODULE-INACTIVE

Nov 8, 2012

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence & remedy

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Additional source detail variants (2)

Air Bags:frontal:sensor/control MODULE-INACTIVE

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

Air Bags

Chrysler is recalling certain model year 2002 and 2003 Jeep Liberty vehicles manufactured January 9, 2001, through March 28, 2003, and 2002 through 2004 Jeep Grand Cherokee vehicles manufactured February 13, 2001, through May 23, 2003. A component in the air bag control module may fail causing the front airbags, side curtain airbags, and/or seatbelt pretensioners to deploy inadvertently while the vehicle is being operated.

Consequence: Inadvertent deployment of the airbags may increase the risk of injury and the possibility of a vehicle crash.

Remedy: Chrysler will notify owners, and dealers will install a supplemental jumper harness to the airbag control module, free of charge. Owners were notified of the recall by interim letter in January 2013. The remedy for affected Liberty vehicles is expected to be available in April 2013. The remedy for affected Grand Cherokee vehicles is expected to be available later in the year. Owners may contact Chrysler at 1-800-247-9753.

09V117000 · Seats:front Assembly:seat Heater/cooler

Apr 9, 2009

CHRYSLER IS RECALLING 103,409 MY 2001-2004 JEEP GRAND CHEROKEE VEHICLES WITH HEATED SEATS AND WITH CHRYSLER RECALL NO. 06V-197 COMPLETED (03-04 MY) OR SEAT HEATER ELEMENTS SERVICE REPLACEMENT (01-02 MY). THE FRONT SEAT ELECTRIC HEATER ELEMENTS COULD OVERHEAT.

Consequence & remedy

Consequence: OVERHEATING COULD POTENTIALLY CAUSE A FIRE OR INJURY.

Remedy: DEALERS WILL REPLACE THE FRONT SEAT HEATER ELEMENTS FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 23, 2009. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.

06V197000 · Seats:front Assembly:seat Heater/cooler

Jun 7, 2006

ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH HEATED SEATS, THE FRONT PASSENGER SEAT ELECTRIC HEATER ELEMENT COULD OVERHEAT.

Consequence & remedy

Consequence: OVERHEATING COULD POTENTIALLY CAUSE A FIRE.

Remedy: DEALERS WILL REPLACE THE HEATED SEAT ELEMENTS. THE RECALL BEGAN ON JULY 24, 2006. OWNERS MAY CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

RQ14001 · Jeep Inadvertent Air Bag Deployment

Opened May 29, 2014 · Closed Nov 13, 2015

Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window; Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Additional source detail variants (24)

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:driver Side:inflator Module

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:frontal:sensor/control MODULE-INACTIVE

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

Air Bags:side/window:curtain

The Office of Defects Investigation (ODI) opened an investigation based on consumer allegations of inadvertent air bag deployments (IABD) occurring after the recall remedy for NHTSA recall 12V-527 had been installed on recalled model year (MY ) 2002-2003 Jeep Liberty and MY 2002-2004 Jeep Grand Cherokee vehicles manufactured by Fiat Chrysler Automobiles (FCA).The recall was in response to the Office of Defects Investigation (ODI) investigation EA12-001 during which data provided by FCA indicate that the air bag circuitry inside the Occupant Restraint Control (ORC) module can degrade. ORC degradation can result in an inadvertent air bag deployment, without a crash or impact, while the vehicle is being operated.An IABD may involve frontal, side and belt pretensioner devices, and may result in injuries consisting of burns, cuts and bruises to the upper body region, and or the potential for a loss of control and or crash.The remedy FCA developed for 12V-527 consisted of installing an in-line jumper harness with an integrated electrical filter for the circuits that connect to the air bag modules (squib circuits).This filter is intended to eliminate transient electrical spikes to the ORC which FCA asserted are responsible for the IABDs.ODI has identified a total of 9 NHTSA complaints across all affected vehicles indicating an IABD event occurring after the vehicle had previously been remedied under 12V-527.In addition, FCA reported 12 additional complaints of post-remedy IABD events. The IABD events took place both while driving and while the vehicle was stationary. Six customers incurred injuries consistent with air bag deployments however no crashes were reported.As a response to this investigation, FCA has issued 2 new recalls involving the IABD.On January 27, 2015 FCA notified ODI that it would conduct a safety recall (15V-046) to remedy potential IABD events occurring in 753,176 MY02-03 Jeep Liberty vehicles built through 03/28/03 and MY 2002-2004 Jeep Grand Cherokee vehicles built through 5/23/03.Note that this recall, which was scoped based on field IABD events does not include all MY 2003 Liberty or MY 2004 Grand Cherokee manufactured with the same level ORC module.According to FCA, the ORC degradation and subsequent electrical overstress condition that causes the air bags to deploy inadvertently is not fully remedied with the filter installed during the 12V-527 campaign.To remedy IABDs under 15V-046, FCA will install a new design ORC module using a next generation electrical architecture.The next generation architecture has been used in other non-subject vehicles for many years without evidence of IABD events occurring.In addition to this recall, on October 15, 2015 FCA advised NHTSA that it would conduct safety recall 15V-673 to remedy potential IABD events in the remaining 284,089 MY 2003 Jeep Liberty and MY 2004 Jeep Grand Cherokee vehicles manufactured with the earlier generation ORC module that were not previously recalled.FCA initially did not recall these populations due to the lack of known IABD events.However, FCA is now aware of 7 IABD events occurring in this population. After consultation with ODI regarding the long term durability and noise toughness of the earlier ORC architecture, FCA decided to recall this population also.The recall actions initiated by the manufacturer address the safety risks identified by the investigation.Accordingly, the investigation is closed.The ODI reports cited above can be reviewed at http://www-odi.nhtsa.dot.gov/owners/SearchSafetyIssues under the following identification (ODI) numbers: 10622092, 10629705, 10619008, 10618842, 10626762, 106404

EA12005 · Crash Related Fuel Tank Fires

Opened Jun 12, 2012 · Closed Nov 14, 2014

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

ODI has completed an extensive analysis of rear crash fuel tank system integrity data for the subject Jeep Cherokee, Grand Cherokee and Liberty vehicles (SVs).As of June 2013, ODI knew of 56 post-collision fatal fires, 28 non-fatal fires, and 6 fuel leak incidents (totaling 90 incidents, 75 fatalities and 58 injuries) involving the SVs.Based on this analysis, ODI issued a Recall Request Letter (RRL) on June 3, 2013 requesting that Chrysler recall the Grand Cherokee and Liberty vehicles due to the rate of fatal, non-fatal fire, and fuel leak incidents when compared to peer vehicles (compact and medium SUVs) built during the same time period.In the RRL, ODI described how the location of the aft-mounted fuel tank made the SVs vulnerable to rear impact crash fuel tank failures.During the analysis, besides the high speed/high severity crashes present in both the SV and peer vehicles, ODI observed a significant number of low and moderate speed rear impact crash related fires and leaks, particularly in the Liberty.The data also demonstrated that SVs originally equipped with towing hitch receivers (trailer hitches) appeared to be under-represented in rear-impact related fuel tank failures.In the RRL, ODI requested that Chrysler provide its response by June 18, 2013, otherwise NHTSA might proceed to an Initial Decision that the SVs contain a safety-related defect.Chrysler responded to the RRL on June 4, 2013 and vigorously disputed the tentative findings of the RRL.Among other things, Chrysler argued that the SVs had an overall safety record superior to their peers, met or exceeded all applicable federal motor vehicle safety standards (FMVSS) and only experienced fires in severe high energy rear impacts.Nonetheless, while continuing to maintain that the SVs did not contain a safety-related defect, Chrysler proposed a recall (13V-252) of approximately 2.5M (1.6M currently registered) model year (MY) 1993 - 1998 Grand Cherokee (ZJ) and MY 2002-2007 Liberty (KJ) vehicles on June 18, 2013.The recall remedy submitted by Chrysler would employ a hitch receiver assembly consisting of a steel cross-member behind the fuel tank with forward-projecting arms bolted to the frame rails on either side of the fuel tank.For the MY 1999 - 2004 Grand Cherokee, Chrysler indicated it would conduct a customer satisfaction campaign and inspect vehicles equipped with aftermarket tow hitch receivers, and if necessary, replace any such hitch receivers whose conditionmay increase the risk of fuel system failure in rear crashes.Examination of the available data established that the MY 1999 - 2004 Grand Cherokee did not pose the same magnitude of safety risk as the MY 1993 - 1998 Grand Cherokee and MY 2002-2007 Liberty, particularly in low and moderate speed rear impacts.Because the agency has concluded that the vehicles do not present an unreasonable risk to safety, ODI is closing its investigation of the MY 1999 - 2004 Grand Cherokee.Although it was not within the scope of the Petition initiating this investigation or the Preliminary Evaluation preceding this EA, ODI also examined the performance of the MY 1993 - 2001 Cherokee as part of this investigation.NHTSA's assessment of the available data for the Cherokee did not establish an unreasonable risk in comparison to peer vehicles.ODI does not approve proposed defect remedies.While offering to install hitch receiver assemblies on the MY 1993-1998 Grand Cherokees and 2002-2007 Liberty, Chrysler did not, in ODI's view, provide enough evidence demonstrating the effectiveness of the proposed remedy in rear impacts.The Complete Summary for this Closing Resume (EA12-005) can be seen by

PE10031 · Crash Related Fuel Tank Fires

Opened Aug 23, 2010 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

NHTSA has conducted extensive analysis of the data regarding fuel tank integrity for the model year (MY) 1993-2004 Jeep Grand Cherokee (JGC). As a result of that work, the agency has decided to upgrade its safety defect investigation to an Engineering Analysis and to expand the scope of vehicles included in the investigation. NHTSA's assessment of the data collected during this investigation indicates that rear-impact-related tank failures and vehicle fires are more prevalent in the JGC than in the non-Jeep peer vehicles. In addition, the agency's analysis of its FARS data for the peer vehicles and three Jeep models shows a higher incidence of rear-impact, fatal fire crashes for the Jeep products.PE10-031 had focused on the fuel tank system integrity of the JGC vehicles during rear-end collisions and impacts.The fuel tank is located at the rear of the vehicle, between the bumper and axle, and is manufactured from a plastic material (HDPE).Three peer vehicles (across the same MY range as the JGC) were identified for comparative assessment: the Chevrolet Blazer, Ford Explorer, and Toyota 4Runner.ODI has collected and assessed a significant volume of data for the JGC and three peer vehicles under the Defect Petition (DP) 09-005 and PE10-031, much of which was either provided by the petitioner or by the subject and peer manufacturers in response to ODI's information request letters.NHTSA has also utilized its FARS database.Fatal crash data was collected for the JGC and its three peers, along with data for two other Jeep vehicles, the Cherokee and Liberty, which were also manufactured with rear mounted fuel tanks and assessed by ODI as Jeep peer vehicles.Based on the agency's current analysis, ODI is upgrading its investigation to determine whether the subject vehicles contain a defect that presents an unreasonable risk to safety.The subject vehicles for EA12-005 will be MY 1993-2004 JGC, MY 1993-2001 Cherokee, and MY 2002-2007 Liberty; the estimated production volumes for these vehicles is approximately 5.1 million, although attrition is a factor for the older vehicles.Please note that the counts shown in the above failure report summary are for the JGC only (values shown in the total column are unique).Data for the other Jeep models and possibly other peer models will be collected during the investigation.The ODI reports cited above can be reviewed online at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification (ODI) numbers:506249, 549376, 734783, 869217, 10009553, 10335943, 10351589, 10351980, 10357528.

DP09005 · Fuel Storage System Crash Related Fires

Opened Nov 6, 2009 · Closed Aug 23, 2010

Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:storage; Fuel System, Gasoline:storage:tank Assembly; Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Additional source detail variants (4)

Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Fuel System, Gasoline:storage:tank Assembly:filler Pipe And Cap

In a letter dated October 2, 2009, the Center for Auto Safety (CAS) petitioned NHTSA to open a defect investigation and recall model year 1993-2004 Jeep Grand Cherokees.CAS alleged that the subject vehicles have defective fuel tank storage systems that present a fire hazard in crashes. CAS alleged that the plastic fuel tank's placement behind the rear axle and below the rear bumper, and the lack of adequate shielding, make it more vulnerable to rupture or leakage from a rear-impact by another vehicle (including damage from other components located on the Grand Cherokee), or in the case of rollover crashes, from other external objects.CAS also alleged that the fuel filler neck tears off in crashes.In its petition, CAS cites data from NHTSA's Fatality Analysis Reporting System (FARS) showing 172 fatal fire crashes with 254 fatalities involving the subject vehicles from calendar years 1992 through 2008.CAS stated that there have been at least 44 crashes with 64 total fatalities (subject and non-subject vehicles) where fire was entered as the Most Harmful Event (MHE) in the FARS database.In response to the CAS petition, ODI made a preliminary examination of available data.FARS data showed 2,988 occupants of the subject vehicles have died in crashes since 1992.Of those, 55 died in 44 crashes where fire was listed as the Most Harmful Event.Identifying crashes most likely associated with the alleged defect as described by CAS (defined as the subject vehicle being struck at the 5, 6 or 7 o'clock positions) isolated 10 crashes with 13 occupant fatalities.ODI also reviewed the Vehicle Owner Questionnaires (VOQ) database and identified 12 reports alleging A) a post-crash fuel tank leak and/or B) a post-crash fire potentially related to a fuel tank leak.Of the 12 reports, 10 involved fires (two involved fuel leaks only) with 9 alleged injuries and 1 alleged fatality.The existence of these post-crash fires does not, by itself, establish a defect trend.Further review and investigation into these incidents is needed to determine the existence of any relationship between the alleged defect and each fire or leak.It should be noted that ODI also conducted a preliminary review of the Early Warning Reporting (EWR) data that did not find the subject vehicles to be over-represented for post-crash fires.ODI's initial review neither supports nor excludes the possibility that a defect exists in the subject vehicles.However, ODI has always taken the position that vehicle fires pose a significant safety risk.Accordingly, ODI has granted the petition to further investigate the conditions associated with post-crash fires in these vehicles.

Go deeper into Jeep Grand Cherokee problems